9999 INTERNATIONAL INTERNATIONAL TSBs (435)
- Bulletin:
- 2017-0938
- Component:
- 060000 engine and engine cooling
- Summary:
- E-one vehicles are designed with electrical circuit protection (e.g. fuses), to provide overcurrent protection during short-circuit conditions or malfunction of components. fuses are sometimes shared amongst different circuits. for example,
- Bulletin:
- IK0400124
- Component:
- 010000 steering
- Summary:
- Bendix stability control, yaw and steering angle sensor troubleshooting
- Bulletin:
- IK0800005
- Component:
- 110000 electrical system
- Summary:
- How to depin an amp 2way, 24way, or 31way connector
- Bulletin:
- IK0800080
- Component:
- 353000 equipment:electrical
- Summary:
- J1939 data link troubleshooting
- Bulletin:
- IK0800092
- Component:
- 353000 equipment:electrical
- Summary:
- First check to make when troubleshooting any body controller or esc issue
- Bulletin:
- IK1400005
- Component:
- 100000 power train
- Summary:
- Driveline information center and troubleshooting procedures
- Bulletin:
- IK1400023
- Component:
- 020000 suspension
- Summary:
- Suspension lean diagnostics
- Bulletin:
- IK1200716
- Component:
- 355100 equipment:other:labels
- Summary:
- Engine emission label replacement, certificate of conformance and clean idle sticker addition procedure
- Bulletin:
- IK0800516
- Component:
- 110000 electrical system
- Summary:
- Isb starter software & hardware update
- Bulletin:
- IK0800523
- Component:
- 110000 electrical system
- Summary:
- General circuit load testing and voltage drop test
- Bulletin:
- IK1201299
- Component:
- 060000 engine (pws)
- Summary:
- Engine oil capacities
- Bulletin:
- IK1400023
- Component:
- 020000 suspension
- Summary:
- Suspension lean diagnostics
- Bulletin:
- IK0800269
- Component:
- 114000 electrical system:wiring
- Summary:
- Proper wire repair
- Bulletin:
- IK1201248
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Cooling system flush procedure
- Bulletin:
- IK1201251
- Component:
- 356000 equipment adaptive
- Summary:
- Catastrophic dpf failures
- Bulletin:
- IK1201258
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Catastrophic doc failures
- Bulletin:
- IK0800482
- Component:
- 111000 electrical system:battery
- Summary:
- Battery testing, diagnostics, and maintenance information
- Bulletin:
- IK1400023
- Component:
- 020000 suspension
- Summary:
- Suspension lean diagnostics
- Bulletin:
- IK0500054
- Component:
- 010000 steering
- Summary:
- Steering gear seal repair guidelines for r.h. sheppard gears
- Bulletin:
- IK1201009
- Component:
- 060000 engine (pws)
- Summary:
- Winter front usage
- Bulletin:
- IK1201010
- Component:
- 060000 engine (pws)
- Summary:
- Service interval and maintenance lamp information models with isx and isb cummins engines
- Bulletin:
- IK1201258
- Component:
- 060000 engine (pws)
- Summary:
- Catastrophic doc and dpf failures
- Bulletin:
- IK1900022
- Component:
- 353600 equipment:air conditioner
- Summary:
- A/c refrigerant and oil capacities
- Bulletin:
- IK0200023
- Component:
- 200000 wheels
- Summary:
- Navistar wheel alignment policy
- Bulletin:
- IK0400040
- Component:
- 036500 service brakes, hydraulic:antilock:wheel speed sensor
- Summary:
- Wheel speed sensor troubleshooting
- Bulletin:
- IK0400051
- Component:
- 030000 brakes (pws)
- Summary:
- Air dryer troubleshooting; all models with bendix air dryers
- Bulletin:
- IK0400107
- Component:
- 030000 brakes (pws)
- Summary:
- Brake noise, squeal or chatter
- Bulletin:
- IK0700067
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Spn 1761 fmi 1: deftl inducement 35; only units with scr aftertreatment systems
- Bulletin:
- IK0700068
- Component:
- 060000 engine (pws)
- Summary:
- Dpf differential pressure tube port thread cleaning / chasing process; only with epa 2007 and newer engines
- Bulletin:
- IK0800380
- Component:
- 111000 electrical system:battery
- Summary:
- Maintaining batteries during vehicle storage
- Bulletin:
- IK0800482
- Component:
- 111000 electrical system:battery
- Summary:
- Battery testing & diagnostics
- Bulletin:
- IK1200288
- Component:
- 060000 engine (pws)
- Summary:
- International engine won?t crank; with international engine only
- Bulletin:
- IK1600051
- Component:
- 160000 structure
- Summary:
- Poor fitting or leaking cab exhausters; only 5000 & 9000 series built prior to 12/22/06 and all other models built prior to 12/5/06
- Bulletin:
- IK0800080
- Component:
- 110000 electrical system
- Summary:
- J1939 data link troubleshooting; only with 250k baud data link (black 9pin diagnostic connector)
- Bulletin:
- IK0800482
- Component:
- 111000 electrical system:battery
- Summary:
- Battery testing, diagnostics, and maintenance information
- Bulletin:
- IK2600230
- Component:
- 118000 electrical system: software
- Summary:
- Oncommand' link essential update; used for over the air programming.
- Bulletin:
- IK2900082
- Component:
- 060000 engine (pws)
- Summary:
- What?s new in tools, electronic service tools, training, and service publications - november 2016 edition
- Bulletin:
- IK3000073
- Component:
- 350000 equipment
- Summary:
- How to order printed materials from the service portal
- Bulletin:
- IK0800482
- Component:
- 111000 electrical system:battery
- Summary:
- Battery testing, diagnostics, and maintenance information
- Bulletin:
- IK1201216
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Leaklocator diagnostic procedure
- Bulletin:
- IK1201310
- Component:
- 060000 engine (pws)
- Summary:
- Engines with active 143 and/or 144 cmp fault codes
- Bulletin:
- IK1400005
- Component:
- 105000 power train:driveline
- Summary:
- Driveline information center and troubleshooting procedures
- Bulletin:
- IK0300008
- Component:
- 020000 suspension
- Summary:
- Vibration troubleshooting
- Bulletin:
- IK0700079
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Scr vehicles setting 336316 (fc1713) due to crossed def heater lines or inverted ccv
- Bulletin:
- IK0700082
- Component:
- 110000 electrical system
- Summary:
- N9/n10/n13 aftertreatment fault codes caused by incorrect dpf differential pressure sensor orientation
- Bulletin:
- IK0800080
- Component:
- 110000 electrical system
- Summary:
- 1939 data link troubleshooting
- Bulletin:
- IK0800403
- Component:
- 112000 electrical system:alternator/generator/regulator
- Summary:
- Alternator troubleshooting and diagnostics
- Bulletin:
- IK0800407
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Starter diagnostics and warranty claim procedure
- Bulletin:
- IK0800482
- Component:
- 111000 electrical system:battery
- Summary:
- Battery testing, diagnostics, and maintenance information
- Bulletin:
- IK1201114
- Component:
- 060000 engine and engine cooling
- Summary:
- All vehicles with cummins engines; lubricating oil consumption and acceptable limits
- Bulletin:
- IK1201248
- Component:
- 060000 engine and engine cooling
- Summary:
- Cooling system flush procedure
- Bulletin:
- IK1201279
- Component:
- 060000 engine (pws)
- Summary:
- Fault code 327 (spn 110 fmi 2)
- Bulletin:
- IK0800080
- Component:
- 110000 electrical system
- Summary:
- J1939 data link troubleshooting
- Bulletin:
- IK0800092
- Component:
- 110000 electrical system
- Summary:
- First check to make when troubleshooting any body controller or esc issue
- Bulletin:
- IK0800482
- Component:
- 111000 electrical system:battery
- Summary:
- Battery testing, diagnostics, and maintenance information
- Bulletin:
- IK0800520
- Component:
- 110000 electrical system
- Summary:
- Ground splice 6747 causing multiple fault codes
- Bulletin:
- IK1200921
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Aftertreatment private data link troubleshooting
- Bulletin:
- IK1400005
- Component:
- 022510 suspension:rear:axle:spindle
- Summary:
- This article provides information to properly check driveline angles and driveline runout, and how to use that information to properly repair
- Bulletin:
- IK0100006
- Component:
- 356000 equipment adaptive
- Summary:
- Removal and installation of huckspin huck bolt fasteners
