2014 VOLKSWAGEN TOUAREG Recalls (2)
- Campaign:
- 16V170000 on 03/23/2016
- Component:
- Service brakes, hydraulic:pedals and linkages
- Affected:
- 46,574
- Defect:
- Volkswagen group of america, inc. (volkswagen) is recalling certain model year 2011-2016 touareg vehicles. the brake pedal pivot pin may be missing a securing clip, allowing the pivot pin to move and the brake pedal to dislodge.
- Consequence:
- If the brake pedal dislodges, the driver may not be able to apply the brakes, increasing the risk of a crash.
- Correction:
- Volkswagen will notify owners, and dealers will inspect the brake pedal assembly to verify the presence of the securing clip and install any missing securing clips, free of charge. the recall began on april 27, 2016. owners may contact volkswagen customer service at 1-800-893-5298. volkswagen's number for this recall is 46g4.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
- Campaign:
- 18V329000 on 05/21/2018
- Component:
- Unknown or other
- Manufactured:
- 10/27/2010 - 02/11/2014
- Affected:
- 252
- Defect:
- Volkswagen group of america, inc. (volkswagen) is recalling certain 2012-2016 eos, 2012 passat, 2012-2016 cc, 2015 e-golf, 2011-2015 touareg, 2012-2015 tiguan, and 2011-2016 golf and 2011-2013 gti vehicles. modifications made while the vehicles were in an internal evaluation period may cause the affected vehicles to not comply with all of the applicable regulatory requirements.
- Consequence:
- If the vehicles do not meet all regulatory requirements, there could be an increased risk of a crash, fire, or injury.
- Correction:
- Volkswagen will notify owners, and dealers will repair the vehicles to make them fully compliant or volkswagen will repurchase them if necessary, free of charge. interim notices informing owners of the safety risk were mailed july 13, 2018. owners will receive a second notice when the remedy becomes available. owners may contact volkswagen customer service at 1-800-893-5298.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
2014 VOLKSWAGEN TOUAREG TSBs (292)
- Bulletin:
- TT-91-11-03
- Component:
- 284000 back over prevention: camera system
- Summary:
- Volkswagen: before rear view camera is properly operational, should be connected to buzzer or sensor faults and working in conjunction with rear parking aid system. models 2009-15 tiguan, cc, passat, touareg. *pe
- Bulletin:
- TT 26-14-01
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TT 26-14-01
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TT 44-13-01
- Component:
- 010000 steering
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TT 44-13-01
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 1012013
- Component:
- 350000 equipment
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 2014-3.0
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 2014-3.0
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 2014-3.6
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TT 57-12-10
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TT 72-12-01
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TT 90-13-02
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TT 90-13-02
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 2036503
- Component:
- 118000 electrical system: software
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 21560R1695T
- Component:
- 190000 tires
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 2038140
- Component:
- 010000 steering
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 2038140
- Component:
- 010000 steering
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- VERSION 1.1
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- RNS850
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 0.03937
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 2014 TOUAREG
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 2014 TOUAREG
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- SA 34G5
- Component:
- 103000 power train:automatic transmission
- Summary:
- Automatic transmission fluid (atf) pipe bracket over time and in rare cases, vehicle and road vibrations can cause a small automatic transmission fluid (atf) pipe leak to occur.
- Bulletin:
- V0116142045221
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Diagnostic aid for inconclusive results while diagnosing dtc p040b exhaust gas recirculation temperature sensor 'a' circuit range performance
- Bulletin:
- V011614_2045221
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Diagnostic aid for inconclusive results while diagnosing dtc p040b exhaust gas recirculation temperature sensor 'a' circuit range performance
- Bulletin:
- TT911615_2045938
- Component:
- 118000 electrical system: software
- Summary:
- Direction to clarify methodology for updating the navigation system using the sd card. additional references to tb and tech talk.
- Bulletin:
- TT171601_2044618
- Component:
- 060000 engine and engine cooling
- Summary:
- Diagnostic assistance should the yellow engine oil lamp remain illuminated with engine oil level at the proper level.
- Bulletin:
- DEALER LETTER -
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- Email to dealers explaining that the registration period for the tdi goodwill package for the 3.0l tdi has been extended.
- Bulletin:
- V011613_2033805
- Component:
- 060000 engine (pws)
- Summary:
- "engine, misfire diagnostic aid the mil is flashing or illuminated."
- Bulletin:
- TT 97-14-02
- Component:
- 110000 electrical system
- Summary:
- Tech tip denoting potential for damage of the data link connector when using after market plug in devices or scan tools and subsequent diagnostic direction.
- Bulletin:
- V661602_2027119
- Component:
- 162000 structure:body
- Summary:
- Update "conditions not covered by warranty" section, remove oxydation wording, insert anodized wording, and update model year and model applicability.
- Bulletin:
- VWS-15-01
- Component:
- 060000 engine (pws)
- Summary:
- This communication informs dealers of the warranty claim coding for 30-day inventory maintenances on 2.0l and 3.0l tdi vehicles.
- Bulletin:
- VIN-4-A-PIN APRI
- Component:
- 020000 suspension
- Summary:
- Mil-on, fault p309f or p309d, no electric drive mode customer states crank no start and/or in-tank fuel pump making noise and possibly with fuel pump faults mil-on, fault p013e in the ecm mil-on, fault p164b in ecm mil-on, fault
- Bulletin:
- VIN-4-A-PIN APRI
- Component:
- 010000 steering
- Summary:
- Mil-on, fault p309f or p309d, no electric drive mode customer states crank no start and/or in-tank fuel pump making noise and possibly with fuel pump faults mil-on, fault p013e in the ecm mil-on, fault p164b in ecm mil-on, fault
- Bulletin:
- V941601_2011521
- Component:
- 120000 lighting (pws)
- Summary:
- Update technical bulletin to include all 2017 models
- Bulletin:
- V011606_2014603
- Component:
- 110000 electrical system
- Summary:
- Update technical bulletin to include all models for 2015, 2016, 2017 model year applicability.
- Bulletin:
- V001706_2033708
- Component:
- 160000 structure
- Summary:
- Update tb to include model year 2016 & 2017 applicability
- Bulletin:
- V231702_2041118
- Component:
- 080000 fuel system, diesel
- Summary:
- Update fuel sampling requirement and update touareg parts table.
- Bulletin:
- V271701_2033978
- Component:
- 060000 engine (pws)
- Summary:
- Update existing technical bulletin to include model year 2017 applicability.
- Bulletin:
- On-Car Analysis
- Component:
- 100000 power train
- Summary:
- On-car analysis list of customer complaints: mil?on
- Bulletin:
- On-Car Analysis
- Component:
- 100000 power train
- Summary:
- On-car analysis list of customer complaints: mil?on
- Bulletin:
- TT 00-14-02
- Component:
- 070000 fuel system, gasoline
- Summary:
- Tech tips (adapting injector quantity adjustment correction values (ima/iva)): when replacing or adapting fuel injectors, if there is no guided functions test plan, utilize this documents procedure
- Bulletin:
- TT 44-13-01
- Component:
- 010000 steering
- Summary:
- Tech tips (vibration or steering wheel shimmy at highway speeds): the suspension characteristics of the touareg make it more susceptible to variations in the rim and/or tire. for this reason a diagnostic balancer is necessary to balance, f
- Bulletin:
- TT 44-13-04
- Component:
- 010000 steering
- Summary:
- Tech tips (steering wheel off center): this tech tip was established to explain the influence the adjustable steering column tilt position has on the steering wheel being off center and to provide information on checking for steering wheel
- Bulletin:
- TT 50-14-01
- Component:
- 190000 tires
- Summary:
- Tech tips (all vehicles-tire dressing for vehicle detailing): the use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle. this document informs that the use of non-water based products wil
- Bulletin:
- TT 90-13-02
- Component:
- 110000 electrical system
- Summary:
- Tech tips: this document informs on how to reset the inspection service, and interval service.
