2015 TOYOTA HIGHLANDER Recall
- Campaign:
- 15V144000 on 03/12/2015
- Component:
- Steering:electric power assist system
- Manufactured:
- 08/14/2014 - 12/22/2014
- Affected:
- 110,085
- Defect:
- Toyota motor engineering & manufacturing (toyota) is recalling certain model year 2015 camry, camry hybrid, highlander, and highlander hybrid, and 2014-2015 rav4 vehicles. a component of the electric power steering (eps) electronic control unit (ecu) may have been damaged during the manufacturing process. over time, this damage may result in failure of the electric power steering system.
- Consequence:
- An unexpected loss of power steering increases the risk of a crash.
- Correction:
- Toyota will notify owners, and dealers will inspect the serial number of the eps ecu or steering column assembly. if the number is within the affected range, the eps ecu will be replaced, free of charge. the recall began on may 7, 2015. owners may contact toyota customer service at 1-800-331-4331.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
2015 TOYOTA HIGHLANDER TSBs (198)
- Bulletin:
- T-TT-0315-14
- Component:
- 020000 suspension
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- T-SB-0160-14
- Component:
- 118000 electrical system: software
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- T-SB-0078-14
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TAB0077-14A
- Component:
- 160000 structure
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- T-SB-0023-16 REV
- Component:
- 162300 structure:body:door
- Summary:
- "tsb: revision notice august 3, 2016 rev1: warranty information section has been updated with a new op code. supersession notice the information contained in this bulletin supersedes sb no. t-sb-0027-15. any previous printed versions o
- Bulletin:
- T-SB-0074-16
- Component:
- 110000 electrical system
- Summary:
- Tsb: some 2014 ' 2015 model year highlander vehicles may exhibit a mil 'on' condition with diagnostic trouble code (dtc) p2610 (ecm/pcm engine off timer performance) present. the engine control module (ecm) logic has been modified to reduc
- Bulletin:
- T-SB-0074-16
- Component:
- 060000 engine (pws)
- Summary:
- Tsb: some 2014 ' 2015 model year highlander vehicles may exhibit a mil 'on' condition with diagnostic trouble code (dtc) p2610 (ecm/pcm engine off timer performance) present. the engine control module (ecm) logic has been modified to reduc
- Bulletin:
- T-SB-0085-16
- Component:
- 353600 equipment:air conditioner
- Summary:
- Tsb: some 2014 ' 2015 model year highlander vehicles may exhibit a condition when the a/c system is turned on, it may take a longer than expected amount of time until it begins to blow cool air. under certain conditions a/c cooling is dela
- Bulletin:
- T-SB-0085-16
- Component:
- 060000 engine and engine cooling
- Summary:
- Tsb: some 2014 ' 2015 model year highlander vehicles may exhibit a condition when the a/c system is turned on, it may take a longer than expected amount of time until it begins to blow cool air. under certain conditions a/c cooling is dela
- Bulletin:
- T-TT-0392-16 REV
- Component:
- 110000 electrical system
- Summary:
- Tt: some customers may experience bluetooth connection issues after updating the android operating system to 5.x.x (lollipop) or later.
- Bulletin:
- T-SB-0035-16
- Component:
- 350000 equipment
- Summary:
- Tsb: some 2014 model year applicable vehicles equipped with entune' audio (version 010169) / entune' audio plus (version 010171) / entune' premium audio (version 010185) may exhibit one or more of the following conditions.
- Bulletin:
- T-TT-0385-16
- Component:
- 110000 electrical system
- Summary:
- "tech tip: this tech tip is being provided to bring attention to the new location of the entune/nav/map update and upgrade usb directory. click on the tis tab, diagnostics tab, telematics tab, and the document is now located under the refe
- Bulletin:
- T-TT-0374-15
- Component:
- 350000 equipment
- Summary:
- "tt: since my 2011, several different update or upgrade usb sst's have been issued for toyota audio and navigation system. refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicabil
- Bulletin:
- T-TT-0377-15
- Component:
- 350000 equipment
- Summary:
- Tt: some customers may experience poor outgoing bluetooth sound quality, this can occur for various reasons. current multimedia systems are designed with the ability to adjust bluetooth sound quality to compensate for echo or excessive back
- Bulletin:
- T-TT-0375-15
- Component:
- 350000 equipment
- Summary:
- Tt: for customer concerns of no or poor outgoing sound from the bluetooth systems there are diagnostics in the repair manual which can be performed to diagnose the condition.
- Bulletin:
- T-TT-0315-14
- Component:
- 200000 wheels
- Summary:
- "tt: chrometec (plastic clad) wheels are being damaged during mounting and dismounting of tires. refer to photos below for identifying plastic and aluminum portions of wheel:"
- Bulletin:
- T-SB-0012-13 REV
- Component:
- 060000 engine (pws)
- Summary:
- "tsb: flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bul
- Bulletin:
- T-TT-0322-15 REV
- Component:
- 134000 visibility:sun roof assembly
- Summary:
- Tech tip: some vehicles may experience a condition in which the drain hoses for the sunroof/moonroof assembly become kinked, or pinched. this may cause water leaks into the cabin from the housing assembly drip trays, or the customer may not
- Bulletin:
- T-TT-0381-16
- Component:
- 350000 equipment
- Summary:
- Tech tip: some customers may experience difficulty programming homelink.
- Bulletin:
- T-SB-0028-14
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- "tsb: long-term or off-site storage requires special care to keep vehicles factory fresh and ready for delivery. the following guidelines should be performed to minimize vehicle component/part degradation due to extended vehicle storage c
- Bulletin:
- T-TT-0309-14 REV
- Component:
- 353000 equipment:electrical
- Summary:
- Tt: some customers may experience bluetooth disconnections or loss of sms text message functionality on the navigation/audio system with android phones running os 4.4 or later. condition tends to occur to customers who have many previous te
- Bulletin:
- T-TT-0357-15
- Component:
- 020000 suspension
- Summary:
- Tt: spare tire carrier will bind/seize when lowering or raising spare tire or cable will not fully extend when attempting to lower spare tire, therefore making it difficult to remove from the cable.
- Bulletin:
- T-TT-0360-15
- Component:
- 350000 equipment
- Summary:
- Tt: customers may experience connectivity issues when the following conditions are met: the customer's iphone is operating on ios9 firmware. the customer's iphone is connected to the vehicle via bluetooth. the customer may complain of the f
- Bulletin:
- T-TT-0344-15 REV
- Component:
- 350000 equipment
- Summary:
- Tt: iphone text messages do not appear on multimedia dis[play.
