2017 VOLVO VN TSBs (90)
- Bulletin:
- FSB 257-004
- Component:
- 060000 engine (pws)
- Summary:
- Volvo trucks has received reports from the aftermarket regarding oil leaks at the ccv housing inlet tube and at the split line between the upper and lower housings on chassis builds between january 1, 2014 and january 26, 2016 with d11 engi
- Bulletin:
- FSB 395-001
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- On some volvo trucks built between august 19, 2014 and august 19, 2016 possible audible feedback may occur while using the am/fm bands when the cb microphone is keyed. keying the microphone could also cut the volume of the radio when using
- Bulletin:
- FSB 561-025
- Component:
- 110000 electrical system
- Summary:
- Some volvo vn model trucks built from 11/01/2011 to 10/03/2016, and equipped with the meritor/wabco electronic controlled air dryer (ecad) may experience excessive moisture build up in the air tanks.
- Bulletin:
- FSB 891-019
- Component:
- 350000 equipment
- Summary:
- Volvo trucks has determined that some vn truck models may experience cracked or broken back of cab fairing brackets on vehicles manufactured from 03/12/2012 to 07/12/2016.
- Bulletin:
- SP 284-064
- Component:
- 060000 engine (pws)
- Summary:
- Software updates with enhancements are available for the engine control module (ecm) for volvo d11j, d13j and d16j engines with us2016 emission level on vehicles built from january 4, 2016 to may 6, 2016.
- Bulletin:
- FSB 213-002, Exh
- Component:
- 060000 engine and engine cooling
- Summary:
- In some instances the exhaust rocker piston cap screw may become loose and back out causing loss of engine compression, or a mechanical injector diagnostic trouble code (dtc).
- Bulletin:
- SP 258-038, Afte
- Component:
- 060000 engine and engine cooling
- Summary:
- Certain volvo vn trucks built between 10/03/2016 and 11/07/2016 may experience a coolant leakage issue with the aftertreatment diesel exhaust fluid (def) dosing valve.
- Bulletin:
- SP 215-021, Timi
- Component:
- 350000 equipment
- Summary:
- This repair requires the installation of a missing screw in the timing gear plate into the flywheel housing as the referenced in this installation procedure.
- Bulletin:
- RVXX1603, One Pi
- Component:
- 010000 steering
- Summary:
- One piece steering shaft, replacement recall
- Bulletin:
- FSB 776-002, Con
- Component:
- 190000 tires
- Summary:
- Tire pressure monitoring system (tpms) connector, remove
- Bulletin:
- FSB 257-004, CCV
- Component:
- 060000 engine (pws)
- Summary:
- Ccv housing inlet tube, replacement
- Bulletin:
- FSB 366-003, Fro
- Component:
- 118000 electrical system: software
- Summary:
- Front radar, reprogramming, certain volvo trucks built from 11/11/2013 through 07/01/2016, and equipped with front radar (collision avoidance system with adaptive cruise control), may display an acc sensor fault (warning / pop-up) at key of
- Bulletin:
- FSB 514-001, Bra
- Component:
- 030000 brakes (pws)
- Summary:
- Brake s-cam, replacement,some volvo vn trucks built after 05/13/2013, equipped with bendix brake s-cams on the steer axle may require replacement to reduce or eliminate brake noise during braking.
- Bulletin:
- FSB 257-004, CCV
- Component:
- 060000 engine (pws)
- Summary:
- Volvo trucks has received reports from the aftermarket regarding oil leaks at the ccv housing inlet tube and at the split line between the upper and lower housings on chassis builds between january 1, 2014 and january 26, 2016 with d11 engi
- Bulletin:
- FSB 395-001, Rad
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- On some volvo trucks built between august 19, 2014 and august 19, 2016 possible audible feedback may occur while using the am/fm bands when the cb microphone is keyed. keying the microphone could also cut the volume of the radio when using
- Bulletin:
- FSB 561-025, Ele
- Component:
- 353000 equipment:electrical
- Summary:
- Some volvo vn model trucks built from 11/01/2011 to 10/03/2016, and equipped with the meritor/wabco electronic controlled air dryer (ecad) may experience excessive moisture build up in the air tanks.
- Bulletin:
- FSB 891-019, Cab
- Component:
- 350000 equipment
- Summary:
- Volvo trucks has determined that some vn truck models may experience cracked or broken back of cab fairing brackets on vehicles manufactured from 03/12/2012 to 07/12/2016.
