9999 NABI NABI TSBs (76)
- Bulletin:
- L3-FSV-130
- Component:
- 060000 engine (pws)
- Summary:
- Nabi trolley: engine cover seal and insulation. the insulation is coming loose. *js
- Bulletin:
- L3-FSV-127
- Component:
- 071120 fuel system, gasoline:storage:tank assembly:mounting
- Summary:
- New jersey transit: surge tank support. surge tank mounting brackets are cracking. design should have included reinforcement of brackets. *js
- Bulletin:
- WN-L3-FSV-141
- Component:
- 111000 electrical system:battery
- Summary:
- Nabi: due to mud flaps being missing, this causes an acceleration of corrosion to the battery disconnect compartment and mud flaps needs checking and replace, if necessary. no models listed. *pe
- Bulletin:
- WN-LS-FSV-140
- Component:
- 042600 service brakes, air:supply:hoses, lines/piping, and fittings
- Summary:
- Nabi: on some buses, the straight brake hose fittings needs to be replace with 45 degree fitting at the rear axle brake chamber chamber. models nj transit 40sfw, 164200, 164400, 279000, 289000, 308000. no model years listed.
- Bulletin:
- L3-FSV-151
- Component:
- 356000 equipment adaptive
- Summary:
- Nabi: the rivets, that holds ceiling panels, are breaking and panels are coming loose. the aluminum rivets will be replace with stainless steel rivets. models dart 304500. no model years. *pe
- Bulletin:
- L3-LSV-159
- Component:
- 356000 equipment adaptive
- Summary:
- Nabi: without bus idling and bus in transmission gear, three emergency brake releases, as required by law, cannot be performed, due to insufficient air in reservoir, after 2 full releases, and a higher capacity air tank must replace previo
- Bulletin:
- L3-FSV-150
- Component:
- 114000 electrical system:wiring
- Summary:
- Nabi: on some buses, apc grounds wires for the passenger automatic counter, do not work due to not being connected and needs re-connecting. model dart 304500. no model years listed. *pe
- Bulletin:
- L3-FSV-149
- Component:
- 350000 equipment
- Summary:
- Nabi: information provided regarding an issue in side of bus compartment, where air dryer is discharging due to no discharge holes. model dart 304500. no model year listed. *pe
- Bulletin:
- L3-FSV-158
- Component:
- 350000 equipment
- Summary:
- Nabi: on some buses, the stainless steel bolts, used for wheel chair ramp, has failed due to being installed incorrectly and need to be replaced with the grade 8 type. model dart 304500. no model year listed. *pe
- Bulletin:
- L3-FSV-157
- Component:
- 355100 equipment:other:labels
- Summary:
- Nabi: on some buses, a new clean decal needs to be installed due to old decal, watch your step, failing to properly adhere to step. model dart 304500. no model year listed. *pe
- Bulletin:
- SB-10-02-02-A
- Component:
- 112000 electrical system:alternator/generator/regulator
- Summary:
- Nabi: the preventative maintenance schedule and maintenance manual has been updated with enhanced instructions regarding buses alternator that is critical to charge/start reliability and safe operation. no model and no years. *pe
- Bulletin:
- FSV-199
- Component:
- 160000 structure
- Summary:
- Nabi: instruction information being provided regarding the repair of roof cap bolt. model 60brt 295000, 42brt 303000. no years listed. *pe
- Bulletin:
- FSV-201
- Component:
- 150000 seat belts
- Summary:
- Nabi: due to retractor not releasing webbing, as designed, the seat belt is a discomfort and/or an inconvenient to wearer, and replace seat belt, if needed. model 38001-38030, 390001-39156. no years listed. *pe
- Bulletin:
- FSV-207
- Component:
- 042600 service brakes, air:supply:hoses, lines/piping, and fittings
- Summary:
- Nabi: information on moisture in 35 psi brake interlock pressure sensor switch freezing, causing diagnostic light to illuminate, erroneously, on dash, during low temperature days. no model or years listed. *pe
- Bulletin:
- FSV-195
- Component:
- 162000 structure:body
- Summary:
- Nabi: information regarding the inspection and the repairing of cracks on structure and/or frame of buses. model 76000, 87000, 125000, 128000. no years listed. *pe
- Bulletin:
- FSV-162
- Component:
- 013000 steering:gear box (other than rack and pinion)
- Summary:
- Nabi: overtime, while in use, the steering gear box mounting hardware torque may relax due applied undercoat to gear box mounting surface. model dart 304500. no years listed. *pe
- Bulletin:
- FSV-179
- Component:
- 081100 fuel system, diesel:storage:tank assembly