- Bulletin:
- T-TT-0234-13 REV
- Component:
- 350000 equipment
- Summary:
- Tt: since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicabilit
- Bulletin:
- T-SB-0026-14 REV
- Component:
- 190000 tires
- Summary:
- "tsb: during the manufacturing process tires are mounted on the vehicle as matched sets to help reduce conditions such as pulling or drifting. if the wheels are replaced or refinished before vehicle delivery, it is important that the tire
- Bulletin:
- T-SB-0044-16
- Component:
- 350000 equipment
- Summary:
- Tsb: on some vehicles, when rapgard' is removed, the paint may have a stained appearance. these stains appear to be under the clear coat (repainting this area is not necessary). the stain patterns are usually under wrinkles in the rapgard'
- Bulletin:
- T-SB-0048-16
- Component:
- 138000 visibility:defroster/defogger system
- Summary:
- Tsb: some 2015 model year highlander and highlander hv vehicles equipped with dual front air conditioning systems may exhibit an intermittent buzzing noise condition coming from the center of the instrument panel during hvac operation. the
- Bulletin:
- T-SB-0023-16
- Component:
- 162300 structure:body:door
- Summary:
- Tsb: some 2014 ' 2015 model year highlander and highlander hv vehicles may exhibit a condition in which the power back door is inoperative or stops during operation. in some cases this condition may be associated with cold weather. follow t
- Bulletin:
- T-TT-0268-13 REV
- Component:
- 350000 equipment
- Summary:
- "tt: some customers may encounter bluetooth connectivity concerns such as: ' difficulty pairing the phone. ' intermittent bluetooth failure to connect when first turning on the vehicle. ' various bluetooth audio functions are no lo
- Bulletin:
- T-TT-0374-15 REV
- Component:
- 350000 equipment
- Summary:
- "tt: since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applica
- Bulletin:
- T-TT-0339-15
- Component:
- 350000 equipment
- Summary:
- Tt: some vehicles may exhibit an error message when trying to perform a radio software update: "unable to update the software. please try again later." if the following screen is seen, follow the directions below.
- Bulletin:
- T-SB-0160-14 OBS
- Component:
- 110000 electrical system
- Summary:
- Tsb: obsolete notice: this bulletin is now obsolete. please see t-sb-0035-16.
- Bulletin:
- T-TT-0400-16
- Component:
- 020000 suspension
- Summary:
- Tt: post tsb rear trailing arm noise.
- Bulletin:
- T-SB-0150-14
- Component:
- 353000 equipment:electrical
- Summary:
- Tsb: the purpose of this general information service bulletin is to announce sub-component diagnosis and replacement is now available for the hybrid transaxle assembly equipped on 2007 - 2011 model year camry hv, 2006 - 2015 model year high
- Bulletin:
- T-TT-0315-14
- Component:
- 200000 wheels
- Summary:
- Tt: chrometec (plastic clad) wheels are being damaged during mounting and dismounting of tires.
- Bulletin:
- T-SB-0381-09 Rev
- Component:
- 020000 suspension
- Summary:
- Tsb: the only acceptable towing method for vehicles equipped with an active torque control 4wd system is to have all four wheels off the ground. flat towing or towing where only the front or rear wheels are supported may damage the all-whee
- Bulletin:
- T-SB-0006-11 Rev
- Component:
- 100000 power train
- Summary:
- Tsb: world standard (ws) automatic transmission fluid (atf) was introduced to reduce maintenance costs and increase the mileage between scheduled maintenance checks. here are some important tips when working with atf-ws in toyota vehicles r
- Bulletin:
- T-SB-0014-11 Rev
- Component:
- 103000 power train:automatic transmission
- Summary:
- Tsb: the purpose of this service bulletin is to provide information regarding the installation of the correct torque converter bolts during automatic transmission/transaxle assembly replacement. incorrect torque converter bolts or missing w
- Bulletin:
- T-TT-0307-14
- Component:
- 118000 electrical system: software
- Summary:
- Tech tip: customer complains of carious bluetooth connectivity concerns after upgrading to ios 8.0 and later. conditions typically experienced include inability to pair the iphone to the system, poor sound quality during phone calls placed
- Bulletin:
- T-TT-0309-14
- Component:
- 118000 electrical system: software
- Summary:
- Tech tip: some customers may experience bluetooth disconnections or loss of sms text message functionality on the navigation/audio system with android phones running os 4.4 or later. condition tends to occur to customers who have many previ
- Bulletin:
- T-SB-0134-14
- Component:
- 100000 power train
- Summary:
- Tsb: the purpose of this bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid mil "on" shifting issues and/or transmission damage. use the information in this bulletin when insta
- Bulletin:
- T-SB-0077-14
- Component:
- 356000 equipment adaptive
- Summary:
- Tsb: toyota highlander/highlander hv 2015 pre-delivery service check sheet
- Bulletin:
- T-SB-0078-14
- Component:
- 110000 electrical system
- Summary:
- Tsb: pre-delivery service (pds) is a critical step in satisfying our new car customers. customer feedback indicates the following areas deserve special attention when performing pds: ? careful inspection for paint chips/scratches and body
- Bulletin:
- T-SB-0043-14 Rev
- Component:
- 353000 equipment:electrical
- Summary:
- Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased. follow the procedures in this bulletin to
- Bulletin:
- T-SB-0047-15
- Component:
- 134000 visibility:sun roof assembly
- Summary:
- Tsb: some 2014 - 2015 model year highlander/highlander hv vehicles may exhibit a condition in which the panoramic sunroof seal is bulging, not sitting properly, torn, has water or air leaks into the vehicle cabin, has poor appearance, or is
- Bulletin:
- T-TT-0344-15
- Component:
- 118000 electrical system: software
- Summary:
- Tt: iphone text messages do not appear on multimedia display.
- Bulletin:
- T-SB-0083-13 Rev
- Component:
- 353600 equipment:air conditioner
- Summary:
- Tsb: the procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. refer to the applicable repair manual for vehicle specific repair procedures and parts.