- Bulletin:
- SP 284-064, Engi
- Component:
- 060000 engine (pws)
- Summary:
- Software updates with enhancements are available for the engine control module (ecm) for volvo d11j, d13j and d16j engines with us2016 emission level on vehicles built from january 4, 2016 to may 6, 2016.
- Bulletin:
- FSB 373-022, Eng
- Component:
- 060000 engine (pws)
- Summary:
- The engine harness on volvo d11 us2015 engines built between march 1, 2015 and september 2, 2016 may be making contact with the air compressor head and rubbing through.
- Bulletin:
- FSB375-013
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- On certain volvo models built between november 10, 2014 and july 7, 2017, with bluetooth radio and ldws (lane departure warning system); the audio for the bluetooth phone call may be low and with poor quality.
- Bulletin:
- FSB711-008
- Component:
- 020000 suspension
- Summary:
- Some volvo vn, vhd and vnx trucks built from 09/03/2012 to 07/17/2017, and equipped with the neway adz rear suspension may exhibit cracks in the rear suspension front of bogie or bogie crossmember.
- Bulletin:
- FSB 237-020
- Component:
- 060000 engine and engine cooling
- Summary:
- Volvo vn, vhd, vah, and vt trucks built from 2009 to 2017 and equipped with 11, 13, and 16 liter engines (em-usa10, em-usa14, and em-usa17), will require a new torque specification for the unit injector yoke hold-down bolt. effective immedi
- Bulletin:
- SP237-001
- Component:
- 070000 fuel system, gasoline
- Summary:
- Certain volvo vn, vhd, and vah trucks built from 05/16/2015 to 09/09/2016 and equipped with hde13 engines have been identified as high risk for injector sleeve combustion gas leakage due to excessive graphite paste application during assemb
- Bulletin:
- FSB237-020
- Component:
- 070000 fuel system, gasoline
- Summary:
- Volvo vn, vhd, vah, and vt trucks built from 2009 to 2017 and equipped with 11, 13, and 16 liter engines (em-usa10, em-usa14, and em-usa17), will require a new torque specification for the unit injector yoke hold-down bolt. effective immedi
- Bulletin:
- FSB373-023
- Component:
- 110000 electrical system
- Summary:
- Scr harness connector, replacement: the front chassis harness on some volvo vnl trucks equipped with a cummins engine and aftertreatment system built between 02/04/2013 and 12/31/2016 may have paint inside the scr connector.
- Bulletin:
- TJ30848
- Component:
- 110000 electrical system
- Summary:
- Customer may intermittently experience the vehicle orvm (outer rear view mirror) will not fold when locking/unlocking.
- Bulletin:
- K40525473
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Obd2015/16 ( my - 2016/2017 ) trucks are logging u3017 fault code ( dtc )
- Bulletin:
- FSB211-002
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- On some volvo vn, vhd, and vah trucks built from january 2014 to july 2017 and equipped with the name plate on a two piece valve cover, the name plate may come loose.
- Bulletin:
- FSB373-024
- Component:
- 103000 power train:automatic transmission
- Summary:
- Some volvo trucks equipped with ishift transmissions built between january 15, 2007 and august 14, 2017 may have pto solenoid bracket or transmission harness connector failures due to excessive vibration.
- Bulletin:
- FSB237-020
- Component:
- 103700 power train:automatic transmission:torque converter
- Summary:
- Volvo vn, vhd, vah, and vt trucks built from 2009 to 2017 and equipped with 11, 13, and 16 liter engines (em-usa10, em-usa14, and em-usa17), will require a new torque specification for the unit injector yoke hold-down bolt.
