9999 CATERPILLAR CATERPILLAR Recalls (3)
- Campaign:
- 77E020000 on 10/11/1979
- Component:
- Engine and engine cooling:engine
- Affected:
- 400
- Defect:
- The top end of the main spring that controls the governor in the speed control is positioned by a two-piece seat. the inside of this seat can wear and cause the sleeve portion of the seat to separate from the washer portion. consequently, the sleeve can drop down and lock the fuel rack in the fully open position, causing engine overspeed.
- Correction:
- Dealer will install an improved seat assembly and guides, without charge.
- Notes:
- Vehicle category: trucks.system: equipment; speed control system, model no. 3408.consequences of defect: this condition could lead to loss of vehicle controland an accident.note: if engine overspeeding occurs before the defect has been corrected, thespeed control switch should be immeditely shut off and the truck left in gearto prevent possible engine damage.
- Campaign:
- 82E018000 on 09/27/1982
- Component:
- Fuel system, gasoline:storage:auxillary tank
- Manufactured:
- 09/30/1977 - 08/31/1982
- Affected:
- 272
- Defect:
- A possibility exists on the involved vehicles, that due to vibrations generated by the truck, the fuel filter"s top connector may break from the bottom of the fuel tank due to metal fatigue. this failure allows the diesel ignition improver to spray out fuel.
- Correction:
- The dealer will inspect and, if necessary, remove the filters from the tank and install a flexible hose from the bottom of the tank to the filter.
- Notes:
- Vehicle category: trucks equipped with caterpillar 3208 engines.system: fuel; fuel injection, model no. 9n3771.consequences of defect: if the tank is inside the engine compartment, a firecould result which could cause serious personal injury to anyone in thevehicle.
- Campaign:
- 83E020000 on 12/08/1983
- Component:
- Engine and engine cooling:engine:diesel
- Manufactured:
- 07/31/1983 - 09/30/1983
- Affected:
- 112
- Defect:
- Shield over the governor flyweights may detatch from carrier and interfere with movement of the weights and governor linkage. the vehicle operator may not be able to shift into gear selected or to prevent engine over-speed.
- Correction:
- Shields found to be cracked will be replaced and staked at four points. others will be staked at two additional points, making a total of four.
- Notes:
- Vehicle category: heavy trucks equipped with diesel engines caterpillar modelno. 3406b.system: engine; governor control shield.consequences of defect: loss of control over engine speed may lead to loss ofvehicle control and an accident. also, unexpected movement may result in anaccident or personal injury.
9999 CATERPILLAR CATERPILLAR TSBs (143)
- Bulletin:
- 8363
- Component:
- 060000 engine and engine cooling
- Summary:
- Product improvement program for replacing the coolant conditioner lines on certain c-10 and c-12 truck engines. *tt
- Bulletin:
- 8366
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Product support program for replacing the exhaust rocker arms on certain c-15 and c-16 truck engines equipped with jacobs 340d compression brakes. *tt
- Bulletin:
- 8371
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Product support program for repairing a broken crankshaft on certain 3406e truck engines. *tt
- Bulletin:
- 8395
- Component:
- 353000 equipment:electrical
- Summary:
- Product improvement program for updating software on certain c-10 and c-12 trucks. *tt
- Bulletin:
- U206
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Product improvement program for repairing the high pressure oil line and fittings between the heui oil pump and the head on certain 3126b engines installed on fmtv trucks. *tt
- Bulletin:
- REBE 3452-00
- Component:
- 350000 equipment
- Summary:
- Product improvement program to verify production software and remove the emissions exemption label on certain 3126, c-7, c-9, c-10, c-11, c-13, and c-15 engines. model years unknown. csc was received. *pe
- Bulletin:
- REBE-4472-00
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Caterpillar: product support program for installing software and purge air check valve on certain c7 and c9 engines. model and model years unknown. *pe
- Bulletin:
- TSB-U-5580-00
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Caterpillar engine: nozzle heater assembly does not seat properly. model 108b, 108e and 108m. model years unknown. *pe
- Bulletin:
- SL-RE-4964-00
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Caterpillar: product support program for inspecting and possibly updating the caterpillar regeneration system on certain c13 on highway truck engines equipped with 12 volt and certain 24 volt heated nozzle after treatment regeneration devic
- Bulletin:
- SL-REBE-4987-01
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Caterpillar: product support program for installing updated open crankcase ventilation filter on certain c13 truck engines. model and model years unknown. *pe
- Bulletin:
- SL-PS-51637
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Caterpillar: product support program for updating the caterpillar regeneration system on certain c13 and c15 on highway truck engines. model and model years unknown. *pe
- Bulletin:
- SL-PI-31649
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Caterpillar: product improvement program for replacing the aftertreatment regeneration device (ard) combustion body on c15 on highway truck engines installed in certain international chassis. model and model years unknown.
