2008 FORD F-250 SD Recall
- Campaign:
- 08E026000 on 03/30/2008
- Component:
- Equipment
- Affected:
- 338
- Defect:
- Truxxx is recalling 338 aftermarket replacement welded 3" lift blocks for rear suspensions, part no. 206073, included in suspension kit nos. 108035 and 108036, sold between july 26, 2007 and march 4, 2008, for use on ford my 2005-2008 f-250 superduty 4x4 light trucks. compressive forces of the welded lift blocks resulting from foreseeable and excess vehicle payloads as well as over-tightening of the u-bolts during installation may distort the blocks, reducing the intended clamping force of the u-bolts.
- Consequence:
- This could allow possible shifting and damage to the rear drive shaft and axle.
- Correction:
- Truxxx will notify customers/installers and will replace affected welded lift blocks with either non-welded aluminum or cast iron blocks free of charge. the recall is expected to begin on or about april 16, 2008. owners may contact truxxx at 1-800-381-8320.
- Notes:
- Truxxx recall no. 08-01blk.this recall only pertains to aftermarket suspension kits and has not relation to any original equipment installed on ford motor company vehicles.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
2008 FORD F-250 SD TSBs (76)
- Bulletin:
- 19612
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Malfunction indicator lamp on with code p132b. *kb
- Bulletin:
- 19614
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Air filter water ingestion / snow packing with codes p0103. *kb
- Bulletin:
- 19620
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Injector circuit open codes p0201, p0202, p0203, p0204, p0205, p0206, p0207, p0208 with a misfire / rough running / lack of power condition. *kb
- Bulletin:
- 19621
- Component:
- 070000 fuel system, gasoline
- Summary:
- Lack of power due to low fuel pressure, fuel tank liner seperation. *kb
- Bulletin:
- 19622
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Ids unable to communicate with the pcm. *kb
- Bulletin:
- 06221
- Component:
- 103000 power train:automatic transmission
- Summary:
- Helix angle and tooth pressure angle count and look the same. installing a z92 gear on this transmission will result in premature failure. *kb updated 12/12/07. *nj
- Bulletin:
- 0791
- Component:
- 120000 exterior lighting
- Summary:
- Lighting on snow plow equipped vehicles. *kb
- Bulletin:
- 19768
- Component:
- 120000 exterior lighting
- Summary:
- Stop/turn lamp separation. *kb
- Bulletin:
- 19703
- Component:
- 135200 visibility:rearview mirrors/devices:exterior
- Summary:
- Power folding mirror. *kb
- Bulletin:
- 19704
- Component:
- 114000 electrical system:wiring
- Summary:
- Wiring fault on trailer, displayed in message center with dtc c2806. *kb
- Bulletin:
- 19715
- Component:
- 117000 digital instrument panel
- Summary:
- Instrument panel lights dim - spdjb must learn resistance values of dimmer. *kb
- Bulletin:
- 19728
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Lack of power due to low fuel pressure - fuel tank liner seperation. *kb
- Bulletin:
- 19730
- Component:
- 114000 electrical system:wiring
- Summary:
- Wiring fault on trailer displayed in message center with dtc c2806. *kb
- Bulletin:
- 0772
- Component:
- 022000 suspension:rear
- Summary:
- Rear of vehicle is too high/low -5th wheel and goose neck applications. *kb
- Bulletin:
- 0777
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Exhaust smoke from front of vehicle. exhaust odor inside the vehicle. *kb
- Bulletin:
- 19807
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Air induction snow restriction. vehicle operated in heavy snow conditions may experience a lack of power during acceleration. this could cause the check air filter message on dash. *nj
- Bulletin:
- 19813
- Component:
- 073000 fuel system, gasoline:fuel injection system
- Summary:
- Injector circuit open- dtc(s) p0201-p0208 with a misfire/rough running/lack of power condition. *nj
- Bulletin:
- 071110
- Component:
- 040000 service brakes, air
- Summary:
- Brake booster system may exhibit a brake pedal kickback and/or grabbing condition when applying the brakes. *nj
- Bulletin:
- 0707
- Component:
- 080000 fuel system, diesel
- Summary:
- In some of the affected vehicles, three fuel injectors were subjected to a reverse polarity voltage during engine testing that may have damaged the injector resulting in reduced fuel flow. this may potentially cause the vehicle to run roug
- Bulletin:
- 19817