- Summary:
- Nabi: due to fuel tank being pressurized and is a two piece flange, diesel fuel can seep onto top of fuel tank when pressurized filling. model new jersey transit. no years listed. *pe
- Bulletin:
- FSV-186
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Nabi: the designed for the cgi pipe is inadequate and is failing prematurely and needs to be replaced. model new jersey transit. no years listed. *pe
- Bulletin:
- FSV-187
- Component:
- 161000 structure:frame and members
- Summary:
- Nabi: the frame has no support to keep compressor line from rubbing and would need to have clamp and bracket added. model dart-304500. no years listed. *pe
- Bulletin:
- FSV-172
- Component:
- 060000 engine (pws)
- Summary:
- Nabi: on some buses, the type or brand of relays have reliability issues in engine control box and need to be replaced. model 39001-39104. no years listed. *pe
- Bulletin:
- FSV-184
- Component:
- 162000 structure:body
- Summary:
- Nabi: the front, right wheelwell has water leaking at kick plate rivet due to wax holes not being plugged inside and the rivets, at floor level, needs to be replaced. model 304500. no years listed. *pe
- Bulletin:
- FSV-194
- Component:
- 353600 equipment:air conditioner
- Summary:
- Nabi: there is limited access to surge tank from drain line, on some buses, due to routing of drain lines across top of surge tank fill cap and drain lines needs to be rerouted away from surge tank. model 304500. no years listed.
- Bulletin:
- FSV-190
- Component:
- 161000 structure:frame and members
- Summary:
- Nabi: information regarding inspecting, repairing and re-aligning the c frame after damages of hairline cracks, alignment, driving and road conditions. model all nabi. no years listed. *pe
- Bulletin:
- FSV-193
- Component:
- 135200 visibility:rearview mirrors/devices:exterior
- Summary:
- Nabi: on some buses, the mirror switches are loose, in side dash, and needs repairing. model 304500. no years listed. *pe
- Bulletin:
- SB-13-11-01
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Nabi: updated information, for service manual, is being provided for the adjustable floor pedal by the manufacturer, kongsberg automotive. no model or years listed. *pe
- Bulletin:
- FSV-196
- Component:
- 162000 structure:body
- Summary:
- Nabi: instruction information provided regarding the repair of an effected area that has corrosion issues. model wmata 221000. no years listed. *pe
- Bulletin:
- FSV-185
- Component:
- 060000 engine (pws)
- Summary:
- Nabi: to prevent corrosion and allow proper thread engagement, the wrong engine door hardware, that was installed, would be replaced, since engine mounting hardware is showing evidence of rust and gas strut bracket hardware failed to provi
- Bulletin:
- FSV-188
- Component:
- 135200 visibility:rearview mirrors/devices:exterior
- Summary:
- Nabi: where the fiberglass and tapping plate meets, there are cracks in the paint that needs to be grind out at the seams and then filled with sikaflex. model 390001-39053. no years listed. *pe
- Bulletin:
- FSV-189
- Component:
- 220000 seats
- Summary:
- Nabi: the spacing for the passenger seats needs to be adjusted from hip to knee. model 304500. no years listed. *pe
- Bulletin:
- FSV-173
- Component:
- 114000 electrical system:wiring
- Summary:
- Nabi: the wiring harness, on some buses, at time of assembly, fail to have identifying labels, and instruction is provided for applying the labels. model 39001-39119. no years listed. *pe
- Bulletin:
- FSV-192
- Component:
- 356000 equipment adaptive
- Summary:
- Nabi: due to pp1 valve, on some buses, being too big, and only two screws are securing the side dash, which is wavy and needs a better securement. model 304500. no years listed. *pe
- Bulletin:
- L3-FSV-212
- Component:
- 160000 structure
- Summary:
- Nabi: some customers may complain about corrosion issues. the affected must be repaired per the provided instructions. *js
- Bulletin:
- L3-FSV-213
- Component:
- 010000 steering
- Summary:
- Nabi: manufacturing variability of the welding of the steering gear plate has been identified. this procedure is an engineering deviation to correct the issue. *js
- Bulletin:
- L3-FSV-214
- Component:
- 160000 structure
- Summary:
- Nabi: some vehicles require removal of the kneel sensor and bracket. the kneel sensor hits the wheelchair ramp and becomes bent. *js
- Bulletin:
- L3-FSV-215
- Component:
- 284000 back over prevention: camera system