- Bulletin:
- SL-PS-42865
- Component:
- 060000 engine and engine cooling
- Summary:
- Caterpillar: product support program for rerouting the shunt line on certain c13 and c15 on highway truck engines. model and model years unknown. *pe
- Bulletin:
- SL-PS-42877
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Caterpillar: product support program for replacing the diesel particulate filter (dpf) on c9 engines installed in mass transit buses. model and model years unknown. *pe
- Bulletin:
- TIB-5690-00
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Caterpillar: procedure for repairing oil leak at spacer plate. oil may leak from engine at the left rear corner or the right rear corner of cylinder block around spacer plate. the spacer plate is located between the cylinder head and the en
- Bulletin:
- SL-PI-70309
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Caterpillar: product improvement program for inspecting and possibly reworking or0997, or1000, or1001, or1002, or1003, or1004, or1005, and or1006 reman water pumps in dealer parts stock. certain reman water pumps were discovered to have t
- Bulletin:
- SL-PI-70310
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Caterpillar: product improvement program for inspecting and possibly reworking or9749, or9750, and 148-2144 cylinder heads in dealer parts stock. some cylinder heads were assembled with intake and exhaust valves in the incorrect position.
- Bulletin:
- SB-SMCS-5502
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Caterpillar: new improved air lines for air compressors. new air compressors groups are used for all engines. the changes include steel braided hose and new fittings that will add improved life and reliability to the parts. model engine
- Bulletin:
- PI-31761
- Component:
- 102000 power train:manual transmission
- Summary:
- Caterpillar service campaign: see document search button for owner letter. product improvement program for reworking the number 2 clutch and updating planet carrier and shafts on certain cx31 retarder transmissions. csc letter was rec'd.
- Bulletin:
- PI-31768
- Component:
- 102000 power train:manual transmission
- Summary:
- American caterpillar/caterpillar service campaign: see document search button for owner letter. product improvement program for reworking train 3 planet carrier and shafts on certain cx31 retarder transmissions. the train 3 planet carrier
- Bulletin:
- PI-10816
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Caterpillar service campaign: see document search button for owner letter. product improvement program for installing 365-6842 engine software on certain c9 engines installed in pierce fire trucks. software needs to be installed on certai
- Bulletin:
- TSB-43159
- Component:
- 102000 power train:manual transmission
- Summary:
- Caterpillar: the thrust bearing can fail on some cx31 transmissions. *rm
- Bulletin:
- TIB-6146
- Component:
- 080000 fuel system, diesel
- Summary:
- Caterpillar: there is thread damage to the temperature sensor and diesel filter ports. *rm
- Bulletin:
- CLIB-0007
- Component:
- 101000 power train:clutch assembly
- Summary:
- Caterpillar: inspection requirements before installing a clutch. *rm
- Bulletin:
- TIBU-6332-00
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Caterpillar: on certain on highway trucks, audible air leaks at the air control valve. *pe
- Bulletin:
- SEPD-1316-00
- Component:
- 102000 power train:manual transmission
- Summary:
- Caterpillar: an incorrect diagnostic code for certain cx transmissions potential repair option for replacement of the oil level sensor. *pe
- Bulletin:
- SEPD-1318-00
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Caterpillar: under air cleaner near steering column, located in engine compartment, is the remote mounted engine control feature connectors. and wiring. *pe
- Bulletin:
- TIBU-6580
- Component:
- 060000 engine and engine cooling
- Summary:
- Caterpillar: certain remanufactured cylinder packs for 3400 series engines contain improperly installed piston rings. *kb
- Bulletin:
- SEPD-1433
- Component:
- 118000 electrical system: software
- Summary:
- Caterpillar: on certain on highway trucks and transmissions, a new improved software is available for power transmissions. *pe
- Bulletin:
- SEB-6869
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Caterpillar: on some truck engines, to prevent exhaust gas leakage and exhaust leakage, new shields and seals, of slip joint, are available. model c11, c13, c15. no model years listed. *pe
- Bulletin:
- SEPD-1519
- Component:
- 102000 power train:manual transmission
- Summary:
- Caterpillar: new one piece housing design replaces two piece housing design and eliminates unnecessary bolted joint on torque converter groups on certain transmissions. models cx31, cx35. no model years listed. *pe
- Bulletin:
- SEBD-6871
- Component:
- 092100 fuel system, other:delivery:fuel pump
- Summary:
- Caterpillar: with different shaft and seal materials and tighter tolerances on internal components, new primping pump helps prevent loss of engine fuel priming, when machine is not operational and improves initial fuel priming. all mode
