2007 FORD F-250 SD Recalls (3)
- Campaign:
- 08E026000 on 03/30/2008
- Component:
- Equipment
- Affected:
- 338
- Defect:
- Truxxx is recalling 338 aftermarket replacement welded 3" lift blocks for rear suspensions, part no. 206073, included in suspension kit nos. 108035 and 108036, sold between july 26, 2007 and march 4, 2008, for use on ford my 2005-2008 f-250 superduty 4x4 light trucks. compressive forces of the welded lift blocks resulting from foreseeable and excess vehicle payloads as well as over-tightening of the u-bolts during installation may distort the blocks, reducing the intended clamping force of the u-bolts.
- Consequence:
- This could allow possible shifting and damage to the rear drive shaft and axle.
- Correction:
- Truxxx will notify customers/installers and will replace affected welded lift blocks with either non-welded aluminum or cast iron blocks free of charge. the recall is expected to begin on or about april 16, 2008. owners may contact truxxx at 1-800-381-8320.
- Notes:
- Truxxx recall no. 08-01blk.this recall only pertains to aftermarket suspension kits and has not relation to any original equipment installed on ford motor company vehicles.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 11V352000 on 07/12/2011
- Component:
- Exterior lighting:tail lights
- Affected:
- 26,715
- Defect:
- Ford is recalling certain model year 2011 ranger trucks built from january 25, 2011, through april 25, 2011 at the twin cities assembly plant, and service parts distributed to dealers for certain 2004 through 2011 model year ranger trucks, 2002 through 2005 model year excursion vehicles, and 2002 through 2007 model year f-250, f-350, f-450, and f-550 trucks for failing to comply with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." the multi-function switch was shipped with a subcomponent (slider) that may experience deformation. a multi-function switch with a deformed slider may malfunction causing the turn signal, tail lights, hazard warning signal flashers and/or brake lights not to activate.
- Consequence:
- Non-functioning lights could increase the risk of a crash.
- Correction:
- Dealers will replace the switches free of charge. the safety recall began on august 15, 2011. owners may contact ford motor company customer relationship center at 1-866-436-7332.
- Notes:
- Ford's safety recall no. 11c18.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
- Campaign:
- 11V352000 on 07/12/2011
- Component:
- Exterior lighting:brake lights
- Affected:
- 26,715
- Defect:
- Ford is recalling certain model year 2011 ranger trucks built from january 25, 2011, through april 25, 2011 at the twin cities assembly plant, and service parts distributed to dealers for certain 2004 through 2011 model year ranger trucks, 2002 through 2005 model year excursion vehicles, and 2002 through 2007 model year f-250, f-350, f-450, and f-550 trucks for failing to comply with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." the multi-function switch was shipped with a subcomponent (slider) that may experience deformation. a multi-function switch with a deformed slider may malfunction causing the turn signal, tail lights, hazard warning signal flashers and/or brake lights not to activate.
- Consequence:
- Non-functioning lights could increase the risk of a crash.
- Correction:
- Dealers will replace the switches free of charge. the safety recall began on august 15, 2011. owners may contact ford motor company customer relationship center at 1-866-436-7332.
- Notes:
- Ford's safety recall no. 11c18.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
2007 FORD F-250 SD TSBs (33)
- Bulletin:
- 0754
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Cold start driveability - white smoke, lacks power, exhaust odor, surges, runs, rough, or no start. *kb
- Bulletin:
- 07515
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- 6.0l oil seep or boost pressure leak at hot side charge air cooler duct. *kb
- Bulletin:
- 06177
- Component:
- 120000 exterior lighting
- Summary:
- Adding additional bulbs to turn indicator or hazard flasher circuits. *kb
- Bulletin:
- 19614
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Air filter water ingestion / snow packing with codes p0103. *kb
- Bulletin:
- 19621
- Component:
- 070000 fuel system, gasoline
- Summary:
- Lack of power due to low fuel pressure, fuel tank liner seperation. *kb
- Bulletin:
- 0798
- Component:
- 046400 service brakes, air:antilock:abs warning light
- Summary:
- Abs light on and possible c1175, c1236, p0500,p0503. *kb
- Bulletin:
- 19772
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Power steering pump pulley alignment. *kb
- Bulletin:
- 0643
- Component:
- 031000 service brakes, hydraulic:pedals and linkages
- Summary:
- Customer satisfaction program. vehicles equipped with fixed pedals accelerator pedal inspection. effective until june 30, 2007. *kb this program is being extended until june 30, 2008. updated on 09/25/07. *nj
- Bulletin:
- 19521
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Lack of power or lack of performance condition when operated above 5,000 feet of altitude. *kb
- Bulletin:
- 19529