- Bulletin:
- FSB 293-016
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- Exhaust gas recirculation (egr) valve oil supply line, updated part
- Bulletin:
- FSB 284-047
- Component:
- 114000 electrical system:wiring
- Summary:
- Oil level sensor harness wire splice
- Bulletin:
- FSB 284-046
- Component:
- 117000 digital instrument panel
- Summary:
- Instrument cluster reported fuel economy calibration
- Bulletin:
- SP 284-049
- Component:
- 118000 electrical system: software
- Summary:
- Engine control module (ecm) software update
- Bulletin:
- FSB 432-014
- Component:
- 103000 power train:automatic transmission
- Summary:
- Transmission ecu compatibility
- Bulletin:
- FSB 371-049
- Component:
- 111100 electrical system:battery:cables
- Summary:
- Battery cable, routing
- Bulletin:
- SP 386-004
- Component:
- 118000 electrical system: software
- Summary:
- Fuel management module, replacement, incorrect calibration
- Bulletin:
- FSB 375-010
- Component:
- 220000 seats
- Summary:
- Seat harness routing (non-swivel) wires pulling away from clipping points
- Bulletin:
- FSB 375-011
- Component:
- 220000 seats
- Summary:
- Seat harness routing (swivel) wires pulling away from clipping points
- Bulletin:
- FSB 293-024
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- Exhaust gas recirculation (egr) differential pressure sensor
- Bulletin:
- FSB 593-012
- Component:
- 113100 electrical system:starter assembly:solenoid
- Summary:
- Hill start assist solenoid, replacement
- Bulletin:
- FSB 216-001
- Component:
- 100000 power train
- Summary:
- Twin mass flywheel conversion, transmission removed
- Bulletin:
- FSB 293-027
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- Egr mass flow rate low, diagnostic trouble code
- Bulletin:
- FSB 431-010
- Component:
- 350000 equipment
- Summary:
- Range synchronizer, repair
- Bulletin:
- FSB 293-012
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- Exhaust gas recirculation, part update
- Bulletin:
- FSB 811-005
- Component:
- 350000 equipment
- Summary:
- Floor cracks repair (front panel)
- Bulletin:
- FSB 811-006
- Component:
- 350000 equipment
- Summary:
- Floor cracks repair (rear panel)
- Bulletin:
- FSB 284-038
- Component:
- 118000 electrical system: software
- Summary:
- Engine coolant thermostat software update
- Bulletin:
- FSB 215-002
- Component:
- 354000 equipment:mechanical
- Summary:
- Timing plate leak repair
- Bulletin:
- FSB 593-012
- Component:
- 113100 electrical system:starter assembly:solenoid
- Summary:
- Hill start assist solenoid, replacement
- Bulletin:
- FSB 215-003
- Component:
- 350000 equipment
- Summary:
- Timing plate flange screw
- Bulletin:
- FSB 284-057
- Component:
- 060000 engine (pws)
- Summary:
- High soot output
- Bulletin:
- FSB 222-004
- Component:
- 060000 engine (pws)
- Summary:
- Oil filter housing
- Bulletin:
- FSB 262-005
- Component:
- 060000 engine and engine cooling
- Summary:
- Coolant bypass housing seal
- Bulletin:
- FSB 432-013
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Amt high range cone replacement
- Bulletin:
- FSB 801-003
- Component:
- 162300 structure:body:door
- Summary:
- Service door rust prevention
- Bulletin:
- FSB 593-012
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Hill start assist solenoid, replacement
- Bulletin:
- FSB 234-018
- Component:
- 070000 fuel system, gasoline
- Summary:
- Single fuel tank ventilation filter kit
- Bulletin:
- FSB 234-019
- Component:
- 070000 fuel system, gasoline
- Summary:
- Dual fuel tanks ventilation filter kit
- Bulletin:
- SP 293-027
- Component:
- 060000 engine and engine cooling
- Summary:
- Coolant hose, egr cooler, replacement
- Bulletin:
- FSB 293-024
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- Exhaust gas recirculation (egr) differential pressure sensor
- Bulletin:
- FSB 293-026
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Exhaust gas recirculation (egr) differential pressure sensor
- Bulletin:
- FSB 252-031
- Component:
- 061120 engine and engine cooling:engine:gasoline:turbo-charger
- Summary:
- Turbocharger outlet pipe
- Bulletin:
- FSB 258-035
- Component:
- 070000 fuel system, gasoline
- Summary:
- Aftertreatment def tank vent filter
- Bulletin:
- FSB 258-036
- Component:
- 353000 equipment:electrical
- Summary:
- Def sensor assembly routing
- Bulletin:
- FSB 284-059
- Component:
- 110000 electrical system
- Summary:
- Nox sensor signal
- Bulletin:
- FSB 210-045
- Component:
- 110000 electrical system
- Summary:
- Regeneration in pto mode
- Bulletin:
- FSB 222-004
- Component:
- 060000 engine (pws)
- Summary:
- Oil filter housing
- Bulletin:
- FSB 593-012
- Component:
- 113100 electrical system:starter assembly:solenoid
- Summary:
- Hill start assist solenoid, replacement
- Bulletin:
- SP 284-064
- Component:
- 118000 electrical system: software
- Summary:
- Software updates with enhancements are available for the engine control module (ecm) for volvo d11j, d13j and d16j engines with us2016 emission level on vehicles built from january 4, 2016 to may 6, 2016.
