9999 CUMMINS C8.3 Recalls (2)
- Campaign:
- 96E014000 on 05/22/1996
- Component:
- Vehicle speed control
- Manufactured:
- 09/30/1995 - 03/31/1996
- Affected:
- 88
- Defect:
- The insulation material between the field effect transistor and ground in the throttle actuator can fail, resulting in an electrical short.
- Consequence:
- This condition can result in an uncommanded throttle condition. under these conditions, without warning, the operator could experience loss of throttle control and subsequent engine acceleration.
- Correction:
- Cummins will replace the throttle actuator on the engines involved.
- Notes:
- System: fuel; throttle linkages and control. equipment description: automotive, heavy-duty, natural gas-fueled engines. the two engines involved are the c8.3-250g and l10-300g natural gas engines. note: owner notification is expected to begin during june 1996. note: owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time, should contact cummins at 1-800-343-7457. also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
- Campaign:
- 98E030000 on 09/28/1998
- Component:
- Engine and engine cooling:engine:diesel
- Manufactured:
- 11/25/1991 - 10/11/1995
- Affected:
- 625
- Defect:
- Equipment description: c8.3 urban bus engines shipped to flxible corporation. the lubricating thermostat internal pin exerts force on the inside face of the large aluminum hex nut, wearing a hole in this nut. lubricating oil can then leak or spray up onto the exhaust manifold and into the engine compartment.
- Consequence:
- Oil leakage onto the engine's exhaust manifold and into the engine compartment could possibly result in a fire.
- Correction:
- Dealers will replace the oil thermostat with a new lubricating bypass valve.
- Notes:
- Owner notification began october 2, 1998.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact cummins at 1-800-343-7357 (1-800-diesels).also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
9999 CUMMINS C8.3 TSBs (11)
- Bulletin:
- 0139
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- C8.3g throttle actuator. *tt
- Bulletin:
- C0819
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Cummins: orion voltage regulator campaign. addressing a fuel lift pump voltage regulator issue. authorizes repair shop to remove cummins voltage regulator from wiring harness and install separate 12-vdc power source for orion bus applica
- Bulletin:
- TB-09T6-35
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Cummins: the purpose of this service/parts topic is to announce the release of an improved isc/l cm2150 fuel injector. engine models 6c, c8.3, isl, isle3, qsl9. no model years listed. *pe
- Bulletin:
- SB-E-09059
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Cummins engine: aftertreatment faults due to wiring harness corrosion from coolant level sensor leak. it allows coolant to seep through the wiring harness and cause corrosion. engine models isbe4 (6 cylinder), isl, isle3, qsl9, 6c, c8.3.
- Bulletin:
- SB-09T12-11
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Cummins engine: air compressor head replacement kit. various model engine. no model years listed. *pe
- Bulletin:
- TSB-E09087
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Cummins: removing power from transmission controller before calibrating ecm on grove crane vehicles. this on engines in autocar chassis, specifically units that make use of a multiplexed throttle, such as some grove crane models. failure
- Bulletin:
- SB-10T11-18
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Cummins: new aftertreatment decomposition tube. the purpose of this service/parts topic is to notify the field of an aftertreatment decomposition tube design change aimed at reducing diesel exhaust fluid (def) deposits. *pe
- Bulletin:
- TSB160051
- Component:
- 350000 equipment
- Summary:
- This technical service bulletin describes the replacement of a plastic coolant shut-off valve with a stainless steel shut-off valve.
- Bulletin:
- TSB140061-071316
- Component:
- 060000 engine (pws)
- Summary:
- The isc/qsc cm850/cm2150/cm2250/cm2350, isl g cm2180, and isl/qsl cm850/cm2150/cm2250/cm2350 product lines offer multiple lubricating oil pan options that vary the orientation and mounting hardware. the lubricating oil pan option is selecte
- Bulletin:
- TSB160051-051616
- Component:
- 060000 engine (pws)
- Summary:
- This technical service bulletin describes the replacement of a plastic coolant shut-off valve with a stainless steel shut-off valve.
- Bulletin:
- TSB140061-041816
- Component:
- 060000 engine (pws)
- Summary:
- The isc/qsc cm850/cm2150/cm2250/cm2350, isl g cm2180, and isl/qsl cm850/cm2150/cm2250/cm2350 product lines offer multiple lubricating oil pan options that vary the orientation and mounting hardware. the lubricating oil pan option is selecte
Home | Privacy