2005 TOYOTA SIENNA Recalls (12)

Campaign:
05V327000 on 07/19/2005
Component:
Seat belts
Manufactured:
01/09/2003 - 05/17/2005
Affected:
345,443
Defect:
On certain mini vans, in the middle row seating position, the shoulder portion of the seat belt may bind in the bezel trim piece. the affected seat belt bezel is located on the shoulder portion of the seat in the right side seat of the seven passenger models and the center seating position in the eight passenger models.
Consequence:
If the seat belt binds in the bezel, that extra webbing may exist in the seat belt which could result in an improperly fitted seat belt on a passenger. in the event of a crash, a seat occupant may not be properly restrained increasing the risk of personal injury.
Correction:
Dealers will replace the seat belt bezel and clip. the recall began august 5, 2005. owners may contact toyota at 1-800-331-4331.
Notes:
Toyota recall no. 50l.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236; (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
08V244000 on 06/02/2008
Component:
Structure:body:hatchback/liftgate
Affected:
196,222
Defect:
Toyota is conducting a safety improvement campaign involving 196,222 my 2004-2006 toyota sienna vehicles equipped with power rear liftgate struts. the gas struts used to help lift and support the rear power liftgate could wear out sooner than expected. as the gas struts deteriorate, the performance of the liftgate will begin to degrade and the power rear liftgate will operate more slowly than when the gas struts were new.
Consequence:
If not repaired, the gas struts may not be able to support the weight of the liftgate when it is open eventually, the gas struts could deteriorate to the point that the liftgate will fall about ten inches after it reaches the fully open position, at which point the power motor will engage and power the liftgate to the fully closed position. this condition may cause injury to a person who is struck by the liftgate when it falls or when it is closing.
Correction:
Dealers will replace the gas struts with newly designed gas struts that have a longer service life. the campaign began on august 8, 2008, and will be mailed in three phases ending in late december 2008. owners may contact toyota at 1-888-270-9371.
Notes:
Toyota no. 80c.this action is deemed a safety improvement campaign and is not being conducted under the safety act. however, toyota has informed nhtsa that it will provide the modifications described above free of charge.
Campaign:
09V234000 on 06/24/2009
Component:
Equipment:other:labels
Manufactured:
12/31/2002 - 05/03/2009
Affected:
2,204
Defect:
Toyota is recalling certain model year 2006 through 2009 sienna and 2009 lexus gx passenger vehicles. the vehicle capacity weight on the tire and loading information label and the gvwr on the certification label is insufficient for certain vehicles. some vehicles were accessorized through vehicle processing centers and had accessories installed that caused the vehicle to exceed the gvwr value. these vehicles fail to comply with the requirements of federal motor vehicle safety standard no 110, "tire selection and rims," and 49 cfr part 567.
Consequence:
The gvwr is insufficient for the load carrying capacity of the vehicles.
Correction:
Toyota will notify owners instructing them to return their vehicle to a toyota or lexus dealer for an exchange of the certification label and the tire and loading information label, an installation of the load carrying capacity modification label, if necessary, and a correction to the owner's manual. this remedy will be performed free of charge. the safety recall began on december 10, 2009. owners may contact toyota at 1-888-270-9371.
Notes:
Recall number ssc 9lf.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
10V036000 on 02/02/2010
Component:
Equipment:other:labels
Affected:
153,418
Defect:
Southeast toyota is recalling certain model year 2005-2011 passenger vehicles for failing to comply with the requirements of federal motor vehicle safety standard no. 110, "tire selection and rims." these vehicles were sold without the requisite load carrying capacity modification labels.
Consequence:
A driver may overload a vehicle which may increase the risk of a crash.
Correction:
Dealers will mail to consumers the corrected label or the customer will have the option for dealers to install the label free of charge. the safety recall began on may 27, 2010. owners may contact southeast toyota at 1-800-301-6859.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
10V035000 on 02/02/2010
Component:
Equipment:other:labels
Affected:
271,417
Defect:
Gulf states toyota is recalling certain model year 2005-2010 vehicles for failing to comply with the requirements of federal motor vehicle safety standard no. 110, "tire selection and rims." these vehicles were sold between september 1, 2005 and june 2, 2008 without the requisite load carrying capacity modification labels.
Consequence:
This does not meet the standard requirements.
Correction:
Dealers will mail to consumers the corrected label or the customer will have the option for dealers to install the label free of charge. dealers will also correct the owner's manual. the safety recall began on may 27, 2010. owners may contact gulf states toyota at 713-580-3300.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
10V160000 on 04/19/2010
Component:
Structure
Manufactured:
01/15/2003 - 01/03/2010
Affected:
600,000
Defect:
Toyota is recalling certain model year 1998 through 2010 sienna passenger vehicles manufactured between august 7, 1997 and january 4, 2010, currently registered in or originally sold in connecticut, delaware, illinois, indiana, kentucky, maine, maryland, massachusetts, michigan, minnesota, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, washington district of columbia, virginia, west virginia, and wisconsin. the subject vehicles are equipped with the spare tire stowed under the vehicle. if the vehicle is operated in the cold climate regions of the united states where road salt is frequently used, water splashed backwards with high concentrations of road salt can reach the spare tire carrier and corrode the spare tire carrier assembly cable.
Consequence:
The cable may break due to excessive corrosion and the spare tire may separate from the vehicle, possibly resulting in a vehicle crash.
Correction:
Toyota will notify owners with an interim letter initially instructing them to bring their vehicle to authorized dealers to inspect for corrosion. a second notice will be sent when the permanent remedy is available. for more information, please see toyota's amended recall report of july 19, 2010. the safety recall is expected to begin on october 12, 2010. owners may contact toyota at 1-800-331-4331.
Notes:
Toyota recall no. aoe.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
11V539000 on 11/08/2011
Component:
Engine and engine cooling
Manufactured:
05/31/2004 - 01/30/2005
Affected:
420,326
Defect:
Toyota is recalling certain model year 2004 avalon vehicles; 2004 and 2005 camry, camry solara, highlander, and sienna vehicles, 2006 highlander hybrid; 2004 and 2005 lexus es330 and rx330; and 2006 lexus rx400h vehicles manufactured from june 1, 2004 through march 31, 2005, equipped with the 1mz-fe or 3mz-fe engine. the amount of adhesive agent applied between the outer ring and the torsional rubber damper (inner ring) in the crankshaft pulley may be inadequate. if the adhesive is insufficient, there is a possibility that the outer ring may become misaligned and it may not properly rotate with the inner ring, causing noise and/or illumination of the battery discharge indicator light.
