2012 PETERBILT 320 Recalls (4)

Campaign:
11V127000 on 02/24/2011
Component:
Fuel system, other:storage:tank assembly
Manufactured:
03/09/2008 - 02/22/2011
Affected:
4,664
Defect:
Paccar is recalling certain model year 2008-2012 kenworth t2000, t660, t700, t800, and w900, as well as model year 2009-2012 peterbilt 365, 367, 384, 386, 387, 388, 389, and 587 trucks equipped with paccar mx engines. the oil module centrifugal spinner filter cap in the paccar mx engine may become loose, possibly allowing the cap to come off and engine oil to partially discharge from the oil module onto exhaust components.
Consequence:
The discharge of engine oil onto exhaust components which are hot, such as when the engine is under significant load, may cause a fire.
Correction:
Dealers will re-torque the oil module filter cap and install a secondary retention device on the secondary centrifugal spinner filter cap. this service will be performed free of charge. the safety recall is expected to begin during march 2011. owners may contact kenworth at 1-425-828-5440 and peterbilt at 1-940-591-4196.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
12V026000 on 01/30/2012
Component:
Service brakes, air:supply:check valve
Manufactured:
01/30/2011 - 01/18/2012
Affected:
15,932
Defect:
Paccar is recalling certain model year 2012-2013 kenworth t170, t270, t370, t440, t470, t660, t700, t800, w900, and peterbilt 320, 330, 337, 348, 365, 367, 382, 384, 386, 388, 389, and 587 vehicles, manufactured from january 31, 2011, through january 19, 2012, and equipped with bendix atr-6 antilock traction relay valves. in extremely cold conditions, these bendix relay valves may potentially develop internal leakage. internal leakage can lead to air pressure being delivered to affected primary or secondary brake causing continuous brake application.
Consequence:
Unexpected continuous brake application can cause the brakes to overheat and lead to a fire. unexpected continuous brake application can cause the driver to lose control of the vehicle, increasing the risk of a crash. also, the brakes may be applied without illuminating the brake lights, failing to give proper warning to other drivers.
Correction:
Paccar will notify owners, and provide a temporary repair until bendix develops a permanent remedy. this service will be performed free of charge. the safety recall began on february 10, 2012. owner may contact kenworth at 1-425-828-5440 and peterbilt at 1-940-591-4196.
Notes:
Kenworth and peterbilt recall numbers 12kwa/0112-a.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
15V108000 on 02/23/2015
Component:
Steering:linkages:tie rod assembly
Manufactured:
07/20/2008 - 02/27/2014
Affected:
5,141
Defect:
Paccar incorporated (paccar) is recalling certain model year 2009-2015 peterbilt 320, 365, 367, 388, and 389 trucks manufactured july 21, 2008, to february 28, 2014. the front axle tie rod end clamp bolts may be improperly torqued.
Consequence:
Undertorqued tie rod end clamp bolts are susceptible to corrosion, which may cause loose bolts to separate resulting in a loss of vehicle control and an increased risk of a crash.
Correction:
Paccar will notify owners, and dealers will replace the front axle tie rod assembly on any vehicle where the factory installed assembly has not been previously replaced, free of charge. owners were mailed interim notices on may 11, 2015. the recall began on april 4, 2016. owners may contact peterbilt customer service at 1-940-591-4220. paccar's number for this recall is 215-c.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
15V309000 on 05/25/2015
Component:
Engine and engine cooling:engine
Manufactured:
07/26/2007 - 04/27/2015
Affected:
4,823
Defect:
Paccar incorporated (paccar) is recalling certain model year 2010-2016 kenworth t440, t800, and w900 trucks manufactured august 31, 2009, to april 20, 2015, and 2008-2015 peterbilt 320, 337, 348, 365, 382, and 384 trucks manufactured july 27, 2007, to april 28, 2015, and equipped with certain cummins westport isl g engines. excessive engine crankcase pressures may cause the 90-degree elbow of the vent tube assembly to detach from the crankcase ventilation breather, possibly allowing engine oil to come into contact with hot surfaces.
Consequence:
If engine oil comes into contact with a hot surface, there is an increased risk of a fire.
Correction:
Cummins will notify owners on behalf of paccar, and cummins service centers will administer the repairs which include securing the ends of the 90-degree elbow and reprogramming the electronic control module (ecm) with software that can adjust the engine output under misfire conditions to limit crankcase pressures. these repairs will be performed free of charge. the recall began on june 12, 2015. owners may contact kenworth customer service at 1-425-828-5000, peterbilt customer service at 1-940-591-4000 or cummins inc. at 1-800-343-7357. paccar's number for this recall is 15kwh and 515-g.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

2012 PETERBILT 320 TSBs (4)

Bulletin:
SB-9-11
Component:
353600 equipment:air conditioner
Summary:
Peterbilt: technical information is provided for certain trucks operating in high ambient temperature (100 f) and is idling or during stop and go driving, may cause the high side pressure switch to shut off the compressor. *pe
Bulletin:
SB-10-11
Component:
091120 fuel system, other:storage:tank assembly:mounting
Summary:
Peterbilt: information regarding gap and proper torque allowed on def tank straps. tank straps have a spring to ensure they remain tight during expansion and contraction of def tank. straps may look loose but actually are not unless gap
Bulletin:
SB-11-13
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Peterbilt: an active fault code 3911, ammonia sensor communication, may be displayed and a repair strategy is being provided. model 320. *pe
Bulletin:
15-16
Component:
063000 engine and engine cooling:exhaust system
Summary:
Fix-as-fail: repair for horizontal exhaust diffuser configurations with broken brackets or cracked diffuser.

Home | Privacy