9999 CARRIER TRANSICOLD CARRIER TRANSICOLD Recall
- Campaign:
- 76E007000 on 10/11/1979
- Component:
- Fuel system, gasoline:storage:tank assembly:mounting
- Affected:
- 546
- Notes:
- Possibility that the fuel tank straps used to install diesel poweredrefrigeration equipment may have defective welds.failure of welded area maycause fuel tank to break free from trailer.if this occurs, it could become ahazard to traffic safety.(correct by inspecting and replacing or reweldingstraps as necessary).
9999 CARRIER TRANSICOLD CARRIER TRANSICOLD TSBs (60)
- Bulletin:
- TSB-12-002
- Component:
- 072200 fuel system, gasoline:delivery:hoses, lines/piping, and fittings
- Summary:
- Carrier transicold: a retrofit kit has been developed for battery cable, generator wires and fuel hose, due to being either pinched or rubbed, and causing potential damage to vector units. no model years listed. *pe updated
- Bulletin:
- SER-12-036
- Component:
- 060000 engine (pws)
- Summary:
- Carrier: an outboard bearing carrying blower wheel load and to provide extra stability to unit is applied in extreme operating environment was introduced, along with tapered shaft fan adapter. model and model years unknown. *
- Bulletin:
- SER-12-038
- Component:
- 060000 engine (pws)
- Summary:
- Carrier: before replacing compressor, for failing megaohm test, in vector unit, with terminal block removed, check compressor windings. model and model years unknown. *pe
- Bulletin:
- SER-11-006
- Component:
- 110000 electrical system
- Summary:
- Carrier: certain units, with electric standby 450/3/60, need to have overload relay replaced, due to overloads in units might fail to trip when required, resulting in damage to unit, power supply and/or personal injury. models supra, ultr
- Bulletin:
- SER-10-006
- Component:
- 092300 fuel system, other:fuel filter
- Summary:
- Carrier: due to fuel filter housing being reassembled, after changing the fuel filter element, the drain fitting may contact fuel supply line due to the drain port being off center. no model or model years listed. *pe
- Bulletin:
- TI-98-50296-REVB
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Carrier: information being provided regarding the installation of flex exhaust support bracket on x2 2500a units, which can not be use on other units. no models or model years listed. *pe
- Bulletin:
- SER-11-029 REVA
- Component:
- 072200 fuel system, gasoline:delivery:hoses, lines/piping, and fittings
- Summary:
- Carrier: retrofit kits has been developed for battery cables, generator wires, and fuel hoses that may be pinched or rubbing, and may cause potential damage and should be installed to correct the situation. models 6500/6600mt, 1800mt. no
- Bulletin:
- SER-10-011
- Component:
- 062200 engine and engine cooling:cooling system:fan
- Summary:
- Carrier: check condenser fan, prior and after installation, for spinning freely, and if locked or fan blades contact plastic outer plastic housing or any resistance to motion, then replace condenser fan. no model or model years listed.