Consequence:
In some cases, the belt for the power steering pump may become detached from the pulley which could result in a loss of power steering and a sudden increase in steering effort, increasing the risk of a crash.
Correction:
Toyota will notify owners, and dealers will check the crankshaft pulley to identify whether it was produced by the u.s. supplier. if so, the dealer will replace the pulley with a new one at no charge. the safety recall is expected to begin during early january 2012. owners may contact toyota at 1-800-331-4331.
Notes:
Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
13V429000 on 09/25/2013
Component:
Power train:automatic transmission
Manufactured:
01/09/2003 - 08/09/2005
Affected:
614,722
Defect:
Toyota is recalling certain model year 2004-2005 sienna vehicles manufactured january 10, 2003, through august 10, 2005; and model year 2007-2009 sienna vehicles manufactured february 20, 2007, through december 12, 2008. in the affected vehicles, due to a problem within the shift lock solenoid, there is a possibility that the shift lever could be moved out of park position without depressing the brake pedal.
Consequence:
If the shift lever is moved out of the park position without the brake applied, the transmission will either engage a drive gear or neutral, increasing the risk of a backover or roll away crash.
Correction:
Toyota will mail interim notifications to owners beginning in late october 2013. when parts are available, owners will be sent a second notice and dealers will replace the shift lock solenoid, free of charge. owners may contact toyota at 1-800-331-4331.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
14V273000 on 05/22/2014
Component:
Tires:temporary/emergency spare tire
Affected:
419,520
Defect:
Toyota motor engineering & manufacturing (toyota) is recalling certain model year 2004-2011 sienna vehicles originally sold in, or currently registered in, connecticut, delaware, illinois, indiana, kentucky, maine, maryland, massachusetts, michigan, minnesota, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, virginia, west virginia, wisconsin and the district of columbia. the affected vehicles have a spare tire carrier assembly mounted under the vehicle whose attachment cable may corrode due to high concentrations of road salt splashing onto the spare tire carrier.
Consequence:
If the carrier cable is corroded due to road salt, the spare tire may separate from the vehicle, increasing the risk of a crash.
Correction:
Toyota sent owners in august 2014 an interim notification to advise owners of the recall and that dealers will perform an interim remedy to remove the spare tire and relocate it to the luggage compartment, free of charge. owners are being mailed a second letter as parts become available and dealers will replace the spare tire carrier assembly with an improved one, free of charge. the remedy campaign is being performed in phases. the first phase of the recall began july 7, 2015. owners may contact toyota customer service at 1-800-331-4331. note: 2004-2010 siennas subject to this recall were subject to recall campaign 10v-160 initiated in 2010. those owners are advised that they must have their vehicles remedied again under this campaign and that having the earlier recall completed did not remedy their vehicles. additionally, model year 1998-2003 siennas were recalled as part of safety recall 10v-160. owners of those vehicles that have not had not the remedy performed on their vehicles, should contact their toyota dealer to schedule a free repair.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
14V743000 on 11/18/2014
Component:
Seats:front assembly:seat heater/cooler
Manufactured:
05/31/2004 - 09/29/2011
Affected:
3,233
Defect:
Southeast toyota distributors, llc (set) is recalling certain model year 2010-2011 prius and corolla, 2009-2011 venza, 2006-2010 avalon, 2007-2010 fj cruiser, 2005-2011 sienna and sequoia, 2006-2011 tacoma 4x2 and 4x4, camry, highlander, tundra 4x2 and 4x4, and 2007-2011 rav4 and 4runner. the affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence:
Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Correction:
Set will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. the recall is expected to began in january 2015. owners may contact set customer service at 1-866-405-4226.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
16V396000 on 06/01/2016
Component:
Seats:front assembly:seat heater/cooler
Manufactured:
12/04/1987 - 01/26/2012
Affected:
7,749
Defect:
Southeast toyota distributors, llc (set) is recalling certain 2005-2011 4runner, highlander, sequoia, and sienna, 2005-2010 avalon and tundra, 2006-2008 camry solara, 2006-2010 highlander hybrid, 2006-2011 rav4 and tacoma, 2007-2010 fj cruiser, 2007-2011 camry hybrid, 2009-2010 venza, 2010-2012 prius, 1988-1990 and 2005-2010 camry, and 1989 and 2009-2010 corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. the electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence:
If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Correction:
Set will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. the recall began on july 14, 2016. owners may contact set customer service at 1-866-405-4226. set number for this recall is set16b.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
Campaign:
17V657000 on 10/18/2017
Component:
Power train:automatic transmission
Manufactured:
08/07/2005 - 03/04/2007
Affected:
310,475
Defect:
Toyota motor engineering & manufacturing (toyota) is recalling certain 2005-2007 and 2009-2010 toyota sienna vehicles. in the affected vehicles, due to a problem within the shift lock assembly, the shift lever may be moved out of the 'park' position without depressing the brake pedal.
Consequence:
If the shift lever can be moved from the "park" position without depressing the brake pedal and the parking brake is not applied, the vehicle may roll, increasing the risk of a crash.
