2009 CHRYSLER TOWN AND COUNTRY Recalls (6)
- Campaign:
- 09V046000 on 02/03/2009
- Component:
- Electrical system:fuses and circuit breakers
- Manufactured:
- 06/22/2008 - 12/15/2008
- Affected:
- 6,138
- Defect:
- Chrysler is recalling 6,138 my 2009 town and country and dodge grand caravan vehicles. unused electrical connectors for the blind spot detection system may become corroded and could short circuit, which can cause a variety of conditions.
- Consequence:
- If the fuse for this circuit does not blow, the connectors could overheat and potentially catch fire.
- Correction:
- Dealers will seal the power circuit at the subject connector and replace the fuse for this circuit if necessary free of charge. the recall began on march 9, 2009. owners may contact chrysler at 1-800-853-1403.
- Notes:
- Chrysler recall no. j01.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
- Campaign:
- 09V351000 on 09/10/2009
- Component:
- Service brakes, hydraulic
- Manufactured:
- 01/30/2008 - 05/30/2009
- Affected:
- 82
- Defect:
- Eldorado national is recalling model year 2008-2009 amerivan mobility vehicles built on chrysler town & country and dodge grand caravan platforms vehicles. the rear brake lines may have been improperly routed and not secured properly during the alteration. if not routed and secured properly, the brake lines could rub against the vehicle causing a brake fluid leak.
- Consequence:
- A brake fluid leak could result in a loss of braking ability, possibly causing a crash.
- Correction:
- Eldorado national amerivan dealers will inspect the vehicles and if the brake lines were improperly routed they will be correctly reinstalled free of charge. the safety recall began on october 13, 2009. owners may contact eldorado national at 1-800-955-9086. these minivans have been altered into wheelchair accessible vehicles by eldorado. this recall is not being conducted by chrysler group llc and will not be performed at no cost by dodge or chrysler dealers unless they are also an eldorado national dealer.
- Notes:
- Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
- Campaign:
- 14V055000 on 02/13/2014
- Component:
- Suspension:rear:axle:non-powered axle assembly
- Manufactured:
- 01/31/2008 - 01/30/2011
- Affected:
- 130
- Defect:
- Freedom motors inc., (freedom motors) of savaria vehicle group (formerly the liberty motor company) is recalling one model year 2009 volkswagen routan and certain model year 2008-2010 dodge grand caravan and chrysler town & country wheelchair accessible vehicles modified by the liberty motor company from february 2008 through january 2011. over time and with use, the vehicle's rear axle may develop cracks which could lead to axle failure.
- Consequence:
- Failure of the rear axle may increase the risk of a crash.
- Correction:
- Freedom motors will notify owners, and dealers will replace the affected axles, free of charge. the recall began on april 1, 2014. owners can contact freedom motors at 1-800-561-9600. freedom motors' number for this recall is engf0216-3.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
- Campaign:
- 14V373000 on 06/25/2014
- Component:
- Electrical system:ignition:switch
- Manufactured:
- 01/25/2007 - 06/16/2010
- Affected:
- 722,705
- Defect:
- This defect can affect the safe operation of the airbag system. until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. the key fob (if applicable), should also be removed from the key ring. chrysler group llc (chrysler) is recalling certain model year 2009-2010 dodge journey vehicles manufactured june 29, 2007, to june 17, 2010, and 2008-2010 dodge grand caravan and chrysler town and country vehicles manufactured january 26, 2007, to june 17, 2010. road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
- Consequence:
- If the ignition key inadvertently moves into the off or accessory position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
- Correction:
- Chrysler will notify owners, and dealers will replace the ignition switch and key fobs, free of charge. the recall began on may 26, 2015. owners may contact chrysler customer service at 1-800-853-1403. chrysler's number for this recall is r03. note: this is an expansion of recall 11v-139.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
- Campaign:
- 14V373000 on 06/25/2014
- Component:
- Air bags
- Manufactured:
- 01/25/2007 - 06/16/2010
- Affected:
- 722,705
- Defect:
- This defect can affect the safe operation of the airbag system. until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. the key fob (if applicable), should also be removed from the key ring. chrysler group llc (chrysler) is recalling certain model year 2009-2010 dodge journey vehicles manufactured june 29, 2007, to june 17, 2010, and 2008-2010 dodge grand caravan and chrysler town and country vehicles manufactured january 26, 2007, to june 17, 2010. road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
- Consequence:
- If the ignition key inadvertently moves into the off or accessory position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
- Correction:
- Chrysler will notify owners, and dealers will replace the ignition switch and key fobs, free of charge. the recall began on may 26, 2015. owners may contact chrysler customer service at 1-800-853-1403. chrysler's number for this recall is r03. note: this is an expansion of recall 11v-139.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
- Campaign:
- 16V047000 on 01/28/2016
- Component:
- Air bags:frontal
- Manufactured:
- 06/17/2007 - 08/30/2008
- Affected:
- 110,482
- Defect:
- Fca us llc (chrysler) is recalling certain model year 2009 dodge journey vehicles manufactured december 31, 2007, to august 31, 2008, 2008-2009 dodge grand caravan and chrysler town and country vehicles manufactured june 18, 2007, to august 31, 2008. in the affected vehicles, the air bag control units may corrode and fail.
- Consequence:
- If the air bag control unit fails, the air bags may not deploy in the event of a crash, increasing the risk of occupant injury. additionally, the air bags may inadvertently deploy, increasing the risk of a crash.
- Correction:
- Chrysler will notify owners, and dealers will replace the air bag control unit, free of charge. the recall began on december 6, 2016. owners may contact chrysler customer service at 1-800-853-1403. chrysler's number for this recall is s07.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
2009 CHRYSLER TOWN AND COUNTRY TSBs (42)
- Bulletin:
- TSB-08-037-08
- Component:
- 110000 electrical system
- Summary:
- Chrysler: an intermittent or partial unlatch of the 60 percent third row seat inboard latch while attempting to stow seat. *pe
- Bulletin:
- SB-08-001-09
- Component:
- 222000 seats:mid/rear assembly
- Summary:
- Chrysler: an intermittent or partial unlatch of the 60 percent third row seat inboard latch while attempting to stow the seat. *pe
- Bulletin:
- J-03
- Component:
- 063110 engine and engine cooling:exhaust system:emission control:crankcase (pcv)
- Summary:
- Chrysler\dodge service campaign: see document search button for owner letter. an incorrect positive crankcase ventilation (pcv) valve may have been installed. an incorrect pcv valve can cause excessive exhaust emissions. csc letter was rec
- Bulletin:
- SB-1800309 REVC
- Component:
- 100000 power train
- Summary:
- Chrysler/jeep/dodge: flash-driveability improvements or mil illumination diagnostic trouble code p0452-evap pressure switch stuck closed. includes my09 town&country; voyager and caravan. *pe
- Bulletin:
- SB-J19
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- Chrysler/jeep/dodge: california emissions warranty addendum. the warranty book on certain vehicles may contain errors or may be missing information regarding the coponents covered by the california emissions warranty. dodge-caravan/grand
- Bulletin:
- CS-K-04
- Component:
- 353600 equipment:air conditioner
- Summary:
- Dodge/chrysler: the air conditioning (a/c) discharge hose on about 182,000 certain vehicles may crack and leak refrigerant. this could cause a loss of a/c cooling. the air conditioning discharge hose must be replaced. csc letter was rec
- Bulletin:
- CS-J-29
- Component:
- 062100 engine and engine cooling:cooling system:radiator assembly
- Summary:
- Chrysler/dodge: radiator cap on about 276,000 grand caravan and town and country vehicles may experience engine coolant weep and/or a slow leak resulting in low engine coolant levels. the radiator cap must be replaced. csc letter was rec
- Bulletin:
- SB-19-001-10
- Component:
- 015100 steering:hydraulic power assist:pump
- Summary:
- Chrysler: power steering return lines. involves inspecting and if necessary removing and replacing the gear to cooler power steering return hose with a kevlar braided return hose. may experience leaks in power steering return line, at co