- Bulletin:
- SER-10-012
- Component:
- 110000 electrical system
- Summary:
- Carrier: some trucks fail to have ground fault circuit interrupter (gfci) outlet and installed in trucks, with running water, and could pose a risk of electrocution. power outlet must be removed and replaced with gfci outlet to prevent pot
- Bulletin:
- SER-11-004
- Component:
- 110000 electrical system
- Summary:
- Carrier: absence of gfci outlet in trucks with running water source could pose a risk of electrocution and would need ground fault circuit interrupter (gfci) installed in trucks to eliminate potential hazard of electrocution. models pc500
- Bulletin:
- PTS-10-036
- Component:
- 090000 fuel system, other
- Summary:
- Carrier: information provided regarding recall of part 20-12-9342c, the fuel/water separator, concerning an issue with the threads on the filters. no models or model years listed. *pe
- Bulletin:
- SER-13-016
- Component:
- 118000 electrical system: software
- Summary:
- Carrier transicold: rev 4.15 and 4.16 with rev u2 4.06 have software available for a field upgrade on some vehicles. *js
- Bulletin:
- SER-13-015
- Component:
- 160000 structure
- Summary:
- Carrier transicold: the multi-port suction line fitting on the direct drive product line ay be blocked with brazing alloy. if after inspection it is found to be blocked drill out the material with a .125" or 3.17mm drill bit. *js
- Bulletin:
- SER-13-021
- Component:
- 092300 fuel system, other:fuel filter
- Summary:
- Carrier: a new blue fluor-silicone o-ring (p/n 74-01031-00) has been produced in order to replace the existing bevel gasket to address potential fuel leaks between the bowl and filter. *js
- Bulletin:
- CTR-GSER-13-001
- Component:
- 092300 fuel system, other:fuel filter
- Summary:
- Carrier transicold: see document search button for owner letter. a new blue fluor-silicone o-ring (p/n 74-01031-00) has been produced in order to replace the existing bevel gasket to address potential fuel leaks between the bowl and filt
- Bulletin:
- SER-13-028
- Component:
- 118000 electrical system: software
- Summary:
- Carrier transicold: the latest advance software, u05.08.00, v05.08.00, is available for all microprocessor trailer and rail units and information installation. *pe
- Bulletin:
- TI98-5030900REVA
- Component:
- 356000 equipment adaptive
- Summary:
- Carrier: instruction information provided regarding the enhancement of product line that includes tape cover for generator wires. *pe
- Bulletin:
- SER-14-012
- Component:
- 118000 electrical system: software
- Summary:
- Carrier: a new and revised version of eprom software, for standard (summit) microprocessors, has been released and has been moved from numeric only to alpha and numeric characters. *pe
- Bulletin:
- TI-098-5034500
- Component:
- 114000 electrical system:wiring
- Summary:
- Carrier: instruction on rerouting of supply air sensor (sas) harness, that could lead to chaffing of wiring harness, if failure to reroute and cause supply air sensor (sas) to fail, affecting temperature control unit. *pe
- Bulletin:
- TI-98-5031000
- Component:
- 072200 fuel system, gasoline:delivery:hoses, lines/piping, and fittings
- Summary:
- Carrier: instructions regarding units missing split loom on return fuel line and they (split loom) should be installed on the fuel hose. *pe
- Bulletin:
- SER15-021
- Component:
- 118000 electrical system: software
- Summary:
- Subject: advance' software u05.10.00 & v05.10.00 u05.10.00 and v05.10.00 versions of microprocessor software are now available for all advance microprocessor trailer & rail units. with the release of this bulletin, u05.10.00 and v05.10.0
- Bulletin:
- SER16-018
- Component:
- 114000 electrical system:wiring
- Summary:
- To promote best pratices in inpsecting and repairing electrical wiring and harnesses, carrier transicold technical publications group is mailing free copies of the electrical wiring and harness inspection and repair guidelines to each deale
- Bulletin:
- 98-50368-00
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- The main mounting bracket for the carrier engine emission system (ees) was not fabricated properly, and as a result the main mounting bracket could develop cracks. to address, carrier transicold is requesting that dealers replace suspect m
- Bulletin:
- 98-50370-00
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- The main mounting bracket for the carrier engine emission system (ees) was not fabricated properly, and as a result the main mounting bracket could develop cracks. to address, carrier transicold is requesting that dealers replace suspect m
- Bulletin:
- SER16-027
- Component:
- 118000 electrical system: software
- Summary:
- U05.12.00 and v05.12.00 software versions are now available for all advance microprocessor trailer and rail units. these software versions introduce new features and minor corrections related to the refrigeration unit operation and control
- Bulletin:
- PTS16-002
- Component:
- 060000 engine (pws)
- Summary:
- Consistent with continuous product improvement efforts, material changes were made to enhance the reliability of shaft seals used in 05g compressors.
- Bulletin:
- PTS16-011
- Component:
- 350000 equipment
- Summary:
- All shipments of the vortex return air bulkhead now include shielding tape and updated installation instructions. the shield tape is for use with carrier vector units only.