- Bulletin:
- V941403 2011521
- Component:
- 120000 exterior lighting
- Summary:
- Technical bulletin (exterior lights, moisture accumulation): this document informs of the condensation and or water droplets visible on inside of exterior light lenses. the document also informs how to service the issue.
- Bulletin:
- PDI - 2014 Touar
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- "volkswagen perfect delivery process ? sales consultant delivery checklist: this document informs the seller of a vehicle with a checklist to cover the experience of a customer who is interested in purchasing a vehicle"
- Bulletin:
- TT 23-14-01
- Component:
- 070000 fuel system, gasoline
- Summary:
- Tech tips (2009-2014 all tdi (2.0l, 3.0l) common rail models passat, golf, jetta, jetta sportwagen, touareg adapting injector quantity adjustment correction values (ima/iva)): this document informs when replacing or adapting fuel injectors
- Bulletin:
- TT 32-14-01
- Component:
- 103700 power train:automatic transmission:torque converter
- Summary:
- Tech tips (torque converter/flywheel/flexplate installation): incorrect torque converter or flywheel/flexplate installation can result in transmission damage. when installing an engine, flywheel or transmission, please follow the installat
- Bulletin:
- V001406 2015780
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Technical bulletin (pdi - vehicle inspection, protection removal and detailing): this document informs on the service a vehicle shouold received when it has successfully reached a dealership. ? inspecting vehicle for damage (to be compl
- Bulletin:
- V001407 2036935
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Technical bulletin (by-pack at delivery): components missing from the by-pack should be claimed in one of two ways. (warranty or transportation) understanding when to claim one versus the other is very important. this document informs of t
- Bulletin:
- V001408 2036935
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Technical bulletin (components may be missing from the by-pack at delivery): components missing from the by-pack should be claimed in one of two ways. (warranty or transportation) understanding when to claim one versus the other is very
- Bulletin:
- V461406 2015173
- Component:
- 020000 suspension
- Summary:
- Technical bulletin (brake disc pulsation or vibration): when applying brakes at highway speeds the following symptoms may occur: ? brake pedal pulsation ? vibration felt in vehicle body ? steering wheel shakes for brake vibration or pu
- Bulletin:
- V461405 2010245
- Component:
- 020000 suspension
- Summary:
- Technical bulletin (vibration or noise when braking): vibration or noise when braking may be due to brake disc corrosion protection which has not been completely removed by normal braking or surface rust built up during transportation. thi
- Bulletin:
- V301402 2031366
- Component:
- 101000 power train:clutch assembly
- Summary:
- Technical bulletin (slave cylinder - clutch pedal operation diagnosis): customer may comment: ? complaints on clutch system. ? after pressing the clutch pedal, it remains on the floor. due to mis-diagnosis of clutch systems, and to prev
- Bulletin:
- V171402 2037201
- Component:
- 060000 engine (pws)
- Summary:
- Technical bulletin (engine oil level): technicians may find during pdi that the oil level is below the full mark, but still within the hash marks on the engine oil dip stick. all volkswagen engines are filled to a specific volume before le
- Bulletin:
- On car analysis-
- Component:
- 110000 electrical system
- Summary:
- On-car analysis list of customer complaints: mil?on with fault code p046c, untouched vehicles
- Bulletin:
- TT 87-14-01
- Component:
- 353600 equipment:air conditioner
- Summary:
- Tech tips (ac compressor replacement, refrigerant circuit flushing requirement): this document informs when replacing the air conditioning compressor it is necessary to flush the entire system to remove all the pag oil. replacement ac comp
- Bulletin:
- TT 57-10-11
- Component:
- 110000 electrical system
- Summary:
- Tech tips (comfort module (j393) or bcm (j519) replacement): this document informs if a comfort or body control module is replaced during normal diagnosis, make sure the factory mode has been switched off. this can be accomplished by selec
- Bulletin:
- Quick Reference
- Component:
- 118000 electrical system: software
- Summary:
- Quick reference update guide: this document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle
- Bulletin:
- V871409 2019947
- Component:
- 353600 equipment:air conditioner
- Summary:
- Technical bulletin (air conditioning, cleaning of the refrigerant circuit): in cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or component is circ
- Bulletin:
- V481404 2038140
- Component:
- 010000 steering
- Summary:
- Technical bulletin (power steering rack vibrations in steering wheel): this document informs that after a short stationary period (sometimes as little as a few hours) flat spots can develop after the warm tire has cooled down. the effect t
- Bulletin:
- V171404 2012855
- Component:
- 060000 engine (pws)
- Summary:
- Technical bulletin (engine oils which meet volkswagen oil quality standard): this document informs of a sample list of products generally available in the north american market that meet the volkswagen oil quality standard
- Bulletin:
- On car analysis-
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- On-car analysis list of customer complaint: mil?on
- Bulletin:
- On-car Analysis
- Component:
- 356000 equipment adaptive
- Summary:
- On-car analysis list of customer complaints: mil?on
- Bulletin:
- On-car analysis
- Component:
- 356000 equipment adaptive
- Summary:
- On-car analysis list of customer complaint: mil?on
- Bulletin:
- Elsa Newsletter
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Reminder that odis service v3.0.0 is now available for installation, and that it is mandatory on all diagnostic devices used on vehicles covered by the new vehicle warranty. with the release of v3.0.0. installation dvds are no longer used.
- Bulletin:
- TT 90-13-02ss3
- Component:
- 118000 electrical system: software
- Summary:
- How to reset inspection service and interval service software
- Bulletin:
- V401601 2043146
- Component:
- 021300 suspension:front:shock absorber
- Summary:
- Technical bulletin about a customer concern stating that customer observed one or more of the shocks/struts appearing to have an oil leak. document contains examples of strut or shock absorber leak assessments
- Bulletin:
- V371601 2033975
- Component:
- 103000 power train:automatic transmission
- Summary:
- This document was created in response to multiple dealership inquires about aftermarket universal (one fluid fits all) automatic transmission fluids and transmission flushing, volkswagen group of america, volkswagen canada have prepared the
- Bulletin:
- V341601 2034406
- Component:
- 101000 power train:clutch assembly
- Summary:
- Discusses possible causes of customer concern customer states there is a noise from the clutch, transmission or driveline components under varying driving conditions with varying sound levels
- Bulletin:
- V271601 2033978
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Document discusses possible needs for generator replacement, charging system inoperative/malfunctions, noise from engine compartment, accessory drive belt damaged or missing. document also discusses where to find warranty information for co
- Bulletin:
- V231602 2041118
- Component:
- 080000 fuel system, diesel
- Summary:
- A how to guide for diesel fuel system diagnosis and repair
- Bulletin:
- V191601 2022549
- Component:
- 060000 engine and engine cooling
- Summary:
- Tech bullentin concerning electric coolant fans that continue to run after ignition is switched off
- Bulletin:
- V011602 2014815
- Component:
- 070000 fuel system, gasoline
- Summary:
- Technical tips on what to do if improper gasoline has been added to the vehicle.
- Bulletin:
- V001602 2033846
- Component:
- 073000 fuel system, gasoline:fuel injection system
- Summary:
- Fuel additive to help prevent sporadic misfire faults a volkswagen approved fuel additive is available to help remove and prevent deposits on fuel injectors and intake valves.
