2005 GMC SIERRA 2500 Recalls (3)

Campaign:
06E010000 on 01/31/2006
Component:
Steering
Affected:
1,360
Defect:
Certain fabtech aftermarket replacement pitman arms, p/nos. fts71000 and fts71001, installed for use on certain 2001-2006 gm c/k 2500 pick up trucks and sport utility vehicles. the pin located inside the pitman arm can shear off due to a reverse bending fatigue condition, resulting in a total loss of steering control.
Consequence:
Loss of steering control could lead to a vehicle crash with potential injury or death.
Correction:
Fabtech will notify owners and replace the pitman and idler arms free of charge. the recall is expected to begin during february 2006. owners may contact fabtech at 909-597-7800.
Notes:
This recall only pertains to aftermarket fabtech replacement pitman arms and has no relation to any original equipment installed on c/k 2500 pick ups, suvs, and hummer h2 vehicles manufactured by general motors.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
06E050000 on 06/05/2006
Component:
Service brakes, air
Affected:
6,800
Defect:
Certain federal-mogul national and carquest aftermarket hub assemblies, p/n 515058, sold for use on 2001-2006 general motors 1500 and 2500 4wd trucks. on the subject hub assemblies, the abs sensor cord departs from the hub assembly at a 90 degree angle. as a result, there is a fit issue with the brake rotor dust shield interfering with the abs sensor cord. if the hub assembly is installed despite this interference, the gap between the abs sensor and the tone wheel may be altered. this may weaken the output of the abs sensor. diminished output could result in an unwanted abs activation at low speeds and stopping distance could be affected.
Consequence:
If stopping distance is limited, a vehicle crash could occur.
Correction:
Federal-mogul will notify its owners and will either credit the customers account or replace the unit. the recall is expected to begin during june 2006. owners can contact federal-mogul customer service at 1-800-563-8507 ext 3530.
Notes:
This recall only pertains to aftermarket national and carquest hub assemblies and has no relation to any original equipment installed on vehicles manufactured by general motors.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
08V519000 on 10/06/2008
Component:
Equipment adaptive
Manufactured:
03/31/2005 - 09/05/2006
Affected:
133
Defect:
Mobilityworks is recalling 133 my 2005-2006 ford e250, my 2000, 2004-2006 e350, my 2000, 2005 e450, my 2005-2006 gmc 2500, gmc 3500, and my 2006 dodge 2500 vans equipped with ricon platform style wheelchair lifts. these lifts fail to comply with the requirements of federal motor vehicle safety standard no. 403, "platform lift systems for motor vehicles." the anti-stow interlock may not detect the presence of a wheelchair or mobility aid user. the pressure sensing switch that detects the presence of weight on the platform was not adjusted to the necessary sensitivity level. the lift could stow even though someone or something is still on the lift.
Consequence:
A lift occupant can be injured should the lift begin to stow unintentionally.
Correction:
Mobilityworks is working with ricon to correct the wheelchair lifts free of charge (please see 07e097). owners may contact ricon at 1-818-267-3000 or mobilityworks at 1-800-769-8267.
Notes:
Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.

2005 GMC SIERRA 2500 TSBs (89)

Bulletin:
030309002
Component:
020000 suspension
Summary:
Rear leaf spring slap or clunk noise (replace spring inserts) *tt updated 10/18/07. *nj
Bulletin:
3189
Component:
170000 latches/locks/linkages
Summary:
Unable to disable auto door locks. this includes 05 chevrolet gmc cadillac full size trucks and utilities. *eh also includes avalance, silverado suburban tahoe; gmc sierra, yukon, denali, yukon xl, denali xl. updated 8/26/08. *pe
Bulletin:
609
Component:
353600 equipment:air conditioner
Summary:
A/c low pressure switch diagnosis. *sc
Bulletin:
SB-07-06-04-019A
Component:
061000 engine and engine cooling:engine
Summary:
General motors: intermittent mil/ses/ dtc p2138 with reduced engine power (repair instrument panel (ip) to body harness connector). 2005-08 gm passengers cars/light duty trucks (incl. saturns). *pe updated 11/5/10. *pe updated 4/4/1
Bulletin:
SB-09-06-03-004A
Component:
110000 electrical system
Summary:
Gm/hummer/saab: intermittent illumination of mil, service lamps, service messages, or dtc set by various control modules-diagnosing and repairing fretting corrosion (disconnect affected connector and apply dielectric lubricant). *pe up
Bulletin:
05-09-40-002E
Component:
151200 seat belts:front:webbing
Summary:
Gm: service bulletin explaining when the safety belts are supposed to lock. *rm updated 12/6/11. *pe
Bulletin:
PIT-3749D
Component:
161000 structure:frame and members
Summary:
Gm: on some truck models there is some frame corrosion. *rm updated on 5/2/2012. *kb
Bulletin:
CSP-10414
Component:
111000 electrical system:battery
Summary:
Gmc/chevrolet: see docuemtn search button for owner letter. auxiliary battery feed may cause fusible link to melt and open circuit to prevent damage or fire in wiring harness, due to electrical over load. *pe
Bulletin:
PIC-5260-A
Component:
110000 electrical system
Summary:
This preliminary information communication advises the technician the steps on diagnosing the concern. vehicle's sunroof operation intermittent, bind, noise, auto-reverse, and/or water leaks.