Correction:
Toyota will notify owners, and dealers will replace the shift lock solenoid and reapply the grease, free of charge. owners may contact toyota customer service at 1-800-331-4331. toyota's number for this recall is h0v. vehicles that were previously recalled under campaign 13v-429 are not affected by this recall.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

2005 TOYOTA SIENNA TSBs (182)

Bulletin:
00703
Component:
100000 power train
Summary:
Engine control module (ecm) calibration - shifting enhancement. *tt update. *tt
Bulletin:
00304
Component:
162000 structure:body
Summary:
Back door stay leak and cold weather shudder improvement. *tt
Bulletin:
00404
Component:
162300 structure:body:door
Summary:
Sliding door rattle. *tt
Bulletin:
03704
Component:
980000 unknown or other
Summary:
Pre-delivery service (pds). *tt *nm
Bulletin:
08102004
Component:
350000 equipment
Summary:
New scantool software, production version 11.0a, is now available on tis. scantool support for 2005 model year vehicles. *tt
Bulletin:
00804
Component:
353000 equipment:electrical
Summary:
Automatic door lock (adl) function. *tt
Bulletin:
00504
Component:
199000 tires:pressure monitoring and regulating systems
Summary:
Tire pressure warning system information and re-initialization. *tt
Bulletin:
04604
Component:
110000 electrical system
Summary:
Short pin installation during pds. *tt
Bulletin:
04704
Component:
133000 visibility:power window devices and controls
Summary:
Initialization of driver's door power window. *tt
Bulletin:
04804
Component:
353000 equipment:electrical
Summary:
Initial calibration of compass during pds (pre-delivery service). *tt
Bulletin:
04304
Component:
353000 equipment:electrical
Summary:
Initialization of power sliding doors. *tt
Bulletin:
04404
Component:
353000 equipment:electrical
Summary:
Initialization of power back door. *tt
Bulletin:
04504
Component:
134000 visibility:sun roof assembly
Summary:
Initialization of moon roof. *tt
Bulletin:
01204
Component:
061000 engine and engine cooling:engine
Summary:
Entering vin during ecm (pcm) replacement and/or diagnostic trouble code p0630. *tt
Bulletin:
TC04016
Component:
015200 steering:hydraulic power assist:hose, piping, and connections
Summary:
Limited service campaign 40h to replace the power steering fluid return hoses. technical instructions; dealership and owner notification. *tt
Bulletin:
01004
Component:
102000 power train:manual transmission
Summary:
Transmission shifter may become progressively difficult to move. *tt
Bulletin:
00805
Component:
137000 visibility:rear window wiper/washer
Summary:
Rear wiper improvement. *tt
Bulletin:
01605
Component:
060000 engine and engine cooling
Summary:
Fuel injector ticking noise. *tt *sc
Bulletin:
00405
Component:
190000 tires
Summary:
Run flat tire repair criteria. *tt
Bulletin:
01005
Component:
353000 equipment:electrical
Summary:
Diagnostic guide for rear seat entertainment systems. *tt
Bulletin:
04305
Component:
061000 engine and engine cooling:engine
Summary:
No start in sub-freezing ambient air temperatures. *tt
Bulletin:
00605
Component:
138110 visibility:defroster/defogger system:windshield:blower
Summary:
Squeal or chirp type noise emitted from the blower motor at various speeds. *tt
Bulletin:
01205
Component:
110000 electrical system
Summary:
Repair manual supplement: laser cruise control beam axis adjustment. *ak
Bulletin:
05805
Component:
061000 engine and engine cooling:engine
Summary:
Malfunction indication light came on diagnostic trouble code p0171, p0174, p2195, p2197. *ts
Bulletin:
00405
Component:
021000 suspension:front
Summary:
Front suspension tick noise. *tt
Bulletin:
0506
Component:
062100 engine and engine cooling:cooling system:radiator assembly
Summary:
Warranty coverage enhancement - isolated reports from extreme cold climate areas that the radiator may crack at the base of one or more of the radiator tubes, resulting in coolant leakage - customer support program. *tt
Bulletin:
0601
Component:
190000 tires
Summary:
Reports regarding uneven or premature tire wear on some factory-equipped dunlop sp sport 4000 dsst p225/60r17 and bridgestone b380 rft p225/60r17 run-flat tires. customer support program - warranty coverage enhancement for all wheel drive
Bulletin:
00107
Component:
010000 steering
Summary:
Steering intermediate shaft in high road salt areas. *kb
Bulletin:
01011901
Component:
190000 tires
Summary:
Class action lawsuit settlement notice. run flat tires may have uneven wear. *kb
Bulletin:
00307
Component:
162300 structure:body:door
Summary:
Door check popping noise. *kb
Bulletin:
05506
Component:
061000 engine and engine cooling:engine
Summary:
Engine pinging or knocking noise. *kb
Bulletin:
07017
Component:
162300 structure:body:door
Summary:
Customer support program - warranty coverage extension for the front door check on certain 2004-2007 my sienna vehicles. *nj
Bulletin:
07015
Component:
980000 unknown or other
Summary:
Customer support program - warranty coverage extension on certain 2004 - early 2005 my 4runner, land cruiser and sienna vehicles equipped with the optional rear (back-up) camera. *nj
Bulletin:
01107
Component:
162300 structure:body:door
Summary:
Power back door & power sliding door difficult close. *nj
Bulletin:
0801
Component:
162600 structure:body:hatchback/liftgate
Summary:
Customer support program - warranty coverage enhancement for certain 2004 through 2006 model year sienna models back door stay (rear liftgate strut). *nj
Bulletin:
08001
Component:
162620 structure:body:hatchback/liftgate:support device
Summary:
Customer support program - warranty coverage extension for the back door stays (rear liftgate struts) on certain 2004 through 2006 my sienna vehicles. *nj
Bulletin:
EL001-08
Component:
141100 air bags:frontal:sensor/control module
Summary:
Repair manual supplement: srs light [on] - dtc b0111/b0116 - open side squib circuit. *nj updated 5/1/08. *nj
Bulletin:
0077-08
Component:
355200 equipment:other:owners/service/other manual
Summary:
Mobility converted vehicle service information. *pe
Bulletin:
T-SB-0252-08
Component:
140000 air bags
Summary:
Toyota: for vehicles that exhibit diagnostic trouble code (dtc) b0111 and/or b0116, a new service part has been made available for 05-08 model year sienna vehicles. *pe
Bulletin:
TSB-0085-09
Component:
162300 structure:body:door
Summary:
Toyota: vehicles may experience a condition where the power function of the sliding door is inoperative. *pe
Bulletin:
POL-09-01
Component:
141000 air bags:frontal
Summary:
Toyota: new service replacement parts available for front seat assembly with airbag. *pe
Bulletin:
TSB-0162-10
Component:
114000 electrical system:wiring
Summary:
Toyota: supplemental restraint systems. some model vehicles may exhibit an srs lamp on condtion with diagnostic trouble code (dtc) b0111 and/or b0116. an updated repair procedure is available to address this condition. *pe
Bulletin:
TSB-0064-10
Component:
061000 engine and engine cooling:engine
Summary:
Toyota: techstream ecu flash reprogramming procedure. flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures de
Bulletin:
SB-0280-10
Component:
162300 structure:body:door
Summary:
Toyota: some vehicles may exhibit a condition where one or both sliding doors do not open or close smoothly. inspect the sliding door lock assemblies and replace the affected components as needed, according to the listed instructions.