- Bulletin:
- IK0800080
- Component:
- 118000 electrical system: software
- Summary:
- J1939 data link troubleshooting
- Bulletin:
- IK0800151
- Component:
- 110000 electrical system
- Summary:
- Advanced logic request
- Bulletin:
- IK0800407
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Starter diagnostics and warranty claim procedure
- Bulletin:
- IK0800411
- Component:
- 110000 electrical system
- Summary:
- Body controller resource center
- Bulletin:
- IK0800504
- Component:
- 110000 electrical system
- Summary:
- Repair procedures for vehicles struck by lightning
- Bulletin:
- IK1200392
- Component:
- 118000 electrical system: software
- Summary:
- Split shaft pto interfering with programming through nets
- Bulletin:
- IK1200438
- Component:
- 060000 engine (pws)
- Summary:
- Diagnostic trouble code (dtc) 6315, 6317, and 6318
- Bulletin:
- IK1200464
- Component:
- 070000 fuel system, gasoline
- Summary:
- Fuel system diagnostic codes
- Bulletin:
- IK1201043
- Component:
- 060000 engine (pws)
- Summary:
- Icp adaptation reset
- Bulletin:
- IK1201080
- Component:
- 060000 engine (pws)
- Summary:
- Intake air heater test, dtc 62611 and 62618
- Bulletin:
- IK1201086
- Component:
- 060000 engine (pws)
- Summary:
- Egr cooler diagnostics
- Bulletin:
- IK1201096
- Component:
- 060000 engine (pws)
- Summary:
- Lt egr core removal and insertion on prostar model trucks
- Bulletin:
- IK1201113
- Component:
- 060000 engine (pws)
- Summary:
- Ht egr core removal/installation
- Bulletin:
- IK1201279
- Component:
- 060000 engine (pws)
- Summary:
- Fault code 327 (spn 110 fmi 2)
- Bulletin:
- IK1201299
- Component:
- 060000 engine (pws)
- Summary:
- Engine oil capacities
- Bulletin:
- IK1500075
- Component:
- 090000 fuel system, other
- Summary:
- Fuel tank label request process
- Bulletin:
- IK1600117
- Component:
- 160000 structure
- Summary:
- Body and chassis paint guidelines
- Bulletin:
- IK0800403
- Component:
- 112000 electrical system:alternator/generator/regulator
- Summary:
- Alternator troubleshooting and diagnostics
- Bulletin:
- IK0800475
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Radio diagnostics and information
- Bulletin:
- IK1200288
- Component:
- 060000 engine (pws)
- Summary:
- International engine won?t crank
- Bulletin:
- IK1200307
- Component:
- 061120 engine and engine cooling:engine:gasoline:turbo-charger
- Summary:
- Turbocharger unison ring replacement
- Bulletin:
- IK1201150
- Component:
- 060000 engine (pws)
- Summary:
- Injector sleeve replacement
- Bulletin:
- IK0800080
- Component:
- 110000 electrical system
- Summary:
- J1939 data link troubleshooting
- Bulletin:
- IK0800351
- Component:
- 110000 electrical system
- Summary:
- J1939 data link source address information
- Bulletin:
- IK0800374
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- How to get a helios capture; only 1939 and 1708 multiplexed trucks
- Bulletin:
- IK0800403
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Alternator troubleshooting and diagnostics
- Bulletin:
- IK0800080
- Component:
- 110000 electrical system
- Summary:
- 1939 data link troubleshooting
- Bulletin:
- IK0800503
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Isb starting system diagnostics
- Bulletin:
- IK1201202
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Procedure for recording 0-60 mph & lug down test
- Bulletin:
- IK0800080
- Component:
- 118000 electrical system: software
- Summary:
- J1939 data link troubleshooting
- Bulletin:
- IK1200921
- Component:
- 118000 electrical system: software
- Summary:
- Isx, n13, and n9 / n10 aftertreatment private data link troubleshooting
- Bulletin:
- IK1201009
- Component:
- 060000 engine (pws)
- Summary:
- Winter front usage
- Bulletin:
- IK1201299
- Component:
- 060000 engine (pws)
- Summary:
- Engine oil capacities
- Bulletin:
- IK1201356
- Component:
- 103000 power train:automatic transmission
- Summary:
- Engines logging spn 560 fmi 2 when using auto neutral; only trucks with 500k baud rate communication and with auto neutral
- Bulletin:
- IK1201409
- Component:
- 060000 engine (pws)
- Summary:
- Valve train component changes for i6 engines
- Bulletin:
- IK2700100
- Component:
- 118000 electrical system: software
- Summary:
- Oncommand ez-tech
- Bulletin:
- IK4300001
- Component:
- 118000 electrical system: software
- Summary:
- Updating oncommand link with accelerator
- Bulletin:
- IK0500038
- Component:
- 010000 steering
- Summary:
- Steering shake, shimmy, shudder, or steering vibration; only with 14k front weight rated axles and below
- Bulletin:
- IK0500058
- Component:
- 010000 steering
- Summary:
- Steering fluids
- Bulletin:
- IK0700079
- Component:
- 060000 engine and engine cooling
- Summary:
- Scr vehicles setting 3363-16 (fc1713) due to crossed def tank coolant lines or inverted defthv
- Bulletin:
- IK0800080
- Component:
- 118000 electrical system: software
- Summary:
- J1939 data link troubleshooting
- Bulletin:
- IK0800351
- Component:
- 118000 electrical system: software
- Summary:
- J1939 data link source address information
- Bulletin:
- IK1201248
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Cooling system flush procedure
- Bulletin:
- IK0300008
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Vibration troubleshooting (vehicle not moving)
- Bulletin:
- IK0700097
- Component:
- 070000 fuel system, gasoline
- Summary:
- New ultrasonic def tank sending unit; all scr vehicles
- Bulletin:
- IK0800025
- Component:
- 111000 electrical system:battery
- Summary:
- Measuring parasitic battery load
- Bulletin:
- IK1201241
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Ecm calibration for dpf replacement
- Bulletin:
- IK1201255
- Component:
- 062300 engine and engine cooling:cooling system:hose
- Summary:
- High pressure fuel pump and oil fill hose oil leak repair procedure
- Bulletin:
- IK1201360
- Component:
- 060000 engine (pws)
- Summary:
- Cylinder performance analyzer (cpa) resource center
- Bulletin:
- IK1201387
- Component:
- 060000 engine (pws)
- Summary:
- Cpa snapshot viewer: air management test (amt)
- Bulletin:
- IK2500511
- Component:
- 118000 electrical system: software
- Summary:
- Using supplier software to check dtcs
- Bulletin:
- IK0400062
- Component:
- 046000 service brakes, air:antilock
- Summary:
- Navistar hydraulic abs software will not comunicate with abs module; hydraulic abs only
- Bulletin:
- IK0800144
- Component:
- 110000 electrical system
- Summary:
- Injector and glow plug harness change
- Bulletin:
- IK0800148
- Component:
- 060000 engine (pws)
- Summary:
- Engine electrical harness and connector repair kit
- Bulletin:
- IK0800183
- Component:
- 060000 engine (pws)
- Summary:
- Engine sensor harness installation
- Bulletin:
- IK0800080
- Component:
- 110000 electrical system
- Summary:
- J1939 data link troubleshooting
- Bulletin:
- IK1200378
- Component:
- 060000 engine (pws)
- Summary:
- Service engine calibration for active aftertreatment regeneration during pto ( engine speed control) operation
- Bulletin:
- IK0700079
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Scr vehicles setting 3363-16 (fc1713) due to crossed def tank coolant lines or inverted defthv
- Bulletin:
- IK0800351
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- J1939 data link source address information
- Bulletin:
- IK0800374
- Component:
- 118000 electrical system: software
- Summary:
- How to get a helios capture; only 1939 and 1708 multiplexed trucks
- Bulletin:
- IK0800403
- Component:
- 112000 electrical system:alternator/generator/regulator
- Summary:
- Alternator troubleshooting and diagnostics
- Bulletin:
- IK1201252
- Component:
- 072100 fuel system, gasoline:delivery:fuel pump
- Summary:
- Cpa hpfp test
- Bulletin:
- IK1201325
- Component:
- 060000 engine (pws)
- Summary:
- Cpa base engine analysis module (beam): test descriptions and detailed information
- Bulletin:
- IK1201360
- Component:
- 060000 engine (pws)
- Summary:
- Cylinder performance analyzer (cpa) resource center; only models with 2004 thru 2017 international engines.