Bulletin:
PIC-5050-A
Component:
110000 electrical system
Summary:
This preliminary information communication advises the technician the steps on repairing the concern. a customer may identify a concern of unable to reactivate a vehicle's onstar that has been previously disabled by onstar. dealer is to ca
Bulletin:
PIC-4935-E
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to help the dealership technicians perform a parasitic drain test for the onstar module. when performing battery parasitic drain test, there may be some confusion as to what th
Bulletin:
PIP5094A
Component:
110000 electrical system
Summary:
This preliminary information communication advises the technician that ,when testing any circuit for open or resistance, it is imperative that all related terminal pin fit and tension be checked when the test steps require disconnection of
Bulletin:
16NA260
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
This technical bulletin provides a procedure to reprogram the media disc player with the latest calibrations to correct a condition of the rear entertainment system not operating as intended in colder ambient temperature areas due to calibr
Bulletin:
000601012F
Component:
060000 engine (pws)
Summary:
This informational bulletin provides information to gm dealers on the correct cleaning methods when cleaning engine gasket sealing surfaces.
Bulletin:
000601026I
Component:
060000 engine (pws)
Summary:
This informational bulletins provides information on the intake manifold inspection/replacement after servere internal engine damage.
Bulletin:
030603004R
Component:
060000 engine (pws)
Summary:
This informational bulletin provides information on how to test a battery and what is needed to warranty a battery.
Bulletin:
030604017I
Component:
061200 engine and engine cooling:engine:diesel
Summary:
This informational bulletin explains the use of diesel fuel additives in an engine, are not required unless the customer desires additives to prevent fuel concerns depending on fuel or temperature related conditions.
Bulletin:
PI1394A
Component:
060000 engine (pws)
Summary:
This informational bulletin provides additional information on how to install pistons and suggest what tools to use.
Bulletin:
PIP4786C
Component:
060000 engine and engine cooling
Summary:
This preliminary information communication provides information to the technician about vehicles that may have low oil pressure message. technician may also find a diagnostic trouble code p0521 in the engine control module. technician shoul
Bulletin:
PIT5074J
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about the use of j-35616-64b terminal test probe, replacement terminals, and terminated leads. the j-35616-64b is the latest test probe released for checking
Bulletin:
PIC4935E
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to help the dealership technicians perform a parasitic drain test for the onstar module. when performing battery parasitic drain test, there may be some confusion as to what th
Bulletin:
PIC5050A
Component:
353000 equipment:electrical
Summary:
This preliminary information communication advises the technician the steps on repairing the concern. a customer may identify a concern of unable to reactivate a vehicle's onstar that has been previously disabled by onstar. dealer is to ca
Bulletin:
PIC5088F
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
This preliminary information communication advises the technician on the steps to diagnose and repair the concern. the vehicle's xm radio only has xm preveiw channels.
Bulletin:
PIC5260A
Component:
130000 visibility
Summary:
This preliminary information communication advises the technician the steps on diagnosing the concern. vehicle's sunroof operation intermittent, bind, noise, auto-reverse, and/or water leaks.
Bulletin:
PIT5389A
Component:
353500 equipment:electrical:navigational system(global positioning system)
Summary:
This preliminary information communication advises the technician on the steps for diagnosing the concern. the vehicle may be unable to connect to onstar using the white, blue or red onstar buttons.
Bulletin:
PIT5485B
Component:
110000 electrical system
Summary:
This preliminary information communication advises the technician if unable to place an onstar call in the ignition on mode after the onstar canada upgrade, to contact the gm technical assistance center onstar group for further assistance.
Bulletin:
PIT5485A
Component:
110000 electrical system
Summary:
This preliminary information communication advises the technician, if unable to place an onstar call in the ignition on mode after the onstar canada upgrade to contact the gm technical assistance center onstar group for further assistance.
