9999 EATON EATON Recalls (3)
- Campaign:
- 78E011000 on 10/11/1979
- Component:
- Service brakes, air:antilock:control unit/module
- Manufactured:
- 10/31/1974 - 02/29/1976
- Affected:
- 455
- Defect:
- The involved anti-lock system contains an electrical component that is not of eaton specifications. also, an opening of a solder connection exists between the printed circuit board and another electrical component. this can cause the anti-lock valve solenoid (coiled current conducting wire) to be continuously energized. the brakes in the axle, being controlled by the affected anti-lock system, may become inoperative.
- Correction:
- Defective controllers will be replaced without charge to owners.
- Notes:
- Vehicle category: heavy trucks.system: service brakes; anti-lock system, model 21.consequences of defect: partial loss of braking capability could result in lossof vehicle control and an accident.
- Campaign:
- 79E005000 on 10/11/1979
- Component:
- Service brakes, air:disc:chamber
- Affected:
- 2,249
- Defect:
- The antilock system may swell due to exposure of the internal piston to high concentrations of fluid contaminants. this may cause the piston to stick in the valve, which fails to comply with federal motor vehicle safety standard no. 121, "air brake systems".
- Correction:
- The dealer will replace the existing equipment to prevent failure, without charge.
- Notes:
- Vehicle category: heavy tractors and trucks.system: service brakes; eaton antilock system, model no. 21.consequences of defect: the brakes on the affected axle will cease to functionwithout warning; this could result in loss of vehicle control and a vehicleaccident.note: the chances of the problem occurring will be reduced if owner follows themaintenance practice of draining all fluids from the brake system daily ortemporarily disconnecting the antilock system until a permanent remedy can becompleted.
- Campaign:
- 78E025000 on 10/11/1979
- Component:
- Service brakes, air:disc:chamber
- Manufactured:
- 09/30/1974 - 08/31/1977
- Affected:
- 1,726
- Defect:
- Piston sticking in the valve can occur due to exposure to high concentrations of fluid contaminants which may collect in the braking system. as a result, no air would be delivered to the brake chambers supplied by the anti-lock valve. lack of air to the air chambers will result in a "no brake" condition on the affected axle. this constitutes a non-compliance to federal motor vehicle safety standard no. 121, "air brake systems".
- Correction:
- Dealer will replace the suspect valves free of charge.
- Notes:
- Vehicle category: heavy trailers.system: service brakes; anti-lock system, model 21, valve solenoid.consequences of defect: loss of braking capability could cause loss of vehiclecontrol and an accident.note: the maintenance practice of draining any fluids from the trailer brakesystem should be performed daily and no fluids should be added directly intothe trailer brake lines until the valve can be inspected and replaced.
9999 EATON EATON TSBs (100)
- Bulletin:
- TMIB0115
- Component:
- 102000 power train:manual transmission
- Summary:
- Subject regarding the heavy duty transmission product has experienced complaints of high range synchronizer friction material failures.
