2008 VOLVO VAH Recall
- Campaign:
- 13V268000 on 06/27/2013
- Component:
- Power train:clutch assembly
- Manufactured:
- 12/19/2006 - 05/21/2013
- Affected:
- 23,056
- Defect:
- Volvo trucks north america (volvo) is recalling certain model year 2007-2014 vah, vhd, vnl, vnm, and vt models. the affected vehicles were built without a redundant clutch disengagement switch. without a redundant switch, a loss of signal from the brake air pressure switch can prevent the clutch from automatically disengaging when the brake is applied.
- Consequence:
- Without a signal to disengage the clutch when the brakes are applied, the distance required to stop the truck may lengthen, increasing the risk of a crash.
- Correction:
- Volvo trucks will notify owners and dealers will inspect and repair the vehicles if necessary. the recall began on august 26, 2013. volvo's recall number is rvxx1303. owners may contact volvo at 1-336-393-2000.
- Notes:
- Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
2008 VOLVO VAH TSBs (63)
- Bulletin:
- FSB-284-047
- Component:
- 114000 electrical system:wiring
- Summary:
- Volvo: on some trucks, there is an oil contamination into the engine wire harness because of a failure of the oil level sensor. models vah, vhd, vn, vt. no model years listed. *pe
- Bulletin:
- FSB-51-001
- Component:
- 045000 service brakes, air:disc
- Summary:
- Volvo: the air disc brake, on some trucks, may experience thermal overload due to an over adjustment of normal pad wear compensation that maintains clearance running between brake pad and rotor. models vah, vhd, vn. no years listed.
- Bulletin:
- FSB-512-002
- Component:
- 045000 service brakes, air:disc
- Summary:
- Volvo: on some trucks, air disc brake may experience a condition of thermal overload. thermal overload reduces running clearance between pad and rotor below desired level which is an over adjustment of normal pad wear compensation. model
- Bulletin:
- SP-721-005
- Component:
- 021240 suspension:front:springs:leaf spring assembly
- Summary:
- Volvo: the front springs can over travel and break, overtime, at spring leaf and a spacer plate needs to be installed to increase height of suspension bumpstops. model vah. no years listed. *pe
- Bulletin:
- FSB-432-013
- Component:
- 103000 power train:automatic transmission
- Summary:
- Volvo truck: procedural information regarding the replacement of high range cone in the section of the automated manual transmission (amt). model vn, vhd, vah, vt. *pe updated 8/8/14. *pe
- Bulletin:
- FSB-593-012
- Component:
- 118500 electrical system: integrated trailer brake control
- Summary:
- Volvo truck: due to internal build up contamination of grime, salt, road debris, in harsh environments, causes solenoid valve to malfunction and trailer brake circuit to maintain trailer brake pressure after hill start assist event. model
- Bulletin:
- 371-049
- Component:
- 110000 high voltage battery
- Summary:
- Volvo trucks: vn, vhd &vah 2008-2014: to prevent chafing of the battery cables, avoid the crossing of cables behind the battery box and cut off switch. *lj
- Bulletin:
- FSB 293-016
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- Exhaust gas recirculation (egr) valve oil supply line, updated part
- Bulletin:
- SP 721-005
- Component:
- 021210 suspension:front:springs:coil springs
- Summary:
- Front spring breakage
- Bulletin:
- FSB 210-001
- Component:
- 355100 equipment:other:labels
- Summary:
- Engine data label
- Bulletin:
- FSB 284-047
- Component:
- 114000 electrical system:wiring
- Summary:
- Oil level sensor harness wire splice
- Bulletin:
- FSB 284-046
- Component:
- 117000 digital instrument panel
- Summary:
- Instrument cluster reported fuel economy calibration
- Bulletin:
- SP 284-049
- Component:
- 118000 electrical system: software
- Summary:
- Engine control module (ecm) software update
- Bulletin:
- FSB 432-014
- Component:
- 103000 power train:automatic transmission
- Summary:
- Transmission ecu compatibility
- Bulletin:
- FSB 371-049
- Component:
- 111100 electrical system:battery:cables
- Summary:
- Battery cable, routing
- Bulletin:
- FSB 375-010
- Component:
- 220000 seats
- Summary:
- Seat harness routing (non-swivel) wires pulling away from clipping points
- Bulletin:
- FSB 375-011
- Component:
- 220000 seats
- Summary:
- Seat harness routing (swivel) wires pulling away from clipping points
- Bulletin:
- FSB 293-024