Bulletin:
PI0373A
Component:
135000 visibility:rearview mirrors/devices
Summary:
This preliminary informational bulletin provides a procedure for relearning the power folding mirriors and road testin to verify they correct a condtion of the power folding mirriors glass shakes, flutters at normal driving conditions.
Bulletin:
PIC5953
Component:
353000 equipment:electrical
Summary:
This preliminary information communication provides information to the technician about vehicles that may have an issue when using bluetooth voice recognition with an iphone. technician should work with the customer to insure the phone cont
Bulletin:
PIP5163A
Component:
060000 engine and engine cooling
Summary:
This preliminary information communication provides information to the technician about engine block of possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leakage or blo
Bulletin:
PIC4310J
Component:
353000 equipment:electrical
Summary:
This preliminary information communication provides information to the technician about vehicle that may have an onstar system that has progression tones when pressing the blue or red button. technician will need to call general motors tech
Bulletin:
PIC5959B
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
This preliminary information communication provides information to the technician about vehicle that has no xm audio on certain channels but xm channel info is displayed. technician will need to contact xm and deactivate and activate the mo
Bulletin:
PIT3099M
Component:
356000 equipment adaptive
Summary:
This preliminary information communication provides information to the technician about installing general motors accessory pats. technician can check service information for some accessories. technician can also contact partect for assista
Bulletin:
PIP5226
Component:
060000 engine and engine cooling
Summary:
This preliminary information communication provides information to the technician about finding needle bearings during an oil change. technician will gain access to the roller rockers to inspect them. only replace the roller rocker that is
Bulletin:
PIP5163
Component:
060000 engine and engine cooling
Summary:
This preliminary information communication provides information to the technician about engine block of possible cylinder bore damage, scoring or out of round as the possible cause of engine oil consumption, misfire, cylinder leakage or blo
Bulletin:
PIT3237F
Component:
131000 visibility:windshield
Summary:
This preliminary information communication provides information to the technician about the percentage of ultraviolet protection or tint offered by the windshield or side glass. technician should be advised windshield reduces ultraviolet ra
Bulletin:
PIT3099J
Component:
356000 equipment adaptive
Summary:
This preliminary information communication provides information to the technician about installing general motors accessory parts. technician can check service information for some accessories. technician can also contact partech for assist
Bulletin:
PIC4935D
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about vehicles that during battery parasitic drain test, there may be some confusion as to what the normal power consumption reading should be from the onstar
Bulletin:
PIT4208D
Component:
015300 steering:hydraulic power assist:power steering fluid
Summary:
This preliminary information communication provides information to the technician about vehicles that may have a power steering pump whine noise. technician will need to flush and refill the power steering system with lucas power steering f
Bulletin:
PIT4907A
Component:
030000 brakes (pws)
Summary:
This preliminary information communication provides information to the technician about brake rotors on new vehicles and replacement parts from general motors service parts operations. technician should be advised the costing should not be
Bulletin:
PIP3720D
Component:
106000 power train:axle assembly
Summary:
This preliminary information communication provides information to the technician with the axel setup information from american axle manufacturing. technician should be advised that the maximum pinion shim to be used or stacked behind the p
Bulletin:
PIT3173C
Component:
060000 engine and engine cooling
Summary:
This preliminary information communication provides information to the technician that fluid contamination may be directed to one of the following testing centers according to the type of fluid needing testing. dealer should send the correc
Bulletin:
PIC3718E
Component:
110000 electrical system
Summary:
This preliminary information communication provides information to the technician about vehicles may have a no power or no connect concern. technician will find that the onstar led is red and diagnostic trouble code u1500 is set. technician
Bulletin:
PIP5094
Component:
110000 electrical system
Summary:
This preliminary information communication advises the technician that, when testing any circuit for open or resistance, it is imperative that all related terminal pin fit and tension be checked when the test steps require disconnection of
Bulletin:
PIT5399
Component:
353000 equipment:electrical
Summary:
This preliminary information communication provides information to the technician about connectivity concerns when connecting an apple device via usb cord. technician should insure the customer is using an original equipment manufacturer ap
Bulletin:
PIP5232B
Component:
063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
Summary:
This preliminary information communication provides information to the technician about gasoline powered cars, mid-size trucks, light duty trucks, and heavy duty trucks with premature catalytic converter failures. it is recommended to inspe
Bulletin:
10-00-89-017V
Component:
356000 equipment adaptive
Summary:
This informational bulletin provides information on newly release bulletins used to fi the vehicles in the field the first time.