Bulletin:
TC-11-003
Component:
198000 tires:temporary/emergency spare tire
Summary:
Toyota service campaign: see document search button for owner letter. in cold weather where salt is used, the salt can corrode the spare tire carrier cable. 1998-2020 sienna. *rm
Bulletin:
TSB-0061-11
Component:
162600 structure:body:hatchback/liftgate
Summary:
Toyota: 2004-2009 sienna. the power rear hatch will not close completely. the hatch will start to close and then will reverse back up to the open position. *rm
Bulletin:
TSB-0122-11
Component:
140000 air bags
Summary:
Toyota: information provided for replacing the seat covers for vehicles equipped with side airbags. *pe
Bulletin:
T-SB-0381-08
Component:
198000 tires:temporary/emergency spare tire
Summary:
Toyota: spare tire carrier binding. some customers may experience that the spare tire is difficult to remove or the cable is binding. *js
Bulletin:
TSB-0069-12
Component:
114000 electrical system:wiring
Summary:
Toyota: updated information provided regarding the repairing procedures available for floor wire harness and replace/repair side airbag squib circuit, depending on production date. *pe model 2005-09 sienna. updated 4/15/13.
Bulletin:
TSB-0087-12
Component:
181000 vehicle speed control:accelerator pedal
Summary:
Toyota: accelerator pedal sensor assembly information regarding the inspection, removal, and installation, if lubrication or oil, is applied. *pe
Bulletin:
TSB-0097-12
Component:
013000 steering:gear box (other than rack and pinion)
Summary:
Toyota: information being provided regarding repair procedure to correct oil leakage from boots of steering gear assembly. *pe
Bulletin:
TC-14-001
Component:
110000 electrical system
Summary:
Toyota: see document search button for owner letter. there is an excessive electrical resistance, on some vehicles, where the connector had been improperly crimped, during time of manufacturing, and oxidization buildup, in connector, res
Bulletin:
POL-14-11
Component:
117000 digital instrument panel
Summary:
Toyota: during the humidity or heat, the dashboard would be either sticky, melting, or cracked and a part replacement has phased into program. models 2003-05 4runner, 2005-10 avalon, 2007-11 camry & hybrid, 2004-10 sienna, 2004-08 solara
Bulletin:
T-SB-0097-12
Component:
017000 steering:linkages
Summary:
Summary to be provided on a future date.
Bulletin:
TC13-005
Component:
010000 steering
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0187-12
Component:
190000 tires
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0051-10
Component:
353600 equipment:air conditioner
Summary:
Summary to be provided on a future date.
Bulletin:
T-TT-0124-11
Component:
190000 tires
Summary:
Summary to be provided on a future date.
Bulletin:
TC13-019
Component:
355200 equipment:other:owners/service/other manual
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0125-15 REV
Component:
150000 seat belts
Summary:
Tsb: warranty operation codes updated. some 2004 ' 2006 model year sienna vehicles may exhibit a condition where the front driver and/or passenger seat belt becomes abnormally slow to retract, or does not retract smoothly. follow the proc
Bulletin:
T-SB-0125-15 REV
Component:
150000 seat belts
Summary:
Tsb: warranty operation codes updated. some 2004 ' 2006 model year sienna vehicles may exhibit a condition where the front driver and/or passenger seat belt becomes abnormally slow to retract, or does not retract smoothly. follow the proc
Bulletin:
T-SB-0125-15
Component:
151300 seat belts:front:retractor
Summary:
Tsb: some 2004 ' 2006 model year sienna vehicles may exhibit a condition where the front driver and/or passenger seat belt becomes abnormally slow to retract, or does not retract smoothly. follow the procedure in this bulletin to replace th
Bulletin:
ZE6_DEALER 12/3
Component:
350000 equipment
Summary:
Dl: in our continuing efforts to ensure the best in customer satisfaction, toyota has announced a warranty enhancement program (the 'program'). this program extends the warranty coverage for repairs related to cracked and/or sticky/melting
Bulletin:
ZE6_DEALERD 12/3
Component:
350000 equipment
Summary:
Dd: in mid-december 2014, toyota announced the reimbursement phase of this program. since prior to that announcement, toyota has been diligently making parts preparations for the parts replacement phase of this program. due to the age, volu
Bulletin:
POL14-11
Component:
350000 equipment
Summary:
"wpb: toyota has received reports where some vehicles may exhibit cracked and/or sticky/melting dashboards as a result of heat or humidity. in mid-december, 2014, toyota announced the reimbursement phase of this warranty enhancement progra
Bulletin:
T-SB-0012-13 REV
Component:
060000 engine (pws)
Summary:
"tsb: flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bul
Bulletin:
T-TT-0381-16
Component:
350000 equipment
Summary:
Tech tip: some customers may experience difficulty programming homelink.
Bulletin:
T-TT-0360-15
Component:
350000 equipment
Summary:
Tt: customers may experience connectivity issues when the following conditions are met: the customer's iphone is operating on ios9 firmware. the customer's iphone is connected to the vehicle via bluetooth. the customer may complain of the f
Bulletin:
T-TT-0362-15
Component:
060000 engine (pws)
Summary:
Tt: the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
Bulletin:
WPB (POL 14-11)_
Component:
160000 structure
Summary:
"wpb: toyota has received reports where some vehicles may exhibit cracked and/or sticky/melting dashboards as a result of heat or humidity. in mid-december, 2014 toyota announced the reimbursement phase of this warranty enhancement program
Bulletin:
ZF2_DEALER LETTE
Component:
150000 seat belts
Summary:
"dealer letter: background toyota has received a number of reports regarding front seatbelts in certain 2004 ' 2006 model year sienna vehicles. in these reports, customers have indicated that the front seatbelts (right and/or left) may slow
Bulletin:
ZF2_WARRANTY POL
Component:
150000 seat belts
Summary:
In certain 2004 to 2006 model year sienna vehicles, toyota has received some reports where the front seatbelts (right and/or left) may slowly or non-smoothly retract.
Bulletin:
GR1_REGION LETTE
Component:
100000 power train
Summary:
Region letter: toyota will be sending safety recall follow-up notices to remind owners whose vehicles have not yet had campaign repairs completed. please note the following information for regional and pd associates.
Bulletin:
GR1_DEALER LETTE
Component:
100000 power train
Summary:
"dealer letter: safety recall completion is important not only in satisfying government requirements, but also is an integral part of our commitment to meet customer expectations of toyota products. toyota will be sending safety recall foll
Bulletin:
ER11_Re-Notifica
Component:
021530 suspension:front:control arm:lower arm
Summary:
Region letter: toyota will be sending safety recall follow-up notices to remind owners whose vehicles have not yet had campaign repairs completed. please note the following information for regional and pd associates.