- Bulletin:
- T-SB-0025-15
- Component:
- 110000 electrical system
- Summary:
- Tsb: while a vehicle is in inventory, the battery is subject to conditions that can reduce its performance and life. batteries can become discharged due to an extended storage period, temperature, parasitic drain, or while demonstrating veh
- Bulletin:
- T-SB-0027-15
- Component:
- 162300 structure:body:door
- Summary:
- Tsb: some 2014 - 2015 model year highlander vehicles may exhibit a condition in which the power back door starts to open or close normally, then intermittently stops and beeps twice. in most cases no current dtc is present, but dtc b2226 or
- Bulletin:
- T-SB-0142-13 Rev
- Component:
- 353600 equipment:air conditioner
- Summary:
- Tsb: some 2004 - 2015 model year toyota vehicles may exhibit odors naturally occurring from the hvac system and/or related environmental factors. although there is no way to eliminate these odors, follow the general procedure in this bullet
- Bulletin:
- T-SB-0101-11 Rev
- Component:
- 110000 electrical system
- Summary:
- Tsb: when servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. many lubricants, cleaners, and automotive chemicals contain silicone or othe
- Bulletin:
- T-SB-0160-14 Rev
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Tsb: entune audio head unit update
- Bulletin:
- T-TT-0262-13 Rev
- Component:
- 060000 engine and engine cooling
- Summary:
- Tt: starting with 2010 model year, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil. there are multiple benefits of this oil. due to the them improved performance and durability of 0w-20 synthetic oil, to
- Bulletin:
- T-TT-0234-13 Rev
- Component:
- 353000 equipment:electrical
- Summary:
- Tt: since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicabilit
- Bulletin:
- T-TT-0337-15
- Component:
- 118000 electrical system: software
- Summary:
- Tt: when updating either the navigation or radio firmware, verify the vehicle applicability before beginning the update.
- Bulletin:
- T-SB-0040-08
- Component:
- 162000 structure:body
- Summary:
- Tsb: on some vehicles, when rapgard is removed, the paint may have a stained appearance. these stains appear to be under the clear coat (repainting this area is not necessary). the stain patterns are usually under wrinkles in the rapgard. t
- Bulletin:
- TT-0307-14 Rev2
- Component:
- 118000 electrical system: software
- Summary:
- Tt: some customers may encounter various bluetooth connectivity concerns after upgrading to ios 8.0 and later. conditions typically experienced include inability to pair the iphone to the system, poor sound quality during phone calls placed
- Bulletin:
- T-TT-0268-13 Rev
- Component:
- 118000 electrical system: software
- Summary:
- Tt: some customers may encounter bluetooth® connectivity concerns such as: * difficulty to pair the phone. * intermittent bluetooth® failure to connect to the vehicle when first turning on the vehicle. * various bluetooth® audio function
- Bulletin:
- T-TT-0322-15
- Component:
- 134000 visibility:sun roof assembly
- Summary:
- Tt: some vehicles may experience a condition in which the drain hoses for the sunroof/moon roof assembly become kinked, or pinched. this may cause water leaks into the cabin from the housing assembly drip trays, or the customer may note wat
- Bulletin:
- T-TT-307-14 Rev1
- Component:
- 118000 electrical system: software
- Summary:
- Tt: customers complain of various bluetooth connectivity concerns after upgrading to ios 8.0 and later. conditions typically experienced include inability to pair the iphone to the system, poor sound quality during phone calls placed throug
- Bulletin:
- T-TT-0344-15
- Component:
- 353000 equipment:electrical
- Summary:
- Tt: iphone text messages do not appear on multimedia display.
- Bulletin:
- T-TT-0322-15
- Component:
- 134000 visibility:sun roof assembly
- Summary:
- Tt: some vehicles may experience a condition in which the drain hoses for the sunroof/moon roof assembly become kinked, or pinched. this may cause water leaks into the cabin from the housing assembly drip trays, or the customer may note wat
- Bulletin:
- T-TT-307-14 Rev1
- Component:
- 353000 equipment:electrical
- Summary:
- Tt: customers complain of various bluetooth connectivity concerns after upgrading to ios 8.0 and later. conditions typically experienced include inability to pair the iphone to the system, poor sound quality during phone calls placed throug
- Bulletin:
- T-SB-0040-08
- Component:
- 162000 structure:body
- Summary:
- Tsb: on some vehicles, when rapgard is removed, the paint may have a stained appearance. these stains appear to be under the clear coat (repainting this area is not necessary). the stain patterns are usually under wrinkles in the rapgard. t
- Bulletin:
- TT-0307-14 Rev2
- Component:
- 353000 equipment:electrical
- Summary:
- Tt: some customers may encounter various bluetooth connectivity concerns after upgrading to ios 8.0 and later. conditions typically experienced include inability to pair the iphone to the system, poor sound quality during phone calls placed
- Bulletin:
- T-TT-0268-13 Rev
- Component:
- 353000 equipment:electrical
- Summary:
- Tt: some customers may encounter bluetooth® connectivity concerns such as: * difficulty to pair the phone. * intermittent bluetooth® failure to connect to the vehicle when first turning on the vehicle. * various bluetooth® audio function
- Bulletin:
- T-SB-0142-13 Rev
- Component:
- 353600 equipment:air conditioner
- Summary:
- Tsb: some 2004 - 2015 model year toyota vehicles may exhibit odors naturally occurring from the hvac system and/or related environmental factors. although there is no way to eliminate these odors, follow the general procedure in this bullet
- Bulletin:
- T-SB-0101-11 Rev
- Component:
- 110000 electrical system
- Summary:
- Tsb: when servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. many lubricants, cleaners, and automotive chemicals contain silicone or othe
- Bulletin:
- T-SB-0160-14 Rev
- Component:
- 353000 equipment:electrical
- Summary:
- Tsb: entune audio head unit update
- Bulletin:
- T-TT-0262-13 Rev
- Component:
- 060000 engine and engine cooling
- Summary:
- Tt: starting with 2010 model year, toyota began a gradual transition to the use of synthetic 0w-20 viscosity engine oil. there are multiple benefits of this oil. due to the them improved performance and durability of 0w-20 synthetic oil, to
- Bulletin:
- T-TT-0234-13 Rev
- Component:
- 353000 equipment:electrical
- Summary:
- Tt: since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicabilit
- Bulletin:
- T-TT-0337-15
- Component:
- 118000 electrical system: software
- Summary:
- Tt: when updating either the navigation or radio firmware, verify the vehicle applicability before beginning the update.
- Bulletin:
- T-SB-0043-14 Rev
- Component:
- 353000 equipment:electrical
- Summary:
- Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased. follow the procedures in this bulletin to
- Bulletin:
- T-SB-0047-15
- Component:
- 134000 visibility:sun roof assembly
- Summary:
- Tsb: some 2014 - 2015 model year highlander/highlander hv vehicles may exhibit a condition in which the panoramic sunroof seal is bulging, not sitting properly, torn, has water or air leaks into the vehicle cabin, has poor appearance, or is
- Bulletin:
- T-SB-0026-14 Rev
- Component:
- 200000 wheels
- Summary:
- Tsb: during the manufacturing process tires are mounted on the vehicle as matched sets to help reduce conditions such as pulling or drifting. if the wheels are replaced or refinished before vehicle delivery, it is important that the tires
- Bulletin:
- T-TT-0315-14
- Component:
- 200000 wheels
- Summary:
- Tt: chrometec (plastic clad) wheels are being damaged during mounting and dismounting of tires. refer to photos below for identifying plastic and aluminum portions of wheel:
- Bulletin:
- T-SB-0028-14
- Component:
- 350000 equipment
- Summary:
- Tsb: long-term or off-site storage requires special care to keep vehicles factory fresh and ready for delivery. the following guidelines should be performed to minimize vehicle component/part degradation due to extended vehicle storage co
- Bulletin:
- T-TT-0309-14 Rev
- Component:
- 353000 equipment:electrical
- Summary:
- Tt: some customers may experience bluetooth disconnections or loss of sms text message functionality on the navigation/audio system with android phones running os 4.4 or later. condition tends to occur to customers who have many previous te
- Bulletin:
- T-SB-0083-13 Rev
- Component:
- 353600 equipment:air conditioner
- Summary:
- Tsb: the procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. refer to the applicable repair manual for vehicle specific repair procedures and parts.
