2010 CHAMPION EZ-TRANS Recalls (4)
- Campaign:
- 09V369000 on 09/28/2009
- Component:
- Interior lighting
- Manufactured:
- 12/31/2002 - 08/29/2009
- Affected:
- 69
- Defect:
- Champion bus is recalling certain model year 2003 through 2010 transit buses manufactured between january 2003 and august 2009 equipped with luminator horizon led side destination signs. the connector board can corrode due to an accumulation of moisture under the connector.
- Consequence:
- A short could occur, possibly causing smoke and fire.
- Correction:
- Champion bus will notify owners and luminator will repair the buses free of charge. please see luminator's defect report 09e-054. the safety recall began on december 11, 2009. owners may contact luminator at 1-972-516-3033 or champion bus at 1-800-331-5761.
- Notes:
- Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
- Campaign:
- 09V426000 on 11/01/2009
- Component:
- Equipment:air conditioner
- Manufactured:
- 04/30/2009 - 09/29/2009
- Affected:
- 6
- Defect:
- Champion bus is recalling certain model year 2009 and 2010 transit buses equipped with carrier k410 rooftop condensers. inadequate overcurrent protection of one or more of the fans in the k410 condenser may cause overheating of the fan's wires.
- Consequence:
- Overheating of the condenser unit wires could result in a fire causing property damage, personal injury or death.
- Correction:
- Champion bus will notify owners to contact an authorized carrier dealer to obtain the remedy free of charge. please also see carrier's defect report 09e-055. the safety recall began on november 30, 2009. owners may contact carrier at 1-800-673-2431 or champion bus at 1-810-724-6474.
- Notes:
- Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
- Campaign:
- 11V141000 on 03/02/2011
- Component:
- Equipment:air conditioner
- Manufactured:
- 05/31/2007 - 02/27/2011
- Affected:
- 974
- Defect:
- Champion bus is recalling certain vehicles equipped with carrier genv em-1 evaporator units. due to time, temperature, and/or vibration, the fuse may loosen in the fuse holder resulting in high resistance and arcing.
- Consequence:
- If sufficient arcing occurs, the fuse holder may melt, and may be accompanied by flame, smoke and potential fire.
- Correction:
- Champion bus will notify owners and provide information on how to obtain the retrofit kit from carrier along with repair instructions. this service will be performed free of charge. the safety recall began on march 8, 2011. owner may contact carrier at 1-800-793-4741 or champion bus at 1-810-724-6474.
- Notes:
- Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
- Campaign:
- 13V422000 on 09/23/2013
- Component:
- Equipment:electrical
- Manufactured:
- 07/31/2009 - 05/18/2011
- Affected:
- 598
- Defect:
- Champion bus is recalling certain model year 2010 american crusader, american coach, cts-fe, cts-re, and ic low floor buses; and 2009-2010 challenger and crusader buses; and 2009-2011 defender and ez trans buses; and 2010-2011 ic high floor buses. the buses are manufactured from august 1, 2009, through may 19, 2011, and equipped with a&m systems door headers containing model 3230 circuit boards. voltage spikes may damage electrical components and electrical circuits, causing the circuit board to develop high resistance.
- Consequence:
- High resistance may cause the board to overheat, increasing the risk of a fire.
- Correction:
- Champion bus will notify owners, and dealers will inspect the door header and replace any defective circuit board, free of charge. the recall began on october 22, 2013. owners may contact champion at 1-810-724-6474.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Home | Privacy