9999 CUMMINS ISB6.7 Recalls (5)
- Campaign:
- 11E031000 on 08/08/2011
- Component:
- Engine and engine cooling
- Affected:
- 11,860
- Defect:
- Cummins is recalling certain isb6.7, isc8.3, isl9, isx11.9, and isx15 engines shipped from september 2010 through december 2010 to various vehicle manufacturers. these engines were installed in recreational vehicles, emergency vehicles, buses, and certain truck applications. the v-band clamp assembly, part numbers q187684, q187685, and q187686, used to connect the inlet and outlet cone sections to the diesel oxidation catalyst (doc)/diesel particulate filter (dpf) include a t-bolt which can fracture and fail when subjected to stress or load. a fracture or failure of the t-bolt may cause the clamp to loosen and the inlet or outlet sections attached to the doc/dpf housing to disconnect.
- Consequence:
- If the inlet or outlet sections disconnect, hot exhaust gases can vent prior to exiting the tailpipe, creating the risk of combustion and a fire. if both clamps fail, there is a risk in some applications that the doc/dpf housing may detach completely, creating a road hazard.
- Correction:
- Cummins is working with the vehicle manufacturers to identify and notify owners. the safety recall began on october 10, 2011. owners may contact cummins at 1-812-377-5000 or their vehicle manufacturer.
- Notes:
- Cummins' recall campaign number is c1154.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
- Campaign:
- 12E054000 on 11/28/2012
- Component:
- Engine and engine cooling:engine:diesel
- Affected:
- 7,040
- Defect:
- Cummins is recalling certain model isb6.7 diesel engines manufactured from february 16, 2010, through may 4, 2012, equipped with fan pulley part number 3914462 and installed on certain thomas built buses, inc. school buses. the subject fan pulley is part of the accessory drive system on the front of the engine. this system is used to drive such components as the refrigerant compressors, the radiator fan, and the engine water pump. the web of the pulley can fatigue over time, causing the pulley to fail.
- Consequence:
- If this occurs, the fan belt may lose engagement of the water pump, allowing the cooling system to overheat. this may result in exceeding temperature limits, potentially disabling the school bus. if the school bus is occupied when it becomes disabled, the occupants would need to exit the vehicle and be transferred to another vehicle, putting them at risk of injury.
- Correction:
- Cummins will notify thomas built of this defect and the potential safety consequences, and will work with them to identify and notify the affected owners. cummins will install a new fan drive pulley, without charge, through cummins' service network. the recall began on november 27, 2012. notification to owners began on january 4, 2013. owners may contact cummins at 1-812-377-5000.
- Notes:
- Cummins' recall campaign number is c1296.owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
- Campaign:
- 15E073000 on 09/07/2015
- Component:
- Electrical system:ignition:module
- Manufactured:
- 07/29/2015 - 08/02/2015
- Affected:
- 805
- Defect:
- Cummins inc. (cummins) is recalling certain isb6.7, isl9, isx12 and isx15 engines. the affected engines have an engine control module (ecm) that may short circuit and blow a fuse resulting in the engine stalling without warning.
- Consequence:
- An engine that stalls without warning increases the risk of a crash.
- Correction:
- Cummins will notify owners, and dealers will replace any defective ecm with a remedy part, free of charge. the recall began on october 22, 2015. owners may contact cummins customer service at 1-800-343-7357. cummins' number for this recall is c1698.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
- Campaign:
- 15E073000 on 09/07/2015
- Component:
- Electrical system:ignition:module
- Manufactured:
- 07/29/2015 - 08/02/2015
- Affected:
- 805
- Defect:
- Cummins inc. (cummins) is recalling certain isb6.7, isl9, isx12 and isx15 engines. the affected engines have an engine control module (ecm) that may short circuit and blow a fuse resulting in the engine stalling without warning.
- Consequence:
- An engine that stalls without warning increases the risk of a crash.
- Correction:
- Cummins will notify owners, and dealers will replace any defective ecm with a remedy part, free of charge. the recall began on october 22, 2015. owners may contact cummins customer service at 1-800-343-7357. cummins' number for this recall is c1698.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
- Campaign:
- 15E073000 on 09/07/2015
- Component:
- Electrical system:ignition:module
- Manufactured:
- 07/29/2015 - 08/02/2015
- Affected:
- 805
- Defect:
- Cummins inc. (cummins) is recalling certain isb6.7, isl9, isx12 and isx15 engines. the affected engines have an engine control module (ecm) that may short circuit and blow a fuse resulting in the engine stalling without warning.
- Consequence:
- An engine that stalls without warning increases the risk of a crash.
- Correction:
- Cummins will notify owners, and dealers will replace any defective ecm with a remedy part, free of charge. the recall began on october 22, 2015. owners may contact cummins customer service at 1-800-343-7357. cummins' number for this recall is c1698.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
9999 CUMMINS ISB6.7 TSBs (164)
- Bulletin:
- TSB-140079
- Component:
- 060000 engine (pws)
- Summary:
- Cummins: engine mounts are damaged and vibrating, causing internal malfunction to engine control module (ecm), and it might be in rom boot state, failing to communicate. *pe
- Bulletin:
- 15E-073
- Component:
- 060000 engine (pws)
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- ATC1746
- Component:
- 060000 engine (pws)
- Summary:
- This account team coverage authorizes the recalibration of certain isb engines in transit bus applications.