- Bulletin:
- T-SB-0025-15
- Component:
- 110000 electrical system
- Summary:
- Tsb: while a vehicle is in inventory, the battery is subject to conditions that can reduce its performance and life. batteries can become discharged due to an extended storage period, temperature, parasitic drain, or while demonstrating veh
- Bulletin:
- T-SB-0027-15
- Component:
- 162600 structure:body:hatchback/liftgate
- Summary:
- Tsb: some 2014 - 2015 model year highlander vehicles may exhibit a condition in which the power back door starts to open or close normally, then intermittently stops and beeps twice. in most cases no current dtc is present, but dtc b2226 or
- Bulletin:
- T-SB-0023-16 Rev
- Component:
- 162600 structure:body:hatchback/liftgate
- Summary:
- Tsb: revision notice august 3, 2016 rev1: warranty information section has been updated with a new op code. supersession notice the information contained in this bulletin supersedes sb no. t-sb-0027-15. any previous printed versions of
- Bulletin:
- T-TT-0414-16
- Component:
- 353000 equipment:electrical
- Summary:
- Tt: some customers may encounter bluetooth® connectivity concerns such as: *difficulty to pair the phone. *intermittent bluetooth® failure to connect to the vehicle when first turning on the vehicle. *various bluetooth® audio functions a
- Bulletin:
- T-SB-0232-17
- Component:
- 162300 structure:body:door
- Summary:
- Tsb: some 2014 - 2017 model year highlander/highlander hv and 2011 - 2017 model year sienna vehicles equipped with a power back door (pbd) may exhibit a condition in which the back door latch does not release and the pbd cannot be opened fr
- Bulletin:
- SET-TSB-17-007
- Component:
- 120000 lighting (pws)
- Summary:
- Southeast toyota accessory led fog & drl 2 in 1 light inoperative. provide accessory lamp diagnostics and manufacturing date inspection information.
- Bulletin:
- SET-TSB-15-015
- Component:
- 210000 trailer hitches
- Summary:
- Discusses the proper stowage of trailer harnesses on highlander models with southeast toyota accessory trailer hitch.
- Bulletin:
- T-SB-0304-17
- Component:
- 162300 structure:body:door
- Summary:
- Tsb: vehicle replacement certification labels (the vinyl label installed on the driver door or door post) and vin plates (the metal plate riveted to dashboard) may be available from toyota, provided the request meets one of the criteria lis
- Bulletin:
- T-SB-0134-16_Rev
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Tsb: revision notice october 30, 2017 rev1: * applicability has been updated to include 2018 model year vehicles. supersession notice the information contained in this bulletin supersedes sb no. t-sb-0012-13. flash reprogramming allows the
- Bulletin:
- T-SB-0009-18
- Component:
- 220000 seats
- Summary:
- Tsb: the purpose of this service bulletin is to elevate awareness and provide best practices for leather and synthetic leather care in toyota vehicles. as an additional resource, if the vehicle is equipped with factory leather seats, the ve
- Bulletin:
- T-SB-0187-12_Rev
- Component:
- 190000 tires
- Summary:
- Tsb: revision notice february 12, 2018 rev2: ? applicability has been updated to include 2015 ? 2018 model year vehicles. january 23, 2014 rev1: ? applicability has been updated to include 2013 ? 2014 model year vehicles. any previous print
- Bulletin:
- T-SB-0211-17_Rev
- Component:
- 020000 suspension
- Summary:
- Tsb: revision notice february 23, 2018 rev1: ? applicability has been updated to include 2018 model year highlander and highlander hv vehicles. ? the introduction, warranty information, and repair procedure sections have been updated. any
- Bulletin:
- T-SB-0304-17_Rev
- Component:
- 350000 equipment
- Summary:
- Tsb: supersession notice the information contained in this bulletin supersedes service bulletin nos. pg021-88, pg015-89, pg0015-90, pg002-91, pg002-93, pg005-97, pg007-01, pg007-07, and t-sb-0144-08. service bulletin nos. pg021-88, pg015-89
- Bulletin:
- T-SB-0009-18
- Component:
- 350000 equipment
- Summary:
- Tsb: the purpose of this service bulletin is to elevate awareness and provide best practices for leather and synthetic leather care in toyota vehicles. as an additional resource, if the vehicle is equipped with factory leather seats, the ve
- Bulletin:
- T-SB-0187-12_Rev
- Component:
- 190000 tires
- Summary:
- Tsb: revision notice february 12, 2018 rev2: ? applicability has been updated to include 2015 ? 2018 model year vehicles. january 23, 2014 rev1: ? applicability has been updated to include 2013 ? 2014 model year vehicles. any previous print
- Bulletin:
- T-TT-0365-15 Rev
- Component:
- 111000 electrical system:battery
- Summary:
- Tt: a vehicle may arrive to the dealer with a mil ?on? condition and p0a80 or p1ac000 stored in the memory. some cases have been identified with internal modification done to the hv battery. modified or altered parts are not covered under
- Bulletin:
- T-TT-0435-17
- Component:
- 353500 equipment:electrical:navigational system(global positioning system)
- Summary:
- Tt: this bulletin is regarding best practices when handling navigation systems that use hard disc drive or micro sd card memory.