- Bulletin:
- TMIB0114
- Component:
- 102000 power train:manual transmission
- Summary:
- Subject regarding transmission lubricants. *yd
- Bulletin:
- TMIB-0115
- Component:
- 102000 power train:manual transmission
- Summary:
- Information on heavy duty synchronizer improvements. *aj
- Bulletin:
- 010101
- Component:
- 102000 power train:manual transmission
- Summary:
- Pertaining to oil cooler line failures. *aj
- Bulletin:
- 0118
- Component:
- 102000 power train:manual transmission
- Summary:
- Information regarding implementation of helix output shaft. models affected rt/fr/frlo-1x210,1x913,1x410 and 2x918 transmissions. *yh
- Bulletin:
- 021703
- Component:
- 100000 power train
- Summary:
- Hardened bearing housing and roller yoke binding. *tt
- Bulletin:
- 0134
- Component:
- 100000 power train
- Summary:
- Failures of the 14 inch heat exchanger which include internal leaks causing transmission oil and engine coolant to mix and broken mounting brackets causing external oil leak. *tt
- Bulletin:
- 0135
- Component:
- 100000 power train
- Summary:
- 13/18 speed enhanced bearing lube upgrade kit. *tt
- Bulletin:
- 0805
- Component:
- 100000 power train
- Summary:
- Lighting series clutch access cover installation. *tt
- Bulletin:
- 2003CL4115
- Component:
- 100000 power train
- Summary:
- Hydraulic clutch actuator roller fork bearing failure. *tt
- Bulletin:
- MDIB-0030
- Component:
- 118000 electrical system: software
- Summary:
- Eaton: this serviceranger software version has the following enhancement: added j1939 support for park pawl (t-handle) calibraton utility in the advanced product functions. no model or model years listed. *pe
- Bulletin:
- TMIB-0173
- Component:
- 102000 power train:manual transmission
- Summary:
- Eaton inc: there are clutch housing gasket leaks on all rt models. *rm
- Bulletin:
- TAIB-0814
- Component:
- 103000 power train:automatic transmission
- Summary:
- Eaton: there are worn center shaft bushings on some xy shifters causing intermittent shift quality. *rm
- Bulletin:
- TAIB-0831
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Eaton: transmission service light is on. there is water intrusion in an electronic connector. *rm
- Bulletin:
- TMIB-0171
- Component:
- 103000 power train:automatic transmission
- Summary:
- Eaton: transmission fastener information. *rm
- Bulletin:
- TAIB-0818
- Component:
- 103000 power train:automatic transmission
- Summary:
- Eaton: there are various shifting complaints and fault codes. the yoke and sliding clutch may be worn on both sides. *rm
- Bulletin:
- CLIB-0015
- Component:
- 102000 power train:manual transmission
- Summary:
- Eaton: clutch lube hose assembly has changed. *rm
- Bulletin:
- CLIB-0018
- Component:
- 980000 unknown or other
- Summary:
- Eaton: information on the machining of clutch plates. *rm
- Bulletin:
- CLIB-0020
- Component:
- 101000 power train:clutch assembly
- Summary:
- Eaton corp: effects of improper removal of the clutch. *rm
- Bulletin:
- TMIB-0193
- Component:
- 980000 unknown or other
- Summary:
- Eaton: the transmission output shaft nuts have been loosening. *rm
- Bulletin:
- TAIB-0833
- Component:
- 980000 unknown or other
- Summary:
- Eaton: the air filter cover did not adequately close and allowed contaminents to enter. *rm
- Bulletin:
- CLIB-0012
- Component:
- 101000 power train:clutch assembly
- Summary:
- Eaton corp: new clutch product information. *rm
- Bulletin:
- CLIB-0016
- Component:
- 161000 structure:frame and members
- Summary:
- Eaton: information on analyzing vehicle vibration complaints. *rm
- Bulletin:
- CLIB-0014
- Component:
- 101000 power train:clutch assembly
- Summary:
- Easton: clutch evaluation information. *rm
- Bulletin:
- CLIB-0008
- Component:
- 101100 power train:clutch assembly:pedal/linkage
- Summary:
- Eaton: information on noticing when a clutch adjustment is needed. if one is needed and drivers continue driving it could lead to yoke interference with the clutch cover causing damage. *rm
- Bulletin:
- MDIB-0022
- Component:
- 110000 electrical system
- Summary:
- Eaton: there are data and programming problems of the ecu. *rm
- Bulletin:
- MDIB-0021