- Bulletin:
- FSB 293-022
- Component:
- 060000 engine (pws)
- Summary:
- In the event that an egr temperature sensor replacement is required on a volvo d13h engine, a new routing configuration is required.
- Bulletin:
- SP 398-001
- Component:
- 110000 electrical system
- Summary:
- On some trucks with the telematics gateway (tgw) system, the tgw control unit may not correctly communicate with the vehicle systems after restarting.
- Bulletin:
- TJ3085320
- Component:
- 160000 structure
- Summary:
- This document is a technical journal: tj updated with chassis breakpoint and structure week end date.customer may experience some road noise coming from the b-pillar belt adjuster area.
- Bulletin:
- TJ2722740
- Component:
- 020000 suspension
- Summary:
- This document is a technical journal: if vibration or jerk occur during drive in different speeds with small throttle angle and gears at constant speed, follow the advice under service. this might be due to the tires. if the tires are from
- Bulletin:
- SP2 284-036
- Component:
- 118000 electrical system: software
- Summary:
- Software update, revise document
- Bulletin:
- SP 431-021
- Component:
- 118000 electrical system: software
- Summary:
- Transmission ecu programming
- Bulletin:
- K58340423
- Component:
- 060000 engine (pws)
- Summary:
- Volvo trucks has received reports from the aftermarket regarding oil leaks at the ccv housing inlet tube and at the split line between the upper and the lower housings on chassis builds between january 1, 2014 and january 26, 2016 with d11,
- Bulletin:
- FSB 216-001
- Component:
- 350000 equipment
- Summary:
- Twin mass flywheel conversion
- Bulletin:
- K91214678
- Component:
- 100000 power train
- Summary:
- Automated manual transmission ( amt ) faults - diagnostic trouble codes ( dtcs ) p1052 - 18 , pid 33 fmi 5 intermittent fault in cold weatherupdated with new information and procedure
- Bulletin:
- SERVICE INSTRUCT
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Supplier service bulletin sent to customers regarding potential brake caliper issue.
- Bulletin:
- FSB216-002
- Component:
- 060000 engine (pws)
- Summary:
- Flywheel resurfacing guidelines, i-shift
- Bulletin:
- K14003352
- Component:
- 061120 engine and engine cooling:engine:gasoline:turbo-charger
- Summary:
- Diagnostic trouble code ( dtc ) p0422 lighting the malfunction indicator light ( mil ) - us17 (ghg17), common rail fuel system only, updated programming and diagnostic instructions
- Bulletin:
- FSB284-065
- Component:
- 060000 engine (pws)
- Summary:
- Ecm and acm, reprogramming, obd2016
- Bulletin:
- K40245340
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- Volvo chassis - diagnostic trouble code ( dtc ) p026c lighting the malfunction indicator light ( mil ) - us14+obd13, us14+obd15 and us14+obd16 - commonly model years 2015 to 2017 (non-common rail fuel system) chassis
- Bulletin:
- K42708399
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- Volvo chassis - diagnostic trouble code ( dtc ) p0422 lighting the malfunction indicator light ( mil ) - us14+obd15 and us14+obd16 emissions, commonly model years 2016 and 2017
- Bulletin:
- K15560422
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- Selective catalytic reduction ( scr ) efficiency and nox sensor codes p225c, p225e, p221a, p2201, p103c, p20ee, and p207f : nox sensor diagnostic information to be used before sensor replacement - obd13 and newer emissions (commonly model y
- Bulletin:
- FSB284-065
- Component:
- 110000 electrical system
- Summary:
- Ecm and acm, reprogramming, obd2016
- Bulletin:
- K65385571
- Component:
- 010000 steering
- Summary:
- Volvo chassis - vn models equipped with bendix brakes, bendix s-cam on steer axle - excessive brake noise; diagnosis and repair information; fsb 514-001, brake s-cam, replacement - model years 2014 to 2018
- Bulletin:
- SP284-067
- Component:
- 110000 electrical system
- Summary:
- Ecm and acm, software updates
- Bulletin:
- K40245340
- Component:
- 073100 fuel system, gasoline:fuel injection system:fuel rail
- Summary:
- Expired - volvo chassis - diagnostic trouble code ( dtc ) p026c lighting the malfunction indicator light ( mil ) - us14+obd13, us14+obd15 and us14+obd16 - commonly model years 2015 to 2017 (non-common rail fuel system) chassis
Home | Privacy