- Bulletin:
- IK1201363
- Component:
- 070000 fuel system, gasoline
- Summary:
- Cpa injector misfire detection; only models with 2004 thru 2017 international engines.
- Bulletin:
- IK1201369
- Component:
- 060000 engine (pws)
- Summary:
- Cpa base engine analysis module (b.e.a.m) overview
- Bulletin:
- IK1900022
- Component:
- 060000 engine and engine cooling
- Summary:
- A/c refrigerant and oil capacities
- Bulletin:
- IK2500426
- Component:
- 060000 engine (pws)
- Summary:
- A26 extended oil drain interval program
- Bulletin:
- IK2700090
- Component:
- 118000 electrical system: software
- Summary:
- Oncommand ez-tech download center
- Bulletin:
- IK2700100
- Component:
- 118000 electrical system: software
- Summary:
- Oncommand eztech
- Bulletin:
- IK2900030
- Component:
- 118000 electrical system: software
- Summary:
- Dealer ez-tech and diagnostic software support resource center
- Bulletin:
- AFC17902
- Component:
- 021242 suspension:front:springs:leaf spring assembly:hanger,bracket
- Summary:
- To inspect for a gap between the front spring bracket and the lower flange of the frame rails.
- Bulletin:
- IK0800522
- Component:
- 121000 exterior lighting:headlights
- Summary:
- Repair information for damaged headlight connector
- Bulletin:
- IK1201009
- Component:
- 060000 engine (pws)
- Summary:
- Winter front usage
- Bulletin:
- IK1201325
- Component:
- 060000 engine (pws)
- Summary:
- Cpa base engine analysis module (beam): test descriptions and detailed information
- Bulletin:
- IK1201353
- Component:
- 060000 engine (pws)
- Summary:
- Egr cooler kits
- Bulletin:
- IK1201356
- Component:
- 117000 digital instrument panel
- Summary:
- Engines logging spn 560 fmi 2 when using auto neutral; only engines/vehicles with 500k baud rate communication trucks w/ auto neutral
- Bulletin:
- IK1201365
- Component:
- 350000 equipment
- Summary:
- Installation and service of the stainless steel oil pans
- Bulletin:
- IK1201377
- Component:
- 060000 engine and engine cooling
- Summary:
- Cold ambient protection rpm response
- Bulletin:
- IK1201378
- Component:
- 017300 steering:linkages:arm:idler and attachment
- Summary:
- Low idle increment feature no longer supported
- Bulletin:
- IK1201379
- Component:
- 061320 engine and engine cooling:engine:other fuel types:turbo-charger
- Summary:
- Audible turbocharger flutter or engine surge
- Bulletin:
- IK1201380
- Component:
- 060000 engine (pws)
- Summary:
- Fault clearing
- Bulletin:
- IK1201381
- Component:
- 110000 electrical system
- Summary:
- Communication related faults when connecting an electronic service tool (est)
- Bulletin:
- IK1700016
- Component:
- 200000 wheels
- Summary:
- Centrifuge drum best practices; only models with centrifuse drums on steer axle
- Bulletin:
- IK0400153
- Component:
- 046400 service brakes, air:antilock:abs warning light
- Summary:
- Loss of power and abs light iluminated and faults - meritor wabco esc04azx/eaton transmission 13gxk 2622-2 5606-19; only models with feature codes 04azx wabco electronic hsa and 13gxk eaton ultrashift
- Bulletin:
- IK0700079
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- Scr vehicles setting def quality faults due to crossed def tank coolant lines or inverted defthv;
- Bulletin:
- IK0700096
- Component:
- 110000 electrical system
- Summary:
- Urea quality sensor (uqs) supplemental diagnostic and service information; only models with scr aftertreatment system and n9, n10, n13, a26 or cummins isb, isl, isx engines built from january 2016
- Bulletin:
- IK0700097
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- New ultrasonic def tank sending unit; only models with scr aftertreatment system.
- Bulletin:
- IK0800546
- Component:
- 060000 engine and engine cooling
- Summary:
- Hvac fault 2609-19 with 4th gen bcm; only models equipped with 4th generation bcm
- Bulletin:
- IK1201338
- Component:
- 060000 engine (pws)
- Summary:
- Oil pump bushing replacement procedure
- Bulletin:
- IK1201365
- Component:
- 350000 equipment
- Summary:
- Installation and service of the stainless steel oil pans
- Bulletin:
- IK1201394
- Component:
- 060000 engine (pws)
- Summary:
- Clearing repeat 1569-31 inducement faults with navistar engine diagnostics
- Bulletin:
- IK2600225
- Component:
- 110000 electrical system
- Summary:
- Engine module programming; only units with 500k baud communications
- Bulletin:
- IK0300008
- Component:
- 021230 suspension:front:springs:air suspension system
- Summary:
- Vibration troubleshooting (vehicle not moving)
- Bulletin:
- IK0400088
- Component:
- 030000 brakes (pws)
- Summary:
- Brake single hot wheel end service procedure
- Bulletin:
- IK0600020
- Component:
- 105000 power train:driveline
- Summary:
- Determine wheel speed or driveline vibration using a smart phone and free vibsensor application
- Bulletin:
- IK0700079
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Scr vehicles setting def quality faults due to crossed def tank coolant lines or inverted defthv; only vehicles with scr.
- Bulletin:
- IK0700096
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Urea quality sensor (uqs) supplemental diagnostic and service information; only models built january 2016 and later
- Bulletin:
- IK0800374
- Component:
- 110000 electrical system
- Summary:
- How to get a helios capture; only models with 1939 and 1708 multiplexed trucks
- Bulletin:
- IK1201252
- Component:
- 070000 fuel system, gasoline
- Summary:
- Cpa high pressure fuel pump (hpfp) test
- Bulletin:
- IK1201258
- Component:
- 060000 engine and engine cooling
- Summary:
- Catastrophic doc and dpf failures
- Bulletin:
- IK1201325
- Component:
- 060000 engine and engine cooling
- Summary:
- Cpa base engine analysis module (beam): test descriptions and detailed information
- Bulletin:
- IK1201339
- Component:
- 060000 engine and engine cooling
- Summary:
- Def tank leakage; only models with international n9, n10, n13 or cummins isb, isx engines
- Bulletin:
- IK1201353
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Egr cooler kits
- Bulletin:
- IK2700065
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Ez-tech download center
- Bulletin:
- IK2700090
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Oncommand ez-tech download center
- Bulletin:
- IK2700100
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Oncommand ez-tech
- Bulletin:
- IK2800175
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Flood inspection guidelines for vehicles or engines
- Bulletin:
- IK0400062
- Component:
- 030000 brakes (pws)
- Summary:
- Navistar hydraulic abs software will not comunicate with abs module.
