2008 FREIGHTLINER FLD120SD Recalls (3)
- Campaign:
- 07V302000 on 07/15/2007
- Component:
- Service brakes, air:supply:check valve
- Manufactured:
- 06/30/2002 - 07/02/2007
- Affected:
- 75,000
- Defect:
- Certain freightliner school bus chassis, heavy trucks, and thomas built school buses manufactured between july 2002 and july 3, 2007, equipped with bendix sr-7 spring brake control valves. the parker scv brass 90 degree single check valves (scv) which attach to the supply port of a bendix sr-7 spring brake modulating valve can break apart. pieces of the parker scv can become lodged inside the sr-7 spring brake modulating valve, potentially causing either leakage out of the sr-7 valve or preventing air from properly exhausting from the sr-7 valve. also, due to a manufacturing defect in the internal rubber check valve inside the sr-7 spring brake modulating valves, the valves can become deformed and not seat properly.
- Consequence:
- These conditions could either result in leakage and cause a delay in the application of the spring brake without warning or possibly lead to unintended vehicle rollaway or brake drag which could result in a vehicle crash, personal injury, or death.
- Correction:
- Freightliner will notify owners and repair the vehicles free of charge. the recall began on january 11, 2008 to freightliner, sterling, and freightliner custom chassis owners; to thomas built bus owners on february 1, 2008. owners can contact freightliner at 1-800-547-0712.
- Notes:
- Freightliner recall no. fl-504.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 07V306000 on 07/17/2007
- Component:
- Steering
- Manufactured:
- 01/04/2007 - 05/16/2007
- Affected:
- 18,000
- Defect:
- Freightliner is recalling certain school bus chassis, heavy trucks, van chassis, rv motorhome chassis manufactured from january 5 to may 17, 2007, equipped with axle alliance company (aac) front axles. during the front axle assembly, the fasteners that attach the steering arm or tie rod arms to the spindle may be over or under tightened.
- Consequence:
- Incorrectly tightened steering arm fasteners may fatigue and fracture which could cause a crash without warning.
- Correction:
- Thomas built will notify owners, inspect the fasteners, and replace the steering arm if necessary. the recall began on december 21, 2007. owners can contact freightliner at 1-800-547-0712.
- Notes:
- Freightliner recall no. fl-501.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 07V316000 on 07/23/2007
- Component:
- Suspension:rear
- Manufactured:
- 10/31/2006 - 11/29/2007
- Affected:
- 1,200
- Defect:
- On certain trucks equipped with tuftrac rear suspensions, the center casting brackets may be out of specification. an out of square casting may have unacceptable stress in the bracket when it is installed and may cause it to crack in service.
- Consequence:
- The drive axle may not be held in position if a cracked bracket fractures completely. this will affect vehicle control and may cause a crash without warning.
- Correction:
- Dealers will inspect and castings that are out of specification will be replaced free of charge. the recall began on december 12, 2007. owners may contact freightliner at 1-800-547-0712.
- Notes:
- Freightliner recall no. fl-502.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Home | Privacy