Bulletin:
ER11_Re-Notifica
Component:
021530 suspension:front:control arm:lower arm
Summary:
Region letter: safety recall completion is important not only in satisfying government requirements but also is an integral part of our commitment to meet customer expectations of toyota products. toyota will be sending safety recall follow
Bulletin:
T-SB-0014-11 Rev
Component:
103000 power train:automatic transmission
Summary:
Tsb: the purpose of this service bulletin is to provide information regarding the installation of the correct torque converter bolts during automatic transmission/transaxle assembly replacement. incorrect torque converter bolts or missing w
Bulletin:
T-SB-0134-14
Component:
100000 power train
Summary:
Tsb: the purpose of this bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid mil "on" shifting issues and/or transmission damage. use the information in this bulletin when insta
Bulletin:
T-SB-0043-14 Rev
Component:
353000 equipment:electrical
Summary:
Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased. follow the procedures in this bulletin to
Bulletin:
T-SB-0039-15
Component:
117000 digital instrument panel
Summary:
Tsb: certain 2003 - 2011 model year toyota vehicles may exhibit a condition where the instrument panel pad (dashboard) becomes cracked and/or has a shiny/degraded appearance. the pad surface may also become sticky or adherent. follow the pr
Bulletin:
ZE6_WEP_Region L
Component:
356000 equipment adaptive
Summary:
Rl: in our continuing efforts to ensure the best in customer satisfaction, toyota is announcing a warranty enhancement program (the "program"). this program extends the warranty coverage for repairs related to cracked and/or sticky/melting
Bulletin:
ZE6_WEP_Dealer L
Component:
356000 equipment adaptive
Summary:
Dl: in our continuing efforts to ensure the best in customer satisfaction, toyota is announcing a warranty enhancement program (the "program"). this program extends the warranty coverage for repairs related to cracked and/or sticky/melting
Bulletin:
ZE6_WPB POL14-11
Component:
356000 equipment adaptive
Summary:
Wpb: toyota has received reports where some vehicles may exhibit cracked and/or sticky/melting dashboards as a result of heat or humidity.
Bulletin:
T-SB-0083-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: the procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. refer to the applicable repair manual for vehicle specific repair procedures and parts.
Bulletin:
T-SB-0142-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: some 2004 - 2015 model year toyota vehicles may exhibit odors naturally occurring from the hvac system and/or related environmental factors. although there is no way to eliminate these odors, follow the general procedure in this bullet
Bulletin:
T-SB-0101-11 Rev
Component:
110000 electrical system
Summary:
Tsb: when servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. many lubricants, cleaners, and automotive chemicals contain silicone or othe
Bulletin:
T-SB-0039-15
Component:
117000 digital instrument panel
Summary:
Tsb: certain 2003 - 2011 model year toyota vehicles may exhibit a condition where the instrument panel pad (dashboard) becomes cracked and/or has a shiny/degraded appearance. the pad surface may also become sticky or adherent. follow the pr
Bulletin:
ZE6_WEP_Region L
Component:
160000 structure
Summary:
Rl: in our continuing efforts to ensure the best in customer satisfaction, toyota is announcing a warranty enhancement program (the "program"). this program extends the warranty coverage for repairs related to cracked and/or sticky/melting
Bulletin:
ZE6_WEP_Dealer L
Component:
160000 structure
Summary:
Dl: in our continuing efforts to ensure the best in customer satisfaction, toyota is announcing a warranty enhancement program (the "program"). this program extends the warranty coverage for repairs related to cracked and/or sticky/melting
Bulletin:
ZE6_WPB POL14-11
Component:
356000 equipment adaptive
Summary:
Wpb: toyota has received reports where some vehicles may exhibit cracked and/or sticky/melting dashboards as a result of heat or humidity.
Bulletin:
T-SB-0142-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: some 2004 - 2015 model year toyota vehicles may exhibit odors naturally occurring from the hvac system and/or related environmental factors. although there is no way to eliminate these odors, follow the general procedure in this bullet
Bulletin:
T-SB-0101-11 Rev
Component:
110000 electrical system
Summary:
Tsb: when servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. many lubricants, cleaners, and automotive chemicals contain silicone or othe
Bulletin:
T-SB-0043-14 Rev
Component:
353000 equipment:electrical
Summary:
Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased. follow the procedures in this bulletin to
Bulletin:
T-SB-0083-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: the procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. refer to the applicable repair manual for vehicle specific repair procedures and parts.
Bulletin:
ESS_ Special Ser
Component:
160000 structure
Summary:
Dealer package: toyota has received reports indicating that some vehicles experienced symptoms of the condition in special service campaign a7e after being inspected and/or repaired.
Bulletin:
T-SB-0304-17
Component:
162300 structure:body:door
Summary:
Tsb: vehicle replacement certification labels (the vinyl label installed on the driver door or door post) and vin plates (the metal plate riveted to dashboard) may be available from toyota, provided the request meets one of the criteria lis
Bulletin:
T-SB-0134-16_Rev
Component:
355200 equipment:other:owners/service/other manual
Summary:
Tsb: revision notice october 30, 2017 rev1: * applicability has been updated to include 2018 model year vehicles. supersession notice the information contained in this bulletin supersedes sb no. t-sb-0012-13. flash reprogramming allows the
Bulletin:
T-SB-0187-12_Rev
Component:
190000 tires
Summary:
Tsb: revision notice february 12, 2018 rev2: ? applicability has been updated to include 2015 ? 2018 model year vehicles. january 23, 2014 rev1: ? applicability has been updated to include 2013 ? 2014 model year vehicles. any previous print
Bulletin:
T-SB-0304-17_Rev
Component:
350000 equipment
Summary:
Tsb: supersession notice the information contained in this bulletin supersedes service bulletin nos. pg021-88, pg015-89, pg0015-90, pg002-91, pg002-93, pg005-97, pg007-01, pg007-07, and t-sb-0144-08. service bulletin nos. pg021-88, pg015-89
Bulletin:
T-SB-0187-12_Rev
Component:
190000 tires
Summary:
Tsb: revision notice february 12, 2018 rev2: ? applicability has been updated to include 2015 ? 2018 model year vehicles. january 23, 2014 rev1: ? applicability has been updated to include 2013 ? 2014 model year vehicles. any previous print
Bulletin:
T-SB-0030-14
Component:
010000 steering
Summary:
A new repair procedure and overhaul kit have been developed for repairing the power steering rack to improve the overall serviceability and reduce ownership cost. this repair procedure only applies to vehicles where the steering rack leak i
Bulletin:
T-SB-0097-12 OBS
Component:
010000 steering
Summary:
This bulletin is now obsolete. please see t-sb-0030-14 .
