2016 DODGE VIPER Recalls (2)
- Campaign:
- 16V736000 on 10/12/2016
- Component:
- Air bags:frontal
- Manufactured:
- 05/23/2016 - 08/27/2016
- Affected:
- 14
- Defect:
- Chrysler (fca us llc) is recalling certain model year 2016 dodge viper vehicles manufactured may 24, 2016, to august 28, 2016. the wires for the driver's frontal air bag may be pinched.
- Consequence:
- If the driver's air bag wires are pinched, the air bag may not deploy properly in the event of a crash necessitating air bag deployment, increasing the risk of injury.
- Correction:
- Dodge will notify owners, and dealers will replace the driver's frontal air bag and clockspring, free of charge. the recall is began on november 17, 2016. owners may contact chrysler customer service at 1-800-853-1403. chrysler's recall number for this recall is s75.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
- Campaign:
- 16V750000 on 10/17/2016
- Component:
- Air bags:passenger side frontal
- Manufactured:
- 01/05/2016 - 01/07/2016
- Affected:
- 2
- Defect:
- Chrysler (fca us llc) is recalling certain 2016 my dodge viper vehicles manufactured january 6, 2016, to january 8, 2016. a defective vibration weld on the passenger airbag chute may cause the passenger air bag door to detach during the air bag deployment.
- Consequence:
- If the air bag door detaches during deployment, there is an increased the risk of injury to vehicle occupants.
- Correction:
- Chrysler will notify owners, and dealers will replace the passenger side upper panel assembly, free of charge. the recall began on november 17, 2016. owners may contact chrysler customer service at 1-800-853-1403. chrysler's number for this recall is s77.
2016 DODGE VIPER TSBs (28)
- Bulletin:
- 03-002-16
- Component:
- 106000 power train:axle assembly
- Summary:
- Subject: replace rear axle symptom/condition: the customer or technician may hear a whining noise between 32-64 kph (20-40 mph) coming from the rear axle.
- Bulletin:
- 03-002-16
- Component:
- 022520 suspension:rear:axle:non-powered axle assembly
- Summary:
- Subject: replace rear axle overview: this bulletin involves replacing the rear axle unit. symptom/condition: the customer or technician may hear a whining noise between 32-64 kph (20-40 mph) coming from the rear axle.
- Bulletin:
- 08-057-16
- Component:
- 110000 electrical system
- Summary:
- Subject: ra3 ra4 radio enhancements overview: this bulletin involves inspecting and, if required, updating the radio software. symptom/condition: a small number of customers may experience one or more of the following: ' navigat
- Bulletin:
- 08-057-16
- Component:
- 118000 electrical system: software
- Summary:
- Subject: ra3 ra4 radio enhancements overview: this bulletin involves inspecting and, if required, updating the radio software. symptom/condition: a small number of customers may experience one or more of the following: ' navigatio
- Bulletin:
- 23-019-16
- Component:
- 350000 equipment
- Summary:
- Subject: trunk pan bolts loose causing clunk when driving over bumps symptom/condition: the customer may describe a noise heard from the rear interior of the vehicle when driving at lower speeds over bumps or on a rough road.
- Bulletin:
- 68232614A$
- Component:
- 060000 engine and engine cooling
- Summary:
- Intake manifold gasket intake manifold gaskets on pentastar upgrade (sales code erc/erf) are reusable provided they are not cut, torn or melted. the gaskets are not required by warranty to be replaced like they are on pentastar classic (
- Bulletin:
- 68249986A$
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- My16 ra3 & ra4 replacement radios all my16 ra3 and ra4 replacement radios must be ordered through the exchange process at united radio. do not order a new radio from mopar. go back and order a "z" level part number. (example: z8249986a$)
- Bulletin:
- 08-028-17 REV. B
- Component:
- 118000 electrical system: software
- Summary:
- Ra3 and ra4 radio over the air software updates this bulletin provides information regarding the latest flash over the air (fota) update and provides the service technician an overview of the steps a customer will need to take to complete
- Bulletin:
- RL108213A$
- Component:
- 060000 engine and engine cooling
- Summary:
- Nag1 (5a580) valve body as per warranty bulletin d-13-22, please use r2108213a$ valve body for all warranty (w), mopar (m) and mopar vehicle protection (f) claims.~ assembly also includes filter (52108325aa) and gasket (52108332aa).~
- Bulletin:
- 9002519
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- 82212076, 82203694 - fabric cleaner this "fabric cleaner" is not intended for sale in california, the otc states (connecticut, delaware, massachusetts, maine, new hampshire, new jersey, new york, pennsylvania, virginia, and washington dc
- Bulletin:
- 9003109
- Component:
- 136000 visibility:windshield wiper/washer
- Summary:
- Washer fluid level sensor prior to replacing this part due to "low washer fluid" tell tale light on the dash and the washer fluid bottle is full, please perform this inspection: check if float sensor is rotated off location from the bottl