- Bulletin:
- SER16-001
- Component:
- 060000 engine (pws)
- Summary:
- Vector 8500/8600mt models use electronic speed control to maintain high and low speed settings. if a vector 8500/8600mt begins to surge or hunt, the condition may be corrected by replacing the encu and updating the software.
- Bulletin:
- SER16-006
- Component:
- 110000 electrical system
- Summary:
- The stepper valve module is used to control the stepper valves within the vector 8100, 8500, and 8600mt models. when a stepper valve module replacement is required, it is important to follow the procedures outlined for proper replacment.
- Bulletin:
- SER16-008
- Component:
- 350000 equipment
- Summary:
- Improvements have been made to the blower motor assemblies used in the vector 8600mt remote evaporators. these improvements include a different electrical connector and harness exit point for the blower motor assembly.
- Bulletin:
- SER16-009
- Component:
- 111000 electrical system:battery
- Summary:
- To improve fitup of the positive battery cable used on solara with apx has changed from part number 22-01633-12 to 22-03029-02. in addition for solara units with the summit controller, the positive battery cable changed from part number 22
- Bulletin:
- VORTEX-ST
- Component:
- 350000 equipment
- Summary:
- Updated installation instructions for the vortex return air bulkhead.
- Bulletin:
- PTS16-052
- Component:
- 350000 equipment
- Summary:
- Carrier transicold has discontinued offering the insulated transport product's (itp) tube chutes and related tube chute accessories. tube chutes are used to distribute air within a refrigerated trailer.
- Bulletin:
- SER16-037
- Component:
- 118000 electrical system: software
- Summary:
- The release notes contain the list of features introduced with apx software version 04.10.00. prior list of features are documented for reference.
- Bulletin:
- SER16-037
- Component:
- 118000 electrical system: software
- Summary:
- This bulletin announces the availability of software version 04.10.00 for apx equipped units. the 04.10.00 software version includes additional features which are listed in the release notes.
- Bulletin:
- SER14-010
- Component:
- 118000 electrical system: software
- Summary:
- U05.09.00 and v05.09.00 software versions for units with the advance microprocessor are now available. new functionality for all models can be found in the bulletin. all trailer models equipped with the advance controller
- Bulletin:
- SER14-012
- Component:
- 118000 electrical system: software
- Summary:
- 3.c5 / 3.c6 software versions for units with the standard microprocessor are now available. new functionality for all models can be found in the bulletin. all models equipped with the standard controller
- Bulletin:
- 98-50349-00
- Component:
- 090000 fuel system, other
- Summary:
- These technical instructions cover the proper procedure for replacing the fuel heater filter element. following the proper procedure is necessary to prevent a potential filter o-ring fuel leak. genset, trailer, and truck units with the fu
- Bulletin:
- SER17-009 Rev A
- Component:
- 118000 electrical system: software
- Summary:
- Apx software version 04.11.00 was introduced in all production apx controlled trailer and rail units except the solara unit. new functionality for all models can be found in the release notes attached to the bulletin.
- Bulletin:
- SER17-010
- Component:
- 118000 electrical system: software
- Summary:
- U05.13.00 / v05.13.00 software versions for models equipped with the advance microprocessor are now available. software update information can be found in the bulletin.
- Bulletin:
- SER15022
- Component:
- 118000 electrical system: software
- Summary:
- Carrier transicold announces the latest release of tru-tech / tru-view pc software program. tru-tech / tru-view is used to interface with standard, advance, and apx controlled refrigeration units.
- Bulletin:
- SER14025A
- Component:
- 060000 engine (pws)
- Summary:
- In ser14-025, carrier announced that pictures were required when submitting a warranty claim for a rear engine main seal. in ser14-025 rev a, the warranty claim for a rear engine main seal was further amended to require the rear engine and
- Bulletin:
- PTS17-034
- Component:
- 356000 equipment adaptive
- Summary:
- Carrier transicold's performance parts group has discovered that certain shipments of part number 30-00426-27 air filters shipped between 7/18/17 - 8/30/17 could have an incorrect air filter packaged within the box. these different air filt
- Bulletin:
- SER17-034
- Component:
- 210000 trailer hitches
- Summary:
- Apx software version 04.14.00 was introduced in all production apx controlled trailer and rail units. new functionality for all models can be found in the release notes attached to the bulletin.