Bulletin:
ZE6 Dealer Daily
Component:
117000 digital instrument panel
Summary:
Dealer daily: voluntary extension of warranty coverage for cracked and/or sticky/melting dashboards (instrument panels) as a result of heat or humidity.
Bulletin:
ZE6_POL14-11_War
Component:
117000 digital instrument panel
Summary:
Warranty policy bulletin pol14-11: revised march 22, 2017: toyota has received reports where some vehicles may exhibit cracked and/or sticky/melting dashboards as a result of heat or humidity.
Bulletin:
HR1_Region Lette
Component:
140000 air bags
Summary:
Region letter: toyota will be sending safety recall follow-up notices to remind owners whose vehicles have not yet had campaign repairs completed.
Bulletin:
HR1_Dealer Lette
Component:
140000 air bags
Summary:
Dealer letter: toyota will be sending safety recall follow-up notices to remind owners whose vehicles have not yet had campaign repairs completed.
Bulletin:
T-TT-0132-11
Component:
030000 service brakes, hydraulic
Summary:
A key part to maintain the proper function and safe operation of the vehicle's braking system is to perform a visual inspection when installing brake pads, calipers, and discs. the following recommendations are intended to provide general
Bulletin:
T-SB-0069-12 Rev
Component:
140000 air bags
Summary:
Some 2004 ? 2009 model year sienna vehicles may exhibit an srs lamp ?on? condition with diagnostic trouble code (dtc) b0111 and/or b0116. an updated repair procedure is available to address this condition. follow the procedures in this bull
Bulletin:
T-SB-0187-12 Rev
Component:
190000 tires
Summary:
Toyota vehicles are equipped with either conventional or run-flat tires. sometimes punctures may occur as a result of contact with road debris or other hazards. if a puncture occurs, it may be possible to repair the tire and return it to se
Bulletin:
T-TT-0213-13
Component:
140000 air bags
Summary:
Toyota vehicles are equipped with supplemental restraint systems (srs), including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. if a customer expresses any concerns that the
Bulletin:
Warranty Enhance
Component:
140000 air bags
Summary:
In our continuing efforts to help ensure the best in customer satisfaction, toyota is announcing a warranty enhancement program to extend the warranty coverage for the side airbag connector on certain 2004 to 2009 model year toyota sienna v
Bulletin:
Warranty Enhance
Component:
140000 air bags
Summary:
Toyota has received reports regarding excessive electrical resistance in the side airbag connector of certain 2004 to 2009 model year sienna vehicles. the connector could have been improperly crimped during the manufacturing process. in cer
Bulletin:
T-SB-0141-13
Component:
050000 parking brake
Summary:
A new special service tool (sst 09709-00002) has been introduced to aid in the inspection procedure for certain vehicles equipped with a floor pedal-type parking brake system. this bulletin references the correct method for installing the b
Bulletin:
T-SB-0142-13
Component:
353600 equipment:air conditioner
Summary:
Some 2004 ? 2014 model year toyota vehicles may exhibit odors naturally occurring from the hvac system and/or related environmental factors. although there is no way to eliminate these odors, follow the general procedure in this bulletin to
Bulletin:
T-SB-0185-13
Component:
130000 visibility
Summary:
The following procedures are recommended during routine maintenance or in the event of a customer concern for wiper performance.
Bulletin:
TS-BO030-01 Obso
Component:
130000 visibility/wiper (pws)
Summary:
This bulletin is now obsolete. please see t-sb-0185-13.
Bulletin:
T-TT-0092-11 Rev
Component:
110000 electrical system
Summary:
Some customers may complain that the rear seat entertainment (rse) system is inoperative if the have misplaced the parental passcode for the system.
Bulletin:
T-TT-0124-11
Component:
190000 tires
Summary:
Please refer to the following recommendations for the best practices for vehicle tire rotations.
Bulletin:
T-SB-0122-11 Rev
Component:
140000 air bags
Summary:
Beginning in 1998, toyota introduced side airbags as optional equipment. toyota does not recommend replacement of original seat covers with non-toyota leather or other seat cover materials on vehicles due to the following: seat covers not
Bulletin:
T-SB-0071-11 Rev
Component:
100000 power train
Summary:
The purpose of this service bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid mil ?on,? shifting issues, and/or transmission damage. use the information in this bulletin when
Bulletin:
T-TT-0269-13
Component:
132000 visibility:glass, side/rear
Summary:
The appearance of spots in tempered glass (when viewed at certain angles) is the result of the heat treating and quick quenching process during manufacturing.
Bulletin:
DR8 Reg Ltr
Component:
140000 air bags
Summary:
Toyota will be sending safety recall follow-up notices to remind owners whose vehicles have not yet had campaign repairs completed. please note the following information for regional and pd associates.
Bulletin:
T-TT-0051-10 Rev
Component:
353600 equipment:air conditioner
Summary:
If a customer states there is an unpleasant odor in the vehicle from the hvac system, there are various factors that may be involved.
Bulletin:
T-SB-0141-10 Rev
Component:
162320 structure:body:door/window:emergency exit
Summary:
If a creak, tick, or rattle noise is heard at the top or bottom of the windshield, or at the top of the rear glass, the source of the noise may be the two stoppers bonded to the top of the windshield/rear glass, or the windshield retainers
Bulletin:
T-SB-0054-13
Component:
350000 equipment
Summary:
California (ca), federal (fed), and 50 state certified emission control underhood labels (emission labels) may be obtained through your dealership?s parts department utilizing standard replacement parts ordering procedures. follow the guide
Bulletin:
T-PG006-00 Obsol
Component:
355100 equipment:other:labels
Summary:
This bulletin is now obsolete. please see t-sb-0054-13.
Bulletin:
T-TT-0092-11 Rev
Component:
110000 electrical system
Summary:
Some customers may complain that the rear seat entertainment (rse) system is inoperative if they have misplaced the parental passcode for the system.