- Bulletin:
- TIBU-6900
- Component:
- 060000 engine (pws)
- Summary:
- Caterpillar: a new gasket for the intake throttle valve is used on certain ct11 and ct13 engines. *js
- Bulletin:
- SEB-9792
- Component:
- 060000 engine (pws)
- Summary:
- Caterpillar: the fuel injectors, used in commercial engines, have been improved, by manufacturing process, to within proper specifications, and correct spray pattern. no models or model years listed. *pe
- Bulletin:
- TAM-61629-100
- Component:
- 356000 equipment adaptive
- Summary:
- Caterpillar: information being provided regarding changes pertaining to equipment and owners and publications, written and/or electronic communications and notices. no models or model years listed. *pe
- Bulletin:
- SEBD-6878
- Component:
- 060000 engine (pws)
- Summary:
- Caterpillar: on certain 3126b truck engines, a new electronic control module (ecm), which has been updated, is now available. no model years listed. *pe
- Bulletin:
- SEBD-6881
- Component:
- 060000 engine (pws)
- Summary:
- Caterpillar(cat): information being provided regarding the accessories and new turbo chargers, replacement and overhaul of variable valve actuator assembly on certain high horsepower truck engines and on highway truck engines. models c11,
- Bulletin:
- REBE-9932-00
- Component:
- 010000 steering
- Summary:
- Caterpillar: information concerning the product support program for replacing the clutch lever and rod assembly. *js
- Bulletin:
- TEBE-0185-00
- Component:
- 060000 engine (pws)
- Summary:
- Caterpillar: information concerning the inspection and possible repair of the engine wiring harness. the engine can have many different routing and clipping failures. this could cause rubbing points on the harness. model ct660. no model yea
- Bulletin:
- TIBU-7219-00
- Component:
- 102000 power train:manual transmission
- Summary:
- Caterpillar: some vehicles disengage out of certain gears. this due to the shift tower experiencing intereference with the lower shift boot. model ct660 built before april 30, 2013. *js
- Bulletin:
- REHS-7743-01
- Component:
- 072100 fuel system, gasoline:delivery:fuel pump
- Summary:
- Caterpillar:information concerning the procedure to install the high pressure fuel pump. model ct660. no model years were provided. *js
- Bulletin:
- REBE-9970
- Component:
- 110000 electrical system
- Summary:
- Caterpillar: information concerning the installation of the ground wire for the ac compressor clutch solenoid. model ct660. no model years were provided. *js
- Bulletin:
- TIBU-7291-00
- Component:
- 060000 engine (pws)
- Summary:
- Caterpillar: in certain c9 and c9.3 engines, the guide springs may break. *js
- Bulletin:
- TIBU-7307-00
- Component:
- 030000 brakes (pws)
- Summary:
- Caterpillar: the improper installation of the brake return spring will not provide proper clearance between return spring and wheel hub. there is no permanent solution for this issue. *js updated 12/20/13. *pe
- Bulletin:
- REHS-7728
- Component:
- 073000 fuel system, gasoline:fuel injection system
- Summary:
- Caterpillar: information concerning the replacement procedure for the fuel injection pump on some ct11 and ct13 engines in ct660 vocational trucks {7000}. *js
- Bulletin:
- REHS-7743-02
- Component:
- 072100 fuel system, gasoline:delivery:fuel pump
- Summary:
- Caterpillar: information concerning the procedure to install the high pressure fuel pump on the ct660 on the highway truck [7000}. *js
- Bulletin:
- REHS-8968
- Component:
- 060000 engine (pws)
- Summary:
- Caterpillar: information concerning the 622 nets programming error in c11, ct13. and ct15 engines. *js
- Bulletin:
- TIBU-7322-00
- Component:
- 353600 equipment:air conditioner
- Summary:
- Caterpillar: information concerning the repair of the hvac dryer failure. desiccant beads release from the dryer into the hvac system. *js
- Bulletin:
- TIBU-7325-00
- Component:
- 070000 fuel system, gasoline
- Summary:
- Caterpillar: information concerning broken, leaking or ruptured high pressure fuel line. bolts may be missing and/or loose. *js
- Bulletin:
- TIBU-7347
- Component:
- 010000 steering
- Summary:
- Caterpillar: oil dipstick p- clip and power steering line p-clamp may be broken. there is no known permanent fix for this failure. *js
- Bulletin:
- SEPD-1676
- Component:
- 060000 engine (pws)
- Summary:
- Caterpillar: information concerning the remote mounted engine control feature 12wbx wiring and connector information for ct11 and ct13 engines. *js
- Bulletin:
- REBE9773-00
- Component:
- 060000 engine (pws)
- Summary:
- Caterpillar: information concerning the product support program for reworking the air control valve connector on some ct660 on highway trucks. *js
- Bulletin:
- SEBD-9877
- Component:
- 060000 engine (pws)
- Summary:
- Caterpillar: information concerning a new cam gear for certain engines (1212). *js
- Bulletin:
- REHS-8728
- Component:
- 060000 engine and engine cooling
- Summary:
- Caterpillar: information instructions regarding, the flushing and cleaning contaminated cooling system, procedure when engine oil enters and mixes with engine coolant, causing an oil cooler failure. model ct660. no years listed.