- Bulletin:
- T-TT-0437-17
- Component:
- 353000 equipment:electrical
- Summary:
- Tt: some customers may experience greyed out buttons or inactive screens (lockouts) while driving. this is to promote safe driving practices and reduce the amount of distractions while driving. these lockouts can?t be deactivated or defeat
- Bulletin:
- T-SB-0024-14
- Component:
- 116000 electrical system:ignition
- Summary:
- Some 2015 model year vehicles are equipped with a smart key system, which allows the customer to enter and start the vehicle without using a mechanical key. to ensure the system is operating properly, the smart key functions (smart entry a
- Bulletin:
- T-SB-0026-14
- Component:
- 200000 wheels
- Summary:
- During the manufacturing process tires are mounted on the vehicle as matched sets to help reduce conditions such as pulling or drifting. if the wheels are replaced or refinished before vehicle delivery, it is important that the tires remain
- Bulletin:
- T-SB-0027-14
- Component:
- 111000 electrical system:battery
- Summary:
- Hybrid vehicles are equipped with 2 types of batteries: hybrid vehicle (hv) battery, 12-volt auxiliary battery. if the hybrid vehicle is put into storage, the state of charge (soc) of its hv battery and auxiliary battery will gradually decr
- Bulletin:
- T-SB-0028-14
- Component:
- 350000 equipment
- Summary:
- Long-term or off-site storage requires special care to keep vehicles factory fresh and ready for delivery. the following guidelines should be performed to minimize vehicle component/part degradation due to extended vehicle storage condition
- Bulletin:
- T-SB-0029-14
- Component:
- 356000 equipment adaptive
- Summary:
- 2015 model year vehicles are equipped with driver?s side floor mat retaining clips to secure the floor mat in the correct position. in addition, some models may utilize retaining clips for passenger side and rear seat floor mats as well. fo
- Bulletin:
- T-SB-0035-16_Rev
- Component:
- 350000 equipment
- Summary:
- Tsb: revision notice march 23, 2017 rev1: ? applicability has been updated to include 2016 - 2017 model year mirai vehicles. g1855ware version information charts and the introduction have been updated. supersession notice: the informa
- Bulletin:
- T-SB-0044-16_Rev
- Component:
- 162000 structure:body
- Summary:
- Tsb: revision notice march 07, 2017 rev1: ? applicability has been updated to include 2017 model year toyota vehicles. on some vehicles, when rapgard? is removed the paint may have a stained appearance. these stains appear to be under the c
- Bulletin:
- T-SB-0033-14_Rev
- Component:
- 353600 equipment:air conditioner
- Summary:
- Tsb: revision notice march 08, 2017 rev1: ? applicability has been updated to include 2015 - 2017 model year toyota vehicles. ? the parts information section has been updated. some vehicles in particular geographic areas may exhibit a c
- Bulletin:
- T-TT-0432-17_Rev
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Tt: rev2 some customers may complain about a hybrid vehicle battery cooling system warning message. this warning message may appear when the hv battery cooling system loses efficiency due to debris on the filter and or some object obstruc
- Bulletin:
- SET-TSB-17-006
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- This publication discusses how to find the diagnostic information and component exchange information for the southeast toyota accessory overhead dvd player.
- Bulletin:
- T-SB-0218-17_Rev
- Component:
- 140000 air bags
- Summary:
- Tsb: revision notice july 20, 2017 rev1: applicability has been updated to exclude 2007 ? 2017 model year avanza vehicles. some hazardous material treatment and handling regulations at the state and local level define the pre-disposal deplo
- Bulletin:
- T-TT-0453-17
- Component:
- 353000 equipment:electrical
- Summary:
- Tt: an error message is received when performing dcm activation initiated by techstream. this is a known condition and will be remedied in the near future. please discontinue dcm activations utilizing techstream until further notice.
- Bulletin:
- T-SB-0160-14 Rev
- Component:
- 110000 electrical system
- Summary:
- Tsb: some 2014 model year applicable vehicles equipped with entune? audio (version 010169) / entune? audio plus (version 010171) entune? premium audio (version 01085) may exhibit one or more of the following conditions: bluetooth® someti
- Bulletin:
- T-SB-0052-15
- Component:
- 110000 electrical system
- Summary:
- Tsb: some 2015 model year highlander and rav4 vehicles without smart key may have a wireless/tpms receiver with a hardware condition that significantly reduces wireless remote control range. follow the repair procedure in this bulletin to
- Bulletin:
- T-SB-0029-14 Rev
- Component:
- 356000 equipment adaptive
- Summary:
- Tsb: 2015 ? 2016 model year vehicles are equipped with driver?s side floor mat retaining clips to secure the floor mat in the correct position. in addition, some models may utilize retaining clips for passenger side and rear seat floor ma
- Bulletin:
- T-SB-0027-14 Rev
- Component:
- 111000 electrical system:battery
- Summary:
- Tsb: hybrid vehicles are equipped with 2 types of batteries: ? hybrid vehicle (hv) battery ? 12-volt auxiliary battery if the hybrid vehicle is put into storage, the state of charge (soc) of its hv battery and auxiliary battery will gra
- Bulletin:
- T-TT-0352-15
- Component:
- 270000 lane departure
- Summary:
- Techtip: in some cases, combination meters may automatically initialize for options detected on a specific vehicle. if a meter is exchanged between vehicles for diagnostic purposes, it may become unusable in the original vehicle. for examp
- Bulletin:
- T-TT-0355-15
- Component:
- 118000 electrical system: software
- Summary:
- Techtip: condition: customers may experience connectivity issues when the following conditions are met: the customer?s iphone is operating on ios9 firmware the customer?s iphone is connected to the vehicle via bluetooth. if the veh
- Bulletin:
- T-TT-0293-14 Rev
- Component:
- 353500 equipment:electrical:navigational system(global positioning system)
- Summary:
- Tt: safety connect is a vehicle option which requires a subscription fee for the system to be active. the first year of service is provided in the vehicle purchase price. once the subscription has lapsed the dcm will be in an inactive state
- Bulletin:
- T-TT-0234-13 Rev
- Component:
- 353500 equipment:electrical:navigational system(global positioning system)
- Summary:
- Tt: since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicabilit
- Bulletin:
- T-TT-0234-13 Rev
- Component:
- 353500 equipment:electrical:navigational system(global positioning system)
- Summary:
- Tt: since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicabilit
- Bulletin:
- T-TT-0339-15
- Component:
- 118000 electrical system: software
- Summary:
- Tt: some vehicles may exhibit an error message when trying to perform a radio software update: ?unable to update the software. please try again later.? if the following screen is seen; follow the directions below.
- Bulletin:
- T-TT-0340-15
- Component:
- 118000 electrical system: software
- Summary:
- Tt: while accessing the repair manuals for models that have undergone a full model change starting with the 2013 rav4, you may encounter disabled (i.e. greyed out) "info button" links while browsing with internet explorer 10. you can identi
- Bulletin:
- T-TT-0327-15
- Component:
- 030000 service brakes, hydraulic
- Summary:
- Techtip: some vehicles may exhibit a condition in which the front corner mounting point of the side shield would separate from the lower frame assembly. this condition may occur when the customer enters or exits the vehicle and significant
- Bulletin:
- T-TT-0309-14 Rev
- Component:
- 110000 electrical system
- Summary:
- Tt: some customers may experience bluetooth disconnections or loss of sms text message functionality on the navigation/audio system with android phones running os 4.4 or later. condition tends to occur to customers who have many previous t
- Bulletin:
- T-TT-0400-16 Rev
- Component:
- 020000 suspension
- Summary:
- Tt: post tsb rear trailing arm noise.