- Component:
- 045000 service brakes, air:disc
- Summary:
- 2008 f-super duty - soft or increased brake pedal travel - perform both master cylinder bypass test and pinpoint test f. *nj
- Bulletin:
- 19815
- Component:
- 092100 fuel system, other:delivery:fuel pump
- Summary:
- 2008 f-super duty - 6.4l diesel engine - the fuel cooling pump noise. *nj
- Bulletin:
- 19849
- Component:
- 073200 fuel system, gasoline:fuel injection system:injectors
- Summary:
- Uvc 15-way connections that are secured by an o-ring. *nj
- Bulletin:
- 19852
- Component:
- 114000 electrical system:wiring
- Summary:
- Wiring fault on trailer displayed in message center with dtc c2806. *nj
- Bulletin:
- 789
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Installation location for all 2008 ford super duty trucks (isolation module). western products. *nj
- Bulletin:
- 003
- Component:
- 980000 unknown or other
- Summary:
- Isolation module - installation location for all 2008 ford super duty trucks. blizzard snowplows. *nj
- Bulletin:
- 19786
- Component:
- 091200 fuel system, other:storage:fuel gauge system
- Summary:
- Distance to empty (dte) and fuel gauge service tip. *nj
- Bulletin:
- 004
- Component:
- 980000 unknown or other
- Summary:
- Blizzard snowplows - on 2008 ford super duty trucks (snowplow headlamp switch operation w/snowplow headlamps connected (6-pin headlamp kit). *nj
- Bulletin:
- 07238
- Component:
- 063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
- Summary:
- Diesel exhaust modification on 2008 ford super duty f-series for mpl series wreckers. *nj
- Bulletin:
- 19918
- Component:
- 114000 electrical system:wiring
- Summary:
- (wiring fault on trailer) displayed in message center with dtc c2806 - my 2008 f-super duty. *nj
- Bulletin:
- 07166
- Component:
- 115000 electrical system:fuses and circuit breakers
- Summary:
- The 2008 f-super duty vehicle is equipped w/ a smart junction box (sjb) or generic electronic module (gem) and its function is to provide protection against excessive current loads, typical of a short circuit, by shutting down circuit opera
- Bulletin:
- 19967
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- 2008 f-super duty - 6.4l air induction snow restriction. *nj
- Bulletin:
- 19891
- Component:
- 103000 power train:automatic transmission
- Summary:
- Some 2008 f-super duty - gas engines/torqshift with water in the transmission. *nj
- Bulletin:
- 19891
- Component:
- 114000 electrical system:wiring
- Summary:
- Some 2008 f-super duty - wiring fault on trailer displayed in message center with dtc c2806. *nj
- Bulletin:
- 19989
- Component:
- 102000 power train:manual transmission
- Summary:
- 2005-2008 f-super duty manual transmission- clutch pedal concern. *nj
- Bulletin:
- 20020
- Component:
- 080000 fuel system, diesel
- Summary:
- Some 2008 f-super duty - 6.4l diesel egr valve and dpf failures due to high sulfur diesel fuel. *nj
- Bulletin:
- 20052
- Component:
- 104000 power train:transfer case (4-wheel drive)
- Summary:
- 1999-2008 f250-f550 super duty 4x4 with electronic shift transfer case not engaging 4x4. *nj
- Bulletin:
- 07192
- Component:
- 015300 steering:hydraulic power assist:power steering fluid
- Summary:
- Some 2008 f-super duty vehicles built before 5/10/07 and equipped with a 5.4l or 6.8l engine and single rear wheels (srw), with a customer concern of power steering pump noise while driving and with hotter than normal powering steering flu
- Bulletin:
- 20124
- Component:
- 013100 steering:gear box:shaft sector
- Summary:
- 2008 e-series and f-series super duty - steering gear leak. *nj
- Bulletin:
- 20127
- Component:
- 062200 engine and engine cooling:cooling system:fan
- Summary:
- 2008 f-series super duty diesels exhibiting dtc p0528 due to snow plow installation on vehicles without factory installed snow plow package. *nj
- Bulletin:
- 20129
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- 2008 f-super duty 6.4l diesel - mil, p006b, p2563, p2263 with or without a drivability complaint. *nj
- Bulletin:
- 20131
- Component:
- 115000 electrical system:fuses and circuit breakers
- Summary:
- 2008 f-super duty 6.4l diesel - vref codes p1335, p0193, p0642, p0643, or p0652. *nj
- Bulletin:
- 08-4-8
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- 6.4l air induction system restriction--snow--built before 9/18/2007. *nj
- Bulletin:
- 20170
- Component:
- 980000 unknown or other
- Summary:
- 2008 f-super duty 6.4l - p040d dtc with a lack of power or lack of boost. *nj