- Bulletin:
- SEBD6880
- Component:
- 060000 engine (pws)
- Summary:
- Caterpillar: when engine is overhauled, the variable valve actuator (vva) assembly should be replaced to eliminate the build up of soot and on internal components, reduce wear. model c7. no years listed. *pe
- Bulletin:
- SEBD-6882
- Component:
- 073200 fuel system, gasoline:fuel injection system:injectors
- Summary:
- Caterpillar: in order to minimize damage from debris, fuel injectors utilize increased hardening and wear coating for critical fuel injector parts. no model or years listed. *pe
- Bulletin:
- TIBU-74-08
- Component:
- 062200 engine and engine cooling:cooling system:fan
- Summary:
- Caterpillar: if fan drive drops below 621 kpa (90 psi) the fan will slip and cause overheating, excessively, that will damage the clutch. *pe
- Bulletin:
- SEBD-9922
- Component:
- 062200 engine and engine cooling:cooling system:fan
- Summary:
- Caterpillar: to extend the life of the lubrication system, a new oil pump and lines group are being used and is more robust. *pe
- Bulletin:
- TIBU-7199
- Component:
- 356000 equipment adaptive
- Summary:
- Caterpillar: due to front axle front spring pin is coming loose, trucks experiencing failures, because bolt are not large enough to prevent spring from moving side to side and causing a popping noise and allowing pin to back out. model c
- Bulletin:
- REHS-8726
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Caterpillar: information being provided regarding procedures, in repairing and testing, of misplaced valve bridges on some engines, in some trucks. model ct660. no years listed. *pe
- Bulletin:
- SEBD-9922-00
- Component:
- 060000 engine (pws)
- Summary:
- Caterpillar: information regarding availability of new liner o ring seal that improves geometry for easier installation in certain engines. models c10, c11, c12, c13. no years listed. *pe
- Bulletin:
- TEBE-0790
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Caterpillar: when truck is either parked or stopped, engine would increase rpm while idling, and calibration has been updated for engine electronic control module (ecm). *pe
- Bulletin:
- SEBD-9927-00
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Caterpillar: on some engines, the oil bypass valve spring plug will back out, due to low torque, lack of thread locker or vibration causing loss of torque. *pe
- Bulletin:
- TEBE0462-0
- Component:
- 160000 structure
- Summary:
- Caterpillar: information concerning the replacement of the lower hood hinge bracket on some vehicles. the failure of mounting studs can lead to the hinge bending. includes certain ct660 on highway trucks. no model year provided. *js
- Bulletin:
- TEBE-01023-00
- Component:
- 070000 fuel system, gasoline
- Summary:
- Caterpillar: information concerning the replacement of the aftertreatment fuel line 1. high pressure from a newer calibration file can cause fuel shut off valve pressure sensor damage. includes certain ct660 on highway trucks. *js
- Bulletin:
- TEBE-1095-00
- Component:
- 130000 visibility/wiper (pws)
- Summary:
- Caterpillar: information concerning the installation of intermittent wipers. applies to ct660 on certain highway trucks. no model years provided. *js
- Bulletin:
- SEPD-1749-00
- Component:
- 103700 power train:automatic transmission:torque converter
- Summary:
- Caterpillar: particular on-highway transmissions, petroleum transmissions, and petroleum power train packages now use improved torque converter housings. *js
- Bulletin:
- SEPD-1751-00
- Component:
- 103700 power train:automatic transmission:torque converter
- Summary:
- Caterpillar: particular on-highway transmissions, petroleum transmissions, and petroleum power train packages now use improved torque converter housings. *js
- Bulletin:
- REHS-9170
- Component:
- 060000 engine (pws)
- Summary:
- Caterpillar: information concerning the procedure to replace the solid aftertreatment fuel line 1 and recalibrate the engine control module and the aftertreatment control. applies to some ct660 vocational trucks {7000}. no model years provi
- Bulletin:
- SEPD-1753-00
- Component:
- 101000 power train:clutch assembly
- Summary:
- Caterpillar: information concerning an improved fastening process for the number two clutch seal housing on particular cx31 and cx35 transmissions. *js
- Bulletin:
- SEBD-6886
- Component:
- 356000 equipment adaptive
- Summary:
- Caterpillar: caterpillar products has a new programming flash file extension and to open it requires caterpillar electronic technician (cat et) 2013b and flash files on previous extensions can be read also. *pe
- Bulletin:
- REHS-1572-02
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Caterpillar: information provided regarding the criteria of replacing the camshaft in 3406e, c15, c-15 and c-16 engines. *pe
- Bulletin:
- REHS-9168-01
- Component:
- 350000 equipment
- Summary:
- Caterpillar: there is a procedure, in place, to remove, replace and installed a cartridge for the high pressure turbocharger. ct11, ct13 engines. *pe
- Bulletin:
- TIBU-7432-01
- Component:
- 073200 fuel system, gasoline:fuel injection system:injectors
- Summary:
- Caterpillar: low engine power or injector misfire causing unplanned downtime and to prevent the failure of injector harness on certain engines, replacement components are available. *pe
- Bulletin:
- REHS-9182
- Component:
- 111100 electrical system:battery:cables
- Summary:
- Caterpillar: near the starter, the battery cable rubs against the bracket bolt, due to cable routing, that holds battery cable in place. *pe
- Bulletin:
- TEBE-1219
- Component:
- 356000 equipment adaptive
- Summary:
- Caterpillar: information on certain parts removed, gauge clusters, from dealer parts stock, due to needles sticking. *pe
- Bulletin:
- TIBU-7573
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Caterpillar: the excessive exhaust temperatures are caused by boost leaks, typically, due to cracking turbocharger turbine housing, on certain acert trucks. *pe
- Bulletin:
- REHS-9179
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Caterpillar: information regarding knock detection diagnostic code of unexpected fueling without demand or cylinder acceleration above normal, engine lamp illuminated with audible alarm. *pe
- Bulletin:
- TIBU-7527
- Component:
- 350000 equipment
- Summary:
- Caterpillar: on some trucks, the thrust plate thickness is out of specification, and the thrust plate not made to print and bolts are sheared off and would need to be replace. *pe
- Bulletin:
- TIBU-6576-03
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Caterpillar: information regarding the failure of guide spring because of inconsistencies, during production, in the part and would need to be inspected before installation. *pe
- Bulletin:
- TIBU-7605
- Component:
- 060000 engine (pws)
- Summary:
- Caterpillar: some vehicles may have coolant in the oil. the engine oil will be light gray in color and have a sludge-like appearance. the crankcase may be overfilled. 2010-2013 ct11 and ct13. model ct660. no model year provided. *js
- Bulletin:
- TIBU-7603
- Component:
- 060000 engine (pws)
- Summary:
- Caterpillar: there may be low coolant and/or consumption on 2010-2013 ct11 and ct13 liter engines. there may be a need to regularly refill the deaeration tank and active or previously active dtcs in relation to the cooling system. model ct6
- Bulletin:
- TIBU-7586
- Component:
- 060000 engine (pws)
- Summary:
- Caterpillar: information concerning using a wear sleeve when replacing the crankshaft seal. using the wear sleeve may cause stress to the seal creating a repeat failure on certain c9 and c9.3 engines. *js
- Bulletin:
- SEBD-9941
- Component:
- 073200 fuel system, gasoline:fuel injection system:injectors
- Summary:
- Caterpillar: information concerning an appearance change on the heui injectors to c7 an c9 engines (1251,1254,1290,1713). *js
- Bulletin:
- SEBD-9943
- Component:
- 060000 engine (pws)
- Summary:
- Caterpillar: information concerning low engine oil pressure issues, oil pump failures for c9 and c9.3 commercial engines (1304,1315). *js
- Bulletin:
- SEPD-1786
- Component:
- 160000 structure
- Summary:
- Caterpillar: information concerning the procedure for the improved floor mat cut-out on ct660 highway trucks(7000). *js
- Bulletin:
- REHS-9166
- Component:
- 070000 fuel system, gasoline
- Summary:
- Caterpillar: information concerning troubleshooting for some ct660 highway trucks. there may be a failure to start due to low rail fuel pressure. no model years were provided. *js
- Bulletin:
- REHS-9167
- Component:
- 070000 fuel system, gasoline
- Summary:
- Caterpillar: information concerning troubleshooting for below minimum with maximum command on certain ct660 highway trucks. *js
- Bulletin:
- REHS-9188
- Component:
- 060000 engine (pws)
- Summary:
- Caterpillar: information concerning the procedure for trouble shooting the spn 190 fmi 0 engine oversped vehicle event fault. *js
- Bulletin:
- TEBE-1360
- Component:
- 111100 electrical system:battery:cables
- Summary:
- Caterpillar: the battery cables current routing, near starter, is rubbing against the bracket bolt that holds it in place. model ct660, ct681. *pe
- Bulletin:
- TIBU-7637
- Component:
- 350000 equipment
- Summary:
- Caterpillar: the spool assembly check ball, in main relief valve, is missing and the missing ball can cause noise or pressure instability in power train oil system. *pe
- Bulletin:
- TEBE-1530
- Component:
- 060000 engine (pws)
- Summary:
- Caterpillar: see document search button for owner letter. on certain trucks, the engine can shut down due to electronic control module (ecm) can reset to operating temperature and needs replacing. *pe
- Bulletin:
- SEBD6893
- Component:
- 092100 fuel system, other:delivery:fuel pump
- Summary:
- Caterpillar: the fuel pumps have an improved seal between the pump housing and transfer pump. *lj
- Bulletin:
- TEBE1878-00
- Component:
- 060000 engine (pws)
- Summary:
- Caterpillar: piston skirts with u182-183 codes can lead to piston seizure on certain 3456 or c-16 engines. *lj
- Bulletin:
- TIBU-8100
- Component:
- 060000 engine (pws)
- Summary:
- Caterpillar: on various engine, in trucks, are failures of valve lifter assemblies and guide springs and the failures are causing damage to valve lifter and cam lobe that requires extensive repairs. model c9, c9.3. no years listed.