- Bulletin:
- IK0800475
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Radio diagnostics and information
- Bulletin:
- IK1200502
- Component:
- 060000 engine and engine cooling
- Summary:
- Engine vibration
- Bulletin:
- IK1200704
- Component:
- 060000 engine and engine cooling
- Summary:
- Engine flushing procedure due to lubrication system contamination
- Bulletin:
- IK1200763
- Component:
- 060000 engine and engine cooling
- Summary:
- Dtc 1268/1284 diagnostics
- Bulletin:
- IK1200921
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Aftertreatment private data link troubleshooting
- Bulletin:
- IK1200938
- Component:
- 060000 engine and engine cooling
- Summary:
- High pressure turbo center section replacement.
- Bulletin:
- IK1200991
- Component:
- 060000 engine and engine cooling
- Summary:
- Diagnosing hard start / no start, rough idle complaints or icp pressure concerns with the cpa tool
- Bulletin:
- IK1201013
- Component:
- 060000 engine and engine cooling
- Summary:
- Fault monitor updates; only engines with hd-obd feature
- Bulletin:
- IK1201048
- Component:
- 060000 engine and engine cooling
- Summary:
- Dtc 190-0 engine overspeed vehicle event fault
- Bulletin:
- IK1201061
- Component:
- 060000 engine and engine cooling
- Summary:
- Spn 3055 fmi 0 frp exceeded maximum troubleshooting
- Bulletin:
- IK1201063
- Component:
- 060000 engine and engine cooling
- Summary:
- Spn 3055 fmi 15 frp below minimum troubleshooting
- Bulletin:
- IK1201100
- Component:
- 060000 engine and engine cooling
- Summary:
- Spn 2659 fmi 21 egr low flow
- Bulletin:
- IK1201106
- Component:
- 060000 engine and engine cooling
- Summary:
- Dtc spn 629 fmi 8 ecm error - engine off timer fault active; only engines with hd-obd feature
- Bulletin:
- IK1201113
- Component:
- 060000 engine and engine cooling
- Summary:
- High temp egr core removal/installation
- Bulletin:
- IK1201117
- Component:
- 063110 engine and engine cooling:exhaust system:emission control:crankcase (pcv)
- Summary:
- Open crankcase breather
- Bulletin:
- IK1201142
- Component:
- 060000 engine and engine cooling
- Summary:
- Leaklocator diagnostic procedures
- Bulletin:
- IK1201150
- Component:
- 060000 engine and engine cooling
- Summary:
- Injector sleeve replacement
- Bulletin:
- IK1201174
- Component:
- 060000 engine and engine cooling
- Summary:
- Step-based diagnostics for spn 164 fmi 0 and icp sensor diagnostics
- Bulletin:
- IK1201175
- Component:
- 060000 engine and engine cooling
- Summary:
- Charge air cooler cleaning procedure
- Bulletin:
- IK1201196
- Component:
- 060000 engine and engine cooling
- Summary:
- Diagnostics for spn 3251 fmi 21 dpfdp excessively low (sensor/circuit fault or missing dpf)
- Bulletin:
- IK1201213
- Component:
- 070000 fuel system, gasoline
- Summary:
- Dtc 3055 fuel system diagnostics
- Bulletin:
- IK1201216
- Component:
- 060000 engine and engine cooling
- Summary:
- Leaklocator diagnostic procedure heavy duty
- Bulletin:
- IK1201218
- Component:
- 060000 engine and engine cooling
- Summary:
- Internal coolant leak diagnostics
- Bulletin:
- IK1201222
- Component:
- 060000 engine and engine cooling
- Summary:
- Misfire diagnostics
- Bulletin:
- REC14513
- Component:
- 350000 equipment
- Summary:
- Safety triangle kits sold as aftermarket parts only from 15 august 2012 through 25 july 2014 as international® part number flttrikit3 do not comply with federal motor vehicle safety standard 125
- Bulletin:
- IK0800482
- Component:
- 111000 electrical system:battery
- Summary:
- Battery testing, diagnostics, and maintenance information
- Bulletin:
- IK1200335
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Trouble code 3338
- Bulletin:
- IK1200909
- Component:
- 061120 engine and engine cooling:engine:gasoline:turbo-charger
- Summary:
- Complete turbocharger replacement guidelines
- Bulletin:
- IK1201241
- Component:
- 060000 engine and engine cooling
- Summary:
- Ecm calibration for dpf replacement
- Bulletin:
- IK1201314
- Component:
- 350000 equipment
- Summary:
- Performing rct (relative compression test) and misfire test with cpa tool
- Bulletin:
- IK1200033
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- Dpf (diesel particulate filter) operating conditions and parked regeneration process on 2007 epa emission vehicles
- Bulletin:
- IK1200069
- Component:
- 110000 electrical system
- Summary:
- Engine won't shut off with the key 5 amp fuse blowing
- Bulletin:
- IK1200073
- Component:
- 060000 engine and engine cooling
- Summary:
- Dtc 242 or vss codes in cummins; only with cummins engines and automatic transmissions
- Bulletin:
- IK1200098
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- Reports engine overheat on 2007 epa engines. hest ( high exhaust system temperature) lamp on being misdiagnosed as engine overheat condition; all 2007 epa emission engine vehicles with hest lamp.
- Bulletin:
- IK1200099
- Component:
- 100000 power train
- Summary:
- Code 1113, 1135, 1134 or 1112 ecm / idm power (clean power fuses blowing) or aps codes
- Bulletin:
- IK1200126
- Component:
- 060000 engine and engine cooling
- Summary:
- Valve train damage repair procedure
- Bulletin:
- IK1200131
- Component:
- 061120 engine and engine cooling:engine:gasoline:turbo-charger
- Summary:
- Turbocharger to cac hose coming off - cac hose clamp alignment and torque update
- Bulletin:
- IK1200163
- Component:
- 061320 engine and engine cooling:engine:other fuel types:turbo-charger
- Summary:
- Updated evrt/vgt turbocharger diagnostics check sheet and repair procedures for engines that exibit dtc 353 / 354
- Bulletin:
- IK1200166
- Component:
- 060000 engine (pws)
- Summary:
- Replacing terminal pins on the single box (dlc) engine controller (ecm) chassis harness connector
- Bulletin:
- IK1200193
- Component:
- 062200 engine and engine cooling:cooling system:fan
- Summary:
- Engine fan troubleshooting; only with with on / off fans
- Bulletin:
- IK1200194
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- The default cummins ecm password on new trucks; only models equipped with cummins engines
- Bulletin:
- IK1200288
- Component:
- 063110 engine and engine cooling:exhaust system:emission control:crankcase (pcv)
- Summary:
- International engine won?t crank; with international engine only
- Bulletin:
- IK1200344
- Component:
- 110000 electrical system
- Summary:
- Dtc 1373 during actuator test
- Bulletin:
- IK1200357
- Component:
- 062200 engine and engine cooling:cooling system:fan
- Summary:
- Horton 2 speed drive master fan clutch missing or loose magnets; only with maxxforce dt, 9 and 10 engines and feature 12tht horton drive master 2 speed fan clutch
- Bulletin:
- IK1200376
- Component:
- 103000 power train:automatic transmission
- Summary:
- Stumble or misfire on acceleration and setting cam codes on i6 engines
- Bulletin:
- IK1200378
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Service engine calibration for active aftertreatment regeneration during pto ( engine speed control) operation
- Bulletin:
- IK1200398
- Component:
- 061120 engine and engine cooling:engine:gasoline:turbo-charger
- Summary:
- Borg warner turbocharger flange kit; engines with borg warner turbochargers
- Bulletin:
- IK1200404
- Component:
- 080000 fuel system, diesel
- Summary:
- Misfire, rough idle and poor performance
- Bulletin:
- IK1200437
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- Experiencing an air leak at the egr control valve
- Bulletin:
- IK1200442
- Component:
- 061120 engine and engine cooling:engine:gasoline:turbo-charger
- Summary:
- Diagnosing low power and turbocharger replacement or repair
- Bulletin:
- IK1200444
- Component:
- 060000 engine (pws)
- Summary:
- Camshaft and lifter service guidelines
- Bulletin:
- IK1200453
- Component:
- 060000 engine (pws)
- Summary:
- Prelubing an i6 engine with engine oil after engine rebuild
- Bulletin:
- IK1200463
- Component:
- 060000 engine (pws)
- Summary:
- Front engine power take off (fepto) mounting adapter sizing
- Bulletin:
- IK1200464
- Component:
- 080000 fuel system, diesel
- Summary:
- Fuel system diagnostic codes and diagnostic steps
- Bulletin:
- IK1200468
- Component:
- 110000 electrical system
- Summary:
- Procedure to clear active fault 2698
- Bulletin:
- IK1200469
- Component:
- 060000 engine (pws)
- Summary:
- Oil leaking out of road draft tube
- Bulletin:
- IK1200475
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Red error reading for the exhaust back pressure (ebp) in servicemaxx
- Bulletin:
- IK1200478
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- On vehicle doc cleaning
- Bulletin:
- IK1200480
- Component:
- 092300 fuel system, other:fuel filter
- Summary:
- High pressure pump assembly inlet filter service kit
- Bulletin:
- IK1200494
- Component:
- 063110 engine and engine cooling:exhaust system:emission control:crankcase (pcv)
- Summary:
- Repair procedure for oil leak on at the crankcase centrifugal breather assembly
- Bulletin:
- IK1200502
- Component:
- 060000 engine (pws)
- Summary:
- Engine vibration
- Bulletin:
- IK1200508
- Component:
- 110000 electrical system
- Summary:
- Experiencing dtc 1628 lambda sensor adaption procedure
- Bulletin:
- IK1200535
- Component:
- 061320 engine and engine cooling:engine:other fuel types:turbo-charger
- Summary:
- Diagnosing turbocharger oil discharge
- Bulletin:
- IK1200562
- Component:
- 061320 engine and engine cooling:engine:other fuel types:turbo-charger
- Summary:
- Turbocharger mounting bolts
- Bulletin:
- IK1200598
- Component:
- 350000 equipment
- Summary:
- Chassis mounted oil centrifuge filter diagnostics (air & oil leaks)
- Bulletin:
- IK1200619
- Component:
- 073200 fuel system, gasoline:fuel injection system:injectors
- Summary:
- Injector driver module (idm) bottom kit
- Bulletin:
- IK1200633
- Component:
- 060000 engine (pws)
- Summary:
- High fuel temperature
- Bulletin:
- IK1200636
- Component:
- 060000 engine (pws)
- Summary:
- Engine calibration releases
- Bulletin:
- IK1200642
- Component:
- 080000 fuel system, diesel
- Summary:
- Fuel pressure adaptation reset feature
- Bulletin:
- IK1200649
- Component:
- 050000 parking brake
- Summary:
- Pto parking brake interlock feature
- Bulletin:
- IK1200707
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Service support information for the maxxforce diesel engines; workhorse custom chassis models only
- Bulletin:
- IK1200739
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- Egr valve - spn 27 fmi 7 and spn 27 fmi 4
- Bulletin:
- IK1200799
- Component:
- 060000 engine (pws)
- Summary:
- Oil filter kit packaging change
- Bulletin:
- IK1200816
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Parked regeneration failed
- Bulletin:
- IK1200930
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Breather replacement strategy; only hd-obd engines
- Bulletin:
- IK1200938
- Component:
- 061320 engine and engine cooling:engine:other fuel types:turbo-charger
- Summary:
- Replacement procedure for high-pressure turbocharger center section; only hd-obd engines
- Bulletin:
- IK1201004
- Component:
- 070000 fuel system, gasoline
- Summary:
- Electric fuel pump step-based diagnostics
- Bulletin:
- IK1201013
- Component:
- 110000 electrical system
- Summary:
- Obd ghost codes; only with with obd (onboard diagnostics)
- Bulletin:
- IK1201028
- Component:
- 060000 engine (pws)
- Summary:
- Calibration update - fault monitor updates; only hd-obd engines
- Bulletin:
- IK1201043
- Component:
- 093000 fuel system, other:fuel injection system
- Summary:
- Icp adaptation reset
- Bulletin:
- IK1201048
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Dtc 190-0 engine overspeed vehicle event fault
- Bulletin:
- IK1201061
- Component:
- 073100 fuel system, gasoline:fuel injection system:fuel rail
- Summary:
- Spn 3055 fmi 0 frp exceeded maximum troubleshooting
- Bulletin:
- IK1201062
- Component:
- 073100 fuel system, gasoline:fuel injection system:fuel rail
- Summary:
- Spn 3055 fmi 1 no start due to low rail fuel pressure troubleshooting
- Bulletin:
- IK1201064
- Component:
- 073100 fuel system, gasoline:fuel injection system:fuel rail
- Summary:
- Spn 3055 fmi 17 frp above maximum with minimum command troubleshooting
- Bulletin:
- IK1201065
- Component:
- 060000 engine (pws)
- Summary:
- Spn 724 fmi 20: oxygen (o2) sensor diagnostic
- Bulletin:
- IK1201073
- Component:
- 061320 engine and engine cooling:engine:other fuel types:turbo-charger
- Summary:
- Turbo cartridge replacement
- Bulletin:
- IK1201075
- Component:
- 060000 engine (pws)
- Summary:
- Intake throttle valve causing regen issues
- Bulletin:
- IK1500002
- Component:
- 080000 fuel system, diesel
- Summary:
- Fuel level not equal between tanks on dual draw dual return dual tank systems.
- Bulletin:
- IK1500075
- Component:
- 070000 fuel system, gasoline
- Summary:
- Fuel tank label request process
- Bulletin:
- IK2500095
- Component:
- 060000 engine and engine cooling
- Summary:
- Breather replacement
- Bulletin:
- IK0800403
- Component:
- 112000 electrical system:alternator/generator/regulator
- Summary:
- Alternator troubleshooting and diagnostics
- Bulletin:
- IK1200378
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Service engine calibration for active aftertreatment regeneration during pto ( engine speed control) operation
- Bulletin:
- IK1200915
- Component:
- 350000 equipment
- Summary:
- Valve bridges falling off
- Bulletin:
- IK1200991
- Component:
- 060000 engine (pws)
- Summary:
- Diagnosing hard start / no start complaints or icp pressure concerns with the cpa tool
- Bulletin:
- IK1201012
- Component:
- 060000 engine (pws)
- Summary:
- Dtc - 731-16/18 knock detected; only with the latest 3.15 software level (calibration id xxxxarxx or higher)
- Bulletin:
- IK1201028
- Component:
- 060000 engine (pws)
- Summary:
- (obd) maxxforce dt/9/10 calibration update - fault monitor updates
- Bulletin:
- IK1201043
- Component:
- 073000 fuel system, gasoline:fuel injection system
- Summary:
- Icp adaptation reset
- Bulletin:
- IK1201062
- Component:
- 073100 fuel system, gasoline:fuel injection system:fuel rail
- Summary:
- Spn 3055 fmi 1 no start due to low rail fuel pressure troubleshooting
- Bulletin:
- IK1201066
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Coolant consumption and spn-111 fmi-1
- Bulletin:
- IK1201089
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Coolant in the exhaust
- Bulletin:
- IK1201090
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Coolant in the intake
- Bulletin:
- IK1201091
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Coolant leak to the lube oil
- Bulletin:
- IK1201105
- Component:
- 060000 engine (pws)
- Summary:
- I-6 engine hydro-locked
- Bulletin:
- IK1201106
- Component:
- 060000 engine (pws)
- Summary:
- Dtc spn 629 fmi 8 ecm error - engine off timer fault active
- Bulletin:
- IK1300017
- Component:
- 100000 power train
- Summary:
- Pto on the eaton aws transmission engages, but will not run under load; only with feature 13gmk (asw ultra shift transmission).