- Bulletin:
- C1634C
- Component:
- 350000 equipment
- Summary:
- This campaign is being issued to address turbocharger actuator failures in certain engines in transit bus applications. this campaign authorizes the recalibration of the turbocharger actuator. this is an update to a previously released co
- Bulletin:
- TSB150089-020516
- Component:
- 350000 equipment
- Summary:
- This technical service bulletin introduces a revised backflow connector for the bosch aftertreatment def (diesel exhaust fluid) dosing unit. in some cases, the aftertreatment def dosing lines are not being fully purged during the purge cyc
- Bulletin:
- TSB160010-020216
- Component:
- 350000 equipment
- Summary:
- This technical service bulletin communicates an error message when making adjustments to the aftertreatment diesel exhaust fluid level system configuration programmable parameters with the insite electronic service tool.
- Bulletin:
- ATC1771A
- Component:
- 060000 engine (pws)
- Summary:
- This account team coveraged is being issued to address def dosing valve gasket failures in certain isb6.7 cm2250 engines in school bus applications. this atc provides authorization for certified repair locations to replace the current gaske
- Bulletin:
- TSB150057-062116
- Component:
- 350000 equipment
- Summary:
- This technical service bulletin describes the troubleshooting and repair steps to correct water intrusion that may cause the malfunction of the aftertreatment outlet nox sensor resulting in fault code 1887, 3583 or 3545 on certain aftertrea
- Bulletin:
- ATC1746
- Component:
- 060000 engine (pws)
- Summary:
- This account team coverage authorizes the recalibration of certain isb engines in transit bus applications.
- Bulletin:
- C1634C
- Component:
- 060000 engine (pws)
- Summary:
- This campaign is being issued to address turbocharger actuator failures in certain engines in transit bus applications. this campaign authorizes the recalibration of the turbocharger actuator. this is an update to a previously released co
- Bulletin:
- TSB150089-020516
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- This technical service bulletin introduces a revised backflow connector for the bosch aftertreatment def (diesel exhaust fluid) dosing unit. in some cases, the aftertreatment def dosing lines are not being fully purged during the purge cyc
- Bulletin:
- TSB150197-121615
- Component:
- 350000 equipment
- Summary:
- This technical service bulletin instructs service technicians to use certain previous versions of the incal dvd if, when attempting to calibrate a turbocharger actuator using the calibrations from the december 2015 incal dvd, a message stat
- Bulletin:
- TSB160010-020216
- Component:
- 080000 fuel system, diesel
- Summary:
- This technical service bulletin communicates an error message when making adjustments to the aftertreatment diesel exhaust fluid level system configuration programmable parameters with the insite electronic service tool.
- Bulletin:
- T1629B
- Component:
- 060000 engine (pws)
- Summary:
- This temporary repair practice is being issued to address units that have found fault code 1887, 3545, and/or 3583 active or inactive. the implementation of this trp will correct the issue of liquid impingment by applying a water shield ov
- Bulletin:
- TSB110036-010616
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- This technical service bulletin announces the release of a new air intake tube to be installed when replacing the air intake connection. the new air intake tube relocates the air supply further from the exhaust gas recirculation (egr) po
- Bulletin:
- TSB150040-012116
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin desribes the troubleshooting and repair steps to correct belt tensioner locating pin malfunctions and belt shredding on certain isb engines in thomas pusher school busses. original equipment manufacturer (oe
- Bulletin:
- TSB150171-012216
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the proper troubleshooting steps to diagnose lubricating oil found around the turbocharger section gear and the variable geometry turbucharger actuator gear. this is a normal and does not indicate
- Bulletin:
- TSB150177-123015
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin introduces the release of a new coolant level sensor. certain engines in transit bus applications are experiencing pin corrosion as the result of poor cealing performance of the original equipment manufactur
- Bulletin:
- C1634C
- Component:
- 350000 equipment
- Summary:
- This campaign is being issued to address turbocharger actuator failures in certain engines in transit bus applications. this campaign authorizes the recalibration of the turbocharger actuator. this is a revision to a previously released c
- Bulletin:
- TSB101059-080116
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin announces new dipsticks to improve reliability. the main change to the dipsticks is that a notch was removed from the blade. the old dipsticks were susceptible to breakage in this area. the modification is
- Bulletin:
- TSB120261-080116
- Component:
- 060000 engine and engine cooling
- Summary:
- This technical service bulletin describes the corrective action for coolant leaks from a torque converter coolant hoses due to the air compressor plumbing rubbing against coolant hoses on engines equipped with certain options. this is a re
- Bulletin:
- TSB130052-080116
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin announces a new heavy duty tapered bearing fan support in place of the standard duty fan support. certain applications have seen an increased number of standard fan support bearing failures. the heavy duty
- Bulletin:
- TSB150006-072216
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- This technical sesrvice bulletin describes the verification and resolution of diesel exhaust fluid (def) leaking around the aftertreatment def dosing unit electrical connector, caused by internal cracking due to freezing def. possible faul
- Bulletin:
- TSB150071-081616
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the verification and resolution of fault codes 122, 123, 124, 125 or 2973 due to intake manifold pressure/temperature sensor water intrusion. this is a revision to a previous communication.