- Bulletin:
- TEBE-2790
- Component:
- 060000 engine (pws)
- Summary:
- Caterpillar: some trucks have a related engine emission defect and would need calibration file to be updated on electronic control module (ecm) for engine. model 2013 ct13. *pe
- Bulletin:
- IK0400125
- Component:
- 030000 brakes (pws)
- Summary:
- Navistar: various types navistar vehicles will be receiving updates on the rear s cam tube/ bracket parts. *ta updated 9/10/15 *cn
- Bulletin:
- TIBU-8069
- Component:
- 356000 equipment adaptive
- Summary:
- Caterpillar: on some trucks, due to new a design the cooler straps or cooler strap bolts never be loosen or be removed or adjusted and if loosen or removed, must be replaced. model 2015 ct 13. *pe
- Bulletin:
- 2007-00
- Component:
- 060000 engine (pws)
- Summary:
- Ct660 truck now uses an improved transmission harness routing which prevents damage from the seat mechanism *cn
- Bulletin:
- 3156-00
- Component:
- 350000 equipment
- Summary:
- On some ct660 highway trucks the current exhaust flex pipes can crack, causing leakage. *cn
- Bulletin:
- 8374-00
- Component:
- 350000 equipment
- Summary:
- On certain ct680 highway trucks the steer axle brake chamber air line rubs the front tire. *cn
- Bulletin:
- M0076487-00
- Component:
- 114000 electrical system:wiring
- Summary:
- Improved wiring harnesses are now used on certain engines - the improved wiring harnesses are built with non-degrading braiding.
- Bulletin:
- M0075571-01
- Component:
- 114000 electrical system:wiring
- Summary:
- Improved wiring harnesses are now used on certain engines - the improved wiring harnesses are built with non-degrading braiding. added s/n's for r1d and egh.
- Bulletin:
- M0075571-00
- Component:
- 114000 electrical system:wiring
- Summary:
- Improved wiring harnesses are now used on certain engines - the improved wiring harnesses are built with non-degrading braiding
- Bulletin:
- M0075270-01
- Component:
- 073200 fuel system, gasoline:fuel injection system:injectors
- Summary:
- Improved fuel injectors are now used on certain c7 and c9 - the improved fuel injectors have loctite® impregnated solenoid coils.
- Bulletin:
- M0075762-00
- Component:
- 080000 fuel system, diesel
- Summary:
- Reman cat® cleaned diesel particulate filters may be missing the serial number prefix - reman cat cleaned diesel particulate filters (dpfs) may be missing the first 4 digits of the serial number. use the first 4 digits from the dpf being re
- Bulletin:
- M0075266-01
- Component:
- 100000 power train
- Summary:
- New control valve bolt is now used on certain cx31 on-highway transmissions - new bolts are more robust which improves the bolted joint to the separator plate.
- Bulletin:
- M0071400-00
- Component:
- 060000 engine (pws)
- Summary:
- A new head gasket is used on certain truck engines - truck engine news, sebd6904, 23, september 2015, a new head gasket is used on certain truck engines . disregard the previous article. refer to the following information. description of ch
- Bulletin:
- M0073142-00
- Component:
- 118000 electrical system: software
- Summary:
- New software is now used on certain c9 truck engines - the new software was updated to eliminate false derates.