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- Exhaust gas recirculation (egr) differential pressure sensor
- Bulletin:
- FSB 593-012
- Component:
- 113100 electrical system:starter assembly:solenoid
- Summary:
- Hill start assist solenoid, replacement
- Bulletin:
- FSB 293-027
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- Egr mass flow rate low, diagnostic trouble code
- Bulletin:
- FSB 431-010
- Component:
- 350000 equipment
- Summary:
- Range synchronizer, repair
- Bulletin:
- FSB 293-012
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- Exhaust gas recirculation, part update
- Bulletin:
- FSB 811-005
- Component:
- 350000 equipment
- Summary:
- Floor cracks repair (front panel)
- Bulletin:
- FSB 593-012
- Component:
- 113100 electrical system:starter assembly:solenoid
- Summary:
- Hill start assist solenoid, replacement
- Bulletin:
- FSB 215-003
- Component:
- 350000 equipment
- Summary:
- Timing plate flange screw
- Bulletin:
- FSB 284-057
- Component:
- 060000 engine (pws)
- Summary:
- High soot output
- Bulletin:
- FSB 222-004
- Component:
- 060000 engine (pws)
- Summary:
- Oil filter housing
- Bulletin:
- FSB 262-005
- Component:
- 060000 engine and engine cooling
- Summary:
- Coolant bypass housing seal
- Bulletin:
- FSB 432-013
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Amt high range cone replacement
- Bulletin:
- FSB 801-003
- Component:
- 162300 structure:body:door
- Summary:
- Service door rust prevention
- Bulletin:
- FSB 593-012
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Hill start assist solenoid, replacement
- Bulletin:
- FSB 234-018
- Component:
- 070000 fuel system, gasoline
- Summary:
- Single fuel tank ventilation filter kit
- Bulletin:
- FSB 234-019
- Component:
- 070000 fuel system, gasoline
- Summary:
- Dual fuel tanks ventilation filter kit
- Bulletin:
- FSB 293-024
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- Exhaust gas recirculation (egr) differential pressure sensor
- Bulletin:
- FSB 293-026
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Exhaust gas recirculation (egr) differential pressure sensor
- Bulletin:
- FSB 284-059
- Component:
- 110000 electrical system
- Summary:
- Nox sensor signal
- Bulletin:
- FSB 210-045
- Component:
- 110000 electrical system
- Summary:
- Regeneration in pto mode
- Bulletin:
- FSB 222-004
- Component:
- 060000 engine (pws)
- Summary:
- Oil filter housing
- Bulletin:
- FSB 593-012
- Component:
- 113100 electrical system:starter assembly:solenoid
- Summary:
- Hill start assist solenoid, replacement
- Bulletin:
- FSB 293-022
- Component:
- 060000 engine (pws)
- Summary:
- In the event that an egr temperature sensor replacement is required on a volvo d13h engine, a new routing configuration is required.
- Bulletin:
- SP 398-001
- Component:
- 110000 electrical system
- Summary:
- On some trucks with the telematics gateway (tgw) system, the tgw control unit may not correctly communicate with the vehicle systems after restarting.
- Bulletin:
- K24483157
- Component:
- 110000 electrical system
- Summary:
- Diagnostic trouble codes ( dtc ) p208e and p103b logging with possible derate (scr inducement ) - us13 emissions and newer
- Bulletin:
- K91214678
- Component:
- 100000 power train
- Summary:
- Automated manual transmission ( amt ) faults - diagnostic trouble codes ( dtcs ) p1052 - 18 , pid 33 fmi 5 intermittent fault in cold weatherupdated with new information and procedure
- Bulletin:
- K04596533
- Component:
- 271000 lane departure: warning
- Summary:
- "volvo chassis - equipped with volvo active driver assist ( vada ), with or without lane departure warning ( ldws ) - diagnostic trouble code ( dtc ) spn 70 mi 9, bendix code 64 with possible ""lane departure warning malfunction"" message
- Bulletin:
- K42708399
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Diagnostic trouble code ( dtc ) p0422 lighting the malfunction indicator light ( mil ) - obd15 and obd16 chassis (non-common rail)updated to reflect release of fsb284-064 (above)
- Bulletin:
- K84412328
- Component:
- 120000 exterior lighting
- Summary:
- Diagnostic trouble code ( dtc ) p249c intermittently lighting the malfunction indicator lamp ( mil ) - obd15 and obd16, model year ( my ) 2016 and 2017 chassisupdated to reflect release of fsb284-064 (above)
- Bulletin:
- K03179378
- Component:
- 090000 fuel system, other
- Summary:
- Service only regen requested with no warning. active fault codes p24a4 / p10fe - obd15 and obd16 chassis; does not apply to us17 (common rail fuel system) chassisupdated to reflect release of fsb284-064 (above)
- Bulletin:
- K15164821
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Volvo chassis - diagnostic trouble code ( dtc ) p2002, diagnostic information - obd13 and newerupdated to reflect release of fsb284-064 (above)
- Bulletin:
- K27690302
- Component:
- 120000 exterior lighting
- Summary:
- Volvo chassis - diagnostic trouble code ( dtc ) p226c intermittently lighting the malfunction indicator lamp ( mil ) - obd15 and obd16 conventional chassisupdated to reflect release of fsb284-064 (above)
- Bulletin:
- K86412082
- Component:
- 110000 electrical system
- Summary:
- Engine diagnostic trouble codes ( dtc's ) p24a0 and p249f lighting the malfunction indicator lamp ( mil ) - obd15 (commonly model year 2016) and newerupdated to reflect release of fsb284-064 (above)
- Bulletin:
- K05680314
- Component:
- 270000 lane departure
- Summary:
- Volvo chassis - equipped with volvo active driver assist ( vada ), with or without lane departure warning ( ldws ) - diagnostic trouble code ( dtc ) spn 516103 fmi 19, bendix code 167 with possible "lane departure warning malfunction" messa
- Bulletin:
- K82320750
- Component:
- 103000 power train:automatic transmission
- Summary:
- Automated manual transmission ( amt - f ) ( i-shift) clutch valve unit ( cvu ) makes intermittent buzzing noise with the key on and engine offchanged repair information to reflect new software available.
- Bulletin:
- K97651904
- Component:
- 117000 digital instrument panel
- Summary:
- Volvo chassis - diagnostic trouble code ( dtc ) p2459 lighting the malfunction indicator lamp ( mil ); possible frequent regeneration requests - obd15 and newer chassisupdated to reflect release of fsb284-064 (above)
- Bulletin:
- K14637412
- Component:
- 073100 fuel system, gasoline:fuel injection system:fuel rail
- Summary:
- Diagnostic trouble code ( dtc ) p0194 - 00 - fuel rail pressure sensor ( rps ), circuit erratic, intermittent - us17 ( ghg17 ) emissions and newer ( common rail fuel system ); common model years 2017 and 2018changed repair instructions to r
- Bulletin:
- FSB284-064
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Ecm and acm reprogramming, obd2015
- Bulletin:
- K14701433
- Component:
- 073100 fuel system, gasoline:fuel injection system:fuel rail
- Summary:
- Diagnostic trouble code ( dtc ) p009e - 73 - fuel pressure relief control performance / stuck off - ghg17 ( us17 ) chassis with common rail fuel systemchanged repair instructions to reflect new procedures
- Bulletin:
- SERVICE INSTRUCT
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Supplier service bulletin sent to customers regarding potential brake caliper issue.
- Bulletin:
- FSB216-002
- Component:
- 060000 engine (pws)
- Summary:
- Flywheel resurfacing guidelines, i-shift
- Bulletin:
- K52326370
- Component:
- 073100 fuel system, gasoline:fuel injection system:fuel rail
- Summary:
- Volvo chassis - diesel exhaust fluid ( def ) contamination in fuel system, inspection and repair - us10 to us14 ( non-common rail fuel system ) removed information for common rail chassis - now has its own solution.
- Bulletin:
- K97651904
- Component:
- 060000 engine (pws)
- Summary:
- Volvo chassis - diagnostic trouble code ( dtc ) p2459 lighting the malfunction indicator lamp ( mil ); possible frequent regeneration requests - obd15 and us14+obd16 (non-common rail) chassis, changed repair instructions to reflect obd16 so
- Bulletin:
- K24400052
- Component:
- 013000 steering:gear box (other than rack and pinion)
- Summary:
- Volvo chassis - equipped with an automated manual transmission (amt, i-shift ) - error code 126 displayed in premium tech tool (ptt ) while performing the calibration procedure after the shift control housing has been removed and installed,
- Bulletin:
- K24483157
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- Diagnostic trouble codes ( dtc ) p208e and p103b logging with possible derate ( scr inducement ) - obd15, us14+obd16 emissions and newer rewrote test procedure for better clarity.
- Bulletin:
- K14701433
- Component:
- 080000 fuel system, diesel
- Summary:
- Diagnostic trouble code ( dtc ) p009e - 73 - fuel pressure relief control performance / stuck off - ghg17 ( us17 ) chassis with common rail fuel system, updated to reflect ghg17 software release
Home | Privacy