Bulletin:
ZE6_Toyota POL14
Component:
117000 digital instrument panel
Summary:
Warranty policy bulletin pol14-11: rev toyota has received reports where some vehicles may exhibit cracked and/or sticky/melting dashboards as a result of heat or humidity.
Bulletin:
T-TT-0086-11
Component:
060000 engine (pws)
Summary:
Techtip: condition - the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
Bulletin:
ZE6_Warranty Enh
Component:
117000 digital instrument panel
Summary:
Rl: in our continuing efforts to ensure the best in customer satisfaction, toyota is announcing a warranty enhancement program (the ?program?). this program extends the warranty coverage for repairs related to cracked and/or sticky/melting
Bulletin:
ZE6_Dealer Lette
Component:
117000 digital instrument panel
Summary:
Dl: in our continuing efforts to ensure the best in customer satisfaction, toyota is announcing a warranty enhancement program (the ?program?). this program extends the warranty coverage for repairs related to cracked and/or sticky/melting
Bulletin:
ZE6_Region Lette
Component:
117000 digital instrument panel
Summary:
Region letter: in our continuing efforts to ensure the best in customer satisfaction, toyota is announcing a warranty enhancement program. this program extends the warranty coverage for repairs related to cracked and/or sticky/melted dashbo
Bulletin:
ZE6_Electronic C
Component:
117000 digital instrument panel
Summary:
Electronic communication: in our continuing efforts to ensure the best in customer satisfaction, toyota is announcing a warranty enhancement program. this program extends the warranty coverage for repairs related to cracked and/or sticky/me
Bulletin:
T-SB-0085-09_Rev
Component:
110000 electrical system
Summary:
Tsb: revision notice october 25, 2017 rev2: ? applicability has been updated to include 2008 ? 2010 model year sienna vehicles. ? the production change information section has been removed. ? the parts information and repair procedure secti
Bulletin:
T-SB-0043-14
Component:
353100 equipment:electrical:anti-theft devices
Summary:
Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased.
Bulletin:
T-SB-0043-14 Rev
Component:
353100 equipment:electrical:anti-theft devices
Summary:
Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased.
Bulletin:
T-SB-0012-13 Rev
Component:
118000 electrical system: software
Summary:
Tsb: flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bullet
Bulletin:
T-TT-0010-10 Rev
Component:
060000 engine (pws)
Summary:
Tech tip: low battery voltage can contribute to a mil "on" condition for p0335 (crankshaft position
Bulletin:
T-SB-0142-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: revision notice november 10, 2016 rev2: ? applicability has been updated to include 2016 ? 2017 model year toyota vehicles. ? parts information section has been updated. some 2004 ? 2017 model year toyota vehicles may exhibit odor
Bulletin:
T-SB-0012-13 Rev
Component:
118000 electrical system: software
Summary:
Tsb: obsolete notice: september 14, 2016: this bulletin is now obsolete. please see t-sb-0134-16.
Bulletin:
T-SB-0144-08_Obs
Component:
350000 equipment
Summary:
Tsb: obsolete notice november 21, 2017: this bulletin is now obsolete. please see t-sb-0304-17.
Bulletin:
T-SB-0229-12_Rev
Component:
110000 electrical system
Summary:
Tsb: revision notice november 22, 2017 rev1: ? applicability has been updated to include 2014 ? 2018 model year vehicles. any previous printed versions of this bulletin should be discarded. in the event that a toyota vehicle becomes submerg
Bulletin:
ER4 Region Lette
Component:
136100 visibility:windshield wiper/washer:switch/wiring
Summary:
Toyota will be sending safety recall follow-up notices to remind owners whose vehicles have not yet had campaign repairs completed. please note the following information for regional and pd associates.
Bulletin:
ER4 Dealer Lette
Component:
136100 visibility:windshield wiper/washer:switch/wiring
Summary:
Safety recall completion is important not only in satisfying government requirements but also is an integral part of our commitment to meet customer expectations of toyota products. toyota will be sending safety recall follow-up notices to
Bulletin:
ER4 Region Lette
Component:
355200 equipment:other:owners/service/other manual
Summary:
Toyota will be sending safety recall follow-up notices to remind owners whose vehicles have not yet had campaign repairs completed. please note the following information for regional and pd associates.
Bulletin:
ER4 Dealer Lette
Component:
355200 equipment:other:owners/service/other manual
Summary:
Safety recall completion is important not only in satisfying government requirements but also is an integral part of our commitment to meet customer expectations of toyota products. toyota will be sending safety recall follow-up notices to
Bulletin:
T-SB-0391-08 Rev
Component:
100000 power train
Summary:
This bulletin contains general vehicle pulling diagnosis and repair procedures along with specific information to help correct pulling complaints.
Bulletin:
T-TT-0226-13
Component:
110000 electrical system
Summary:
The customer is having difficulty changing the multi-display screen from day mode. if the multi-display screen is set to day mode when the headlights are on, the setting we be memorized when the engine is turned off.
Bulletin:
SST Requirements
Component:
355200 equipment:other:owners/service/other manual
Summary:
Ssts are key elements to provide your customers with swift and accurate repairs resulting in superior customer satisfaction.
Bulletin:
Recall Follow Up
Component:
355200 equipment:other:owners/service/other manual
Summary:
Toyota will be sending safety recall follow-up notices to remind owners whose vehicles have not yet had campaign repairs completed
Bulletin:
Recall Follow Up
Component:
355200 equipment:other:owners/service/other manual
Summary:
Toyota will be sending safety recall follow-up notices to remind owners whose vehicles have not yet had campaign repairs completed
Bulletin:
T-SB-0064-10 Rev
Component:
118000 electrical system: software
Summary:
Flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bulletin de
Bulletin:
T-SB-0069-12 Rev
Component:
355200 equipment:other:owners/service/other manual
Summary:
Some 2004 ? 2009 model year sienna vehicles may exhibit an srs lamp ?on? condition with diagnostic trouble code (dtc) b0111 and/or b0116. an updated repair procedure is available to address this condition. follow the procedures in this bull
Bulletin:
T-SB-0012-13
Component:
118000 electrical system: software
Summary:
Flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bulletin de
Bulletin:
T-SB-0064-10 Rev
Component:
355200 equipment:other:owners/service/other manual
Summary:
This bulletin is now obsolete. please see t-sb-0012-13.