- Bulletin:
- TSB150105-081516
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin announces new aftertreatment selective catalyst reduction (scr) catalyist part numbers and supporting parts. this is an update to a previously submitted communication.
- Bulletin:
- C1422A
- Component:
- 060000 engine (pws)
- Summary:
- This campaign authorizes the replacement of the flexplate on certain engines.
- Bulletin:
- TSB140041-050614
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the verification and resolution of greenhouse gas (ghg) parameters for vehicle speed and idle shutdown programmed incorrectly in certain paccar vehicles. ghg parameters are password protected by t
- Bulletin:
- TSB140046-041514
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin introduces the release of a revised air compressor repair kit for cummins air compressors. the revised kit provides the necessary parts to repair the air compressor by replacing the compressor head assembly.
- Bulletin:
- TSB140048-042914
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the verification and resolution of leaking diesel exhaust fluid (def) leaking from the aftertreatment def dosing unit electrical connector. multiple electrical diagnostic fault codes can be set due
- Bulletin:
- TSB140060-050814
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin discribes the verification and resolution of fault codes 155 and/or 2964 due to intake manifold temperature sensor failures with a certain date code range exhibiting a high rate of early life failures.
- Bulletin:
- C1395A
- Component:
- 060000 engine (pws)
- Summary:
- This campaign authorizes certified repair locations to recalibrate the engine control module (ecm) and clean the exhaust gas recirculation (egr) valve, connection tube and egr delta pressure ports on certain engines in convential drive tran
- Bulletin:
- TSB101067-100710
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin announces a product improvement for this engine model's water pump. the improved pump contains a more robust water pump pulley that is capable fo withstanding higher side-loading forces.
- Bulletin:
- TSB140038-040614
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the verification and resolution of inlet and outlet nox sensor wire lead damage caused by the use of incorrect wire ties.
- Bulletin:
- C1458
- Component:
- 060000 engine (pws)
- Summary:
- This campaign addresses 24v turbocharger actuators on certain engines. this is a reissue of a previous communication.
- Bulletin:
- T1338A
- Component:
- 060000 engine (pws)
- Summary:
- This temporary repair practice addresses exhaust manifold slip joint leaks by installing a one piece manifold on certain engines.
- Bulletin:
- TSB120180-012214
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin introduces new fan hub pulleys for the affected engine models and provides direction on supercession/compatibility for different front end accessory drive arrangements.
- Bulletin:
- TSB130081-031114
- Component:
- 110000 electrical system
- Summary:
- This technical service bulletin describes the verification and resolution of fault code 2222 caused by the absence of the required fuel tank level input multiplexed to the engine control module (ecm). this is a revision to a previous comm
- Bulletin:
- C1458
- Component:
- 060000 engine (pws)
- Summary:
- This campaign addresses 24v turbocharger actuators on certain engines.
- Bulletin:
- TSB120060-120513
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the verification and resolution of certain malfunctions due to incorrect switch input wiring on some engines. certain engine control module switch inputs, such as the power take-off (pto)/accelerat
- Bulletin:
- TSB150105-070516
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin announces new aftertreatment selective catalyst reduction (scr) catalyist part numbers and supporting parts. this is an update to a previously submitted communication.
- Bulletin:
- TSB150192-121415
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin announces the release of a new exhaust gas recirculation (egr) coolant return line and turbocharger coolant return hose part numbers and associated service instructions.
- Bulletin:
- TSB130081-042913
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the verification and resolution of fault code 2222 caused by the absence of the required fuel tank level input multiplexed to the engine control module (ecm).
- Bulletin:
- C1395
- Component:
- 060000 engine (pws)
- Summary:
- This campaign authorizes certified repair locations to recalibrate the engine control module (ecm) and clean the exhaust gas recirculation (egr) valve, connection tube and egr delta pressure ports on certain engines in convential drive tran
- Bulletin:
- TSB120261-092712
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the corrective action for coolant leaks from a torque converter coolant hoses due to the air compressor plumbing rubbing against coolant hoses on engines equipped with certain options.
- Bulletin:
- C1634B
- Component:
- 060000 engine (pws)
- Summary:
- This campaign is to address turbocharger actuator failures in certain engines in transit bus applications. this campaign authorizes the recalibration of the turbocharger actuator. this is a revision to a previously released communication.
- Bulletin:
- T1288A
- Component:
- 061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
- Summary:
- This temporary repair practice is for certain isb 6.7 cm2250 engines in school bus applications built with option cf9235. it improves the belt length for better front end accessory drive system performance.
- Bulletin:
- ATC1771B
- Component:
- 060000 engine (pws)
- Summary:
- This account team coverage is being issued to address def dosing valve gasket failures in certain isb6.7 cm2250 engines in school bus applications. this atc provides authorization for certified repair locations to replace the current gasket
- Bulletin:
- TSB100025-092116
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin informs the field of an issue causing fuel pump leaks on bosch common rail fuel systems. high fuel inlet and fuel drain line restrictions can lead to an external or internal fuel leak from the fuel pump. it
- Bulletin:
- TSB150089-110315
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin introduces a revised backflow connector for the bosch aftertreatment def (diesel exhaust fluid) dosing unit. in some cases, the aftertreatment def dosing lines are not being fully purged during the purge cyc
- Bulletin:
- TSB150177-110315
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin introduces the release of a new coolant level sensor. certain engines in transit bus applications are experiencing pin corrosion as the result of poor cealing performance of the original equipment manufactur
- Bulletin:
- TSB150040-032315
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin desribes the troubleshooting and repair steps to correct belt tensioner locating pin malfunctions and belt shredding on certain isb engines in thomas pusher school busses. original equipment manufacturer (oe
- Bulletin:
- TSB100031-092116
- Component:
- 060000 engine (pws)
- Summary:
- This technical servivce bulletin describes an issue where the malfunction indicator lamp (mil) will be illuminated with no fault codes present in the engine control module (ecm). the resolution for the issue is described.