- Bulletin:
- V001601 2034407
- Component:
- 350000 equipment
- Summary:
- Document informs meaning of service numbers to discribe issuse with if the customer is experiencing clutch related issues and the concern is found to be within the clutch components if the customer is experiencing manual gearbox relat
- Bulletin:
- TT 26-16-01
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Tech tips for tdi-recommended adblue concentration
- Bulletin:
- VWC-16-01
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Adjustment of time unit correction payments for 2014/2015 model year maintenance claims
- Bulletin:
- TT 97-14-02ss1
- Component:
- 110000 electrical system
- Summary:
- Tech tips damage to data link connector (dlc) from aftermarket devices (cannot communicate with vehicle obd system)
- Bulletin:
- V461603 2015173
- Component:
- 011000 steering:wheel and handle bar
- Summary:
- Technical bulletin informing that when applying brakes at highway speeds the following symptoms may occur: - brake pedal pulsation - vibration felt in vehicle body - steering wheel shakes it informs how to inspect brakes. it informs of
- Bulletin:
- V501604 2014370
- Component:
- 162000 structure:body
- Summary:
- Technical bulletin about paint finish, reducing swirl marks and fine scratches new vehicles (prior to retail delivery) with swirl marks and or fine scratches from polishing or cleaning. the document also have infromation about where to fi
- Bulletin:
- V921501 2037322
- Component:
- 350000 equipment
- Summary:
- Technical bulletin: this document concerns the sensitivity of the washer solvent level sensor (g33) can be affected by the type, concentration, and the presence of additives in the washer solvent currently in the tank. the operation of the
- Bulletin:
- TT 26-15-02
- Component:
- 073200 fuel system, gasoline:fuel injection system:injectors
- Summary:
- Tech tips: 3.0 tdi touareg adblue injector quantity volume test
- Bulletin:
- TT 57-10-15
- Component:
- 110000 electrical system
- Summary:
- Tech tips: vehicles with immobilizer with download/discharge? new key will not program
- Bulletin:
- V271501 2011894
- Component:
- 111000 electrical system:battery
- Summary:
- Technical bulletin: battery, testing and charging using midtronics vas6161, mcr340v, incharge 940, or grx3000vas charger
- Bulletin:
- V171501 2037201
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Technical bulletin: the document discusses proper engine oil level diagnosis and servicing issues
- Bulletin:
- TT 27-15-01
- Component:
- 113000 electrical system:starter assembly
- Summary:
- Tech tips: no crank, no start after cold soak issues
- Bulletin:
- V481501 2038140
- Component:
- 010000 steering
- Summary:
- Technical bulletin: vibrations in steering wheel issues document discusses diagnosis of problem, and potential remedy of issue. the diagnosis codes for checking warranty coverage for servicing the vehicle are also available. the document a
- Bulletin:
- V011503 2014815
- Component:
- 070000 fuel system, gasoline
- Summary:
- Discusses the issues associated with using contaiminated gasoline. there are recommendations to use top tier gasoline retailers
- Bulletin:
- V941501 2011521
- Component:
- 120000 exterior lighting
- Summary:
- Technical bulletin: condensation and or water droplets becomming visible on inside of exterior light lenses issue is discussed in this document
- Bulletin:
- V911502 2036310
- Component:
- 118000 electrical system: software
- Summary:
- Technical bulletin: umi software update for bluetooth concerns ? voice prompts stuck in non-english language ? poor call clarity on receiving end ? various bluetooth® connectivity & paring issues this procedure in the document corrects
- Bulletin:
- V661502 2027119
- Component:
- 356000 equipment adaptive
- Summary:
- Technical bulletin: diagnosing with damage on external chrome or aluminum surfaces
- Bulletin:
- V461502 2010245
- Component:
- 030000 brakes (pws)
- Summary:
- Technical bulletin: vibration or noise when braking issues are addressed
- Bulletin:
- V271503 2016076
- Component:
- 111000 electrical system:battery
- Summary:
- Technical bulletin: battery, discharged, diagnosis for excessive static current draw
- Bulletin:
- V001501 2036935
- Component:
- 356000 equipment adaptive
- Summary:
- Technical bulletin: a notification that components may be missing from the by-pack at delivery. it also informs that components missing from the by-pack should be claimed in one of two ways. (warranty or transportation)
- Bulletin:
- TT 91-11-03
- Component:
- 284000 back over prevention: camera system
- Summary:
- Tech tips (rear view camera inoperative issues): the rear view camera operates in conjunction with the rear parking aid system. if there are no faults in the radio or rear view camera, be sure to check the parking aid system for faults. buz
- Bulletin:
- TT 27-15-02
- Component:
- 356000 equipment adaptive
- Summary:
- Tech tips (test plan to calibrate adaptive cruise control sensors will not begin notice): notification that if the test plan to calibrate the adaptive cruise control sensors will not begin, turn off the overhead lights in the shop. the wave
- Bulletin:
- TT 27-15-01
- Component:
- 063110 engine and engine cooling:exhaust system:emission control:crankcase (pcv)
- Summary:
- Tech tips: no crank, no start after cold soak
- Bulletin:
- TT 44-13-04
- Component:
- 010000 steering
- Summary:
- Tech tips (steering wheel off center): this tech tip was established to explain the influence the adjustable steering column tilt position has on the steering wheel being off center and to provide information on checking for steering wheel
- Bulletin:
- TT 20-13-01
- Component:
- 091200 fuel system, other:storage:fuel gauge system
- Summary:
- Tech tips (ecm fault p1250 "fuel level too low" will not clear): this document informs to clear static ecm fault p1250 "fuel level too low", add fuel to vehicle and complete a road test of at least 10 miles. simply adding fuel without co
- Bulletin:
- On-car analysis
- Component:
- 356000 equipment adaptive
- Summary:
- On-car analysis list of customer complaints: mil-on with fault code p046c, untouched vehicles
- Bulletin:
- On-car analysis
- Component:
- 356000 equipment adaptive
- Summary:
- On-car analysis list of customer complaints: mil-on with fault code p046c, untouched vehicles
- Bulletin:
- V191401 2022549
- Component:
- 060000 engine and engine cooling
- Summary:
- Technical bulletin (electric coolant fans continue to run after ignition is switched off): this documentation informs it is considered normal operation for the electric coolant fans to continue to run for up to 15 minutes after the ignit
- Bulletin:
- V001411 2033708
- Component:
- 160000 structure
- Summary:
- Technical bulletin (removing paint contaminants from exterior paint): this document informs how to remove paint contaminants such as rail dust and industrial fallout from exterior paint.
- Bulletin:
- V001410 2036935
- Component:
- 350000 equipment
- Summary:
- Technical bulletin (by-pack at delivery): components may be missing from the by-pack at delivery. components missing from the by-pack should be claimed in one of two ways. (warranty or transportation) understanding when to claim one versus
- Bulletin:
- Customer Program
- Component:
- 350000 equipment
- Summary:
- This document includes what incentives are included in the volkswagen tdi customer goodwill package.
- Bulletin:
- Revised_Oil_Capa
- Component:
- 060000 engine (pws)
- Summary:
- Job aid ? vw engine oil capacities (gasoline, diesel, hybrid engines)
- Bulletin:
- V481601 2038140
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Updated to include model year 2017 applicability.