- Bulletin:
- IK1300019
- Component:
- 100000 power train
- Summary:
- Required pto wiring automatic transmission feature code 13adl
- Bulletin:
- IK1300021
- Component:
- 102000 power train:manual transmission
- Summary:
- Transmission keeps shifting and display keeps flashing after ignition is turned off; only with freedom line transmission
- Bulletin:
- IK1300039
- Component:
- 102000 power train:manual transmission
- Summary:
- Harsh upshifts; only with allison at/mt transmissions with international t444e, dt 466e and 530e engines
- Bulletin:
- IK1300049
- Component:
- 102000 power train:manual transmission
- Summary:
- Circuit and installation diagrams for 5000; only with allison gen 3 hd transmission
- Bulletin:
- IK1300051
- Component:
- 100000 power train
- Summary:
- Circuit and installation diagrams for 5000; only models with the allison gen 4 hd transmission manufactured after april 2, 2006.
- Bulletin:
- IK1300068
- Component:
- 100000 power train
- Summary:
- 5r110 transmission troubleshooting
- Bulletin:
- IK1300069
- Component:
- 100000 power train
- Summary:
- Vehicle speed ( vss ) surge in cruise control or when shifting transmission from high to low range; only models with transfer case.
- Bulletin:
- IK1400033
- Component:
- 023100 suspension:multiple axle:torque arm
- Summary:
- Torque change for 5/8 inch rear axle shaft flange mounting stud with cone locks and flat washer type hardware.
- Bulletin:
- TSI 141203
- Component:
- 061320 engine and engine cooling:engine:other fuel types:turbo-charger
- Summary:
- Turbo oil supply tube retrofit
- Bulletin:
- IK0200023
- Component:
- 020000 suspension
- Summary:
- Navistar wheel alignment policy
- Bulletin:
- IK0800219
- Component:
- 110000 electrical system
- Summary:
- Accelerator position sensor/idlevalidation switch aps / ivs diagnostics navpak; only cec equipped engine control systems
- Bulletin:
- IK0800223
- Component:
- 110000 electrical system
- Summary:
- Accelerator position sensor/idle validation switch aps / ivs diagnostics dlcii equipped engine control systems
- Bulletin:
- IK0800361
- Component:
- 110000 electrical system
- Summary:
- Bluetooth stereo adapter infromation; only bluetooth equipped units
- Bulletin:
- IK0800393
- Component:
- 102000 power train:manual transmission
- Summary:
- Cluster voltage gauge and or all cluster gauges freeze.
- Bulletin:
- IK0800455
- Component:
- 123000 exterior lighting:tail lights
- Summary:
- Stop/turn/tail lamp improvement; light part numbers: tl40229r
- Bulletin:
- IK0800460
- Component:
- 110000 electrical system
- Summary:
- Rear chassis wiring harness - replacemet harness
- Bulletin:
- IK0900017
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Coolant fill procedure (pre- 2010 emissions)
- Bulletin:
- IK0900028
- Component:
- 060000 engine and engine cooling
- Summary:
- Service information new shell rotella ultra extended life coolant (elc) used in epa 2010 compliant and newer maxxforce 11, 13, and 15 engines
- Bulletin:
- IK0900064
- Component:
- 060000 engine and engine cooling
- Summary:
- Charge air cooler (cac) leak test (air decay test); only vehicles whose ewngines are equipped with charge air coolers.
- Bulletin:
- IK1200146
- Component:
- 060000 engine (pws)
- Summary:
- Engine will not crank (crank inhibit); only models built prior to march 18,2013 and equipped with maxxforce engines.
- Bulletin:
- IK1200309
- Component:
- 060000 engine (pws)
- Summary:
- Dt466/530 piston pin boss scuffing; engine s/n 1,194,039 thru 2,000,000
- Bulletin:
- IK1200422
- Component:
- 060000 engine (pws)
- Summary:
- How to reset the service interval (oil change) light; all models equipped with maxxforce engines only
- Bulletin:
- IK1200476
- Component:
- 060000 engine (pws)
- Summary:
- Experiencing low power after programming the ecm.
- Bulletin:
- IK1200481
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Aftertreatment soot level reset after afi, dpf or doc cleaning or replacement
- Bulletin:
- IK1200719
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Thermal management valve kit programmable parameter information; only engine s/n 5306833 and up.
- Bulletin:
- IK1200739
- Component:
- 060000 engine (pws)
- Summary:
- Spn 27 fmi 7 egrp does not agree with commanded position
- Bulletin:
- IK1200768
- Component:
- 060000 engine (pws)
- Summary:
- Boost leak at the intake throttle valve housing; retired - info has moved to ik1200969
- Bulletin:
- IK1200812
- Component:
- 060000 engine (pws)
- Summary:
- Diagnosing performance related symptoms using the cpa tool
- Bulletin:
- IK1200839
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Aftertreatment service
- Bulletin:
- IK1200857
- Component:
- 060000 engine (pws)
- Summary:
- Cpa or buzz test showing three (3) failed injectors
- Bulletin:
- IK1200909
- Component:
- 061320 engine and engine cooling:engine:other fuel types:turbo-charger
- Summary:
- High pressure turbocharger service plan information
- Bulletin:
- IK1200930
- Component:
- 060000 engine (pws)
- Summary:
- Breather replacement strategy
- Bulletin:
- IK1200937
- Component:
- 060000 engine (pws)
- Summary:
- Oil filter bypass slug in oil filter housing
- Bulletin:
- IK1200948
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- High temperature exhaust gas recirculation cooler housing (ht egrc) to mid-plate alignment
- Bulletin:
- IK1200949
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Guide to i-6 exhaust system conditions and operating characteristics
- Bulletin:
- IK1200955
- Component:
- 060000 engine (pws)
- Summary:
- Spn 651 fmi 7- injector 1 spool motion compensation max authority reached; only 2013 hd-obd engines
- Bulletin:
- IK1200961
- Component:
- 060000 engine (pws)
- Summary:
- High pressure fuel supply line broken / leaking
- Bulletin:
- IK1200962
- Component:
- 060000 engine and engine cooling
- Summary:
- Cold side egr cooler replacement
- Bulletin:
- IK1200964
- Component:
- 061320 engine and engine cooling:engine:other fuel types:turbo-charger
- Summary:
- Turbo wastegate actuator replacement
- Bulletin:
- IK1200965
- Component:
- 061320 engine and engine cooling:engine:other fuel types:turbo-charger
- Summary:
- Maxxforce 7 turbo cleaning
- Bulletin:
- IK1200966
- Component:
- 060000 engine (pws)
- Summary:
- Dpf soot load reset procedure
- Bulletin:
- IK1200969
- Component:
- 060000 engine (pws)
- Summary:
- Engine throttle valve (etv)
- Bulletin:
- IK1200972
- Component:
- 050000 parking brake
- Summary:
- Parked regen convenience feature
- Bulletin:
- IK1201004
- Component:
- 092100 fuel system, other:delivery:fuel pump
- Summary:
- Electric fuel pump diagnostic tips
- Bulletin:
- IK1900197
- Component:
- 353600 equipment:air conditioner
- Summary:
- A/c compressor failures and repair practices
- Bulletin:
- TSI-131218
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- High temperature exhaust gas recirculation (egr) cooler housing to mid-plate alignment
- Bulletin:
- IK0700003
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Exhaust modifications on 2007 emmissions engines
- Bulletin:
- IK0700030
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Determining a dpf?s health on a used vehicle
- Bulletin:
- IK0700031
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Dpf cleaning or replacement warranty
- Bulletin:
- IK0700032
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Dpf snap accel test - quick test
- Bulletin:
- IK0700035
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Dpf replacement-critical steps for technicians
- Bulletin:
- IK0700058
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Exhaust leak troubleshooting for epa 2010 emission engines
- Bulletin:
- IK0800004
- Component:
- 110000 electrical system
- Summary:
- Finding the location of my vehicles relays, switches, connectors and fuse blocks
- Bulletin:
- IK0800364
- Component:
- 110000 electrical system
- Summary:
- Sart module diagnostics
- Bulletin:
- IK0800470
- Component:
- 110000 electrical system
- Summary:
- Ensure accurate battery test results when using midtronics tester
- Bulletin:
- IK0900006
- Component:
- 354000 equipment:mechanical
- Summary:
- Aeroquip stc hydraulic push to connect fitting; only models with aeroquip hydraulic stc fittings,
- Bulletin:
- IK0900043
- Component:
- 060000 engine and engine cooling
- Summary:
- Using shell rotella® red extended life coolant; all vehicles with 2010 maxxforce 11, 13, and 15 engines
- Bulletin:
- IK1200433
- Component:
- 060000 engine and engine cooling
- Summary:
- Variable geometry turbo: supplemental diagnostics; only with serial number range 3000000 through 3299999.