- Bulletin:
- TSB130020-092116
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin introduces new troubleshooting trees to improve turbocharger oil leak troubleshooting.
- Bulletin:
- TSB130042-092116
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes an issue where inactive fault codes are present in the engine control module (ecm) after a calibration download. the malfunction indicator lamp (mil) may also be illuminated. the resolution for t
- Bulletin:
- TSB130080-090716
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin introduces a new cummins service engine model identification. this is a revision to a previous communication.
- Bulletin:
- TSB140104-091616
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the verification and resolution of rust preventative oil at the flywheel housing being misdiagnosted as a rear crankshaft seal or crankshaft collar malfunction.
- Bulletin:
- TSB140157-092116
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the verification and resolution of excessive metallic gear train noise during air compressor operation on certain rear gear train engines. this is a revision to a previous communication.
- Bulletin:
- TSB150040-092116
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the troubleshooting and repair steps to correct belt tensioner locating pin malfunctions and belt shredding on certain isb engines in thomas pusher school busses. original equipment manufacturer (o
- Bulletin:
- TSB150071-092116
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the verification and resolution of fault codes 122, 123, 124, 125 or 2973 due to intake manifold pressure/temperature sensor water intrusion. this is a revision to a previous communication.
- Bulletin:
- TSB130080-100615
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin introduces a new cummins service engine model identification
- Bulletin:
- TSB150105-100715
- Component:
- 350000 equipment
- Summary:
- This technical service bulletin announces new aftertreatment selective catalyst reduction (scr) catalyist part numbers and supporting parts. this is an update to a previously submitted communication.
- Bulletin:
- TSB150073-092116
- Component:
- 046400 service brakes, air:antilock:abs warning light
- Summary:
- This technical service bulletin describes the verification and resolution of an anti-lock brake system (abs) fault lamp illuminating immediately after an engine control module (ecm) calibration on certain vehicles equipped with a bendix ec
- Bulletin:
- TSB150081-092316
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin announces the release of new hose clamps for exhaust gas recirculation (egr) plumbing. the new work gear clamp utilizes a band liner and better handle hose wall thickness variations and help prevent extern
- Bulletin:
- TSB150153-090616
- Component:
- 060000 engine (pws)
- Summary:
- This techical service bulletin describes the verification and resolution of fault codes 3314, 3317, 3319, 3146 or 4518 caused by an aftertreatment exhaust gas temperature sensor malfunction. this is an update to a previous communication.
- Bulletin:
- TSB150165-092116
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the verifcation and resolution of starter motor malfunctions in certain engines in international durastar trucks, workstar trucks, and ic buses.
- Bulletin:
- TSB150171-092116
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the proper troubleshooting steps to diagnose lubricating oil found around the turbocharger section gear and the variable geometry turbucharger actuator gear. this is a normal and does not indicate
- Bulletin:
- TSB150177-092116
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin introduces the release of a new coolant level sensor. certain engines in transit bus applications are experiencing pin corrosion as the result of poor cealing performance of the original equipment manufactur
- Bulletin:
- TSB160006-092316
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the verification and resolution of fault code 4713 and the proper injector isolation test procedure. this is a revision to a previous communication.
- Bulletin:
- TSB160092-092116
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the verification and resolution of cruise resume being inoperative after engaging the exhaust retarder on certain engines installed in international durastar chassis.
- Bulletin:
- TSB150158-100215
- Component:
- 350000 equipment
- Summary:
- This technical service bulletin describes the verification and resolution of aftertreatment diesel exhaust fluid (def) dosing units being incorrectly identified as failed after finding what was thought to be a def leak. this is normal and
- Bulletin:
- TSB150165-101515
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the verifcation and resolution of starter motor malfunctions in certain engines in international durastar trucks, workstar trucks, and ic buses.
- Bulletin:
- TSB150171-102615
- Component:
- 350000 equipment
- Summary:
- This technical service bulletin describes the proper troubleshooting steps to diagnose lubricating oil found around the turbocharger section gear and the variable geometry turbucharger actuator gear. this is a normal and does not indicate
- Bulletin:
- C1634B
- Component:
- 060000 engine (pws)
- Summary:
- This campaign is to address turbocharger actuator failures in certain engines in transit bus applications. this campaign authorizes the recalibration of the turbocharger actuator. this is a revision to a previously released communication.
- Bulletin:
- CMI-N5P5E-09
- Component:
- 060000 engine (pws)
- Summary:
- This is a representative letter that was mailed to owners informing them that their engine was subject to campaign c1634.