Bulletin:
T-TT-0213-13
Component:
140000 air bags
Summary:
Toyota vehicles are equipped with srs, including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. if a customer expresses any concerns that the srs airbags or pretensioner devi
Bulletin:
T-SB-0187-12
Component:
162000 structure:body
Summary:
Toyota vehicles are equipped with either conventional or run-flat tires. sometimes punctures may occur as a result of contact with road debris or other hazards. if a puncture occurs, it may be possible to repair the tire and return it to se
Bulletin:
TSB-0012-13 Rev2
Component:
060000 engine (pws)
Summary:
Tsb: flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bull
Bulletin:
T-TT-0381-16
Component:
118000 electrical system: software
Summary:
Tech tip: some customers may experience difficulty programming homelink.
Bulletin:
ZF2_Dealer Lette
Component:
151000 seat belts:front
Summary:
Dealer letter: background toyota has received a number of
Bulletin:
Pol-16-01
Component:
151000 seat belts:front
Summary:
In certain 2004 to 2006 model year sienna vehicles, toyota has received some reports where the front seatbelts (right and/or left) may slowly or non-smoothly retract.
Bulletin:
ZE6_Region Lette
Component:
117000 digital instrument panel
Summary:
Region letter: in our continuing efforts to ensure the best in customer satisfaction, toyota is announcing a warranty enhancement program. this program extends the warranty coverage for repairs related to cracked and/or sticky/melted dashbo
Bulletin:
ZE6_Electronic C
Component:
117000 digital instrument panel
Summary:
Electronic communication: in our continuing efforts to ensure the best in customer satisfaction, toyota is announcing a warranty enhancement program. this program extends the warranty coverage for repairs related to cracked and/or sticky/me
Bulletin:
T-TT-0360-15
Component:
110000 electrical system
Summary:
Tt: customers may experience connectivity issues when the following conditions are met: the customer's iphone is operating on ios9 firmware. the customer's iphone is connected to the vehicle via bluetooth. the customer may complain of the f
Bulletin:
T-TT-0362-15
Component:
060000 engine (pws)
Summary:
Tt: the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
Bulletin:
ZE6_Warranty Enh
Component:
117000 digital instrument panel
Summary:
Rl: in our continuing efforts to ensure the best in customer satisfaction, toyota is announcing a warranty enhancement program (the ?program?). this program extends the warranty coverage for repairs related to cracked and/or sticky/melting
Bulletin:
ZE6_Dealer Lette
Component:
117000 digital instrument panel
Summary:
Dl: in our continuing efforts to ensure the best in customer satisfaction, toyota is announcing a warranty enhancement program (the ?program?). this program extends the warranty coverage for repairs related to cracked and/or sticky/melting
Bulletin:
WPB (POL 14-11)_
Component:
160000 structure
Summary:
Wpb: toyota has received reports where some vehicles may exhibit cracked and/or sticky/melting dashboards as a result of heat or humidity. in mid-december, 2014 toyota announced the reimbursement phase of this warranty enhancement program.
Bulletin:
ESS_Dealer Daily
Component:
198000 tires:temporary/emergency spare tire
Summary:
Dealer daily: toyota has received reports indicating that some vehicles may experience spare tire carrier or carrier cable corrosion even after being inspected and/or repaired as part of a previous special service campaign. during normal us
Bulletin:
ESS_Region Lette
Component:
198000 tires:temporary/emergency spare tire
Summary:
Dealer daily: the special service campaign ess dealer letter and technical instructions are now available on tis.
Bulletin:
ESS_Dealer Lette
Component:
356000 equipment adaptive
Summary:
Dealer letter: toyota has received reports indicating that some vehicles may experience spare tire carrier or carrier cable corrosion even after being inspected and/or repaired as part of a previous special service campaign. during normal u
Bulletin:
ESS_Technical In
Component:
350000 equipment
Summary:
Technical instructions: the repair quality of covered vehicles is extremely important to toyota. all dealership technicians performing this repair are required to successfully complete the most current version of the e-learning course ?safe
Bulletin:
T-SB-0125-15 Rev
Component:
150000 seat belts
Summary:
Tsb: warranty operation codes updated. some 2004 ? 2006 model year sienna vehicles may exhibit a condition where the front driver and/or passenger seat belt becomes abnormally slow to retract, or does not retract smoothly. follow the proc
Bulletin:
T-TT-0086-11
Component:
100000 power train
Summary:
Techtip: condition - the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
Bulletin:
T-SB-0039-15_Rev
Component:
350000 equipment
Summary:
Tsb: revision notice may 25, 2018 rev1: * the introduction, production change information, and repair procedure sections have been updated. any previous printed versions of this bulletin should be discarded. some 2003 - 2011 model year toyo
Bulletin:
ZF2_Expired Reme
Component:
151000 seat belts:front
Summary:
Dealer package: july 2, 2018 a watermark has been added to the dealer letter to indicate that zf2 expired on june 30, 2018. toyota has received a number of reports regarding front seatbelts in certain 2004 ? 2006 model year sienna vehicles
Bulletin:
T-SB-0057-18
Component:
350000 equipment
Summary:
Tsb: supersession notice the information contained in this bulletin supersedes service bulletin no. t-sb-0043-14. ? applicability has been updated to include 2017 ? 2018 model year toyota vehicles. service bulletin no. t-sb-0043-14 is obso
Bulletin:
T-SB-0304-17_Rev
Component:
350000 equipment
Summary:
Tsb: revision notice july 31, 2018 rev2: ? the supersession notice has been updated. january 11, 2018 rev1: ? the supersession notice has been updated. any previous printed versions of this bulletin should be discarded. supersession notice
Bulletin:
PG004-97-Obsolet
Component:
350000 equipment
Summary:
Technical service bulletin: obsolete notice: july 31, 2018: this bulletin is now obsolete. please see t-sb-0304-17.
Bulletin:
PG006-01-Obsolet
Component:
350000 equipment
Summary:
Technical service bulletin: obsolete notice: july 31, 2018: this bulletin is now obsolete. please see t-sb-0304-17.
Bulletin:
Safety Recall an
Component:
350000 equipment
Summary:
Update on technician certification requirements.
Bulletin:
ZE6-Toyota POL14
Component:
350000 equipment
Summary:
Warranty policy bulletin: toyota has received reports where some vehicles may exhibit cracked and/or sticky/melting dashboards as a result of heat or humidity. in mid-december, 2014, toyota announced the reimbursement phase of this voluntar

Home | Privacy