- Bulletin:
- M0073612-00
- Component:
- 060000 engine (pws)
- Summary:
- Cylinder head and spacer plate gasket failures on certain truck engines - improper repair procedures during engine overhaul can cause failure of the cylinder head gasket and/or spacer plate gasket. improper repair procedures cause loss of l
- Bulletin:
- TEBE4773-00
- Component:
- 114000 electrical system:wiring
- Summary:
- Product improvement program for inspecting and possibly removing 100-4721, 255-4533, and 255-4534 injector wiring harnesses from dealer parts stock - certain 100-4721, 255-4533, and 255-4534 injector wiring harnesses may have incorrect brai
- Bulletin:
- REHS7354-10
- Component:
- 118000 electrical system: software
- Summary:
- Release notes for visionlink and visionlink store for all caterpillar products - this special instruction contains information about release notes for visionlink and visionlink store for all caterpillar products. improved visionlink and vi
- Bulletin:
- TIBU5690-03
- Component:
- 060000 engine (pws)
- Summary:
- Procedure for repairing the oil leak at the spacer plate on c15 and c18 engines - oil may leak from the engine at the cylinder block around the spacer plate. the spacer plate is located between the cylinder head and the engine block. repair
- Bulletin:
- TIBU8296-02
- Component:
- 060000 engine (pws)
- Summary:
- Some reman injectors have been labeled with the incorrect part number - the reman injectors in table 1 were labeled with an incorrect part number. using one of the mislabeled injector could cause engine performance issues. if an injector id
- Bulletin:
- TIBU8403-00
- Component:
- 060000 engine (pws)
- Summary:
- Reman fuel injectors have been shipped without providing trim files for certain c15 engines - caterpillar may have shipped the following reman fuel injectors without providing a trim file on the cd in the injector box, or having the trim fi
- Bulletin:
- SEBD6901-00
- Component:
- 060000 engine (pws)
- Summary:
- New turbochargers are available for certain c13 and c15 truck engines - the improved turbochargers have a new oil deflector to prevent possible oil leakage.
- Bulletin:
- REHS5713-04
- Component:
- 060000 engine (pws)
- Summary:
- Correct combinations of connecting rods allowed in remanufactured cylinder packs for certain c13 engines - certain combinations of connecting rods in c13 engines are causing engine vibration. the vibration is occurring when an engine has a
- Bulletin:
- SEBD6904-00
- Component:
- 060000 engine (pws)
- Summary:
- A new head gasket is used on certain truck engines - a new head gasket is being used that has an improved fire ring and a sealing bead around the drain back hole.
- Bulletin:
- TIBU8479-00
- Component:
- 100000 power train
- Summary:
- Bolts for the control valve may come loose on certain cx31 on-highway transmissions in the ct660 on-highway trucks - the ct660 on-highway trucks equipped with the cx31 transmission have had the 8t-4908 bolts loosen from the 371-0891 separat
- Bulletin:
- M0068178-00
- Component:
- 060000 engine (pws)
- Summary:
- Debris in oil system causing repeat failures of the (heui) pump for certain c7 and c9 engines - if repeat, low-hour (heui) pump failures occur, the following are possible paths of debris entering the system in operation. these paths are rec
- Bulletin:
- M0068580-00
- Component:
- 103000 power train:automatic transmission
- Summary:
- The 249-2329 oil filter element as (transmission filter) center post may separate from the filter - the center post plug on the 249-2329 oil filter element as may separate from the end cap of the filter. to prevent damage to the filter duri
- Bulletin:
- M0068690-00
- Component:
- 103000 power train:automatic transmission
- Summary:
- Improved transmission filter bypass switch is now used on certain products - the new switch improves the accuracy of the transmission filter bypass warning indicator.
- Bulletin:
- CPI400017
- Component:
- 060000 engine and engine cooling
- Summary:
- Some reman 3126 heui injectors were shipped with incorrect case orings (p/n 148-2903) these orings are shipped in a separate kit with the injector. please use 148-2903 oring from dealer stock to replace any incorrect orings. incorrect oring
- Bulletin:
- SEBD988700
- Component:
- 356000 equipment adaptive
- Summary:
- Caterpillar extended life inhibitor (eli) is now available for use in applications that freeze protection is not needed - news sebd9670, 06 october 2010, "caterpillar extended life inhibitor (eli) is now available for use in applications th
- Bulletin:
- SEBD688200
- Component:
- 070000 fuel system, gasoline
- Summary:
- Improved caterpillar remanufactured fuel injectors for certain c7 on-highway truck engines - the fuel injectors utilize increased hardening and wear coating to critical fuel injector parts in order to minimize damage from debris.