Bulletin:
11-00-89-005B
Component:
356000 equipment adaptive
Summary:
This warranty administrational bulletin provides information on clarification of use - dealer empowerment labor operations and customer enthusiasm
Bulletin:
09-07-30-018C
Component:
100000 power train
Summary:
This warranty administration bulletin provides information on the change in automatic transmission add conditions documentation and claim submissions
Bulletin:
PI0373A
Component:
135000 visibility:rearview mirrors/devices
Summary:
This preliminary informational bulletin provides a procedure for relearning the power folding mirriors and road testin to verify they correct a condtion of the power folding mirriors glass shakes, flutters at normal driving conditions.
Bulletin:
12-00-89-007
Component:
355100 equipment:other:labels
Summary:
This informational bulletin provides information on dealer responsibility for cargo carrying capacity labeling and the part numbers for the labels.
Bulletin:
06-06-01-007G
Component:
060000 engine and engine cooling
Summary:
This informational bulletin provides information on identifying duramax diesel overpower engine breakdown/non-function due to aftermarket power-up devices vs non overpower engine non-function of pistons, cylinders, valvetrain components, dt
Bulletin:
PIT5570A
Component:
162500 structure:body:tailgate
Summary:
This preliminary information communication provides the technician with weight capacity for the tailgate and cargo loops in the bed.
Bulletin:
PIT3946B
Component:
350000 equipment
Summary:
This preliminary information communicates an issues with the headliner sagging and how to reattachthe velcrousing hardman double bubble epoxy part number 04001.
Bulletin:
PIC3100F
Component:
117000 digital instrument panel
Summary:
This preliminary information communication provides information to the technician about vehicle's odometer appears to be inaccurate relative to a known distance traveled. technician should obtain a hand-held gps unit to test the odomete
Bulletin:
PIC5588B
Component:
350000 equipment
Summary:
This preliminary information communication provides information to the technician on the programming and activation of the onstar system. for many 2008 and prior model year gm vehicles, the programming is performed using the tech 2 and the
Bulletin:
PIC5088E
Component:
350000 equipment
Summary:
This preliminary information communication provides information to the technician about vehicles that may not receiving all channels on the xm band. technician will need to use a scan tool and verify current digital radio receiver status un
Bulletin:
1008110001C
Component:
350000 equipment
Summary:
This information provides the proper way to install the floor mats .
Bulletin:
030848006J
Component:
138000 visibility:defroster/defogger system
Summary:
This informational bulletin provide information for the technicians to repair the rear window defroster contact or tabs.
Bulletin:
05-00-89-029C
Component:
355200 equipment:other:owners/service/other manual
Summary:
This preliminary bulletin provides a information to the dealer for the requirements need for equipment.
Bulletin:
PIC5088E
Component:
353400 equipment:electrical:radio/tape deck/cd etc.
Summary:
This preliminary bulletin provides procedures on how to reset or refresh the xm radio receiver is the customers states that they only get a few channels.
Bulletin:
PI0373B
Component:
135000 visibility:rearview mirrors/devices
Summary:
This preliminary bulletin provides a procedure on how to reset the power folding mirriors after they been folded manually, to fix the customers concern of the mirriors shaking or fluttering at normal driving speeds.
Bulletin:
050308002F
Component:
020000 suspension
Summary:
This informational bulletin was created to aid the technician in diagnosing the difference between a shock or strut that has a fluid residule from a possible external source from a leaking shaft seal.
Bulletin:
06-06-01-007I
Component:
060000 engine and engine cooling
Summary:
This informational bulletin provides information to dealership personnel on identifying duramax diesel overpower engine breakdown or non-function due to aftermarket power-up devices vs. non overpower engine non-function of pistons, cylinder
Bulletin:
05-03-07-009H
Component:
200000 wheels
Summary:
This warranty administration bulletin provides retail, wholesale and fleet personnel with general motors recommendations for customer concerns related to wheel alignment.
Bulletin:
PIP3343F
Component:
092200 fuel system, other:delivery:hoses, lines/piping, and fittings
Summary:
This preliminary information communication provides information to the technician about vehicles that have an oil leak shortly after a cold start when extremely low ambient temperatures are present. technician will need to clean the area of
Bulletin:
PIT3665F
Component:
030000 brakes (pws)
Summary:
This preliminary information communication advises the technician that the hydro-boost is not serviceable and will need to be replaced if the brake pedal moves or applies on its own at a full turn.
Bulletin:
PIP4138Q
Component:
120000 exterior lighting
Summary:
This preliminary information communication provides information to the technician about vehicles that have a service engine soon malfunction indicator lamp on, engine misfire, and/or engine noise. technician may find diagnostic trouble code
Bulletin:
PIT3098F
Component:
160000 structure
Summary:
This preliminary information communication provides information to the technician about vehicles that have a lean to the left or right. technician will need to measure fender wheel-opening heights, front and rear, to quantify vehicle lean.