- Bulletin:
- SER17027
- Component:
- 118000 electrical system: software
- Summary:
- The 12-00664-05 main micro module incorporated hardware enhancements inside the module. one of these enhancements inadverently affected the software logic (prior to 04.14.00) for the module led light. there is no effect on unit operation
- Bulletin:
- TSB530A
- Component:
- 114000 electrical system:wiring
- Summary:
- Impco has determined on certain pc6024 prior to s/n etd22212377 may have an incorrectly wired cfci outlet in the power distribution box. tsb-530 covers the inspection and repair process to correct this fault.
- Bulletin:
- TSB531A
- Component:
- 350000 equipment
- Summary:
- To ensure the correct ordering of replacement generator mounting brackets, tsb-531 covers the pertinent features to observe.
- Bulletin:
- TSB533A
- Component:
- 350000 equipment
- Summary:
- Impco has determined that the install tool used for the red linked belt may cause the belt tab to overstretch or even crack, which could lead to premature failure of the red linked belt. tsb-533 covers the inspection and repair process to
- Bulletin:
- TSB537A
- Component:
- 060000 engine and engine cooling
- Summary:
- Impco has determined on certain pc6020 series apu between the s/n etd22221154 to etd222222115 may have an incorrectly labeled coolant outlet connection. tsb-537 covers the inspection and repair process to correct this fault.
- Bulletin:
- TSB543A
- Component:
- 118000 electrical system: software
- Summary:
- Updated firmware has been released for the apu and dcp for apu's with serial number etd22220943 or after. follow the instructions in tsb-543 when replacing a dpc or apu controller as the replacement controller may require a firmware update
- Bulletin:
- TSB545A
- Component:
- 110000 electrical system
- Summary:
- To provide improved operation of the overheat switch, the 30-g22-62k retrofit kit is available to relocate the switch to an optimal location on the engine.
- Bulletin:
- PB6035A
- Component:
- 110000 electrical system
- Summary:
- As an addendum to the comfortpro operator's manual, pb-6035 details systems improvements for the pc6020 and pc6100 series models.
- Bulletin:
- PB6036A
- Component:
- 110000 electrical system
- Summary:
- Beginning with s/n etd22220943, improvements have been made to the comfort monitor mode and system diagnostics. pb-6036 covers how to update and configure the sytem with these improvements.
- Bulletin:
- PB6040A
- Component:
- 042100 service brakes, air:supply:compressor
- Summary:
- To reduce the compressor load and compressor current draw, a software enhancement is now available that allows the compressor pressures to better equalize prior to restarting the compressor.
- Bulletin:
- IB5137A
- Component:
- 350000 equipment
- Summary:
- Ib-5137 covers the proper replacement process to follow when replacing a sierra00061 compressor with a sierra000151 compressor.
- Bulletin:
- SER18-004
- Component:
- 118000 electrical system: software
- Summary:
- Apx software version 04.15.00 was introduced in all production apx controlled trailer and rail unitst. new functionality for all models can be found in the release notes attached to the bulletin.
- Bulletin:
- CAR-J8P2W-07
- Component:
- 350000 equipment
- Summary:
- Letter sent to dealers reminding them of an open upgrade for the models equipped with the apx control system (see ser15-005).
- Bulletin:
- PTS18-022
- Component:
- 350000 equipment
- Summary:
- Carrier transicold?s performance parts group has discovered that certain shipments of head gasket part number 25-39355-00 could have included an incorrect gasket in the package, which could affect unit performance. this bulletin outlines h
- Bulletin:
- SER18-014
- Component:
- 118000 electrical system: software
- Summary:
- Apx software version 04.16.00 was introduced in all production apx controlled trailer and rail unitst. new functionality for all models can be found in the release notes attached to the bulletin.
- Bulletin:
- CAR-G3Q8L-07
- Component:
- 350000 equipment
- Summary:
- Letter sent to end-user customers reminding them of an open upgrade for models equipped with the apx control system (see ser15-005).
Home | Privacy