- Component:
- 103000 power train:automatic transmission
- Summary:
- Eaton: providng software application updated information regarding the service ranger database for the appropriate bulletin. *pe updated on 4/26/2012. *kb
- Bulletin:
- TMIB-0719
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Eaton: information regarding the transfer, if input shaft is broken preventing torquing, from engine to transmission, which can consist of 2 failure types. *pe
- Bulletin:
- ABIB-0512
- Component:
- 105100 power train:driveline:universal joint
- Summary:
- Eaton: service u-joints kits spl250-3x/spl170-4x replacing previous service u-joints but can be applied to the previous applications. *pe
- Bulletin:
- TAIB-0832
- Component:
- 118000 electrical system: software
- Summary:
- Eaton: transmission controller need not be replaced due to new transmission harness assembly. *pe
- Bulletin:
- ON-11042-N
- Component:
- 110000 electrical system
- Summary:
- Eaton: on some international/navistar trucks, transmission may be susceptible to water intrusion causing the electronic control unit (ecu) to stop working. *pe
- Bulletin:
- ON-11042-D
- Component:
- 102000 power train:manual transmission
- Summary:
- Eaton: on some freightliner trucks, the electronic control unit (ecu) may stop working due to being susceptible to water intrusion issues. *pe
- Bulletin:
- ON-11042-H
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Eaton: on some hino trucks with the gen's 3 electronic control unit (ecu) may fail due to being susceptible to water intrustion. *pe
- Bulletin:
- ON-11042-K
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Eaton: on some kenworth trucks with the electronic control unit (ecu) fails because of intrustion of water issues. *pe
- Bulletin:
- ON-11042-P
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Eaton: the electronic control union (ecu) on some peterbilt trucks, may stop working due to being susceptible to water intrusion issues. *pe
- Bulletin:
- ON-11042-VM
- Component:
- 060000 engine (pws)
- Summary:
- Eaton: on some vehicles the gen 3 electronic control unit (ecm) may fail to work due to being susceptible to water intrusion issues. *pe
- Bulletin:
- TMIB-0210
- Component:
- 103000 power train:automatic transmission
- Summary:
- Eaton: reman transmissions assembled without splitter snap ring. transmission failure occurred due to not installing the splitter gear snap ring. *kb
- Bulletin:
- TAIB-0835
- Component:
- 060000 engine and engine cooling
- Summary:
- Eaton: hla accumulator sensor torque. sensors have loosened during operation in the field. *kb
- Bulletin:
- TAIB-0842
- Component:
- 101000 power train:clutch assembly
- Summary:
- Eaton: when retaining cap is tightly screwed, the sensor will not distort due to sensor body design to minimize the corrosion seizing and integrated retaining clip. no model or model years listed. *pe
- Bulletin:
- TMIB-0124
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Eaton: due to failure of heat exchanger, engine coolant enters transmission case and mixes with lubricant, where a flush procedure, to clean contamination from transmission, is required. no model or model years are listed.
- Bulletin:
- SB-TAIB-0846
- Component:
- 101000 power train:clutch assembly
- Summary:
- Eaton: information on a non-serviceable sealed component, electronic clutch actuator (eca), which is internally greased during initial assembly and designed to extend life of eca by redistributing grease within internal gearing. no model
- Bulletin:
- SB-TAIB-0847
- Component:
- 356000 equipment adaptive
- Summary:
- Eaton: new speed sensor design, for hybrid transmission on some vehicles, has been released and include sensor body designed to minimize corrosion seizing and integrated retaining clip will not distort sensor when retaining capscrew is tig
- Bulletin:
- TAIB-0852
- Component:
- 350000 equipment
- Summary:
- Eaton: during power down calibration to tecu, incorrect values can be saved due to worn or loose x-y shifter internal components and causes harsh or missed shifts, or not confirming or calibrating neutral after x-y shifter was installed.