- Bulletin:
- Campaign Circula
- Component:
- 103000 power train:automatic transmission
- Summary:
- Automatic transmission fluid (atf) pipe bracket: over time and in rare cases, vehicle and road vibrations can cause a small automatic transmission fluid (atf) pipe leak to occur. the corrective action taken for this issue was to install a
- Bulletin:
- Dealer Letter-Da
- Component:
- 103000 power train:automatic transmission
- Summary:
- Volkswagen dealership communication (automatic transmission fluid (atf) pipe bracket): over time and in rare cases, vehicle and road vibrations can cause a small automatic transmission fluid (atf) pipe leak to occur. the corrective action
- Bulletin:
- V011528 2033805
- Component:
- 110000 electrical system
- Summary:
- Technical bulletin (engine, misfire diagnostic aid): this document informs that multiple components should not be replaced for 1 misfiring cylinder. repeat repairs must be carefully addressed to identify the root cause of the concern. if m
- Bulletin:
- V921503 2037322
- Component:
- 060000 engine (pws)
- Summary:
- Technical bulletin (washer level sensor issues): the sensitivity of the washer solvent level sensor (g33) can be affected by the type, concentration, and the presence of additives in the washer solvent currently in the tank. the operation
- Bulletin:
- TT 64-14-02
- Component:
- 138200 visibility:defroster/defogger system:rear window
- Summary:
- Tech tips (heated rear window, one or more lines inoperative): to detect which line(s) is inoperative, utilize a volt meter to check for 0 v, which will be present after the open in the grid line. this document informs of how to diagnose t
- Bulletin:
- V001401 2033846
- Component:
- 061320 engine and engine cooling:engine:other fuel types:turbo-charger
- Summary:
- Technical bulletin (fuel additive to help prevent sporadic misfire faults): fuel quality impacts the operating performance, efficiency and service life of the engine. the use of poor quality fuels may result in deposit build up on the fuel
- Bulletin:
- V461401 2010245
- Component:
- 034500 service brakes, hydraulic:foundation components:disc
- Summary:
- Technical bulletin (vibration or noise when braking): vibration or noise when braking may be due to brake disc corrosion protection which has not been completely removed by normal braking, or surface rust built up during transportation. th
- Bulletin:
- V481406 2038140
- Component:
- 011000 steering:wheel and handle bar
- Summary:
- Technical bulletin (vibrations in steering wheel): after a short stationary period (sometimes as little as a few hours) flat spots can develop after the warm tire has cooled down. the effect the flat spotted tire has on the vehicles perfor
- Bulletin:
- V481406 2038140
- Component:
- 010000 steering
- Summary:
- Technical bulletin (vibrations in steering wheel): after a short stationary period (sometimes as little as a few hours) flat spots can develop after the warm tire has cooled down. the effect the flat spotted tire has on the vehicles perfor
- Bulletin:
- V001413 2033846
- Component:
- 060000 engine (pws)
- Summary:
- Technical bulletin (fuel additive to help prevent sporadic misfire faults): fuel quality impacts the operating performance, efficiency and service life of the engine. the use of poor quality fuels may result in deposit build up on the fuel
- Bulletin:
- TT 00-14-03
- Component:
- 118000 electrical system: software
- Summary:
- Tech tips (svm update instructions): this document informs when performing svm updates, the scan tool should be hardwired to the vehicle and the bluetooth physically turned off. a hard wired internet connection is also recommended.
- Bulletin:
- On-Car Analysis
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- On-car analysis list of customer complaints: mil?on with fault code p046c, untouched vehicles
- Bulletin:
- On-Car Analysis
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- On-car analysis list of customer complaints: mil?on with fault code p046c, untouched vehicles
- Bulletin:
- VWP-17-02
- Component:
- 350000 equipment
- Summary:
- This document informs dealers of a "class bridge warranty" for certain 3.0l tdi gen. 2 vehicles.
- Bulletin:
- V201502 2031426
- Component:
- 060000 engine (pws)
- Summary:
- Technical bulletin (high pressure fuel pump diagnosis): completing the gff high pressure pump function test is essential to diagnose proper pump operation and to avoid unnecessary replacements
- Bulletin:
- TT 44-13-04
- Component:
- 010000 steering
- Summary:
- Tech tips: this tech tip was established to explain the influence the adjustable steering column tilt position has on the steering wheel being off center and to provide information on checking for steering wheel off center
- Bulletin:
- TT 44-13-03
- Component:
- 020000 suspension
- Summary:
- Tech tips: this tech tip provides an overview of vehicle four wheel alignment, and important steps that should be followed when performing four wheel alignments
- Bulletin:
- V601501 2019568
- Component:
- 134000 visibility:sun roof assembly
- Summary:
- Technical bulletin (sunroof or power sunshade, does not open/close or automatic operation does not function). this document contains warranty information for coverage, and informs of methods to to service the issue
- Bulletin:
- V401501 2040561
- Component:
- 010000 steering
- Summary:
- Technical bulletin (squeaking noises from front of vehicle): squeaking/creaking noise from front of vehicle while fully turning steering wheel. the document also gives information on servicing the issue
- Bulletin:
- V001502 2015780
- Component:
- 160000 structure
- Summary:
- Technical bulletin (pdi - vehicle inspection, protection removal and detailing): this document refers to a pre check inspection on the quality of a vehicle such as - inspecting vehicle for damage (to be completed within 48 hours of delive
- Bulletin:
- TT 64-14-02
- Component:
- 110000 electrical system
- Summary:
- Tech tips (heated rear window, one or more lines inoperative): to detect which line(s) is inoperative, utilize a volt meter to check for 0 v, which will be present after the open in the grid line. the check must be performed with the engin
- Bulletin:
- TT 57-12-10
- Component:
- 110000 electrical system
- Summary:
- Tech tips: when adapting keys on a touareg, it is necessary to complete the ?adapt immobilizer? test
- Bulletin:
- TT 21-10-02
- Component:
- 061120 engine and engine cooling:engine:gasoline:turbo-charger
- Summary:
- Tech tips: the document discusses the conditions of when turbo can to be fixed or replaced
- Bulletin:
- TT 27-15-01
- Component:
- 060000 engine (pws)
- Summary:
- Tech tips (no crank, no start after cold soak issues): concern may be the result of a leaking vacuum check valve not holding residual pressure overnight. this results in a hard brake pedal that may require more pressure than usual to allow
- Bulletin:
- V001503 2040590
- Component:
- 160000 structure
- Summary:
- Technical bulletin (paint defect - water migration under the rapgard): water migration under the rapgard® can be mistaken as a paint defect when in fact it is only moisture trapped in the clear coat of the paint. this document discusses.
- Bulletin:
- V921502 2026253
- Component:
- 130000 visibility
- Summary:
- Technical bulletin (windshield wipers streak or smear): windshield or rear window is streaked, has a snakeskin appearance, or the surface feels rough. to avoid unnecessary replacement of wiper blades, the condition and cleanliness of the w
- Bulletin:
- V871508 2005566
- Component:
- 060000 engine and engine cooling
- Summary:
- Technical bulletin (hvac, unpleasant odor): unpleasant odor is coming from heating and ventilation system. odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first start
- Bulletin:
- V871506 2019947
- Component:
- 060000 engine and engine cooling
- Summary:
- Technical bulletin (air conditioning, cleaning of the refrigerant circuit (u.s.only)): in cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or compon
- Bulletin:
- V261505 2041110
- Component:
- 110000 electrical system
- Summary:
- Technical bulletin (selective catalyst reduction (scr) heater electronics being ) contaminated with ad blue): this document informs what repairs are needed to fix the issue. this document contains the fault codes necessary to check the warr
- Bulletin:
- V201503 2031426
- Component:
- 060000 engine (pws)
- Summary:
- Technical bulletin: high pressure fuel pump diagnosis. completing the gff high pressure pump function test is essential to diagnose proper pump operation and to avoid unnecessary replacements. this document contains the procedure to update
- Bulletin:
- TT 90-11-10
- Component:
- 117000 digital instrument panel
- Summary:
- Tech tips (instrument cluster production mode): this document informs the procedure to remove the production mode setting when it is displayed in the instrument cluster.