- Bulletin:
- 9003413
- Component:
- 181000 vehicle speed control:accelerator pedal
- Summary:
- Accelerator pedal before replacing accelerator pedal, be sure to follow fault code diagnostic procedures in service manual. make sure to check wiring and connectors. p2122 and p2127 will set if accelerator pedal connector is disconnected d
- Bulletin:
- 9003357
- Component:
- 060000 engine and engine cooling
- Summary:
- Pentastar oil filter adapter all vehicles equipped with a 3.2l or 3.6l engine; if replacing the oil filter adapter (ofa) due to a leak detected between ofa and block, an o-ring kit (68191356aa) is now available to repair ofa/block interfac
- Bulletin:
- 23-027-17
- Component:
- 121000 exterior lighting:headlights
- Summary:
- Rusty water draining from vehicle this bulletin involves drilling drain holes in the headlamp fastener pocket and replacing two headlamp fasteners. customers may describe rusty water sometimes drains down one or both sides of the vehicle a
- Bulletin:
- 08-046-17
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Ra3 and ra4 radio enhancements this bulletin involves inspecting and if required, updating the radio software. customers may experience one or more of the following:?navigation failed? message is displayed. navigation is inoperative or ina
- Bulletin:
- RL305553A
- Component:
- 100000 power train
- Summary:
- 9-spd transmission: for nafta market only: if you are ordering this transmission please follow all witech pop ups and warranty payment guidelines. if this vehicle contains 1 of the 30 diagnostic codes in the 9 speed tutorial located on the
- Bulletin:
- 68277402A
- Component:
- 185000 vehicle speed control:cruise control
- Summary:
- Adaptive cruise control sensor 1) if you are replacing this part due to the cluster displaying clean radar sensor in front of vehicle or dtc c1266 acc sensor blinded, please verify that there is no blockage in front of the sensor. blockage
- Bulletin:
- 9003687
- Component:
- 150000 seat belts
- Summary:
- Restraints remove i-sheet from packaging. correct information sheet (i-sheet) has been added to star parts. print i-sheet for technician use.
- Bulletin:
- 9003681
- Component:
- 150000 seat belts
- Summary:
- Restraints information sheet (i-sheet) has been added to star parts. print i-sheet for technician use.
- Bulletin:
- 9003694
- Component:
- 060000 engine and engine cooling
- Summary:
- Oil pump assembly if error code p06dd present on any pentastar v6 application, please inspect oil pump for relief valve failure. see photo attached. if valve is found out of place please call bob jackson (248) 944-0466 bob.jackson@fcagroup
- Bulletin:
- 9003696
- Component:
- 162300 structure:body:door
- Summary:
- Door hinge assembly side door hinge noisy. only replace the door hinge with the integral check device. do not replace the simple hinge if it is not damaged it is not the source of the noise. replacing it unnecessary and is an over-repair.
- Bulletin:
- 08-028-17
- Component:
- 350000 equipment
- Summary:
- Ra3 and ra4 radio over the air software updates this bulletin provides information regarding the latest flash over the air update (fota) and provides a service technician an overview of the steps a customer will need to take to complete t
- Bulletin:
- Z5091195A$
- Component:
- 110000 electrical system
- Summary:
- Res / rha / reb radio that supports bluetooth and hands-free for issues with bluetooth, hands-free calling, and/or voice commands, do not replace the radio. diagnose the hands-free module system (also called the telematics module). the t
- Bulletin:
- 03-002-16
- Component:
- 022520 suspension:rear:axle:non-powered axle assembly
- Summary:
- Replace rear axle this bulletin involves replacing the rear axle unit. the customer or technician may hear a whining noise between 32-64 kph (20-40 mph) coming from the rear axle.
- Bulletin:
- 08-057-16
- Component:
- 350000 equipment
- Summary:
- Ra3 ra4 radio enhancements this bulletin involves inspecting and, if required, updating the radio software. a small number of customers may experience one or more of the following: · navigation failed message is displayed. · clock not a
- Bulletin:
- 23-019-16
- Component:
- 200000 wheels
- Summary:
- Trunkpan bolts loose causing clunk when driving over bumps this bulletin involves inspecting and re-tightening the trunkpan bolts in the rear of vehicle. the customer may describe a noise heard from the rear interior of the vehicle when d
- Bulletin:
- 23-019-16 REV. A
- Component:
- 162700 structure:body:trunk lid
- Summary:
- Trunkpan bolts loose causing clunk when driving over bumps this bulletin involves inspecting and re-tightening the trunkpan bolts in the rear of vehicle. the customer may describe a noise heard from the rear interior of the vehicle when d
- Bulletin:
- 31-001-16
- Component:
- 160000 structure
- Summary:
- Do not apply corrosion protection on sheet molding compound (smc) plastic panels this bulletin involves discussing smc plastic panels and applying corrosion protection.
Home | Privacy