2007 HINO NB6J Recalls (4)
- Campaign:
- 06V169000 on 05/17/2006
- Component:
- Steering:linkages
- Manufactured:
- 09/30/2004 - 03/24/2006
- Affected:
- 5,072
- Defect:
- On certain trucks, during assembly, the drag link attachment nuts at the pitman arm and steering arm may have been incorrectly torqued. residual grease and paint which was applied as a rust inhibitor on the steering arm may have contributed to a loss of torque after assembly.
- Consequence:
- Increased wear for the draglink connections can occur creating a noticeable increase in the amount of steering wheel free play. if this condition was ignored, a loss of steering control of the vehicle could occur which could result in a crash.
- Correction:
- Dealers will inspect the steering arm tightness and remove all grease and paint from the steering arms and retorque the draglink attachment nuts at the steering arm and pitman arm. the recall began on may 12, 2006. owners may contact hino at 1-248-648-6430.
- Notes:
- Hino recall no. m0050.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
- Campaign:
- 08V195000 on 04/29/2008
- Component:
- Suspension:front
- Affected:
- 16,805
- Defect:
- Hino is recalling 16,805 my 2005-2008 na6j, nb6j, nc6j, nd8j, ne8j, nj8j, and nv8j trucks. the two vertical right/left side front spring bracket bolts were not tightened properly during the assembly process. this may cause increased stress on the spring bracket which can lead to cracking of the bracket.
- Consequence:
- This could reduce steering control increasing the risk of a crash.
- Correction:
- Dealers will replace the vertical front spring bracket attachment bolts on right/left hanger brackets and re-torque all associated bolts free of charge. the recall began on september 8, 2008. owners may contact hino at 248-699-9300.
- Notes:
- Hino recall no. a5850.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
- Campaign:
- 12V555000 on 12/03/2012
- Component:
- Electrical system:battery:cables
- Manufactured:
- 08/17/2003 - 11/15/2011
- Affected:
- 35,142
- Defect:
- Hino is recalling certain model year 2005 through 2013 medium duty trucks, models na6j, nb6j, nc6j, nd8j, ne8j, nj8j, nf8j, and nv8j, manufactured from august 18, 2003, through november 16, 2011. over time, the main b+ circuit from the battery to the starter could potentially short to ground due to wear that accumulates as a result of interference between the b+ circuit and its convoluted tubing sheath.
- Consequence:
- If the b+ circuit shorts to ground, it may lead to a fire.
- Correction:
- Hino will notify owners, and dealers will repair the vehicles free of charge. the recall began on january 17, 2013. owners may contact hino at 1-248-699-9390.
- Notes:
- Hino's recall campaign number is a8310.owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
- Campaign:
- 12V555000 on 12/03/2012
- Component:
- Electrical system:wiring
- Manufactured:
- 08/17/2003 - 11/15/2011
- Affected:
- 35,142
- Defect:
- Hino is recalling certain model year 2005 through 2013 medium duty trucks, models na6j, nb6j, nc6j, nd8j, ne8j, nj8j, nf8j, and nv8j, manufactured from august 18, 2003, through november 16, 2011. over time, the main b+ circuit from the battery to the starter could potentially short to ground due to wear that accumulates as a result of interference between the b+ circuit and its convoluted tubing sheath.
- Consequence:
- If the b+ circuit shorts to ground, it may lead to a fire.
- Correction:
- Hino will notify owners, and dealers will repair the vehicles free of charge. the recall began on january 17, 2013. owners may contact hino at 1-248-699-9390.
- Notes:
- Hino's recall campaign number is a8310.owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
2007 HINO NB6J TSBs (31)
- Bulletin:
- 167-P0701-12
- Component:
- 061320 engine and engine cooling:engine:other fuel types:turbo-charger
- Summary:
- Introduction of exchange turbocharger program. hino trucks is pleased to announce the introduction of the turbocharger exchange program for its 2005 ? 2008 model year trucks. effective june 21, 2007, the following turbocharger part numbers
- Bulletin:
- 167-P0702-12
- Component:
- 072100 fuel system, gasoline:delivery:fuel pump
- Summary:
- Revised warranty process ? denso fuel pumps & injector nozzles exchange denso fuel pumps & injector nozzles. effective immediately, fuel pumps and injector nozzles replaced under warranty are to be purchased from the memphis pdc. it is no
- Bulletin:
- 167-P0703-12
- Component:
- 061320 engine and engine cooling:engine:other fuel types:turbo-charger
- Summary:
- Tb-001-07 hino uses both davco and racor fuel/water separators on its vehicles. to determine the correct filter you must know which one is on the vehicle. the davco is shown on the left. the racor is shown on the right and has a primer butt
- Bulletin:
- 167-P0704-12
- Component:
- 356000 equipment adaptive
- Summary:
- Tb-04-07 an engineering change in connecting rods was made from a stud with nuts to fasten the cap, to a bolt only to fasten the cap. the connecting rods with the stud and nuts are no longer available. the two different styles are intercha
- Bulletin:
- 167-P0802-12
- Component:
- 021240 suspension:front:springs:leaf spring assembly
- Summary:
- Ptb 03-08 spring assemblies.