- Bulletin:
- TT 66-11-01
- Component:
- 110000 electrical system
- Summary:
- Tech tips: touareg with trailer hitch ? j345 trailer recognition control module and/or trailer brake controller installation
- Bulletin:
- V931503 2035217
- Component:
- 111000 electrical system:battery
- Summary:
- Technical bulletin (high-voltage repairs on hybrid and electric vehicles): this document informs if a repair involving high-voltage components or battery needs to be performed on a hybrid or electric vehicle, a vta ticket must be opened wi
- Bulletin:
- V461505 2015173
- Component:
- 010000 steering
- Summary:
- Technical bulletin (brake disc pulsation or vibration issues): when applying brakes at highway speeds the following symptoms may occur: - brake pedal pulsation - vibration felt in vehicle body - steering wheel shakes for brake vibratio
- Bulletin:
- V461504 2010245
- Component:
- 030000 brakes (pws)
- Summary:
- Technical bulletin (vibration or noise when braking): vibration or noise when braking may be due to brake disc corrosion protection which has not been completely removed by normal braking or surface rust built up during transportation. th
- Bulletin:
- V401502 2033347
- Component:
- 356000 equipment adaptive
- Summary:
- Technical bulletin (cv boot replacement): the recommended procedure for removing damaged cv boot.
- Bulletin:
- V001504 2038059
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Technical bulletin: listed in the table in this document are the time units used in the calculation of the prepaid pdi (ppdi) payment through model year 2016.
- Bulletin:
- TT911101
- Component:
- 110000 electrical system
- Summary:
- Update to existing tech tip 91-11-01 for later model years, to direct technicians to the bluetooth compatibility chart.
- Bulletin:
- V931603_2035217
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- To include model year 2017 applicability.
- Bulletin:
- V941402 2011521
- Component:
- 121000 exterior lighting:headlights
- Summary:
- Technical bulletin (exterior lights, moisture accumulation): exterior light assemblies (headlights, taillights, fog lights, turn signals) are vented and may collect moisture on their inner surfaces, depending on humidity and other climatic
- Bulletin:
- V911404 2035473
- Component:
- 118000 electrical system: software
- Summary:
- Technical bulletin (filling out the infotainment worksheet) this bulletin provides instructions and information for completing and submitting the updated web version of the infotainment worksheet. like the previous version, the infotainmen
- Bulletin:
- V871401 2005566
- Component:
- 353600 equipment:air conditioner
- Summary:
- Technical bulletin (hvac, unpleasant odor): unpleasant odor is coming from heating and ventilation system. odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first start
- Bulletin:
- V601401 2019568
- Component:
- 110000 electrical system
- Summary:
- Technical bulletin (sunroof / sunshade, will not open): the panoramic sunroof, regular sunroof or sunshade cannot be opened. this document discusses the "fault codes" necessary to diagnosis, and potential remedy of the issue. the fault c
- Bulletin:
- V401401 2033347
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Technical bulletin (cv boot replacement): recommended procedure for removing damaged cv boot. this document informs of the expected condition of a cv boot upon removal
- Bulletin:
- V231403 2036656
- Component:
- 061320 engine and engine cooling:engine:other fuel types:turbo-charger
- Summary:
- Technical bulletin (no start, or rough running due to fuel rail issues): when diagnosing the condition above on a common rail diesel vehicle, if no root cause is found after checking all other components and all gff diagnostic procedures
- Bulletin:
- V231402 2036656
- Component:
- 061320 engine and engine cooling:engine:other fuel types:turbo-charger
- Summary:
- Technical bulletin (no start, or rough running issues): when diagnosing a mil on, no-start or rough running concern on a common rail diesel vehicle, and no root cause is found after following all gff diagnostic procedures, it may be necess
- Bulletin:
- V151402 2032150
- Component:
- 060000 engine (pws)
- Summary:
- Technical bulletin (proper removal of engine cover to avoid breakage): pulling on the engine cover in some areas can cause damage. this document informs on the procedure to remove the engine cover.
- Bulletin:
- V011408 2014815
- Component:
- 060000 engine (pws)
- Summary:
- Technical bulletin the use of contaminated gasoline, seasonal fuel changes (summer/winter fuel) or gasoline with a low content of deposit control additives may result in one or more of the following conditions: -excessive accumulation of
- Bulletin:
- V011407 2014603
- Component:
- 118000 electrical system: software
- Summary:
- Technical bulletin this technical bulletin details the general process for carrying out a software version management (svm) software update for any technical bulletin (tsb) / required vehicle update (rvu).
- Bulletin:
- TT 44-13-01
- Component:
- 020000 suspension
- Summary:
- Tech tips (vibration or steering wheel shimmy at highway speeds): the suspension characteristics of the touareg make it more susceptible to variations in the rim and/or tire. for this reason a diagnostic balancer is necessary to balance, f
- Bulletin:
- V871402 2005566
- Component:
- 353600 equipment:air conditioner
- Summary:
- Technical bulletin (hvac, unpleasant odor): condensation, which is a normal condition in all a/c systems, can cause a musty odor. if the odor is noticeable in the vehicle when the engine is not turned on, the cause may be mold and mildew i
- Bulletin:
- V461403 2015173
- Component:
- 045000 service brakes, air:disc
- Summary:
- Technical bulletin (brake disc pulsation or vibration): when applying brakes at highway speeds the following symptoms may occur: ? brake pedal pulsation ? vibration felt in vehicle body ? steering wheel shakes a detailed brake disc ins
- Bulletin:
- V011410 2036503
- Component:
- 118000 electrical system: software
- Summary:
- Technical bulletin (cooling system performance issues): this document informs that diagnostic strategy was demened too sensitive to solve the issue. the production solution to solve the issue was improved software
- Bulletin:
- V001404 2010380
- Component:
- 350000 equipment
- Summary:
- Technical bulletin (squeaks, rattles, noise, repair materials): this doucment contains a list of components and applications developed to repair concerns of squeaks, rattles, noise and trim fit conditions.