- Bulletin:
- T1629A
- Component:
- 060000 engine (pws)
- Summary:
- This temporary repair practice is being issued to address units that have found fault code 1887, 3545, and/or 3583 active or inactive. the implementation of this trp will correct the issue of liquid impingment by applying a water shield ov
- Bulletin:
- TSB140086-092915
- Component:
- 350000 equipment
- Summary:
- This techical service bulletin announces the release of a new aftertreatment selective catalytic reduction (scr) catalyst part numbers as a result of a change in the washcoat used for the catalyst.
- Bulletin:
- TSB150110-071415
- Component:
- 350000 equipment
- Summary:
- This technical service bulletin announces new short turbocharger service kit part numbers for specific perofrmance part options by application. a short turbocharger is a turbocharger without the actuator.
- Bulletin:
- TSB150149-090815
- Component:
- 350000 equipment
- Summary:
- This technical service bulletin explains that the aftertreatment diesel particulate filter (dpf) design was changed. because of this physical design change, service locations questioned if the aftertreatment dpf had a manufacturing defect
- Bulletin:
- TSB150152-091415
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the verification and resolution of an issue in which certain engine control modules of engines installed in navistar chassis will not communicate and will not calibrate using the original equipment
- Bulletin:
- TSB150153-091515
- Component:
- 060000 engine (pws)
- Summary:
- This techical service bulletin describes the verification and resolution of fault codes 3314, 3317, 3319, 3146 or 4518 caused by an aftertreatment exhaust gas temperature sensor malfunction.
- Bulletin:
- ATC1685
- Component:
- 060000 engine (pws)
- Summary:
- This account team coverage addresses certain engines tha have experienced internally leaking def pumps caused by freezing def due to incomplete purges on shut down. certified repair locations are authorized to replace the back flow connect
- Bulletin:
- T1629
- Component:
- 350000 equipment
- Summary:
- This temporary repair practice is being issued to address units that have found fault code 1887, 3545, and/or 3583 active or inactive. the implementation of this trp will correct the issue of liquid impingment by applying a water shield ov
- Bulletin:
- TSB150089-060415
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- This technical service bulletin introduces a revised backflow connector for the bosch aftertreatment def (diesel exhaust fluid) dosing unit. in some cases, the aftertreatment def dosing lines are not being fully purged during the purge cyc
- Bulletin:
- TSB150102-062515
- Component:
- 060000 engine (pws)
- Summary:
- This document introduces new engine wiring harness options.
- Bulletin:
- TSB150105-070915
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin announces new aftertreatment selective catalyst reduction (scr) catalyist part numbers and supporting parts.
- Bulletin:
- ATC1771
- Component:
- 060000 engine (pws)
- Summary:
- This atc is being issued to address def dosing valve gasket failures in certain isb6.7 cm2250 engines in school bus applications. this atc provides authorization for certified repair locations to replace the current gasket with an improved
- Bulletin:
- ATC1752
- Component:
- 060000 engine (pws)
- Summary:
- This account team coverage addresses the upgrade of the ecm base code on certain engines in certain emergency vehicles and the replacement of the engine data plate to correct an engine dataplate error.
- Bulletin:
- TSB120060-031716
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the verification and resolution of certain malfunctions due to incorrect switch input wiring on some engines. certain engine control module switch inputs, such as the power take-off (pto)/accelerat
- Bulletin:
- TSB140157-030116
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the verification and resolution of excessive metallic gear train noise during air compressor operation on certain rear gear train engines. this is an update to a previously submitted communication.
- Bulletin:
- TSB150177-030816
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin introduces the release of a new coolant level sensor. certain engines in transit bus applications are experiencing pin corrosion as the result of poor cealing performance of the original equipment manufactur
- Bulletin:
- TSB160006-012016
- Component:
- 073200 fuel system, gasoline:fuel injection system:injectors
- Summary:
- This technical service bulletin describes the verification and resolution of fault code 4713 and the proper injector isolation test procedure.
- Bulletin:
- TSB160021-031516
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin announces the release of a new j1939 datalink coomponent isolation kit service tool. this tool will help troubleshoot j1939 components that will not communicate with the engine control module.
- Bulletin:
- TSB160031-032116
- Component:
- 080000 fuel system, diesel
- Summary:
- This technical service bulletin describes the verification and resolution of fault code 1715 on international truck and isc bus chassis due to low diesel exhaust fluid (def) level in the def tank.
- Bulletin:
- TSB150057-062515
- Component:
- 350000 equipment
- Summary:
- This technical service bulletin describes the troubleshooting and repair steps to correct water intrusion that may cause the malfunction of the aftertreatment outlet nox sensor resulting in fault code 1887, 3583 or 3545 on certain aftertrea
- Bulletin:
- TSB150081-052815
- Component:
- 070000 fuel system, gasoline
- Summary:
- This technical service bulletin announces the release of new hose clamps for exhaust gas recirculation (egr) plumbing. the new work gear clamp utilizes a band liner and better handle hose wall thickness variations and help prevent extern
- Bulletin:
- TSB150094-061015
- Component:
- 080000 fuel system, diesel
- Summary:
- This technical service bulletin describes removal of the oem rear fiberglass body panel to allow easier access to the aftertreatment diesel exhaust fluid dosing valve in certain new flyer bus applications.
- Bulletin:
- TSB150036-031615
- Component:
- 061320 engine and engine cooling:engine:other fuel types:turbo-charger
- Summary:
- This technical service bulletin announces new short turbocharger service kit part numbers for specific turbocharger performance part options by application.