- Bulletin:
- 20228
- Component:
- 061320 engine and engine cooling:engine:other fuel types:turbo-charger
- Summary:
- 1999-2008 7.3l/6.0l/6.4l/4.5l diesel f-super duty - clean the charge air cooler (cac) system after certain turbo or engine failures - service tip. *nj
- Bulletin:
- 20232
- Component:
- 102000 power train:manual transmission
- Summary:
- 2005-08 f250-550 super duty manual transmission - clutch pedal concern. *nj
- Bulletin:
- SSI-08-T-01
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Ford super duty: demonstration/delivery hold s008 f super duty vehicles; 6/4l diesel engine cooling system venturi tee installation upgrade. affected vehicles, the radiator may develop cracks from a reverse flow of coo air/coolant from the
- Bulletin:
- TSB-08-10-2
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Ford: 6.4l diesel engine. vehicles built between 1/3/08 and 5/5/08 diagnostic trouble codes (dtcs) p0128, p0196, p1335, p0404 and p0406. *pe
- Bulletin:
- TSB-08-18-6
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Ford truck: some trucks equipped with a 6.0l diesel engine may exhibit a hard start/long crank or no start condition due to low injection control pressure (icp). *pe
- Bulletin:
- CSP-08B06
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Ford service campaign: see document search button for owner letter. certain 2008 model year f super duty vehicles equipped with a 6.4l diesel engine cooling system venturi tee installation. *pe updated 5/5/09. csc letter was rec
- Bulletin:
- LP-09L02
- Component:
- 011000 steering:wheel and handle bar
- Summary:
- Ford trucks service campaign: see document search button for owner letter. vehicles have experienced severe steering wheel and front wheel vibrations and oscillations after traveling over a bump or dip in the road. models 2006 f-250/350 su
- Bulletin:
- TSB-09-4-9
- Component:
- 200000 wheels
- Summary:
- Ford: some vehicles with single rear wheels and dual rear wheel may exhibit an excessive drive away shudder or vibration under moderate to heavy acceleration from a stop, especially when heavily loaded. *pe
- Bulletin:
- SB-20720
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Ford sd trucks; this non mil dtc will be stored in the powertrain control module (pcm) when the engine oil temperature (eot), engine coolant temperature (ect) and intake air temperature (iat) are below -15f (-26c) at start up and engine blo
- Bulletin:
- TSB-09-16-10
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Ford: some vehicles equipped with a 6.4l diesel engine and built between 8/3/07 and 1/2/08 may require a calibration update which will cover several different concerns. *pe
- Bulletin:
- TSB-09-16-9
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Ford: some vehicles equipped with a 6.4l diesel engines and built prior to 8/2/07 may require a calibration update which will cover several different concerns. *pe
- Bulletin:
- TSB-09-16-7
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Ford service campaign: see document search button for owner letter.some vehicles equipped with a 6.4l diesel engine may require a calibration update which will cover several different concerns. *pe
- Bulletin:
- TSB-09-20-12
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Ford: some super duty trucks equipped with a 5.4l 3v or 6.8l 3v engine may experience premature automatic shut off of the fuel fill nozzle. *pe
- Bulletin:
- TSB-09-20-5
- Component:
- 105000 power train:driveline
- Summary:
- Ford: shudder or vibration on acceleration, especially when loaded. some super duty vehicles with single rear wheels (srw) and dual rear wheel (drw) may exhibit an excessive drive away shudder or vibration under moderate to heavy accelera
- Bulletin:
- SB-21410
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Ford: some trucks with 6.4l engine will run rough, smokes, or no start due to gasoline or alcohol in the fuel. gasoline/alcohol lack the lubricity of diesel fuel and will cause fuel system failure. *pe
- Bulletin:
- SB-21434
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Ford: supply/return lines installation at high pressure pump-revised washer for trucks equipped with 6.4l engines. when installing supply or return lines at high pressure pump on diesel engines, do not use the bonded style washer (w302870)
- Bulletin:
- CSP-10M05
- Component:
- 063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
- Summary:
- Ford service campaign: see document search button for owner letter. catalyst y pipe warranty extension.. in some of the affected vehicles, certain vehicle operating conditions can cause the catalyst substrate to crack or melt. this can ca
- Bulletin:
- TSB-11-4-22
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Ford: some ford super duty trucks may exhibit a lack of power with a diagnostic trouble code during acceleration. *rm
- Bulletin:
- TSB-11-4-15
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Ford: some ford super duty trucks may exhibit a lack of power with a diagnostic trouble code at full operating temperature during acceleration. *rm
- Bulletin:
- AS-21769
- Component:
- 046000 service brakes, air:antilock
- Summary:
- Ford: if there is an intermittent lack of power, surge, or hesitation while driving the brakes will override acceleration. *rm
- Bulletin:
- TSB-10-23-6
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Ford: the malfunction light may be on with a lack of power. htere may be mulitple trouble codes stored. 2008 f-250/350/450/550. *rm
- Bulletin:
- CSP-11B23
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Ford service campaign: see document search button for owner letter. there are multiple problems with the vehicle. possibliy including: malfunction light on, runs rough, reduced power, excessive smoke from the exhaust, fuel smell from the cr
- Bulletin:
- ASI-22277
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Ford: some trucks may exhibit a situation with diesel engine such as engine knocking, low power, exhaust smoke, long or no crank start and runs rough. *pe
- Bulletin:
- TSB-13-6-7
- Component:
- 350000 equipment
- Summary:
- Ford: when turning, there is a popping or clunking noise that is heard or felt, under floor pan, in some vehicles and more noticeable when weather is cold. model 2008-2012 f-super duty. *pe
- Bulletin:
- TSB-14-0114
- Component:
- 060000 engine (pws)
- Summary:
- Lincoln/ford: when driving from idle up to 1200 rpm, there may be an intermittent rattle noise coming from engine. 2004-2013 f-150, f-250, f-350, expedition, mark lt, navigator. *pe
- Bulletin:
- ASI-44534
- Component:
- 103000 power train:automatic transmission
- Summary:
- Ford: when shifting between park, reverse and/or during 2-3 shift, an intermittent clunk occurs with a torqshift transmission. model 2003-2014 f-super duty, e series, excursion, f-53 motorhome chassis, low cab forward. *p
- Bulletin:
- ASI-44664
- Component:
- 063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
- Summary:
- Ford: there are exhaust leaks, caused by warped exhaust manifold, experience by diesel engine. model 2008-10 f super duty. *pe
- Bulletin:
- ASI-44716
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Ford: due to restrictions from cooling system contamination, diesel engine oil coolers primarily are being replaced because of other components in cooling system. model 2008-10 f-super duty. *pe
- Bulletin:
- ASI-49219
- Component:
- 350000 equipment
- Summary:
- Ford: after rocker pedestal replacement, some diesel trucks are experiencing knocking engine, rough runs, hard start, crank no start because of improper pedestal height causing to hang open the intake or exhaust valves. model 2008-10 f su
- Bulletin:
- ASI-45219
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Ford: diesel engine runs rough, engine knocking, hard start, crank but no start due to height of improper pedestal that causes exhaust or intake valves be hung open. model 2008-10 f super duty. *pe
- Bulletin:
- SSM 46345
- Component:
- 350000 equipment
- Summary:
- Some 2005-2017 f-super duty 4x4 vehicles operated in extreme dust, mud or tar sand conditions may exhibit accelerated 4x4 vacuum hub seal and or wheel bearing wear as a result of harsh operating conditions. a knuckle seal shield kit is now
- Bulletin:
- SSM 47009
- Component:
- 353000 equipment:electrical
- Summary:
- The accessory (wireless) keyless entry keypad can only be used with vehicles that are factory built with remote keyless entry (rke). the master code for the accessory (wireless) keyless entry keypad can be retrieved from fmcdealer - parts a
- Bulletin:
- DOR-B8H4Z-11
- Component:
- 010000 steering
- Summary:
- This sku is a front upper ball joint. the customer communication requested return of unsold inventory to inspect for ball studs with excessive rotational friction in the ball joint assembly. excessive friction in the ball joint assembly ma
Home | Privacy