- Bulletin:
- TSB-23-005-10
- Component:
- 162300 structure:body:door
- Summary:
- Chrysler/dodge: power sliding door will not power open. the power sliding door of the right and/or left side not opening when using the interior or exterior handles or interior b pillar button from full closed position but works with remo
- Bulletin:
- SB-23-014-10
- Component:
- 162300 structure:body:door
- Summary:
- Chrysler: sliding door will not latch in the full open position. involves inspecting the right and/or left sliding door operation and if necessary adjusting the sliding door latch position. applies to vehicles built before 4/30/10. *pe
- Bulletin:
- SB-08-021-10
- Component:
- 110000 electrical system
- Summary:
- Chrysler/dodge: power sliding doors inoperative. this involves flash reprogramming the power sliding door module rear left and/or right (dmrl/dmrr) with new software. power sliding doors will not open from any of the switches. doors wil
- Bulletin:
- 23-009-11
- Component:
- 171100 latches/locks/linkages:doors:latch
- Summary:
- Chrysler group: when the sliding door is fully open and is being closed the door may bind. 2009-2010 town & country. *rm
- Bulletin:
- SB-02-003-11
- Component:
- 021600 suspension:front:wheel bearing
- Summary:
- Chrysler/dodge: the front wheel bearings is humming or growling. remove and replace both front wheel bearings, if necessary. *pe
- Bulletin:
- D-11-52
- Component:
- 030000 brakes (pws)
- Summary:
- my chrysler 2009-2011, dodge caravan: bulletin information regarding front brake components (rotors and pads) extended warranty for certain vehicles. *lj
- Bulletin:
- D-11-44
- Component:
- 021600 suspension:front:wheel bearing
- Summary:
- This tsb contains owner letter. see document search button below: 2008-2010 my minivans extended warranty bulletin information regarding front wheel bearings. *lj
- Bulletin:
- 08-031-13
- Component:
- 118000 electrical system: software
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 08-042-14
- Component:
- 110000 electrical system
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 23-012-12REV.A
- Component:
- 162000 structure:body
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 23-014-14
- Component:
- 162000 structure:body
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- SB-1234
- Component:
- 034520 service brakes, hydraulic:foundation components:disc:pads
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- R4880213A$
- Component:
- 103000 power train:automatic transmission
- Summary:
- "shaft - axle half note: the joint between the splines on the halfshaft and the hub and bearing is an interference fit. the halfshaft nut is to be used to draw the hub and bearing onto the halfshaft splines. this is particularly true if
- Bulletin:
- 9003220
- Component:
- 118000 electrical system: software
- Summary:
- Res / rha / reb radios that supports bluetooth and hands-free for issues with bluetooth, hands-free calling, and/or voice commands, do not replace the radio. diagnose the hands-free module system (also called the telematics module). the
- Bulletin:
- RL108213A$
- Component:
- 060000 engine and engine cooling
- Summary:
- Nag1 (5a580) valve body as per warranty bulletin d-13-22, please use r2108213a$ valve body for all warranty (w), mopar (m) and mopar vehicle protection (f) claims.~ assembly also includes filter (52108325aa) and gasket (52108332aa).~
- Bulletin:
- 9002519
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- 82212076, 82203694 - fabric cleaner this "fabric cleaner" is not intended for sale in california, the otc states (connecticut, delaware, massachusetts, maine, new hampshire, new jersey, new york, pennsylvania, virginia, and washington dc
- Bulletin:
- 20616
- Component:
- 110000 electrical system
- Summary:
- P/n cbszr068aa: inspect & return: module kit - occupant restraint you have been identified as either having stock, or have stock in transit to your dealership. please return part number cbszr068aa as per the qir attached. replacement par
- Bulletin:
- 22892
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Return: lamp assy - chmsl& cargo light you have been identified as either having stock, or have stock in transit to your dealership. please return all stock of follow ing part numbers:55372082ae, 55372082ad, 55372082ac, 55372082ab, 553720