- Bulletin:
- TSB150055-042215
- Component:
- 350000 equipment
- Summary:
- This technical service bulletin announces the introduction of a new aftertreatment diesel exhaust fluid (def) dosing valve gasket to reduce failures experienced with the original design on certain original equipment manufacturer (oem) appli
- Bulletin:
- TSB150073-051815
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the verification and resolution of an anti-lock brake system (abs) fault lamp illuminating immediately after an engine control module (ecm) calibration on certain vehicles equipped with a bendix ec
- Bulletin:
- TSB130080-040215
- Component:
- 350000 equipment
- Summary:
- This technical service bulletin introduces a new cummins service engine model identification. this is a revision to a previous communication.
- Bulletin:
- CMI-A9J8A-11
- Component:
- 060000 engine (pws)
- Summary:
- This owner letter was mailed to inform customers of an emissions campaign on certain engines. it refers to cummins campaign c1634. this was a second notification.
- Bulletin:
- TSB150040-101116
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the troubleshooting and repair steps to correct belt tensioner locating pin malfunctions and belt shredding on certain isb engines in thomas pusher school busses. original equipment manufacturer (o
- Bulletin:
- TSB160031-101716
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- This technical service bulletin describes the verification and resolution of fault code 1715 on international truck and isc bus chassis due to low diesel exhaust fluid (def) level in the def tank. this is a revision to a previous communica
- Bulletin:
- TSB140015-022515
- Component:
- 350000 equipment
- Summary:
- This technical service bulletin describes the verification and resolution of fault code 4526 or 2718 remaining active after performing service brake transition. this is applicable to engines installed in certain ford f-650 and f-750 trucks
- Bulletin:
- TSB140117-032715
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the verification and resolution of fault codes 555 and 556 caused by dust and debris ingestion on certain engines installed in ford f-650 and f-750 chassis. this is a revision to a previous commun
- Bulletin:
- TSB140145-030615
- Component:
- 350000 equipment
- Summary:
- This technical service bulletin announces new valve springs for the affected engines. the new valve springs are backwards compatible and transparent to assembly
- Bulletin:
- TSB150002-010815
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the verification and resolution of diesel exhaust fluid (def) cleanliness. def contamination is one of the primary contributors of aftertreatment related component malfunction
- Bulletin:
- TSB140117-021215
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the verification and resolution of fault codes 555 and 556 caused by dust and debris ingestion on certain engines installed in ford f-650 and f-750 chassis. this is a revision to a previous commun
- Bulletin:
- TSB140105-010815
- Component:
- 350000 equipment
- Summary:
- This technical service bulletin describes the verification and resolution of fault code(s) 1883, 1921, 1922, 1981, 2639, 3135 and 3168 caused by incorrect orientation of the aftertreatment diesel particulate filter (dpf) differential press
- Bulletin:
- TSB140117-121814
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the verification and resolution of fault codes 555 and 556 caused by dust and debris ingestion on certain engines installed in ford f-650 and f-750 chassis. this is a revision to a previous commun
- Bulletin:
- C1422C
- Component:
- 060000 engine (pws)
- Summary:
- This campaign authorizes the replacement of the flexplate on certain engines. this is a revision to a previous communication.
- Bulletin:
- C1451A
- Component:
- 060000 engine (pws)
- Summary:
- This campaign authorizes certified repair location to recalibrate the engine control module (ecm) on certain engines as a product improvement.
- Bulletin:
- TSB120158-111014
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the verification and resolution of fault code 4293 or 4294 becoming active with specific calibrations. these faults may become active if the vehicle is not equipped with the engine brake lamp featu
- Bulletin:
- TSB130080-118114
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin introduces a new cummins service engine model identification. this is a revision to a previous communication.
- Bulletin:
- TSB140145-100614
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin announces new valve springs for the affected engines. the new valve springs are backwards compatible and transparent to assembly.
- Bulletin:
- TSB140153-102914
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the verification and resolution of fault code 3542 caused by engine intake throttle actuator icing.
- Bulletin:
- TSB140156-110514
- Component:
- 080000 fuel system, diesel
- Summary:
- This technical service bulletin describes the verification and resolution of extended aftertreatment diesel exhaust fluid (def) dosing unit purge time.
- Bulletin:
- TSB140157-110514
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the verification and resolution of excessive metallic gear train noise during air compressor operation on certain rear gear train engines.
- Bulletin:
- C1422B
- Component:
- 060000 engine (pws)
- Summary:
- This campaign authorizes the replacement of the flexplate on certain engines. this is a revision to a previous communication.
- Bulletin:
- TSB140105-092814
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the verification and resolution of fault code(s) 1883, 1921, 1922, 1981, 2639, 3135 and 3168 caused by incorrect orientation of the aftertreatment diesel particulate filter (dpf) differential press
- Bulletin:
- TSB140139-092914
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the verfication and resolution of fault code 3494 on certain engines in thomas built school buses. under certain conditions at engine start-up, the vehicle will log a malfunction on the malfunction
- Bulletin:
- TSB140147-101514
- Component:
- 060000 engine (pws)
- Summary:
- The technical service bulletin announces a new engine control module (ecm) calibrations with increased accelerator pedal filtering to mitigate chassis induced frame deflection in some applications, including street sweepers.
