2009 VOLVO VAH Recall

Campaign:
13V268000 on 06/27/2013
Component:
Power train:clutch assembly
Manufactured:
12/19/2006 - 05/21/2013
Affected:
23,056
Defect:
Volvo trucks north america (volvo) is recalling certain model year 2007-2014 vah, vhd, vnl, vnm, and vt models. the affected vehicles were built without a redundant clutch disengagement switch. without a redundant switch, a loss of signal from the brake air pressure switch can prevent the clutch from automatically disengaging when the brake is applied.
Consequence:
Without a signal to disengage the clutch when the brakes are applied, the distance required to stop the truck may lengthen, increasing the risk of a crash.
Correction:
Volvo trucks will notify owners and dealers will inspect and repair the vehicles if necessary. the recall began on august 26, 2013. volvo's recall number is rvxx1303. owners may contact volvo at 1-336-393-2000.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

2009 VOLVO VAH TSBs (64)

Bulletin:
FSB-284-047
Component:
114000 electrical system:wiring
Summary:
Volvo: on some trucks, there is an oil contamination into the engine wire harness because of a failure of the oil level sensor. models vah, vhd, vn, vt. no model years listed. *pe
Bulletin:
FSB-51-001
Component:
045000 service brakes, air:disc
Summary:
Volvo: the air disc brake, on some trucks, may experience thermal overload due to an over adjustment of normal pad wear compensation that maintains clearance running between brake pad and rotor. models vah, vhd, vn. no years listed.
Bulletin:
FSB-512-002
Component:
045000 service brakes, air:disc
Summary:
Volvo: on some trucks, air disc brake may experience a condition of thermal overload. thermal overload reduces running clearance between pad and rotor below desired level which is an over adjustment of normal pad wear compensation. model
Bulletin:
SP-721-005
Component:
021240 suspension:front:springs:leaf spring assembly
Summary:
Volvo: the front springs can over travel and break, overtime, at spring leaf and a spacer plate needs to be installed to increase height of suspension bumpstops. model vah. no years listed. *pe
Bulletin:
FSB-432-013
Component:
103000 power train:automatic transmission
Summary:
Volvo truck: procedural information regarding the replacement of high range cone in the section of the automated manual transmission (amt). model vn, vhd, vah, vt. *pe updated 8/8/14. *pe
Bulletin:
FSB-593-012
Component:
118500 electrical system: integrated trailer brake control
Summary:
Volvo truck: due to internal build up contamination of grime, salt, road debris, in harsh environments, causes solenoid valve to malfunction and trailer brake circuit to maintain trailer brake pressure after hill start assist event. model
Bulletin:
371-049
Component:
110000 high voltage battery
Summary:
Volvo trucks: vn, vhd &vah 2008-2014: to prevent chafing of the battery cables, avoid the crossing of cables behind the battery box and cut off switch. *lj
Bulletin:
FSB 392-004, Rad
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
On volvo trucks built between october 6, 2008 and august 18, 2014, with a factory installed programmable radio, the old radio may no longer be available for purchase. to upgrade from a glad format radio to a dea500 format radio follow the f
Bulletin:
FSB 293-016
Component:
063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
Summary:
Exhaust gas recirculation (egr) valve oil supply line, updated part
Bulletin:
SP 721-005
Component:
021210 suspension:front:springs:coil springs
Summary:
Front spring breakage
Bulletin:
FSB 210-001
Component:
355100 equipment:other:labels
Summary:
Engine data label
Bulletin:
FSB 284-047
Component:
114000 electrical system:wiring
Summary:
Oil level sensor harness wire splice
Bulletin:
FSB 284-046
Component:
117000 digital instrument panel
Summary:
Instrument cluster reported fuel economy calibration
Bulletin:
SP 284-049
Component:
118000 electrical system: software
Summary:
Engine control module (ecm) software update
Bulletin:
FSB 432-014
Component:
103000 power train:automatic transmission
Summary:
Transmission ecu compatibility
Bulletin:
FSB 371-049
Component:
111100 electrical system:battery:cables
Summary:
Battery cable, routing
Bulletin:
FSB 375-010
Component:
220000 seats
Summary:
Seat harness routing (non-swivel) wires pulling away from clipping points
Bulletin:
FSB 375-011
Component:
220000 seats
Summary:
Seat harness routing (swivel) wires pulling away from clipping points
Bulletin:
FSB 293-024
Component:
063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
Summary:
Exhaust gas recirculation (egr) differential pressure sensor
Bulletin:
FSB 593-012
Component:
113100 electrical system:starter assembly:solenoid
Summary:
Hill start assist solenoid, replacement
Bulletin:
FSB 293-027
Component:
063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
Summary:
Egr mass flow rate low, diagnostic trouble code
Bulletin:
FSB 431-010
Component:
350000 equipment
Summary:
Range synchronizer, repair
Bulletin:
FSB 293-012
Component:
063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
Summary:
Exhaust gas recirculation, part update
Bulletin:
FSB 811-005
Component:
350000 equipment
Summary:
Floor cracks repair (front panel)
Bulletin:
FSB 593-012
Component:
113100 electrical system:starter assembly:solenoid
Summary:
Hill start assist solenoid, replacement
Bulletin:
FSB 215-003
Component:
350000 equipment
Summary:
Timing plate flange screw
Bulletin:
FSB 284-057
Component:
060000 engine (pws)
Summary:
High soot output
Bulletin:
FSB 222-004
Component:
060000 engine (pws)
Summary:
Oil filter housing
Bulletin:
FSB 262-005
Component:
060000 engine and engine cooling
Summary:
Coolant bypass housing seal
Bulletin:
FSB 432-013
Component:
355200 equipment:other:owners/service/other manual
Summary:
Amt high range cone replacement
Bulletin:
FSB 801-003
Component:
162300 structure:body:door
Summary:
Service door rust prevention
Bulletin:
FSB 593-012
Component:
355200 equipment:other:owners/service/other manual
Summary:
Hill start assist solenoid, replacement
Bulletin:
FSB 234-018
Component:
070000 fuel system, gasoline
Summary:
Single fuel tank ventilation filter kit
Bulletin:
FSB 234-019
Component:
070000 fuel system, gasoline
Summary:
Dual fuel tanks ventilation filter kit
Bulletin:
FSB 293-024
Component:
063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
Summary:
Exhaust gas recirculation (egr) differential pressure sensor
Bulletin:
FSB 293-026
Component:
063000 engine and engine cooling:exhaust system
Summary:
Exhaust gas recirculation (egr) differential pressure sensor
Bulletin:
FSB 284-059
Component:
110000 electrical system
Summary:
Nox sensor signal
Bulletin:
FSB 210-045
Component:
110000 electrical system
Summary:
Regeneration in pto mode
Bulletin:
FSB 222-004
Component:
060000 engine (pws)
Summary:
Oil filter housing
Bulletin:
FSB 593-012
Component:
113100 electrical system:starter assembly:solenoid
Summary:
Hill start assist solenoid, replacement
Bulletin:
FSB 293-022
Component:
060000 engine (pws)
Summary:
In the event that an egr temperature sensor replacement is required on a volvo d13h engine, a new routing configuration is required.
Bulletin:
SP 398-001
Component:
110000 electrical system
Summary:
On some trucks with the telematics gateway (tgw) system, the tgw control unit may not correctly communicate with the vehicle systems after restarting.
Bulletin:
K24483157
Component:
110000 electrical system
Summary:
Diagnostic trouble codes ( dtc ) p208e and p103b logging with possible derate (scr inducement ) - us13 emissions and newer
Bulletin:
K91214678
Component:
100000 power train
Summary:
Automated manual transmission ( amt ) faults - diagnostic trouble codes ( dtcs ) p1052 - 18 , pid 33 fmi 5 intermittent fault in cold weatherupdated with new information and procedure
Bulletin:
K04596533
Component:
271000 lane departure: warning
Summary:
"volvo chassis - equipped with volvo active driver assist ( vada ), with or without lane departure warning ( ldws ) - diagnostic trouble code ( dtc ) spn 70 mi 9, bendix code 64 with possible ""lane departure warning malfunction"" message
Bulletin:
K42708399
Component:
355200 equipment:other:owners/service/other manual
Summary:
Diagnostic trouble code ( dtc ) p0422 lighting the malfunction indicator light ( mil ) - obd15 and obd16 chassis (non-common rail)updated to reflect release of fsb284-064 (above)
Bulletin:
K84412328
Component:
120000 exterior lighting
Summary:
Diagnostic trouble code ( dtc ) p249c intermittently lighting the malfunction indicator lamp ( mil ) - obd15 and obd16, model year ( my ) 2016 and 2017 chassisupdated to reflect release of fsb284-064 (above)
Bulletin:
K03179378
Component:
090000 fuel system, other
Summary:
Service only regen requested with no warning. active fault codes p24a4 / p10fe - obd15 and obd16 chassis; does not apply to us17 (common rail fuel system) chassisupdated to reflect release of fsb284-064 (above)
Bulletin:
K15164821
Component:
355200 equipment:other:owners/service/other manual
Summary:
Volvo chassis - diagnostic trouble code ( dtc ) p2002, diagnostic information - obd13 and newerupdated to reflect release of fsb284-064 (above)
Bulletin:
K27690302
Component:
120000 exterior lighting
Summary:
Volvo chassis - diagnostic trouble code ( dtc ) p226c intermittently lighting the malfunction indicator lamp ( mil ) - obd15 and obd16 conventional chassisupdated to reflect release of fsb284-064 (above)
Bulletin:
K86412082
Component:
110000 electrical system
Summary:
Engine diagnostic trouble codes ( dtc's ) p24a0 and p249f lighting the malfunction indicator lamp ( mil ) - obd15 (commonly model year 2016) and newerupdated to reflect release of fsb284-064 (above)
Bulletin:
K05680314
Component:
270000 lane departure
Summary:
Volvo chassis - equipped with volvo active driver assist ( vada ), with or without lane departure warning ( ldws ) - diagnostic trouble code ( dtc ) spn 516103 fmi 19, bendix code 167 with possible "lane departure warning malfunction" messa
Bulletin:
K82320750
Component:
103000 power train:automatic transmission
Summary:
Automated manual transmission ( amt - f ) ( i-shift) clutch valve unit ( cvu ) makes intermittent buzzing noise with the key on and engine offchanged repair information to reflect new software available.
Bulletin:
K97651904
Component:
117000 digital instrument panel
Summary:
Volvo chassis - diagnostic trouble code ( dtc ) p2459 lighting the malfunction indicator lamp ( mil ); possible frequent regeneration requests - obd15 and newer chassisupdated to reflect release of fsb284-064 (above)
Bulletin:
K14637412
Component:
073100 fuel system, gasoline:fuel injection system:fuel rail
Summary:
Diagnostic trouble code ( dtc ) p0194 - 00 - fuel rail pressure sensor ( rps ), circuit erratic, intermittent - us17 ( ghg17 ) emissions and newer ( common rail fuel system ); common model years 2017 and 2018changed repair instructions to r
Bulletin:
FSB284-064
Component:
103100 power train:automatic transmission:control module (tcm, pcm)
Summary:
Ecm and acm reprogramming, obd2015
Bulletin:
K14701433
Component:
073100 fuel system, gasoline:fuel injection system:fuel rail
Summary:
Diagnostic trouble code ( dtc ) p009e - 73 - fuel pressure relief control performance / stuck off - ghg17 ( us17 ) chassis with common rail fuel systemchanged repair instructions to reflect new procedures
Bulletin:
SERVICE INSTRUCT
Component:
355200 equipment:other:owners/service/other manual
Summary:
Supplier service bulletin sent to customers regarding potential brake caliper issue.
Bulletin:
FSB216-002
Component:
060000 engine (pws)
Summary:
Flywheel resurfacing guidelines, i-shift
Bulletin:
K52326370
Component:
073100 fuel system, gasoline:fuel injection system:fuel rail
Summary:
Volvo chassis - diesel exhaust fluid ( def ) contamination in fuel system, inspection and repair - us10 to us14 ( non-common rail fuel system ) removed information for common rail chassis - now has its own solution.
Bulletin:
K97651904
Component:
060000 engine (pws)
Summary:
Volvo chassis - diagnostic trouble code ( dtc ) p2459 lighting the malfunction indicator lamp ( mil ); possible frequent regeneration requests - obd15 and us14+obd16 (non-common rail) chassis, changed repair instructions to reflect obd16 so
Bulletin:
K24400052
Component:
013000 steering:gear box (other than rack and pinion)
Summary:
Volvo chassis - equipped with an automated manual transmission (amt, i-shift ) - error code 126 displayed in premium tech tool (ptt ) while performing the calibration procedure after the shift control housing has been removed and installed,
Bulletin:
K24483157
Component:
063100 engine and engine cooling:exhaust system:emission control
Summary:
Diagnostic trouble codes ( dtc ) p208e and p103b logging with possible derate ( scr inducement ) - obd15, us14+obd16 emissions and newer rewrote test procedure for better clarity.
Bulletin:
K14701433
Component:
080000 fuel system, diesel
Summary:
Diagnostic trouble code ( dtc ) p009e - 73 - fuel pressure relief control performance / stuck off - ghg17 ( us17 ) chassis with common rail fuel system, updated to reflect ghg17 software release

Home | Privacy