- Bulletin:
- T-TT-0453-17-Rev
- Component:
- 350000 equipment
- Summary:
- Tt: previously, an error message was received when performing dcm activation initiated by techstream. this condition has been remedied, and dcm activation utilizing techstream can now be resumed.
- Bulletin:
- T-TT-0339-15_Rev
- Component:
- 353000 equipment:electrical
- Summary:
- Tt: some vehicles may exhibit an error message when trying to perform a radio software update: "unable to update the software. please try again later." if the following screen is seen; follow the directions below.
- Bulletin:
- T-SB-0043-14
- Component:
- 353100 equipment:electrical:anti-theft devices
- Summary:
- Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased.
- Bulletin:
- T-SB-0043-14 Rev
- Component:
- 353100 equipment:electrical:anti-theft devices
- Summary:
- Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased.
- Bulletin:
- T-SB-003-01 - OB
- Component:
- 980000 unknown or other
- Summary:
- Tsb: obsolete notice: july 7, 2014: this bulletin is now obsolete.
- Bulletin:
- T-TT-0262-13 Rev
- Component:
- 060000 engine (pws)
- Summary:
- Tech tip: starting with the 2010 model year, toyota began a gradual transition to the use of synthetic 0w20 viscosity engine oil. there are multiple benefits of this oil including: reduced friction and wear on engine surfaces, improved fuel
- Bulletin:
- T-TT-0246-13 Rev
- Component:
- 110000 electrical system
- Summary:
- Tech tip: tips for writing a dpr (dealer product report) on manufacturing issues for windows and windshields.
- Bulletin:
- T-SB-0012-13 Rev
- Component:
- 118000 electrical system: software
- Summary:
- Tsb: flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bullet
- Bulletin:
- T-TT-0010-10 Rev
- Component:
- 060000 engine (pws)
- Summary:
- Tech tip: low battery voltage can contribute to a mil "on" condition for p0335 (crankshaft position
- Bulletin:
- T-SB-0149-16
- Component:
- 200000 wheels
- Summary:
- Tsb: some 2014 ? 2016 highlander/hv vehicles may exhibit a condition where the spare tire cable does not fully unwind. this condition can occur when the spare tire carrier is operated without the wheel attached. follow the repair procedure
- Bulletin:
- T-TT-0424-16
- Component:
- 203000 wheels:lugs/nuts/bolts
- Summary:
- Tt: front brake vibration key points: * issue can occur at any time if improper torque is applied on lug nuts * over time, even one lug nut over or under torqued, can cause a vibration issue * when lug nuts are over torqued, this causes
- Bulletin:
- T-TT-0315-14 Rev
- Component:
- 200000 wheels
- Summary:
- Tt: chrometec (plastic clad) wheels are being damaged during mounting and dismounting of tires.
- Bulletin:
- T-SB-0142-13 Rev
- Component:
- 353600 equipment:air conditioner
- Summary:
- Tsb: revision notice november 10, 2016 rev2: ? applicability has been updated to include 2016 ? 2017 model year toyota vehicles. ? parts information section has been updated. some 2004 ? 2017 model year toyota vehicles may exhibit odor
- Bulletin:
- T-SB-0167-16
- Component:
- 162300 structure:body:door
- Summary:
- Tsb: some 2014 ? 2016 model year highlander and highlander hv vehicles may exhibit a condition in which the door handle material insert of the driver or passenger side door panels is creased, wrinkly, or has started peeling. this condition
- Bulletin:
- T-SB-0027-15 OBS
- Component:
- 110000 electrical system
- Summary:
- Tsb: obsolete notice: march 25, 2016: this bulletin is now obsolete. please see t-sb-0023-16.
- Bulletin:
- T-SB-0012-13 Rev
- Component:
- 118000 electrical system: software
- Summary:
- Tsb: obsolete notice: september 14, 2016: this bulletin is now obsolete. please see t-sb-0134-16.
- Bulletin:
- T-SB-0229-12_Rev
- Component:
- 110000 electrical system
- Summary:
- Tsb: revision notice november 22, 2017 rev1: ? applicability has been updated to include 2014 ? 2018 model year vehicles. any previous printed versions of this bulletin should be discarded. in the event that a toyota vehicle becomes submerg
- Bulletin:
- T-TT-0375-15_Rev
- Component:
- 350000 equipment
- Summary:
- Tt: for customer concerns of no or poor outgoing sound from the bluetooth systems there are diagnostics in the repair manual which can be performed to diagnose the condition.
- Bulletin:
- T-TT-0377-15_Rev
- Component:
- 356000 equipment adaptive
- Summary:
- Tt: some customers may experience poor outgoing bluetooth sound quality, this can occur for various reasons. current multimedia systems are designed with the ability to adjust bluetooth sound quality to compensate for echo or excessive back
- Bulletin:
- T-SB-0160-14 Obs
- Component:
- 118000 electrical system: software
- Summary:
- Tsb: obsolete notice: this bulletin is now obsolete. please see t-sb-0035-16.
- Bulletin:
- T-TT-0399-16
- Component:
- 110000 electrical system
- Summary:
- Tt: multimedia systems reset procedure should be performed when the multimedia system no longer responds or reboots itself.
- Bulletin:
- T-TT-0400-16
- Component:
- 354000 equipment:mechanical
- Summary:
- Tt: post tsb rear trailing arm noise.
- Bulletin:
- TSB-0012-13 Rev2
- Component:
- 060000 engine (pws)
- Summary:
- Tsb: flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bull
- Bulletin:
- T-TT-0322-15 Rev
- Component:
- 134000 visibility:sun roof assembly
- Summary:
- Tech tip: some vehicles may experience a condition in which the drain hoses for the sunroof/moonroof assembly become kinked, or pinched. this may cause water leaks into the cabin from the housing assembly drip trays, or the customer may not
- Bulletin:
- T-TT-0381-16
- Component:
- 118000 electrical system: software
- Summary:
- Tech tip: some customers may experience difficulty programming homelink.
- Bulletin:
- T-TT-0327-15
- Component:
- 160000 structure
- Summary:
- Techtip: some vehicles may exhibit a condition in which the front corner mounting point of the side shield would separate from the lower frame assembly. this condition may occur when the customer enters or exits the vehicle and significant
- Bulletin:
- T-TT-0357-15
- Component:
- 198000 tires:temporary/emergency spare tire
- Summary:
- Tt: spare tire carrier will bind/seize when lowering or raising spare tire or cable will not fully extend when attempting to lower spare tire, therefore making it difficult to remove from the cable.