- Bulletin:
- TT 26-14-01
- Component:
- 081100 fuel system, diesel:storage:tank assembly
- Summary:
- Tech tips (touareg - 3.0l tdi ad blue reset procedure): this document informs how to reset the ad blue level light after the tank has been filled, and if that is not successful
- Bulletin:
- Reference - Refl
- Component:
- 118000 electrical system: software
- Summary:
- Quick reference update guide: this document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle
- Bulletin:
- TT 91-14-02
- Component:
- 118000 electrical system: software
- Summary:
- Tech tips (mdi functions with iphone 5 variants (5, 5c, 5s and ipad fourth generation, ipod nano seventh generation)): the apple iphone 5, iphone 5c, and iphone 5s, as well as the ipad 4th generation and ipod nano 7th generation use a prop
- Bulletin:
- TT 91-11-09
- Component:
- 353500 equipment:electrical:navigational system(global positioning system)
- Summary:
- Tech tips (all navigation radios-all models): when the navigation rns 850/510/315 is in 3d mode, the top portion of the screen may not display streets. this line represents the horizon and is a normal operation of system. this document pro
- Bulletin:
- TT 90-13-02
- Component:
- 118000 electrical system: software
- Summary:
- Tech tips (resetting inspection service and interval service): this document references a difference between the procedure for resetting the "reset inspection service" which is different from "reset interval service". it provides a graphic
- Bulletin:
- On-Car Analysis
- Component:
- 110000 electrical system
- Summary:
- On-car analysis list of customer complaint: mil?on
- Bulletin:
- V921402 2037322
- Component:
- 350000 equipment
- Summary:
- Technical bulletin (washer level sensor): the issue is caused by the outside influence of non-approved formulated washer fluids. non-approved washer fluids leave a clear film coating on the sensor probes, insulating the probes so they cann
- Bulletin:
- TT 97-14-01
- Component:
- 137000 visibility:rear window wiper/washer
- Summary:
- Washer level sensor issues: the indicator lamp in the i.p. for washer fluid remains illuminated and the washer reservoir is full. this documet explains thelocation of the procedure to validate that the washer reservoir is full with the pro
- Bulletin:
- TT 92-14-02
- Component:
- 137000 visibility:rear window wiper/washer
- Summary:
- Tech tips (washer level sensor issues): this document discusses approved windshield washer fluids and the damages non - approved fluids can cause. the document also informs on the procedure to validate the washer reservoir is full with the
- Bulletin:
- TT 26-14-01
- Component:
- 350000 equipment
- Summary:
- Tech tips: 3.0l tdi ad blue reset procedure: to reset the ad blue level light after the tank has been filled; this document informs of the procedure necessary to perform the service
- Bulletin:
- TT 57-12-10
- Component:
- 110000 electrical system
- Summary:
- Tech tips (touareg key adaptation): when adapting keys on a 2011-2014 touareg, it is necessary to complete the ?adapt immobilizer? test plan under 05 access start module. this document informs on the procedure to the ?adapt immobilizer? te
- Bulletin:
- TT 24-13-03
- Component:
- 110000 electrical system
- Summary:
- Tech tips (engine control module fault p130a ?hide cylinder?): this document informs that dtc p130a ?hide cylinder? indicates that excessive misfiring has occurred. as a result, the ecm has turned off a fuel injector to prevent catalyst da
- Bulletin:
- PDI - 2014 TOUAR
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Touareg perfect delivery inspection (pdi) - technician and detailer inspections: a checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has p
- Bulletin:
- V171403 2017813
- Component:
- 060000 engine (pws)
- Summary:
- Technical bulletin (oil consumption measurement): customer states oil consumption is higher than the volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. in order to provide effective lubricati
- Bulletin:
- V001409 2028059
- Component:
- 118000 electrical system: software
- Summary:
- Technical bulletin (prepaid pdi time units): listed in the table within this document are the time units used in the calculation of the prepaid pdi (ppdi) payment through model year 2015
- Bulletin:
- TT 57-10-11
- Component:
- 110000 electrical system
- Summary:
- Tech tips (comfort module (j393) or bcm (j519) replacement): this document informs if a comfort or body control module is replaced during normal diagnosis, make sure the factory mode has been switched off. this can be accomplished by selec
- Bulletin:
- TT 011505
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Tip to perform gff feedback for test plan issues.
- Bulletin:
- TT 011504
- Component:
- 118000 electrical system: software
- Summary:
- Seach tips to assist in finding dtc information
- Bulletin:
- V231707 2041118
- Component:
- 350000 equipment
- Summary:
- Update touareg part table.
- Bulletin:
- V201702 2034072
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Updated to include an additional diagnostic trouble code (p04f0)
- Bulletin:
- TT 200901
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Update to existing tip for fuel quality checking.
- Bulletin:
- TT 011503
- Component:
- 070000 fuel system, gasoline
- Summary:
- Update to expand fuel testing for lean dtcs.
- Bulletin:
- VWP-16-08
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- This bulletin informs dealers of a warranty extension on the exhaust gas temperature sensor (located in the egr cooler).
- Bulletin:
- VWP-16-07
- Component:
- 353600 equipment:air conditioner
- Summary:
- This bulletin informs dealers of a warranty extension on the adblue heater.
- Bulletin:
- VSS-13-17
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Service information (2014 car-net equipped models - market introduction) during the market introduction of 2014 models equipped with car-net volkswagen will collect all warranty repair information for any emerging concerns
- Bulletin:
- VSS-13-16
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Service information (temporary warranty process and parts return program): during the market introduction of 2014 models equipped with umi, volkswagen will collect all warranty repair information related to any components/failures specific
- Bulletin:
- V661301 2027119
- Component:
- 160000 structure
- Summary:
- Technical bulletin (damage on external chrome or aluminum surfaces) the surfaces of chrome parts can get damaged in the production process or by external influences. this document discusses options for repairs covered under warranty, and
- Bulletin:
- V341301 2034406
- Component:
- 100000 power train
- Summary:
- Technical bulletin (manual transmission noise diagnosing): customer states there is a noise from the clutch, transmission or driveline components under varying driving conditions with varying sound levels. this document informs the deal
- Bulletin:
- V201306 2034072
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Technical bulletin activated charcoal filter system, solenoid valve 1 -n80- (canister purge valve) diagnosis): completing the gff function test and performing a vacuum check on the canister purge valve -n80- are essential to diagnose prop
- Bulletin:
- V171302 2017813
- Component:
- 060000 engine and engine cooling
- Summary:
- Technical bulletin (oil consumption measurement): customer states oil consumption is higher than the volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. in order to provide effective lubrica
- Bulletin:
- PDI - TOUAREG TE
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Touareg perfect delivery inspection (pdi) - technician and detailer inspections: a checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has pur
- Bulletin:
- VWP-13-12
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Warranty information (2014 model year volkswagen vehicle warranty, roadside assistance, and carefree maintenance): this document contains the "2014 model year volkswagen vehicle coverage summary".
- Bulletin:
- VSS-13-15
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- 2014 car-net equipped models - market introduction: during the market introduction of 2014 models equipped with car-net, volkswagen will collect all warranty repair information related to any components / failures specific to car-net ensur
- Bulletin:
- VSS-13-14
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Service information (2014 umi equipped models - market introduction): during the market introduction of 2014 models equipped with umi, volkswagen will collect all warranty repair information related to any components / failures specific to
- Bulletin:
- V921302 2024878
- Component:
- 136000 visibility:windshield wiper/washer
- Summary:
- Technical bulletin (wiper blade inspection for proper warranty coding): wiper blade inspection guidelines for wear and tear, outside influence or a factory issue. this document informs what is under coverage for wiper blade issues.
- Bulletin:
- V371301 2033975
- Component:
- 100000 power train
- Summary:
- Technical bulletin (automatic transmission fluid requirements): at this time, volkswagen group of america, volkswagen canada do not support or warranty any use of aftermarket universal automatic transmission fluids or the machines used to
- Bulletin:
- V271301 2033978
- Component:
- 060000 engine and engine cooling
- Summary:
- Technical bulletin (generator replacement): this document informs of charging system inoperative/malfunctions, noise from engine compartment, accessory drive belt damaged or missing. from this condition one or more of the following sympto
- Bulletin:
- TT 21-13-01
- Component:
- 061120 engine and engine cooling:engine:gasoline:turbo-charger
- Summary:
- Tech tips (equipped with turbocharged engine turbocharger replacement tip): if mechanical damage is found to the turbocharger (e.g. damaged compression wheel, loose or broken shaft), it is not enough to just replace the turbocharger. thi
- Bulletin:
- Tire Chain Info
- Component:
- 190000 tires
- Summary:
- 2014 tire chain information (tire chain information (for california dealers only)): as equipped, this vehicle may not be operated with tire chains, but may accommodate some other type of tire traction device. this document informs what cha
- Bulletin:
- PDI - TOUAREG TE
- Component:
- 350000 equipment
- Summary:
- "touareg perfect delivery inspection (pdi) - technician and detailer inspections: a checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has pu
- Bulletin:
- Maintenance Card
- Component:
- 350000 equipment
- Summary:
- 2014 volkswagen touareg maintenance schedule for usa 3.6l fsi gasoline engine: this document contains the maintenance service schedule for a vehicle from 10,000 miles to 120,000 miles.