- Bulletin:
- C1429B
- Component:
- 060000 engine (pws)
- Summary:
- This campaign authorizes recalibration of the engine control module (ecm) on certain engines installed in transit bus applications.
- Bulletin:
- TSB140086-062114
- Component:
- 350000 equipment
- Summary:
- This techical service bulletin announces the release of a new aftertreatment selective catalytic reduction (scr) catalyst part numbers as a result of a change in the washcoat used for the catalyst.
- Bulletin:
- TSB140115-082514
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the additional steps that vehicles certified as greenhouse gas (ghg) compliant require when an engine control module (ecm) replacement is required.
- Bulletin:
- TSB140117-090214
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the verification and resolution of fault codes 555 and 556 caused by dust and debris ingestion on certain engines installed in ford f-650 and f-750 chassis.
- Bulletin:
- TSB140079-061614
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the verification and resolution of an issue with certain engines installed in school buses in which damaged engine mounts cause the engine to not start.
- Bulletin:
- TSB140088-062314
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin addresses multiple fault codes due to shorted or open circuits on certain engines causing "timeout" errors in the selectice catalytic reduction (scr) temperature sensor module, the outlet mono-nitrogen oxides
- Bulletin:
- C1634
- Component:
- 060000 engine (pws)
- Summary:
- This campaign is to address turbocharger actuator failures in certain engines in transit bus applications. this campaign authorizes the recalibration of the turbocharger actuator.
- Bulletin:
- CMI-K6L5D-08
- Component:
- 060000 engine (pws)
- Summary:
- This communication summarized an issue with the manufacturing process of the electronic control module. this communication was sent by the engine assembly plant to vehicle oem plants. this issue could result in a blown fuse and the engine
- Bulletin:
- T1629A
- Component:
- 350000 equipment
- Summary:
- This temporary repair practice is being issued to address units that have found fault code 1887, 3545, and/or 3583 active or inactive. the implementation of this trp will correct the issue of liquid impingment by applying a water shield ov
- Bulletin:
- TSB150116-072115
- Component:
- 080000 fuel system, diesel
- Summary:
- This technical service bulletin announces a new service tool for diesel exhaust fluid (def) system troubleshooting, especially for fault codes 1682, 3574 and 3596.
- Bulletin:
- TSB150132-073115
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- This technical service bulletin describes that using heavy duty exhaust gas recirculation (egr) cooler test strips to test midrange egr coolers for internal coolant leaks is not an acceptable practice and will not provide accurate results.
- Bulletin:
- TSB150071-011717
- Component:
- 350000 equipment
- Summary:
- This technical service bulletin describes the verification and resolution of fault codes 122, 123, 124, 125 or 2973 due to intake manifold pressure/temperature sensor water intrusion. this is a revision to a previous communication.
- Bulletin:
- TSB170024-030120
- Component:
- 060000 engine and engine cooling
- Summary:
- This technical service bulletin describes the verification and resolution of the air compressor ingesting moisture from air compressor inlet tube supplied by navistar. air compressor inlet tube is connected at charge air cooler and condensa
- Bulletin:
- TSB170027-031420
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- This technical service bulletin communicates the release of a new exhaust gas recirculation differential pressure sensor. the new exhaust gas recirculation differential pressure sensor is a more robust design and is better at reading egr di
- Bulletin:
- TSB170031-031720
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the verification and resolution of fault code 6255 present with no other fault codes caused by an engine control module calibration code issue.
- Bulletin:
- TSB170033-031720
- Component:
- 050000 parking brake
- Summary:
- This technical service bulletin describes the verification and resolution of engine runs rough during aftertreatment selective catalytic reduction system test. the test requires parking brake to be engaged when enabled and on engines trimme
- Bulletin:
- TSB170046-040720
- Component:
- 060000 engine and engine cooling
- Summary:
- This technical service bulletin describes the verification and resolution of fan drive belt chirp on international® trucks and school buses. select fan drive belt configurations have a fan drive belt installed that is excessively long causi
- Bulletin:
- TSB170057-042620
- Component:
- 060000 engine and engine cooling
- Summary:
- This technical service bulletin describes the verification and resolution of the hard start or fault code 559 or 4691 caused by an air leak in fuel system caused by incorrect installation of navistar® supplied washer between navistar® suppl
- Bulletin:
- C1847
- Component:
- 060000 engine and engine cooling
- Summary:
- This campaign is being issued to address a calibration update in certain isb6.7 engines installed in thomas built buses. this document authorizes repair locations to recalibrate the engine control module (ecm) to the latest revision.
- Bulletin:
- TSB130080-060620
- Component:
- 060000 engine and engine cooling
- Summary:
- This technical service bulletin introduces a new cummins service engine model identification. this is a revision to a previous communication.