- Bulletin:
- 22867
- Component:
- 110000 electrical system
- Summary:
- Inspect and return: solenoid module - transmission you have been identified as either having stock, or have stock in transit to your dealership. please return suspect stock of follow ing part numbers:52120000aa, 52119435af, 05078709ab. s
- Bulletin:
- 22958
- Component:
- 117000 digital instrument panel
- Summary:
- 1nt30xdvac - inspect and return: panel - instrument panel you have been identified as either having stock, or have stock in transit to your dealership. please return suspect stock of part number 1n t30xdvac. see attachments for identifyin
- Bulletin:
- 20244
- Component:
- 350000 equipment
- Summary:
- Cbxdp361aa return: spacer kit - visor you have been identified as either having stock, or have stock in transit to your dealership. please return stock of part number cbxdp361aa. replacement part number is cbxdp361ab w hich is in stock a
- Bulletin:
- Volume 2, Issue
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Warranty operations newsletter updates from warranty operations
- Bulletin:
- Volume 2, Issue
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Warranty operations newsletter updates from warranty operations
- Bulletin:
- 23137
- Component:
- 350000 equipment
- Summary:
- Inspect and return: trim cover assy - a-pillar rt/lt you have been identified as either having stock, or have stock in transit to your dealership. please return suspect stock of part numbers: 1za04dx9ae, 1za05dx9ae. see attachments for id
- Bulletin:
- 23104
- Component:
- 120000 lighting (pws)
- Summary:
- 05182535ad - lamp assy ?tail light lt you have been identified as either having stock, or have stock in transit to your dealership. please return suspect stock of part number 05182535ad . see attachments for identifying suspect stock. pl
- Bulletin:
- 23027
- Component:
- 114000 electrical system:wiring
- Summary:
- Return: wiring assy - engine you have been identified as either having stock, or have stock in transit to your dealership. please return stock packaged before 2016/07/31 (31 july, 2016)of follow ing part numbers:68176457af, 68176459af. p
- Bulletin:
- 9001645
- Component:
- 063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
- Summary:
- Part description: short runner valve (actuator) issue description: issue 1~ jc,js '08-09my 3.5l only~ caution - do not replace the intake manifold for a short runner valve (srv) fault (p1004 / p2008 / p2016 / p2017) or for a manifold
- Bulletin:
- 9002158
- Component:
- 110000 electrical system
- Summary:
- Part description: wireless ignition node receiver. issue description: wireless ignition node receiver part number 05026875ae is no longer available. the following kits are available as replacements.~ 68241059aa kit for journey (jc) and
- Bulletin:
- 9002385
- Component:
- 162310 structure:body:door:hinge and attachments
- Summary:
- Part description: upper and lower sliding door rollers issue description: if you are replacing this part for a noise condition, please perform the following procedure:~ 1. cycle the sliding door to open, then close and inspect the uppe
- Bulletin:
- 08-042-14
- Component:
- 110000 electrical system
- Summary:
- Flash: dead battery this bulletin involves updating the fold and stow module (fsm) with new software because the fsm stays awake resulting in a continuous electrical draw. the customer may experience a dead battery.
- Bulletin:
- 23-014-14
- Component:
- 162300 structure:body:door
- Summary:
- Sliding door trim contacting vehicle rear quarter this bulletin depending on production date, involves either installing or engaging an additional door panel retention point to prevent the door panel from bowing and contacting the body wh
- Bulletin:
- 9003687
- Component:
- 150000 seat belts
- Summary:
- Restraints remove i-sheet from packaging. correct information sheet (i-sheet) has been added to star parts. print i-sheet for technician use.
- Bulletin:
- 9003681
- Component:
- 150000 seat belts
- Summary:
- Restraints information sheet (i-sheet) has been added to star parts. print i-sheet for technician use.
- Bulletin:
- TS-WI-0290
- Component:
- 220000 seats
- Summary:
- Service bulletin sent to all dealers to inspect l-track bolts for correct torque and to incorporate torque check as part of regular maintenance
Home | Privacy