- Bulletin:
- W2-14-0033
- Component:
- 118000 electrical system: software
- Summary:
- Eaton: information on s26 gear pumps eaton hydraulic manufactured jan.2011-nov. 2014. the manufacture has detected inconsistencies, which proper steps are taking to make corrections of the disc failure. *lj
- Bulletin:
- GW-14-0015REV.A
- Component:
- 072100 fuel system, gasoline:delivery:fuel pump
- Summary:
- Eaton: v2020 vane pump manufactured between july 17,2014 to august 19,2014 heat treat has been detected in drive shaft used in vane pumps. *lj
- Bulletin:
- CLIB0001
- Component:
- 350000 equipment
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- CLIB0025
- Component:
- 350000 equipment
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- CLIB0026
- Component:
- 350000 equipment
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- CLIB0027
- Component:
- 350000 equipment
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- CLIB0028
- Component:
- 350000 equipment
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- MDIB-0016
- Component:
- 118000 electrical system: software
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- MDIB0021
- Component:
- 118000 electrical system: software
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- MDIB-0021
- Component:
- 350000 equipment
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- MDIB-0022
- Component:
- 118000 electrical system: software
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- MBID0038
- Component:
- 350000 equipment
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- MDIB0040
- Component:
- 980000 unknown or other
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- MDIB0041 EN-US
- Component:
- 118000 electrical system: software
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- MDIB0042 EN-US
- Component:
- 350000 equipment
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- MDIB0043
- Component:
- 118000 electrical system: software
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- MDIB0045
- Component:
- 118000 electrical system: software
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- MDIB0039
- Component:
- 118000 electrical system: software
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TAIB0822
- Component:
- 350000 equipment
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TAIB-0825
- Component:
- 980000 unknown or other
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TAIB0834
- Component:
- 350000 equipment
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TAIB0842
- Component:
- 350000 equipment
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TAIB0843
- Component:
- 103000 power train:automatic transmission
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TAIB0844
- Component:
- 350000 equipment
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TAIB0845
- Component:
- 350000 equipment
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TAIB0849
- Component:
- 350000 equipment
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TAIB0850
- Component:
- 350000 equipment
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 10061013
- Component:
- 350000 equipment
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TMIB-0129
- Component:
- 350000 equipment
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TMIB0138
- Component:
- 350000 equipment
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TMIB0152
- Component:
- 350000 equipment
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TMIB0153
- Component:
- 102000 power train:manual transmission
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TMIB0176
- Component:
- 350000 equipment
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TMIB0187
- Component:
- 350000 equipment
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TMIB0254
- Component:
- 350000 equipment
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TMIB0187
- Component:
- 101000 power train:clutch assembly
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TAIB0849
- Component:
- 350000 equipment
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- MDIB0041
- Component:
- 350000 equipment
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- MDIB0021
- Component:
- 350000 equipment
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- MDIB0021
- Component:
- 350000 equipment
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- MDIB-0021
- Component:
- 350000 equipment
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- MDIB0021
- Component:
- 350000 equipment
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- MDIB0021
- Component:
- 350000 equipment
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- MDIB0021
- Component:
- 350000 equipment
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- MDIB0021
- Component:
- 118000 electrical system: software
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- MDIB-0021
- Component:
- 350000 equipment
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- MDIB0021
- Component:
- 350000 equipment
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- CLIB0026
- Component:
- 350000 equipment
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- MDIB-0021
- Component:
- 118000 electrical system: software
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- MDIB-0021
- Component:
- 118000 electrical system: software
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- MDIB0038
- Component:
- 350000 equipment
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TAIB0842
- Component:
- 046300 service brakes, air:antilock:wheel speed sensor
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TAIB0843
- Component:
- 103000 power train:automatic transmission
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TMIB-0176
- Component:
- 103000 power train:automatic transmission
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- MDIB0040
- Component:
- 350000 equipment
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- SB-TAIB-0857
- Component:
- 060000 engine (pws)
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TAIB-0857
- Component:
- 118000 electrical system: software
- Summary:
- Eaton transmission software updates-transmission fault code 76 & engine fault code 5297. after performing transmission software updated for transmission fault code 76 and engine fault code 5297, set active trucks equipped with cummins isx1
Home | Privacy