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Misfire and dtc p0300. *kb
- Bulletin:
- 19537
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Misfire and dtc p0300. *kb
- Bulletin:
- 19728
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Lack of power due to low fuel pressure - fuel tank liner seperation. *kb
- Bulletin:
- 0769
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Buck/jerk when pulling large heavy gooseneck trailers. diesel engines. reprogramming the powertrain control module (pcm) with the latest calibration might solve the issue. *kb
- Bulletin:
- 0772
- Component:
- 022000 suspension:rear
- Summary:
- Rear of vehicle is too high/low -5th wheel and goose neck applications. *kb
- Bulletin:
- 062401
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- 6.0l diesel engine - oil leak or boost pressure leak at hot side charge air cooler duct. *kb
- Bulletin:
- 07112
- Component:
- 046400 service brakes, air:antilock:abs warning light
- Summary:
- Stuck or jumping/bouncing/erratic speedometer and/or tachometer. *nj
- Bulletin:
- 071110
- Component:
- 040000 service brakes, air
- Summary:
- Brake booster system may exhibit a brake pedal kickback and/or grabbing condition when applying the brakes. *nj
- Bulletin:
- 19989
- Component:
- 102000 power train:manual transmission
- Summary:
- 2005-2008 f-super duty manual transmission- clutch pedal concern. *nj
- Bulletin:
- 20052
- Component:
- 104000 power train:transfer case (4-wheel drive)
- Summary:
- 1999-2008 f250-f550 super duty 4x4 with electronic shift transfer case not engaging 4x4. *nj
- Bulletin:
- 07219
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- 6.0l--mil on--p0401, p0402, p0404, p1335--lack of power or surge with some 2003-2007 f-super duty, 2003-2005 excursion and 2004-2008 e-series vehicles. *nj
- Bulletin:
- 08-2-11
- Component:
- 061320 engine and engine cooling:engine:other fuel types:turbo-charger
- Summary:
- 6.0l turbocharger carbon deposit diagnostics and service tips. *nj updated 5/29/08. *nj
- Bulletin:
- 20228
- Component:
- 061320 engine and engine cooling:engine:other fuel types:turbo-charger
- Summary:
- 1999-2008 7.3l/6.0l/6.4l/4.5l diesel f-super duty - clean the charge air cooler (cac) system after certain turbo or engine failures - service tip. *nj
- Bulletin:
- 20232
- Component:
- 102000 power train:manual transmission
- Summary:
- 2005-08 f250-550 super duty manual transmission - clutch pedal concern. *nj
- Bulletin:
- TSB-08-9-9
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Ford: 6.0l diesel hard start/long crank/no start du to low injector control pressure (icp). ipe
- Bulletin:
- TSB-08-18-6
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Ford truck: some trucks equipped with a 6.0l diesel engine may exhibit a hard start/long crank or no start condition due to low injection control pressure (icp). *pe
- Bulletin:
- LP-09L02
- Component:
- 011000 steering:wheel and handle bar
- Summary:
- Ford trucks service campaign: see document search button for owner letter. vehicles have experienced severe steering wheel and front wheel vibrations and oscillations after traveling over a bump or dip in the road. models 2006 f-250/350 su
- Bulletin:
- TSB-09-20-12
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Ford: some super duty trucks equipped with a 5.4l 3v or 6.8l 3v engine may experience premature automatic shut off of the fuel fill nozzle. *pe
- Bulletin:
- AS-21769
- Component:
- 046000 service brakes, air:antilock
- Summary:
- Ford: if there is an intermittent lack of power, surge, or hesitation while driving the brakes will override acceleration. *rm
- Bulletin:
- ASI-44404
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Ford: on some trucks, there is a no crank situation and if voltage on transmission range sensor at pin 21, is less than 5 volts, disconnect the engine cooling fan clutch, electronically, and recheck voltage. model 2003-2007 f super duty,
- Bulletin:
- TSB-14-0114
- Component:
- 060000 engine (pws)
- Summary:
- Lincoln/ford: when driving from idle up to 1200 rpm, there may be an intermittent rattle noise coming from engine. 2004-2013 f-150, f-250, f-350, expedition, mark lt, navigator. *pe
- Bulletin:
- ASI-44534
- Component:
- 103000 power train:automatic transmission
- Summary:
- Ford: when shifting between park, reverse and/or during 2-3 shift, an intermittent clunk occurs with a torqshift transmission. model 2003-2014 f-super duty, e series, excursion, f-53 motorhome chassis, low cab forward. *p
- Bulletin:
- SSM 46345
- Component:
- 350000 equipment
- Summary:
- Some 2005-2017 f-super duty 4x4 vehicles operated in extreme dust, mud or tar sand conditions may exhibit accelerated 4x4 vacuum hub seal and or wheel bearing wear as a result of harsh operating conditions. a knuckle seal shield kit is now
- Bulletin:
- DOR-B8H4Z-11
- Component:
- 010000 steering
- Summary:
- This sku is a front upper ball joint. the customer communication requested return of unsold inventory to inspect for ball studs with excessive rotational friction in the ball joint assembly. excessive friction in the ball joint assembly ma
Home | Privacy