- Bulletin:
- IK1200492
- Component:
- 060000 engine and engine cooling
- Summary:
- No base engine oil pressure
- Bulletin:
- IK1200557
- Component:
- 060000 engine and engine cooling
- Summary:
- Turbo drain line relocation after servicing
- Bulletin:
- IK1200571
- Component:
- 060000 engine and engine cooling
- Summary:
- Mil lamp on after cold start cold start assist diagnostics; only with sn 4100000 and higher
- Bulletin:
- IK1200598
- Component:
- 060000 engine and engine cooling
- Summary:
- Oil centrifuge filter diagnostics
- Bulletin:
- IK1200838
- Component:
- 060000 engine and engine cooling
- Summary:
- Pre-doc mounting clamp broken or missing
- Bulletin:
- IK1200921
- Component:
- 353000 equipment:electrical
- Summary:
- Aftertreatment private data link troubleshooting
- Bulletin:
- IK1200973
- Component:
- 060000 engine and engine cooling
- Summary:
- Engine low mount fan drive service strategy; only models equipped with low mount fan drive
- Bulletin:
- IK1200990
- Component:
- 070000 fuel system, gasoline
- Summary:
- Fuel dilution diagnostics
- Bulletin:
- IK1201007
- Component:
- 060000 engine and engine cooling
- Summary:
- Engine frequent regen issues
- Bulletin:
- IK1201015
- Component:
- 350000 equipment
- Summary:
- New case file layout for dealers and fleet users
- Bulletin:
- IK1201028
- Component:
- 060000 engine and engine cooling
- Summary:
- Obd calibration update; only engine s/n 3500000 and up
- Bulletin:
- IK1201029
- Component:
- 060000 engine and engine cooling
- Summary:
- Spn 629 fmi 0 -ecm cpu load code after calibration update; only engine s/n 3500000 and up
- Bulletin:
- IK1201040
- Component:
- 070000 fuel system, gasoline
- Summary:
- Afi fuel supply line rubbing and/or spn 3556 fmi 7 codes after dealer service
- Bulletin:
- IK1201043
- Component:
- 353000 equipment:electrical
- Summary:
- Icp adaptation reset
- Bulletin:
- IK1201044
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Egr cooler leak test tool leaking
- Bulletin:
- IK1201046
- Component:
- 110000 electrical system
- Summary:
- N13 aftertreatment wiring and component locations
- Bulletin:
- IK0400140
- Component:
- 060000 engine and engine cooling
- Summary:
- Air compressor retrofit; only models equipped with feature code 004spl
- Bulletin:
- IK0500058
- Component:
- 010000 steering
- Summary:
- Steering fluids
- Bulletin:
- IK1201016
- Component:
- 060000 engine and engine cooling
- Summary:
- Ecm diagnostics with the programming station
- Bulletin:
- IK0200003
- Component:
- 106000 power train:axle assembly
- Summary:
- Steer axle alignment
- Bulletin:
- IK0700035
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Dpf replacement-critical steps for technicians
- Bulletin:
- IK0700058
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Exhaust leak troubleshooting
- Bulletin:
- IK0800380
- Component:
- 111000 electrical system:battery
- Summary:
- Maintaining batteries during vehicle storage
- Bulletin:
- IK1200321
- Component:
- 060000 engine and engine cooling
- Summary:
- Engine that has dtc 525 active during cold startup or a 525 inactive during no start
- Bulletin:
- IK1200422
- Component:
- 060000 engine and engine cooling
- Summary:
- How to reset the service interval (oil change) light
- Bulletin:
- IK1200596
- Component:
- 110000 electrical system
- Summary:
- 4766-10 dpf regeneration feedback fault
- Bulletin:
- IK1200744
- Component:
- 060000 engine and engine cooling
- Summary:
- Low oil pressure
- Bulletin:
- IK1200812
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Diagnosing performance related symptoms using the cpa tool
- Bulletin:
- IK1200873
- Component:
- 136000 visibility:windshield wiper/washer
- Summary:
- Washers addition to water pump pulley bolts
- Bulletin:
- IK1200894
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Aftertreatment service
- Bulletin:
- IK1200904
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Spn 173 fmi 0/1 egt diagnostic trouble codes
- Bulletin:
- IK1200908
- Component:
- 070000 fuel system, gasoline
- Summary:
- Fuel in oil worksheet
- Bulletin:
- IK1200909
- Component:
- 061120 engine and engine cooling:engine:gasoline:turbo-charger
- Summary:
- Hp turbocharger center section replacement
- Bulletin:
- TSI-131203
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Manual compression test
- Bulletin:
- IK0800403
- Component:
- 112000 electrical system:alternator/generator/regulator
- Summary:
- Alternator diagnostics and warranty claim documentation
- Bulletin:
- IK0800407
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Starter diagnostics and warranty claim procedure
- Bulletin:
- IK0900071
- Component:
- 110000 electrical system
- Summary:
- Horton stratis fan hub wiring harness re-route procedure; only models with feature code 12thx vmaster ultra (stratis ) viscous fan drive
- Bulletin:
- IK1200709
- Component:
- 060000 engine and engine cooling
- Summary:
- Egr inner and/or outer bellows tube cracked; only engine esn: 4100000 and up
- Bulletin:
- IK1200815
- Component:
- 102000 power train:manual transmission
- Summary:
- Eaton automated manual shifting issues after programming; only models equipped with maxxforce dt, 9, 10 engines and eaton automated manual transmission
- Bulletin:
- IK1200822
- Component:
- 060000 engine and engine cooling
- Summary:
- Under the valve cover icp leak testing
- Bulletin:
- IK1200824
- Component:
- 060000 engine and engine cooling
- Summary:
- Diagnosing spn 3055 fmi 15 - frp below minimum with maximum command
- Bulletin:
- IK1200825
- Component:
- 060000 engine and engine cooling
- Summary:
- Diagnosing spn 3055 fmi 17 - frp above maximum with minimum command
- Bulletin:
- IK1201237
- Component:
- 061120 engine and engine cooling:engine:gasoline:turbo-charger
- Summary:
- Turbocharger oil supply tube retrofit
- Bulletin:
- IK1201241
- Component:
- 060000 engine and engine cooling
- Summary:
- Ecm calibration for dpf replacement
- Bulletin:
- IK1201344
- Component:
- 060000 engine and engine cooling
- Summary:
- Power cylinder replacement process
- Bulletin:
- IK0700051
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- Rear exhaust manifold leak
- Bulletin:
- IK0900071
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Horton stratis fan hub wiring harness re-route procedure; only models with feature code 12thx vmaster ultra (stratis ) viscous fan drive
- Bulletin:
- IK0900075
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Horton stratis fan hub diagnostics; only models with feature code 12thx vmaster ultra (stratis ) viscous fan drive
- Bulletin:
- IK1200013
- Component:
- 060000 engine and engine cooling
- Summary:
- Engine starts when cold but not when it warms up. diagnosing an injection control pressure (icp) system leak - dtc 333 335
- Bulletin:
- IK1200113
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Diagnostic trouble code index (dtc)
- Bulletin:
- IK1200375
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Diagnostic trouble codes (dtc)
- Bulletin:
- IK1200776