- Bulletin:
- TSB170031-082320
- Component:
- 080000 fuel system, diesel
- Summary:
- This technical service bulletin describes the verification and resolution of fault code 6255 present with no other fault codes and possible diesel exahust fluid (def) lamp illumination caused by an engine control module calibration code iss
- Bulletin:
- TSB170063-051220
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- This technical service bulletin describes the verfication and resolution of fault codes 3545 and 1887 caused by water or soap entering the exhaust system when vehicles are washed, contaminating the aftertreatment nox sensor element or crack
- Bulletin:
- TSB170085-071420
- Component:
- 080000 fuel system, diesel
- Summary:
- This technical service bulletin describes the verification and resolution of fault code 5867 (aftertreatment diesel exhaust fluid dosing unit relay feedback- voltage below normal or shorted to low source) often leading to unnecessary replac
- Bulletin:
- TSB150089-102020
- Component:
- 080000 fuel system, diesel
- Summary:
- This technical service bulletin describes the verification and resolution of some cases in which the aftertreatment diesel exhaust fluid (def) dosing lines are not being fully purged during the purge cycle. this can result in internal crack
- Bulletin:
- TSB160031-092920
- Component:
- 080000 fuel system, diesel
- Summary:
- This technical service bulletin describes the verification and resolution of diesel exhaust fluid (def) quality fault codes on international truck and ic bus chassis due to a low diesel exhaust fluid (def) level in the def tank. this is a r
- Bulletin:
- T1975
- Component:
- 060000 engine (pws)
- Summary:
- This temporary repair practice authorizes the inspection and replacement of all six rocker levers on identified engine serial numbers when any rocker lever ball has fractured at the interface of shank and flange on rocker lever.
- Bulletin:
- TSB140017-111320
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the verification and resolution of a lubricating oil leak and high crankcase pressure fault codes on engines with an internal crankcase breather filter. the engines are experiencing crankcase breath
- Bulletin:
- TSB150105-111320
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin announces new aftertreatment selective catalyst reduction (scr) catalyist part numbers and supporting parts. this is a revision to a previously submitted communication.
- Bulletin:
- TSB170117-110920
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the verification and resolution of a fracture of rocker lever ball at interface of shank and flange on rocker lever causing low power, white smoke, black smoke, and/or abnormal engine noise. if frac
- Bulletin:
- TSB170119-112020
- Component:
- 110000 electrical system
- Summary:
- This technical service bulletin describes the verification and resolution of a charging system alternator bracket malfunction: ic bus ce series. the malfunction is due to the use of a non-approved dual freon compressor sysstems installed by
- Bulletin:
- TSB170120-112020
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the verification and resolution of aftertreatment diesel particulate filter (dpf) soot load and regeneration fault codes on international ic buses. the air cleaner accordion boot seal does not seal
- Bulletin:
- T1993
- Component:
- 060000 engine (pws)
- Summary:
- This temporary repair practice (trp) is being issued to address the degraded or missing cylinder crosshatch on certain isb6.7 cm2350 b101 and qsb6.7 cm2350 b105 engines. this trp authorizes certified repair locations to replace the engine i
- Bulletin:
- TSB150006-050120
- Component:
- 060000 engine and engine cooling
- Summary:
- This technical sesrvice bulletin describes the verification and resolution of diesel exhaust fluid (def) leaking around the aftertreatment def dosing unit electrical connector, caused by internal cracking due to freezing def. possible faul
- Bulletin:
- TSB160008-050120
- Component:
- 070000 fuel system, gasoline
- Summary:
- This technical service bulletin provides instructions for preventing the malfunction of the aftertreatment fuel injector caused by water intrusion on international prostar chassis when a new aftertreatment fuel injector is being installed.
- Bulletin:
- TSB180086-062220
- Component:
- 060000 engine and engine cooling
- Summary:
- This technical service bulletin describes the verification and resolution of engine speed instability on certain engines mated to a zf ecolife transmission. engine speed instability may result in top gear when the vehicle is approaching th
- Bulletin:
- TSB180086-062220
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- This technical service bulletin describes the verification and resolution of engine speed instability on certain engines mated to a zf ecolife transmission. engine speed instability may result in top gear when the vehicle is approaching th
- Bulletin:
- TSB120309-061320
- Component:
- 063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
- Summary:
- This technical service bulletin describes the verification and resolution of fault code 3714 active with no other active fault codes. due to a software issue, fault code 3714 may become active after adjusting insite? electronic service tool
- Bulletin:
- TSB180095-080620
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- This technical service bulleting describes the verification and resolution of the diesel exhaust fluid (def) system becoming contaminated with debris. def tanks are cleaned and def dosing units or intake lines areflushed or even replaced, b
- Bulletin:
- TSB180112-082720
- Component:
- 060000 engine and engine cooling
- Summary:
- This technical service bulleting describes the new required re-usable crankshaft seal service tool to be used to failsafe installation and removal of rear crankshaft seals in event of leaks moving forward.
- Bulletin:
- TSB120309-092320
- Component:
- 118000 electrical system: software
- Summary:
- This technical service bulletin describes the verification and resolution of fault code 3714 active with no other active fault codes. due to a software issue, fault code 3714 may become active after adjusting insite? electronic service tool
- Bulletin:
- TSB150153-101620
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- This techical service bulletin describes the verification and resolution of fault codes 3314, 3317, 3319, 3146 or 4518 caused by an aftertreatment exhaust gas temperature sensor malfunction. the cause of the malfunction has been determined
- Bulletin:
- TSB170085-103120
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- This technical service bulletin describes the verification and resolution of fault code 5867 (aftertreatment diesel exhaust fluid dosing unit relay feedback- voltage below normal or shorted to low source) often leading to unnecessary replac
Home | Privacy