2011 VOLVO VT Recall
- Campaign:
- 13V268000 on 06/27/2013
- Component:
- Power train:clutch assembly
- Manufactured:
- 12/19/2006 - 05/21/2013
- Affected:
- 23,056
- Defect:
- Volvo trucks north america (volvo) is recalling certain model year 2007-2014 vah, vhd, vnl, vnm, and vt models. the affected vehicles were built without a redundant clutch disengagement switch. without a redundant switch, a loss of signal from the brake air pressure switch can prevent the clutch from automatically disengaging when the brake is applied.
- Consequence:
- Without a signal to disengage the clutch when the brakes are applied, the distance required to stop the truck may lengthen, increasing the risk of a crash.
- Correction:
- Volvo trucks will notify owners and dealers will inspect and repair the vehicles if necessary. the recall began on august 26, 2013. volvo's recall number is rvxx1303. owners may contact volvo at 1-336-393-2000.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
2011 VOLVO VT TSBs (37)
- Bulletin:
- FSB-284-047
- Component:
- 114000 electrical system:wiring
- Summary:
- Volvo: on some trucks, there is an oil contamination into the engine wire harness because of a failure of the oil level sensor. models vah, vhd, vn, vt. no model years listed. *pe
- Bulletin:
- FSB-221-011
- Component:
- 060000 engine (pws)
- Summary:
- Volvo: low oil pressure, on certain vehicles, during long hard pull conditions, diagnostic trouble codes (dtcs) pid 100 fm1, spn 100 fmi 1 or p252400, can log on, with or without engine shut down lamp. model vn, vt. no years listed. *pe
- Bulletin:
- FSB-432-013
- Component:
- 103000 power train:automatic transmission
- Summary:
- Volvo truck: procedural information regarding the replacement of high range cone in the section of the automated manual transmission (amt). model vn, vhd, vah, vt. *pe updated 8/8/14. *pe
- Bulletin:
- FSB-593-012
- Component:
- 118500 electrical system: integrated trailer brake control
- Summary:
- Volvo truck: due to internal build up contamination of grime, salt, road debris, in harsh environments, causes solenoid valve to malfunction and trailer brake circuit to maintain trailer brake pressure after hill start assist event. model
- Bulletin:
- TJ-25329
- Component:
- 017600 steering:linkages:knuckle:spindle:arm
- Summary:
- Volvo: on some vehicles, the steering knuckle would have wheel hub displaced and would to replace wheel hub. *pe
- Bulletin:
- FSB-216-014
- Component:
- 103000 power train:automatic transmission
- Summary:
- Volvo: information provided regarding the coversion from twin mass flywheel to single mass flywheel. model vn, vt. *pe
- Bulletin:
- FSB 392-004, Rad
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- On volvo trucks built between october 6, 2008 and august 18, 2014, with a factory installed programmable radio, the old radio may no longer be available for purchase. to upgrade from a glad format radio to a dea500 format radio follow the f
- Bulletin:
- FSB 210-001
- Component:
- 355100 equipment:other:labels
- Summary:
- Engine data label
- Bulletin:
- FSB 284-047
- Component:
- 114000 electrical system:wiring
- Summary:
- Oil level sensor harness wire splice
- Bulletin:
- FSB 284-046
- Component:
- 117000 digital instrument panel
- Summary:
- Instrument cluster reported fuel economy calibration
- Bulletin:
- FSB 432-014
- Component:
- 103000 power train:automatic transmission
- Summary:
- Transmission ecu compatibility
- Bulletin:
- FSB 293-024
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- Exhaust gas recirculation (egr) differential pressure sensor
- Bulletin:
- FSB 593-012
- Component:
- 113100 electrical system:starter assembly:solenoid
- Summary:
- Hill start assist solenoid, replacement
- Bulletin:
- FSB 216-001
- Component:
- 100000 power train
- Summary:
- Twin mass flywheel conversion, transmission removed
- Bulletin:
- FSB 431-010
- Component:
- 350000 equipment
- Summary:
- Range synchronizer, repair
- Bulletin:
- FSB 293-012
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- Exhaust gas recirculation, part update
- Bulletin:
- FSB 811-005
- Component:
- 350000 equipment
- Summary:
- Floor cracks repair (front panel)
- Bulletin:
- FSB 811-006
- Component:
- 350000 equipment
- Summary:
- Floor cracks repair (rear panel)
- Bulletin:
- FSB 284-038
- Component:
- 118000 electrical system: software
- Summary:
- Engine coolant thermostat software update
- Bulletin:
- FSB 215-002
- Component:
- 354000 equipment:mechanical
- Summary:
- Timing plate leak repair
- Bulletin:
- FSB 593-012
- Component:
- 113100 electrical system:starter assembly:solenoid
- Summary:
- Hill start assist solenoid, replacement
- Bulletin:
- FSB 262-005
- Component:
- 060000 engine and engine cooling
- Summary:
- Coolant bypass housing seal
- Bulletin:
- FSB 432-013
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Amt high range cone replacement
- Bulletin:
- FSB 801-003
- Component:
- 162300 structure:body:door
- Summary:
- Service door rust prevention
- Bulletin:
- FSB 593-012
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Hill start assist solenoid, replacement
- Bulletin:
- FSB 234-018
- Component:
- 070000 fuel system, gasoline
- Summary:
- Single fuel tank ventilation filter kit
- Bulletin:
- FSB 234-019
- Component:
- 070000 fuel system, gasoline
- Summary:
- Dual fuel tanks ventilation filter kit
- Bulletin:
- FSB 293-024
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- Exhaust gas recirculation (egr) differential pressure sensor
- Bulletin:
- FSB 293-026
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Exhaust gas recirculation (egr) differential pressure sensor
- Bulletin:
- FSB 284-059
- Component:
- 110000 electrical system
- Summary:
- Nox sensor signal
- Bulletin:
- FSB 593-012
- Component:
- 113100 electrical system:starter assembly:solenoid
- Summary:
- Hill start assist solenoid, replacement
- Bulletin:
- FSB 216-001
- Component:
- 350000 equipment
- Summary:
- Twin mass flywheel conversion
- Bulletin:
- K91214678
- Component:
- 100000 power train
- Summary:
- Automated manual transmission ( amt ) faults - diagnostic trouble codes ( dtcs ) p1052 - 18 , pid 33 fmi 5 intermittent fault in cold weatherupdated with new information and procedure
- Bulletin:
- SERVICE INSTRUCT
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Supplier service bulletin sent to customers regarding potential brake caliper issue.
- Bulletin:
- FSB216-002
- Component:
- 060000 engine (pws)
- Summary:
- Flywheel resurfacing guidelines, i-shift
- Bulletin:
- K52326370
- Component:
- 073100 fuel system, gasoline:fuel injection system:fuel rail
- Summary:
- Volvo chassis - diesel exhaust fluid ( def ) contamination in fuel system, inspection and repair - us10 to us14 ( non-common rail fuel system ) removed information for common rail chassis - now has its own solution.
- Bulletin:
- K51303113
- Component:
- 060000 engine (pws)
- Summary:
- Volvo chassis - equipped with an automated manual transmission ( amt, i-shift ) - reverse / back-up lights inoperative, no diagnostic trouble codes (dtc), no issues with circuit, additional check - us10 and us13 emissions, commonly model ye
Home | Privacy