- Summary:
- Nabi: some vehicles may experience a failing backup camera. the camera's wire connector's are not weatherproof and it does not hold to vibration. the camera and wire connectors must be replaced. *js
- Bulletin:
- L3-FSV-216
- Component:
- 062200 engine and engine cooling:cooling system:fan
- Summary:
- Nabi: the ground for fan control relay is causing the fault code 2377. the control relay is inadequate and needs to be removed from the chassis' side. it must be installed into the ecm ground. *js
- Bulletin:
- L3-FSV-217
- Component:
- 353600 equipment:air conditioner
- Summary:
- Nabi: some vehicles may have a rusting grill caused by being painted improperly. the rusted grill needs to be painted with a grill that is painted correctly. *js
- Bulletin:
- SB-13-02-02
- Component:
- 220000 seats
- Summary:
- Nabi: the first row of foward-facing, flip-up seats positioned behind the wheelchair areas on transit buses do not have barriers in front of them. this has caused passengers from similar buses to be injured. the seat must be disabled. *js
- Bulletin:
- FSV-236
- Component:
- 161100 structure: frame and members:underbody shields
- Summary:
- Nabi: on some buses, for unknown reason, the rear upper radius rod bracket was overloaded and broke. model 39001. *pe
- Bulletin:
- FSV-241
- Component:
- 062100 engine and engine cooling:cooling system:radiator assembly
- Summary:
- Nabi: on buses, due to gap at firewall, excessive water is leaking onto cummins grid heater, in cac and radiator compartments. *pe
- Bulletin:
- FSV-231
- Component:
- 350000 equipment
- Summary:
- Nabi: on some buses, water is not draining out of tubes, through water management system, due to drain holes having frame plugs. *pe
- Bulletin:
- L3-FSV-248
- Component:
- 060000 engine (pws)
- Summary:
- Nabi: sealant and foam may not be installed in some the engine compartment areas. inspect and apply to areas noted. *js
- Bulletin:
- L3-FSV-252
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Nabi: there may be inadequate protective coating causing corrosion to the exhaust cradle. the exhaust cradle need to be replaced. new jersey transit model 31lfw no model years were provided. *js
- Bulletin:
- L3-FSV-253
- Component:
- 031000 service brakes, hydraulic:pedals and linkages
- Summary:
- Nabi: the brake pedal may not completely release. inspect,remove, and clean the adjustable konsberg floor pedal. 40lfw and brt no model years provided. *js
- Bulletin:
- L3-FSV-254
- Component:
- 121000 exterior lighting:headlights
- Summary:
- Nabi: the headlight bulb does not properly fit in the mounting bracket. modify the mounting bracket. model la 45clfw no model years were provided. *js
- Bulletin:
- L3-FSV-255
- Component:
- 162310 structure:body:door:hinge and attachments
- Summary:
- Nabi: some units may contain incorrect compartment door hinges. this can eventually cause the hinges to cease. *js
- Bulletin:
- L3-FSV-256
- Component:
- 162200 structure:body:bumpers
- Summary:
- Nabi: the flat washers on the front bumper may be rusting, the washers must be inspected and replaced. no model years were provided. *js
- Bulletin:
- L3-FSV-257
- Component:
- 356000 equipment adaptive
- Summary:
- Nabi: debris may be collecting behind the side panels. the bottom of the panel must be sealed with sikaflax. new jersey transit no model years were provided. *js
- Bulletin:
- L3-FSV-258
- Component:
- 161100 structure: frame and members:underbody shields
- Summary:
- Nabi: access holes are needed to inspect behind the lower cove panels. new jersey transit no model years were provided. *js
- Bulletin:
- L3-FSV-261
- Component:
- 160000 structure
- Summary:
- Nabi: wmata floorboard issues. the floorboards must be replaced. no model years were provided. *js
- Bulletin:
- SB-14-02-01
- Component:
- 162900 structure:body:roof and pillars
- Summary:
- Nabi: information concerning the application of the loctite 246 medium strength thread locker on the mounting bolts of the roof side panels, each time maintenance is performed on the roof. *js
- Bulletin:
- FSV-280
- Component:
- 062300 engine and engine cooling:cooling system:hose
- Summary:
- Nabi: some buses fail to have p-clamps installed on the coolant hose section to prevent it from rubbing and would need them added. model 325000, 325500. *pe
- Bulletin:
- FSV-281
- Component:
- 062300 engine and engine cooling:cooling system:hose
- Summary:
- Nabi: some buses need to add a clamp to the diesel emission fluid (def) coolant hose, to prevent it from rubbing. model 32500, 325500. *pe
- Bulletin:
- FSV-266
- Component:
- 356000 equipment adaptive
- Summary:
- Nabi: on some buses, the roof of bus is contacting the compress natural gas (cng) line cover which needs an isolator. *pe
- Bulletin:
- FSV-262
- Component:
- 356000 equipment adaptive
- Summary:
- Nabi: the splash zone of wheels, the qr1 valve is located and needs to be relocated to prevent a possibility of valve freezing. model dart 304500-306500. *pe
- Bulletin:
- FSV-238
- Component:
- 350000 equipment
- Summary:
- Nabi: on some buses, the tube cavity is used to help spray underbody protective coating. *pe
- Bulletin:
- FSV-260
- Component:
- 350000 equipment
- Summary:
- Nabi: information on underbody protection of tube cavity. *pe
- Bulletin:
- L3-FSV-305
- Component:
- 136200 visibility:windshield wiper/washer:motor
- Summary:
- Nabi: when wipers on high, may overlap a post windshield rubber during highway speeds due worn rod end bearing linkage, or incorrectly adjusted of linkage, that cause motor mount bracket to flex. *pe
- Bulletin:
- L3-FSV-306
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Nabi: over a period of time, the coolant filter will developed a leak from coolant valve, located on engine, and would need to replace coolant valve at coolant filter. *pe
- Bulletin:
- L3-DSV-169
- Component:
- 135200 visibility:rearview mirrors/devices:exterior
- Summary:
- Nabi: when mirror(s) are impacted, there is structure body damage from possible collision and hardware attachment, for mirror, needs to be change to break away bolts type. *pe
- Bulletin:
- L3-FSV-295
- Component:
- 356000 equipment adaptive
- Summary:
- Nabi: on some buses, the overhead handrail are not continuous and need to install the longer handrails. *pe
- Bulletin:
- L3-FSV-300
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Nabi: the intake heater solenoid is powered up, at all times, due to engine wiring change that causes battery to switch off. *pe
- Bulletin:
- L3-FSV-301
- Component:
- 012000 steering:column
- Summary:
- Nabi: dust seal, for steering column rubber boot, is loose and not staying in place due to clamping force being insufficient for boot to stationary part of column. *pe
- Bulletin:
- L3-FSV-302
- Component:
- 114000 electrical system:wiring
- Summary:
- Nabi: an electrical wire was provided for equipment to be installed on radio tray but was not used due to unprotected or not terminated and would need, at end of wire, heat shrink for protection. *pe
- Bulletin:
- LE-FSV-304
- Component:
- 356000 equipment adaptive
- Summary:
- Nabi: during installation, compress natural gas (cng) line was touching top of conduit and was not adjusted or properly formed at the time. model dart. *pe
- Bulletin:
- L3-FSV-303
- Component:
- 353000 equipment:electrical
- Summary:
- Nabi: supplier of light had a different revision levels of ultraviolet light in hvac unit, used from bus to bus, because of different ballast rev. levels in lights. model dart. *pe
- Bulletin:
- SB-14-03-07
- Component:
- 353600 equipment:air conditioner
- Summary:
- Supplier bulletin - sutrak -
- Bulletin:
- SB-14-02-03
- Component:
- 110000 electrical system
- Summary:
- Service bulletin - preventative maintenance - electrical harness inspections
- Bulletin:
- SB-13-11-01
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Service bulletin - kongsberg service manual
- Bulletin:
- SMB126
- Component:
- 060000 engine (pws)
- Summary:
- Service manual bulletin - preventative maintenance - graham-white air dryer
- Bulletin:
- SB-13-02-02_B
- Component:
- 090000 fuel system, other
- Summary:
- Service bulletin - cng fuel cradle mounting hardware torque check
- Bulletin:
- TP1554
- Component:
- 010000 steering
- Summary:
- Supplier bulletin - meritor - tie rod end castle nut torque
- Bulletin:
- AC19 E
- Component:
- 356000 equipment adaptive
- Summary:
- Supplier work instruction - sutrack - evaporator emergency drain hole inspection.
- Bulletin:
- SB-13-02-02
- Component:
- 220000 seats
- Summary:
- Service bulletin - disabling forward facing flip up seats
- Bulletin:
- TSIB 15-07_A
- Component:
- 110000 electrical system
- Summary:
- Technical service manual bulletin - alternator power cable support inspections.
- Bulletin:
- L3-FSV-190
- Component:
- 160000 structure
- Summary:
- Technical instruction to inspect c-frame welding.
Home | Privacy