- Bulletin:
- T-TT-0360-15
- Component:
- 110000 electrical system
- Summary:
- Tt: customers may experience connectivity issues when the following conditions are met: the customer's iphone is operating on ios9 firmware. the customer's iphone is connected to the vehicle via bluetooth. the customer may complain of the f
- Bulletin:
- TTT-0344-15 Rev1
- Component:
- 110000 electrical system
- Summary:
- Tt: iphone text messages do not appear on multimedia dis[play.
- Bulletin:
- TTT-0234-13 Rev6
- Component:
- 353000 equipment:electrical
- Summary:
- Tt: since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicabilit
- Bulletin:
- TTT-0337-15 Rev1
- Component:
- 118000 electrical system: software
- Summary:
- Tt: when updating either the navigation or radio firmware, verify the vehicle applicability before beginning the update.
- Bulletin:
- T-TT-0385-16
- Component:
- 118000 electrical system: software
- Summary:
- Tech tip: this tech tip is being provided to bring attention to the new location of the entune/nav/map update and upgrade usb directory. click on the tis tab, diagnostics tab, telematics tab, and the document is now located under the refer
- Bulletin:
- T-SB-0023-16
- Component:
- 110000 electrical system
- Summary:
- Tsb: some 2014 ? 2015 model year highlander and highlander hv vehicles may exhibit a condition in which the power back door is inoperative or stops during operation. in some cases this condition may be associated with cold weather. follow t
- Bulletin:
- TTT-0268-13 Rev3
- Component:
- 110000 electrical system
- Summary:
- Tt: some customers may encounter bluetooth connectivity concerns such as: ? difficulty pairing the phone. ? intermittent bluetooth failure to connect when first turning on the vehicle. ? various bluetooth audio functions are no lon
- Bulletin:
- T-TT-0374-15
- Component:
- 118000 electrical system: software
- Summary:
- Tt: since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicab
- Bulletin:
- T-TT-0339-15
- Component:
- 118000 electrical system: software
- Summary:
- Tt: some vehicles may exhibit an error message when trying to perform a radio software update: "unable to update the software. please try again later." if the following screen is seen, follow the directions below.
- Bulletin:
- T-TT-0327-15 Rev
- Component:
- 220000 seats
- Summary:
- Tt: some vehicles may exhibit a condition in which the front corner mounting point of the side shield would separate from the lower frame assembly. the condition may occur when the customer enters or exits the vehicle and significant downwa
- Bulletin:
- T-SB-0074-16
- Component:
- 110000 electrical system
- Summary:
- Tsb: some 2014 ? 2015 model year highlander vehicles may exhibit a mil ?on? condition with diagnostic trouble code (dtc) p2610 (ecm/pcm engine off timer performance) present. the engine control module (ecm) logic has been modified to reduc
- Bulletin:
- T-SB-0031-16
- Component:
- 110000 electrical system
- Summary:
- Tsb: some 2014 ? 2016 model year highlander, highlander hv and rav4 vehicles may exhibit an intermittent cruise control stalk illumination flicker condition. please follow the repair procedure below to address this condition.
- Bulletin:
- T-SB-0036-13 Rev
- Component:
- 100000 power train
- Summary:
- Tsb: this bulletin includes basic procedures for inspecting and adjusting world standard (ws) automatic transmission fluid (atf) level at normal vehicle operating temperature. note: the following adjustment procedures are for u660e/f and
- Bulletin:
- T-TT-0392-16
- Component:
- 353000 equipment:electrical
- Summary:
- Tt: some customers may experience bluetooth connection issues after updating the android operating system to 5.x.x (lollipop) or later.
- Bulletin:
- T-SB-0160-14 Rev
- Component:
- 110000 electrical system
- Summary:
- Tsb: some 2014 model year applicable vehicles equipped with entune? audio (version 010169) / entune? audio plus (version 010171) entune? premium audio (version 01085) may exhibit one or more of the following conditions: bluetooth® someti
- Bulletin:
- T-SB-0052-15
- Component:
- 353100 equipment:electrical:anti-theft devices
- Summary:
- Tsb: some 2015 model year highlander and rav4 vehicles without smart key may have a wireless/tpms receiver with a hardware condition that significantly reduces wireless remote control range. follow the repair procedure in this bulletin to
- Bulletin:
- T-SB-0029-14 Rev
- Component:
- 356000 equipment adaptive
- Summary:
- Tsb: 2015 ? 2016 model year vehicles are equipped with driver?s side floor mat retaining clips to secure the floor mat in the correct position. in addition, some models may utilize retaining clips for passenger side and rear seat floor ma
- Bulletin:
- T-SB-0027-14 Rev
- Component:
- 111000 electrical system:battery
- Summary:
- Tsb: hybrid vehicles are equipped with 2 types of batteries: ? hybrid vehicle (hv) battery ? 12-volt auxiliary battery if the hybrid vehicle is put into storage, the state of charge (soc) of its hv battery and auxiliary battery will gra
- Bulletin:
- T-TT-0352-15
- Component:
- 270000 lane departure
- Summary:
- Techtip: in some cases, combination meters may automatically initialize for options detected on a specific vehicle. if a meter is exchanged between vehicles for diagnostic purposes, it may become unusable in the original vehicle. for examp
- Bulletin:
- T-TT-0355-15
- Component:
- 118000 electrical system: software
- Summary:
- Techtip: condition: customers may experience connectivity issues when the following conditions are met: the customer?s iphone is operating on ios9 firmware the customer?s iphone is connected to the vehicle via bluetooth. if the veh
- Bulletin:
- T-TT-0293-14 Rev
- Component:
- 110000 electrical system
- Summary:
- Tt: safety connect is a vehicle option which requires a subscription fee for the system to be active. the first year of service is provided in the vehicle purchase price. once the subscription has lapsed the dcm will be in an inactive state
- Bulletin:
- T-TT-0234-13 Rev
- Component:
- 353600 equipment:air conditioner
- Summary:
- Tt: since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicabilit
- Bulletin:
- T-TT-0234-13 Rev
- Component:
- 353500 equipment:electrical:navigational system(global positioning system)
- Summary:
- Tt: since my 2011, several different update or upgrade usb ssts have been issued for toyota audio and navigation systems. refer to the chart below for a comprehensive list of all current and previously issued usb ssts and their applicabilit
- Bulletin:
- T-TT-0339-15
- Component:
- 110000 electrical system
- Summary:
- Tt: some vehicles may exhibit an error message when trying to perform a radio software update: ?unable to update the software. please try again later.? if the following screen is seen; follow the directions below.