Bulletin:
PIT5195D
Component:
117000 digital instrument panel
Summary:
This preliminary information communication provides information to the technician about vehicles that the speedometer needle appears to be inaccurate. dealer should advise the customer the specification for speedometer needle accuracy is +/
Bulletin:
PIT3219E
Component:
121300 exterior lighting:headlights:high/low beam dimmer switch
Summary:
This preliminary information communicates to techniciansthat the daytime running lamps (drl's) or the auto headlamps will not shut off when using the daytime running lamp disable switch (which is part of the headlamp switch), if the veh
Bulletin:
06-08-47-001M
Component:
355200 equipment:other:owners/service/other manual
Summary:
This information bulletin explains the labor operation numbers used for submitting warranty claims and how to setup, and reprogram modules.
Bulletin:
15-08-44-001I
Component:
118000 electrical system: software
Summary:
This informational bulletin provides information for the gm of canada onstar cellular communication upgrade to 3g/4g lte for vehicles that may need an upgrade.
Bulletin:
15-08-73-001A
Component:
118000 electrical system: software
Summary:
This informational bulletin explains how to update the older onstar module software to new software over gsa.
Bulletin:
17-NA-073
Component:
355200 equipment:other:owners/service/other manual
Summary:
This warranty administration bulletin provides policy information with the field action courtesy transportation policy.
Bulletin:
11-00-89-005C
Component:
355200 equipment:other:owners/service/other manual
Summary:
This warranty administration bulletin provides information on the clarification of use for dealer empowerment labor operations and customer enthusiasm
Bulletin:
10-00-89-017X
Component:
355200 equipment:other:owners/service/other manual
Summary:
This informational bulletin provides a list off all the issues revolving around new vehicles for a one stop place to find growing concerns around them.
Bulletin:
120089007A
Component:
350000 equipment
Summary:
This informational bulletin provides information on dealer responsibility for cargo carrying capacity labeling and the part numbers for the labels.
Bulletin:
03-00-91-001G
Component:
020000 suspension
Summary:
This informational bulletin provides a vibration analysis worksheet the technician can use in conjunction with the appropriate vibration analysis-road testing procedure, when diagnosing vibration concerns.
Bulletin:
07-06-03-009C
Component:
110000 electrical system
Summary:
This informational bulletin adds 2011 - 2014 model years to information on voltmeter gauge fluctuation due to regulated voltage control system and concerns about camper/trailer battery charging.
Bulletin:
PI1391
Component:
060000 engine and engine cooling
Summary:
This preliminary informational bulletin provides a diagnostic tip for coolant leak at oil cooler inlet pipe o-ring after service engine replacement.
Bulletin:
07-06-03-009D
Component:
110000 electrical system
Summary:
This informational bulletin adds models to information on voltmeter gauge fluctuation due to regulated voltage control system and concerns about camper/trailer battery charging.
Bulletin:
PI1394
Component:
060000 engine and engine cooling
Summary:
This preliminary informational bulletin provides technicians an engine repair tip for installation of pistons.
Bulletin:
00-03-10-002I
Component:
200000 wheels
Summary:
This informational bulletin provides information on chemical staining, pitting, corrosion and/or spotted appearance of chromed aluminum wheels, along with warranty information regarding these conditions.
Bulletin:
06-08-47-001K
Component:
110000 electrical system
Summary:
This informational bulletin provides information on control module diagnostics and configuration, programming using the tis service programming system (sps), set-up and warranty.
Bulletin:
10-08-45-001E
Component:
110000 electrical system
Summary:
This informational bulletin updates information on electrical ground repairs using new replacement fasteners with conductive finish.
Bulletin:
PIP3366C
Component:
103000 power train:automatic transmission
Summary:
This preliminary information communicates to the dealer technician thatlight duty trucks equipped with automatic transmissions and 4 wheel drive may exhibit a condition of grinding/ratcheting type noise when shifting the automatic transmiss
Bulletin:
PIP4379N
Component:
100000 power train
Summary:
This preliminary information communication provides information to the technician about vehicles that have not engagement into drive, delayed, no engagement into reverse, and or a range inhibit. technician may find diagnostic trouble codes
Bulletin:
PIP4138R
Component:
060000 engine and engine cooling
Summary:
This preliminary information communication provides information to the technician about vehicles that have a service engine soon malfunction indicator lamp on, engine misfire, and/or engine noise. technician may find diagnostic trouble code

Home | Privacy