- Bulletin:
- Maintenance Card
- Component:
- 350000 equipment
- Summary:
- 2014 volkswagen touareg maintenance schedule for usa 3.0l tdi engine: this document contains the maintenance service schedule for a vehicle from 10,000 miles to 120,000 miles.
- Bulletin:
- Maintenance Card
- Component:
- 060000 engine (pws)
- Summary:
- 2014 volkswagen touareg maintenance schedule for usa 3.0l hybrid engine: this document contains the maintenance service schedule for a vehicle from 10,000 miles to 120,000 miles.
- Bulletin:
- VIN-4-A-PIN02-08
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- On-car analysis list of customer compliants customer complaint: mil-on no electric drive mode, untouched vehicles
- Bulletin:
- VIN-4-A-PIN0212
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- On-car analysis list of customer compliants customer complaint: mil-on no electric drive mode, untouched vehicles
- Bulletin:
- VIN-4-A-PIN0224
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- On-car analysis list of customer compliants customer complaint: mil-on no electric drive mode, untouched vehicles
- Bulletin:
- VIN-4-A-PIN0113
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- On-car analysis list of customer compliants customer complaint: mil-on no electric drive mode, untouched vehicles
- Bulletin:
- V871620 2005566
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Update model and model year applicability.
- Bulletin:
- V691601 2010479
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Update model year applicability to include 2017.
- Bulletin:
- V341602 2034406
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Additional symptom gathering information and guidence to isolate customer concern before beginning repair.
- Bulletin:
- V871622 2019947
- Component:
- 353600 equipment:air conditioner
- Summary:
- Update to model year applicability.
- Bulletin:
- V871621 2043893
- Component:
- 353600 equipment:air conditioner
- Summary:
- Updated to include additional model year applicability.
- Bulletin:
- V661603 2027119
- Component:
- 350000 equipment
- Summary:
- Update model year applicability.
- Bulletin:
- V401602 2040561
- Component:
- 010000 steering
- Summary:
- Updated to include model year 2017 applicability
- Bulletin:
- V371602 2033975
- Component:
- 103000 power train:automatic transmission
- Summary:
- Updated to include an additional model year applicability.
- Bulletin:
- V261604 2041110
- Component:
- 115000 electrical system:fuses and circuit breakers
- Summary:
- Update model year 2015 and 2016 touareg and include vin ranges.
- Bulletin:
- V191602 2022549
- Component:
- 110000 electrical system
- Summary:
- Update model year applicability.
- Bulletin:
- V011615 2014815
- Component:
- 060000 engine (pws)
- Summary:
- Update to include additional model year applicability.
- Bulletin:
- V001605 2033846
- Component:
- 060000 engine (pws)
- Summary:
- Updated to include additional model year applicability.
- Bulletin:
- VIN-4-A-PIN0106
- Component:
- 110000 electrical system
- Summary:
- On-car analysis list of customer compliants customer complaint: mil?on no electric drive mode, untouched vehicles
- Bulletin:
- V001607 2034407
- Component:
- 103000 power train:automatic transmission
- Summary:
- Update to include model year 2017 applicability.
- Bulletin:
- TT 00-16-02
- Component:
- 350000 equipment
- Summary:
- Reminder for dealers to reference the repair manual and replace all necessary fasteners (bolts, nuts) that cannot be re-used
- Bulletin:
- VIN-4-A-PIN 2-3
- Component:
- 110000 electrical system
- Summary:
- On-car analysis list of customer compliants customer complaint: mil?on no electric drive mode, untouched vehicles
- Bulletin:
- STP4-STP6 UPDATE
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Informing of a update of codes for the inventory vehicle open campaign/action report
- Bulletin:
- Update 02122016
- Component:
- 118000 electrical system: software
- Summary:
- Quick reference of vehicle concerns. includes a list of software versions and the technical bulletin numbers that referred to the concerns updated
- Bulletin:
- TT 97-12-02
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- data link connector pin assignment chart that is applicable to all models. update model year applicability.
- Bulletin:
- V931603 2035217
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- To include model year 2017 applicability.
- Bulletin:
- TT171501-2040170
- Component:
- 060000 engine (pws)
- Summary:
- To add model year 2016 and 2017 applicability and reminder about programming activation of oil pressure regulation/retraction on all models with 1.8l cpka and cpra engines after engine assembly, cylinder head or turbocharger replacement.
- Bulletin:
- 1-2017 Update
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This communication is to update our profi dealers of the current status of the latest inbound and outbound profi requests.
- Bulletin:
- Offboard Diagnos
- Component:
- 340000 communication
- Summary:
- Dealer communication - offboard diagnostic information system service (odis) for gen 2 flash
- Bulletin:
- Ref. - Reflash U
- Component:
- 118000 electrical system: software
- Summary:
- Quick reference update guide of the vehicles expected upgraded software level. the latest corresponding technical bulletins that address the issues, and concerns that have been had with the vehicles.
- Bulletin:
- Elsa 6-22-15
- Component:
- 350000 equipment
- Summary:
- This document contains the vw elsa newsletter that contains a general overview of wiring diagrams updates, elsapro infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, tech
- Bulletin:
- Elsa 6-29-15
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This document contains the vw elsa newsletter that contains a general overview of wiring diagrams updates, technical bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions.
- Bulletin:
- VIN-4-A-PIN 7-31
- Component:
- 060000 engine (pws)
- Summary:
- On-car analysis list of customer complaints: customer states the oil light is on
- Bulletin:
- VST-16-01
- Component:
- 131000 visibility:windshield
- Summary:
- Explaination of cross car distorion when looking through the windshield and how the "effect" in normal.
- Bulletin:
- Customer FAQ - T
- Component:
- 350000 equipment
- Summary:
- This document gives answers to frequently ask questions concerning the current owners and lessees of tdi vehicles affected by the emissions issue eligiblality options and issues.
- Bulletin:
- V261605 2041110
- Component:
- 110000 electrical system
- Summary:
- Include additional diagnostic trouble code (dtc) applicability.
- Bulletin:
- Fluid Capacity C
- Component:
- 350000 equipment
- Summary:
- Update adblue quantity specification.
- Bulletin:
- Quick Reference
- Component:
- 118000 electrical system: software
- Summary:
- Quick reference of vehicle concerns. includes a list of software versions and the technical bulletin numbers that referred to the concerns updated
- Bulletin:
- V171604 2037201
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Updated to include additional model year applicability.