- Bulletin:
- T-TT-0340-15
- Component:
- 350000 equipment
- Summary:
- Tt: while accessing the repair manuals for models that have undergone a full model change starting with the 2013 rav4, you may encounter disabled (i.e. greyed out) "info button" links while browsing with internet explorer 10. you can identi
- Bulletin:
- T-TT-0392-16 Rev
- Component:
- 118000 electrical system: software
- Summary:
- Tt: some customers may experience bluetooth connection issues after updating the android operating system to 5.x.x (lollipop) or later.
- Bulletin:
- T-SB-0035-16
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Tsb: some 2014 model year applicable vehicles equipped with entune? audio (version 010169) / entune? audio plus (version 010171) / entune? premium audio (version 010185) may exhibit one or more of the following conditions.
- Bulletin:
- T-TT-0395-16
- Component:
- 111000 electrical system:battery
- Summary:
- Tt: hv batteries have liquid filled cell modules, to prevent leakage from cells, it is very important to confirm the proper orientation mark of the drc.
- Bulletin:
- T-SB-0044-16
- Component:
- 162000 structure:body
- Summary:
- Tsb: on some vehicles, when rapgard? is removed, the paint may have a stained appearance. these stains appear to be under the clear coat (repainting this area is not necessary). the stain patterns are usually under wrinkles in the rapgard?
- Bulletin:
- T-SB-0048-16
- Component:
- 353600 equipment:air conditioner
- Summary:
- Tsb: some 2015 model year highlander and highlander hv vehicles equipped with dual front air conditioning systems may exhibit an intermittent buzzing noise condition coming from the center of the instrument panel during hvac operation. the
- Bulletin:
- T-TT-0496-18
- Component:
- 131000 visibility:windshield
- Summary:
- Tt: vehicles may experience a mil on condition exhibiting codes p314a and/or p0c73 with evidence of water (corrosion) at the a9 inverter water pump connector. this condition may be caused by vehicles being equipped with an aftermarket winds
- Bulletin:
- T-TT-0442-17_Rev
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Tt: safety connect is a vehicle option which requires a subscription fee for the system to be active. the trail period of service is provided upon the vehicle purchase. once the subscription has expired the dcm (telematics transceiver) will
- Bulletin:
- T-SB-0044-16
- Component:
- 160000 structure
- Summary:
- Tsb: on some vehicles, when rapgard? is removed, the paint may have a stained appearance. these stains appear to be under the clear coat (repainting this area is not necessary). the stain patterns are usually under wrinkles in the rapgard?
- Bulletin:
- T-SB-0048-16
- Component:
- 110000 electrical system
- Summary:
- Tsb: some 2015 model year highlander and highlander hv vehicles equipped with dual front air conditioning systems may exhibit an intermittent buzzing noise condition coming from the center of the instrument panel during hvac operation. the
- Bulletin:
- T-SB-0207-17
- Component:
- 220000 seats
- Summary:
- Tsb: some north american produced rav4, highlander, highlander hv, and sienna vehicles equipped with manual front seats may exhibit an inoperative forward/rearward adjustment function. upon closer inspection it may be noticed that the seat
- Bulletin:
- T-SB-0211-17
- Component:
- 022000 suspension:rear
- Summary:
- Tsb: some 2014 ? 2017 model year highlander and highlander hv vehicles may exhibit an abnormal squeak, squawk or groan type noise from the rear suspension when traveling over uneven roads, or when the vehicle comes to a complete stop, which
- Bulletin:
- T-TT-0442-17
- Component:
- 110000 electrical system
- Summary:
- Tt: safety connect is a vehicle option which requires a subscription fee for the system to be active. the first year of service is provided in the vehicle purchase price. once the subscription has expired the dcm (telematics transceiver) wi
- Bulletin:
- T-SB-0057-18
- Component:
- 350000 equipment
- Summary:
- Tsb: supersession notice the information contained in this bulletin supersedes service bulletin no. t-sb-0043-14. ? applicability has been updated to include 2017 ? 2018 model year toyota vehicles. service bulletin no. t-sb-0043-14 is obso
- Bulletin:
- T-SB-0072-18
- Component:
- 020000 suspension
- Summary:
- Tsb: some 2014 ? 2018 model year highlander vehicles may exhibit a vibration from the front brakes during light application of the brake pedal at highway speeds. follow the repair procedure in this bulletin to address this condition.
- Bulletin:
- T-SB-0304-17_Rev
- Component:
- 350000 equipment
- Summary:
- Tsb: revision notice july 31, 2018 rev2: ? the supersession notice has been updated. january 11, 2018 rev1: ? the supersession notice has been updated. any previous printed versions of this bulletin should be discarded. supersession notice
- Bulletin:
- GST-TSB-18-002
- Component:
- 350000 equipment
- Summary:
- This technical service bulletin provides procedures to inspect and repair certain model year 2015-2017 toyota highlander vehicles equipped with the brushed stainless steel running boards accessory which exhibits a sagging condition on the r
- Bulletin:
- PG004-97-Obsolet
- Component:
- 350000 equipment
- Summary:
- Technical service bulletin: obsolete notice: july 31, 2018: this bulletin is now obsolete. please see t-sb-0304-17.
- Bulletin:
- PG006-01-Obsolet
- Component:
- 350000 equipment
- Summary:
- Technical service bulletin: obsolete notice: july 31, 2018: this bulletin is now obsolete. please see t-sb-0304-17.
- Bulletin:
- T-SB-0127-18
- Component:
- 162300 structure:body:door
- Summary:
- Tsb: some 2014 ? 2018 model year highlander and highlander hv vehicles may exhibit a condition where the power back door (pbd) makes a squeak noise while the door is opening or closing. follow the repair procedure in this bulletin to addres
- Bulletin:
- Safety Recall an
- Component:
- 350000 equipment
- Summary:
- Update on technician certification requirements.
- Bulletin:
- T-SB-0313-17
- Component:
- 030000 brakes (pws)
- Summary:
- Tsb: some 2015 ? 2018 model year toyota vehicles may exhibit brake vibration due to improper lug nut torque. brake vibration can occur at any time if improper torque is applied to lug nuts. even one lug nut over or under torqued can cause v
- Bulletin:
- T-TT-0462-17
- Component:
- 091130 fuel system, other:storage:tank assembly:pressure relief devices
- Summary:
- T-tt: vehicles may experience various drivability concerns. upon diagnosis, technicians commonly find no or low fuel pressure as well as a variety of dtcs (commonly p1603, p1604, p1605, p0171, p0300, p0302, p0304, u0100). technicians find t
Home | Privacy