- Bulletin:
- TEBE668600
- Component:
- 073000 fuel system, gasoline:fuel injection system
- Summary:
- Product improvement program for inspecting and possibly replacing an oring seal on certain heui reman fuel injectors in dealer parts stock an incorrect o-ring seal may possibly be included with certain heui reman fuel injectors. if the inc
- Bulletin:
- TEBE663001
- Component:
- 060000 engine (pws)
- Summary:
- Product improvement program for inspecting and possibly removing certain 1r-0716 engine oil filters from dealer parts stock - some 1r-0716 engine oil filters (lube filters) may possess a manufacturing problem which could make the filter dif
- Bulletin:
- M0088469-00
- Component:
- 060000 engine (pws)
- Summary:
- Improved crankshafts are now used on certain cat® engines - the new crankshafts provide improved surface finish for the rear sealing surface on the hub to improve very early hour oil leakage.
- Bulletin:
- CPI384132
- Component:
- 350000 equipment
- Summary:
- Warranty and field complaints have increased on cat 270 air compressors after the change was made to the 20r5604 and 20r5605 part numbers. dealers are experiencing and increased amount of oil passing into the air systems in early hours afte
- Bulletin:
- CPI375841
- Component:
- 070000 fuel system, gasoline
- Summary:
- Fuel is leaking past the injector tip seal, into engine oil resulting in oil dilution with fuel. a newly designed double delta check seal and backing plate are undergoing field validation and bench tests at this time. testing for both the f
- Bulletin:
- CPI384132
- Component:
- 060000 engine and engine cooling
- Summary:
- High oil passing into the air system has been reported after installing areman air compressor on c13 (lee) or c15 (sdp) truck engines. supplier design and manufacture quality issue identified as another root cause of excessive oil passing i
- Bulletin:
- M009174000
- Component:
- 060000 engine and engine cooling
- Summary:
- The function of the intake valve actuation (iva) piston is extremely sensitive to the torque applied to the jam nut. when the torque applied to the jam nut is higher than what is recommended in the service documentation, the piston may beco
- Bulletin:
- CPI383726
- Component:
- 114000 electrical system:wiring
- Summary:
- The wiring harness can have an open circuit, which may result in low power, misfire, etc.
- Bulletin:
- CPI400017
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Some reman 3126 heui injectors were shipped with incorrect case orings (p/n 148-2903) these orings are shipped in a separate kit with the injector. please use 148-2903 oring from dealer stock to replace any incorrect orings. incorrect oring
- Bulletin:
- CPI404428
- Component:
- 350000 equipment
- Summary:
- Bolts and pendulum dampers coming out of the front peanut cover. it has been found the bolts for the pendulum damper ring are not being torqued appropriately from the supplier and spiralock featured machined incorrectly within threaded hole
- Bulletin:
- CPI410778
- Component:
- 060000 engine (pws)
- Summary:
- The engine oil cap will come off while the engine is running and oil splashes out through the fill tube. the engine oil cap will come off while the engine is running and oil splashes out through the fill tube. caterpillar is aware of this p
- Bulletin:
- CPI414053
- Component:
- 110000 electrical system
- Summary:
- Finding instances of oil in the coolant. c18 cylinder liner have been found cracked radially in the top o-ring groove in c18 engines around the world. the 5169693 liner was introduced between march 2017 and november 2017 for reman cylinder
- Bulletin:
- TEBE740500
- Component:
- 060000 engine and engine cooling
- Summary:
- Certain reman cylinder packs built from march 23, 2017 through november 16, 2017 may contain 516-9693 cylinder liner. coolant and engine oil mixture may occur if the cylinder liner o-ring grooves crack if installed.
- Bulletin:
- M009275500
- Component:
- 060000 engine (pws)
- Summary:
- The oil filler cap becomes loose during engine operation due to insufficient tension between tube assembly and the cap. in the event of failure, replace the loose 068-4497 oil filler cap with new 260-4810 engine oil filler cap as.
- Bulletin:
- CPI397779
- Component:
- 350000 equipment
- Summary:
- Water pump leaks through the weep hole leaking water pumps through the weep hole on certain machines forestry, wheel tractor scrapers, motor graders & medium wheel loader. internal pump housing feature causing water to pool in pump housing
- Bulletin:
- CPI404428
- Component:
- 350000 equipment
- Summary:
- Target completion date has changed from 4/13/2018 to 5/11/18.bolts and pendulum dampers coming out of the front peanut cover. it has been found the bolts for the pendulum damper ring are not being torqued appropriately from the supplier and
- Bulletin:
- CPI416932
- Component:
- 060000 engine (pws)
- Summary:
- Sensor design change 06 has incorrect lower operating limit. this causes a false sensor diagnostic (164-4 injector actuation pressure: voltage below normal) due to component design issue. engine remains operational.
- Bulletin:
- CPI425524
- Component:
- 110000 electrical system
- Summary:
- Same as last month's submission but addityional s/n prefix added, mxs. certain 10r5645, 10r5647, 10r5648, 10r5649, and 20r1834 reman ecu's were assembled with incorrect parts causing calibration failures and/or issues with not retaining par
Home | Privacy