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Understanding used oil analysis
- Bulletin:
- IK1200855
- Component:
- 060000 engine and engine cooling
- Summary:
- Eliminate harness rubbing at ecm bracket; only engines built prior to 9/1/2012
- Bulletin:
- IK1500066
- Component:
- 070000 fuel system, gasoline
- Summary:
- Electric fuel pump and low pressure fuel system diagnostics
- Bulletin:
- IK1200834
- Component:
- 060000 engine and engine cooling
- Summary:
- Maf calibration due to ecm reflash
- Bulletin:
- IK1200835
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Driver rewards not working properly
- Bulletin:
- IK1200838
- Component:
- 060000 engine and engine cooling
- Summary:
- Pdoc clamp
- Bulletin:
- IK1200839
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Aftertreatment service
- Bulletin:
- IK1200842
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- How to read engine oil dipstick properly
- Bulletin:
- IK1200844
- Component:
- 060000 engine and engine cooling
- Summary:
- Spn 190 fmi 0 engine over-speed most severe level
- Bulletin:
- IK1300068
- Component:
- 100000 power train
- Summary:
- Tranmission troubleshooting
- Bulletin:
- IK0100010
- Component:
- 021240 suspension:front:springs:leaf spring assembly
- Summary:
- Chassis lean correction
- Bulletin:
- IK0200023
- Component:
- 020000 suspension
- Summary:
- Navistar wheel alignment policy
- Bulletin:
- IK0400107
- Component:
- 030000 brakes (pws)
- Summary:
- Brake noise, squeal or chatter
- Bulletin:
- IK0800463
- Component:
- 110000 electrical system
- Summary:
- High or spiking voltage; only models with feature codes 08gxd; 08gxe; 08gxc; 08gxb - leece-neville alternator using remote voltage sense
- Bulletin:
- IK0800470
- Component:
- 111000 electrical system:battery
- Summary:
- Ensure accurate battery test results when using midtronics tester
- Bulletin:
- IK1200596
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- 4766-10 dpf regeneration feedback fault
- Bulletin:
- IK1200753
- Component:
- 060000 engine (pws)
- Summary:
- Hydrocarbon injector & housing cleaning procedure (afi plugging)
- Bulletin:
- IK1200776
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Understanding used oil analysis
- Bulletin:
- IK1200839
- Component:
- 060000 engine (pws)
- Summary:
- Aftertreatment service
- Bulletin:
- IK1200908
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Fuel in oil worksheet
- Bulletin:
- IK1200953
- Component:
- 060000 engine (pws)
- Summary:
- No start due to low ecm voltage
- Bulletin:
- IK1201004
- Component:
- 070000 fuel system, gasoline
- Summary:
- Electric fuel pump diagnostic tips
- Bulletin:
- IK1201015
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- New case file layout for dealers and fleet users
- Bulletin:
- IK1201016
- Component:
- 060000 engine (pws)
- Summary:
- Ecm diagnostics with the programming station
- Bulletin:
- IK1201017
- Component:
- 060000 engine (pws)
- Summary:
- Jake brake diagnostis
- Bulletin:
- IK1201029
- Component:
- 060000 engine (pws)
- Summary:
- Spn 629 fmi 0 -ecm cpu load code after calibration update; only engines with obd (onboard diagnostics) - engine s/n 3500000 and up
- Bulletin:
- IK1400005
- Component:
- 105000 power train:driveline
- Summary:
- Driveline vibration troubleshooting procedure
- Bulletin:
- IK1600203
- Component:
- 162800 structure:body:hood
- Summary:
- Hood squeak at the hood stops; all models built 08/01/2013 and after
- Bulletin:
- TSI 131211
- Component:
- 061120 engine and engine cooling:engine:gasoline:turbo-charger
- Summary:
- Replacement procedure for high-pressure turbocharger center section; retired
- Bulletin:
- TSI 131217
- Component:
- 060000 engine (pws)
- Summary:
- Charge air cooler cleaning procedure
- Bulletin:
- TSI 131220
- Component:
- 063110 engine and engine cooling:exhaust system:emission control:crankcase (pcv)
- Summary:
- Crankcase breather replacement
- Bulletin:
- IK1500095
- Component:
- 070000 fuel system, gasoline
- Summary:
- Aluminum fuel tank cleaning procedure
- Bulletin:
- IK0400051
- Component:
- 040000 service brakes, air
- Summary:
- Bendix air dryer troubleshooting; only models equipped with bendix ad-9, ad-is, ad-ip air dryers.
- Bulletin:
- IK0400072
- Component:
- 350000 equipment
- Summary:
- System saver series single cartridge air dryers service information and troubleshooting; only models equipped with meritor wabco 1200 and 1800 air dryers
- Bulletin:
- IK0700053
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Diesel exhaust fluid tips; 2013 model year forward international truck and buses using selective catalyst reduction (scr) aftertreatment
- Bulletin:
- IK0800025
- Component:
- 111000 electrical system:battery
- Summary:
- Measuring parasitic battery load
- Bulletin:
- IK0800393
- Component:
- 110000 electrical system
- Summary:
- Voltage gauge and or all cluster gauges freeze
- Bulletin:
- IK1000003
- Component:
- 010000 steering
- Summary:
- Power steering diagnostics flow / pressure specs for power steering gears and power steering pumps
- Bulletin:
- IK1200288
- Component:
- 060000 engine (pws)
- Summary:
- International engine won't crank / international engines have a crank inhibit circuit.
- Bulletin:
- IK1400025
- Component:
- 020000 suspension
- Summary:
- Operational range for iros suspensions; only models built after june 1, 2012 with feature codes 14unm, 14unl, 14unn, 14uns, 14unt, 14unu, or 14tbj
- Bulletin:
- TSI-121604
- Component:
- 353600 equipment:air conditioner
- Summary:
- A/c system flush tool 19-000-01
- Bulletin:
- IK0200013
- Component:
- 020000 suspension
- Summary:
- Suggested alignment target values when performing a vehicle axle alignment
- Bulletin:
- IK0600020
- Component:
- 020000 suspension
- Summary:
- Determine wheel speed or driveline vibration using a smart phone or tablet and a vibration analysis app.
- Bulletin:
- IK1201241
- Component:
- 060000 engine and engine cooling
- Summary:
- Ecm calibration for dpf replacement
- Bulletin:
- IK1201410
- Component:
- 060000 engine and engine cooling
- Summary:
- Rocker arm inspection and replacement guidelines
- Bulletin:
- IK0800284
- Component:
- 110000 electrical system
- Summary:
- Ambient air temperature (aat) sensor faults/location/diagnostics
- Bulletin:
- IK0800403
- Component:
- 110000 electrical system
- Summary:
- Alternator troubleshooting and diagnostics
- Bulletin:
- IK0400080
- Component:
- 350000 equipment
- Summary:
- Bendix products diagnostic guides
- Bulletin:
- IK0800269
- Component:
- 114000 electrical system:wiring
- Summary:
- Proper wire repair
- Bulletin:
- IK0800554
- Component:
- 110000 electrical system
- Summary:
- Telematics installation guidelines; only models with 500k data link
- Bulletin:
- IK0800475
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Radio diagnostics and information
- Bulletin:
- IK1201360
- Component:
- 060000 engine (pws)
- Summary:
- Cylinder performance analyzer (cpa) resource center
- Bulletin:
- IK1900022
- Component:
- 060000 engine (pws)
- Summary:
- A/c refrigerant and oil capacities
Home | Privacy