- Bulletin:
- 167-P0803-12
- Component:
- 060000 engine (pws)
- Summary:
- Ptb 01-08 complete engine assembly part numbers
- Bulletin:
- 167-P0805-12
- Component:
- 200000 wheels
- Summary:
- Ptb 08-08 2005-2008 quick reference guide correction to page 60
- Bulletin:
- 167-P1602-12
- Component:
- 060000 engine (pws)
- Summary:
- 13-008 injection pump drive case. please note the following part number changes to the injection pump bearing case. not replacing the correct replacement parts will result in major engine damage. the hino ordering system has been modified
- Bulletin:
- 167-B0502-12
- Component:
- 110000 electrical system
- Summary:
- Sb - 05 - 004 speedometer recalibration. this document is to inform of the procedure to calibrate the pulse adjust module whenneeded (ex. tire size change, rear carrier ratio change).
- Bulletin:
- 167-B0504-12
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Sb - 05 - 003 this document is to inform dealers and workshops on procedures to activate exhaust brake operation.
- Bulletin:
- 167-B0508-12
- Component:
- 106000 power train:axle assembly
- Summary:
- Sb - 05 - 005 proper maintenance procedures for grease lubricated front axles
- Bulletin:
- 167-B0509-12
- Component:
- 103000 power train:automatic transmission
- Summary:
- Sb ? 05 - 006 upon removal of a transmission assembly from the vehicle, inspection is required to confirm the presence and correct installation of the two dowel pins in the rear engine housing. in some rare cases one or both dowel pins may
- Bulletin:
- 167-B0601-12
- Component:
- 060000 engine and engine cooling
- Summary:
- Sb ? 06 - 001 design change of engine oil cooler housing. the casting for the engine oil cooler housing has been revised to include 2 shallow machined grooves on both sides of the engine oil cooler housing. these grooves aid in the retentio
- Bulletin:
- 167-B0602-12
- Component:
- 061320 engine and engine cooling:engine:other fuel types:turbo-charger
- Summary:
- Sb ? 06 - 002 fuel filter usage. this bulletin provides technical information for proper fuel filter usage as well as an example of damage caused by foreign material allowed to enter the fuel system as a result of using an improper fuel fil
- Bulletin:
- 167-B0702-12
- Component:
- 021600 suspension:front:wheel bearing
- Summary:
- Sb - 07 - 005 the document is to inform the dealers about the change in material and tightening torque of the rocker arm support bolts and camshaft bearing cap bolts.
- Bulletin:
- 167-B0803-12
- Component:
- 203000 wheels:lugs/nuts/bolts
- Summary:
- Sb - 08 - 005 this document is to inform dealers and workshops of the design change to the hood damper, support bolt and the addition of a support collar.
- Bulletin:
- 167-T0603-12
- Component:
- 350000 equipment
- Summary:
- 06 - 008 abs extension harness no throttle response on 2007 air brake chassis with automatic transmissions when selector placed in drive. no cruise control on 2007 air brake chassis with manual transmissions.
- Bulletin:
- 167-T0605-12
- Component:
- 090000 fuel system, other
- Summary:
- 06 - 010 low power (fuel restriction)
- Bulletin:
- 167-T0606-12
- Component:
- 092100 fuel system, other:delivery:fuel pump
- Summary:
- 06-011 high pressure fuel pump front seal failure
- Bulletin:
- 167-B1415-12
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Sb-14-003 the following is to inform you of the revision of the inspection procedure for the dtc?s p0340 and p0341. you are kindly requested to attach this service data to the relevant pages of the workshop manuals for maintenance and to us
- Bulletin:
- 167-B1509-12
- Component:
- 113000 electrical system:starter assembly
- Summary:
- Sb-15-009 this bulletin provides the corrective action for a fluid overflow condition from the main housing breather at startup in cold ambient temperatures at or below +5f (-15c).
- Bulletin:
- 167-B1523-12
- Component:
- 060000 engine and engine cooling
- Summary:
- Sb-15-026 a subject vehicle may exhibit an engine oil leak or engine coolant leaking externally from the engine head gasket sealing area on the exhaust manifold side of the engine. an improved head gasket has been made available as a servic
- Bulletin:
- 167-B1307-12
- Component:
- 103300 power train:automatic transmission:gear position indication (prndl)
- Summary:
- 13-008 design change of the idler gear case and idler gear bolt. abnormal load such as a stuck supply pump was applied to gear train then causing the bolt to loosen. therefore, an enhancement to the case and bolt were carried out. the idle
- Bulletin:
- 167-B1312-12
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Sb-13-009 this bulletin is to inform dealers and workshops of proper paint codes for all hino models. all models
- Bulletin:
- 167-T0703-12
- Component:
- 210000 trailer hitches
- Summary:
- 07 - 003 electric trailer brake controller application
- Bulletin:
- 167-T0704-12
- Component:
- 200000 wheels
- Summary:
- 07 - 004 abs wheel sensor (active fault 3-1 thru 3-4)
- Bulletin:
- 167-T0705-12
- Component:
- 125100 exterior lighting:brake lights:switch
- Summary:
- 07 - 005 no throttle response (brake light switch)
- Bulletin:
- 167-T0706-12
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- 07 - 006 voltage drop test
- Bulletin:
- 167-T0707-12
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- 07 - 008 dx report ? exporting, saving and printing from past work information
- Bulletin:
- 167-T0708-12
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- 06 - 012 speedometer pulse adapter conversion form
- Bulletin:
- 167-T1514-12
- Component:
- 162000 structure:body
- Summary:
- Tt-15-016 the purpose of this publication is to communicate the standard measuring positions on the hino chassis. in some cases, the customer may report a visual chassis posture concern where the chassis appears to be leaning more towards t
Home | Privacy