- Bulletin:
- V171701 2012855
- Component:
- 060000 engine and engine cooling
- Summary:
- 17 17 01 july 5, 2017 2012855 supersedes technical bulletin 17-16-02 (v171602) dated april 29, 2016 due to updated oil standards lists to current specifications. engine oils which meet volkswagen oil quality standards
- Bulletin:
- Emissions Recall
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- 3.0l tdi vehicles were equipped with undisclosed auxiliary emission control devices which are not permitted by emissions regulations. install updated engine control module (ecm) software, transmission control module (tcm) software and hardw
- Bulletin:
- Emissions Recall
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- 3.0l tdi vehicles were equipped with undisclosed auxiliary emission control devices which are not permitted by emissions regulations. install updated engine control module (ecm) software, transmission control module (tcm) software and hardw
- Bulletin:
- Emissions Recall
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- 3.0l tdi vehicles were equipped with undisclosed auxiliary emission control devices which are not permitted by emissions regulations. install updated engine control module (ecm) software, transmission control module (tcm) software and hardw
- Bulletin:
- Emissions Recall
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- 3.0l tdi vehicles were equipped with undisclosed auxiliary emission control devices which are not permitted by emissions regulations. install updated engine control module (ecm) software, transmission control module (tcm) software and hardw
- Bulletin:
- Emissions Recall
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- 3.0l tdi vehicles were equipped with undisclosed auxiliary emission control devices which are not permitted by emissions regulations. install updated engine control module (ecm) software, transmission control module (tcm) software and hardw
- Bulletin:
- Emissions Recall
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- 3.0l tdi vehicles were equipped with undisclosed auxiliary emission control devices which are not permitted by emissions regulations. install updated engine control module (ecm) software, transmission control module (tcm) software and hardw
- Bulletin:
- Dealer Letter -
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- 3.0l tdi vehicles were equipped with undisclosed auxiliary emission control devices which are not permitted by emissions regulations. install updated engine control module (ecm) software, transmission control module (tcm) software and hardw
- Bulletin:
- E-mail - 3.0L AE
- Component:
- 355100 equipment:other:labels
- Summary:
- 3.0l aem touareg tdi - important reminders (23v6 and 23v7 campaigns)
- Bulletin:
- Engine Emissions
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Label allocation update.
- Bulletin:
- Email - Engine E
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- Label allocation update.
- Bulletin:
- Email - Workshop
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Workshop technology communication_tdi touareg gen 2.1 (23v6)
- Bulletin:
- Parts Circular -
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Explains process on submitting tdi kit claims for dealers.
- Bulletin:
- TT001703
- Component:
- 118000 electrical system: software
- Summary:
- Tip for scan tool concerns that may occur duing a test plan
- Bulletin:
- V001716 2049353
- Component:
- 350000 equipment
- Summary:
- Extended inspection for new, unused, unsold model year 2013-2014 volkswagen touareg 3.0l tdi gen 2.1 vehicles in dealer stock with less than 1,000 miles (u.s. only)
- Bulletin:
- V461703 2015173
- Component:
- 045000 service brakes, air:disc
- Summary:
- Updated to include additional models and model year applicability.
- Bulletin:
- VSE-17-20
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- This communication provides important information for obtaining the exhaust stud press tool, model otc 5057 for use with removing broken dpf studs while performing tdi emissions recall 23v6. please ensure you review the repair procedure out
- Bulletin:
- VSS-17-13
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Notification of the 3.0l gen 2.1 and 2.2, tdi remediation fix monitoring via the vta system, in alignment with campaigns 23v6 and 23v7.
- Bulletin:
- VSS-17-14
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- Campaign 23v6 3.0l emissions modification - gen 2.1
- Bulletin:
- VWC-17-12
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This document informs dealers of the sales preparation program for in-service date processing for new, unsold model year 2015 - 2016 volkswagen touareg 3.0l tdi gen 2.2 vehicles in dealer stock with over 1,000 miles
- Bulletin:
- VWC-17-15
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Tthis document informs the dealers of the in-service date processing for new, unsold model year 2013 - 2014 volkswagen touareg 3.0l tdi gen 2.1 vehicles in dealer stock with over 1,000 mile
- Bulletin:
- VWP-17-12
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- This document informs dealers of an "extended emissions warranty" limited warranty extension for 3.0l tdi gen 2.1 touareg vehicles.
- Bulletin:
- VWP-17-14
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- This document informs dealers that the class bridge warranty for 3.0l tdi gen 2.1 and gen 2.2 touareg vehicles is no longer active.
- Bulletin:
- VWP-17-15
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- This document informs dealers of coding instructions for adblue refills after aem performed for 3.0l tdi gen 2.1 and gen 2.2 touareg vehicles.
- Bulletin:
- VWP-17-16
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- This document informs dealers of coding instructions for fuel fill after aem performed for 3.0l tdi gen 2.1 and gen 2.2 touareg vehicles.
- Bulletin:
- On-car Analysis
- Component:
- 353000 equipment:electrical
- Summary:
- On-car analysis list of customer complaint: mil?on no electric drive mode, untouched vehicles
- Bulletin:
- On-car Analysis
- Component:
- 353000 equipment:electrical
- Summary:
- On-car analysis list of customer complaint: mil?on no electric drive mode, untouched vehicles
- Bulletin:
- On-Car Analysis
- Component:
- 060000 engine (pws)
- Summary:
- On-car analysis list of customer compliants customer complaint: mil?on no electric drive mode, untouched vehicles
- Bulletin:
- On-Car Analysis
- Component:
- 060000 engine (pws)
- Summary:
- On-car analysis list of customer compliants customer complaint: mil?on no electric drive mode, untouched vehicles
- Bulletin:
- On-car analysis
- Component:
- 060000 engine and engine cooling
- Summary:
- On-car analysis list of customer complaints: mil-on with fault code p046c, untouched vehicles
- Bulletin:
- On-car analysis
- Component:
- 060000 engine and engine cooling
- Summary:
- On-car analysis list of customer complaint: mil?on with fault code p046c, untouched vehicles
- Bulletin:
- A971861 2013504-
- Component:
- 110000 electrical system
- Summary:
- This information bulletin contains instructions for checking the pins/terminals for contacts and nano contacts.
- Bulletin:
- On-car analysis
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- On-car analysis list customer complaint: mil?on with fault code p046c, untouched vehicles
- Bulletin:
- On-car analysis
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- On-car analysis of customer complaints: customer states the oil light is on
- Bulletin:
- On-car analysis
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- On-car analysis list of customer complaints: customer states the oil light is on
- Bulletin:
- On-car analysis
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- On-car analysis list of customer complaints: customer states the oil light is on
- Bulletin:
- On-car analysis
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- On-car analysis list of customer complaints: customer states the oil light is on
- Bulletin:
- On-car analysis
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- On-car analysis list of customer complaints: mil?on
- Bulletin:
- SM 59-2017
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- This special notice is to inform dealers to return all part numbers listed in the document. only superseded part numbers to be ordered going forward.
- Bulletin:
- On-car analysis
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- On-car analysis list of customer complaint: mil-on with fault code p046c, untouched vehicles
- Bulletin:
- On-car analysis
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- On-car analysis list of customer complaints: customer states the oil light is on
- Bulletin:
- On-car analysis
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- On-car analysis list customer complaints: customer states the oil light is on
- Bulletin:
- On-car analysis
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- On-car analysis list of customer complaints: customer states the oil light is on
- Bulletin:
- On-car analysis
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- On-car analysis list of customer complaints: customer states the oil light is on
- Bulletin:
- On-car analysis
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- On-car analysis list of customer complaints: customer states the oil light is on
- Bulletin:
- On-car analysis
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- On-car analysis list of customer complaints: customer states the oil light is on
- Bulletin:
- On-car analysis
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- On-car analysis list of customer complaints: customer states the oil light is on
- Bulletin:
- On-car analysis
- Component:
- 100000 power train
- Summary:
- On-car analysis list of customer complaints: transmission concerns(including clutch assembly, bevel box and haldex)
Home | Privacy