2005 CHRYSLER PT CRUISER Recalls (5)
- Campaign:
- 04V268000 on 06/02/2004
- Component:
- Steering:hydraulic power assist:hose, piping, and connections
- Manufactured:
- 01/16/2000 - 04/25/2004
- Affected:
- 438,391
- Defect:
- On certain passenger vehicles equipped with 2.4l non-turbocharged engines and automatic transaxles, the power steering pressure hose may contact the automatic transaxle differential cover, potentially damaging the hose.
- Consequence:
- Power steering fluid leakage in the presence of an ignition source can result in an underhood fire.
- Correction:
- Dealers will inspect and relocate, or replace as necessary, the power steering hose and confirm torque of the hose fastener at the steering gear end. the recall began on september 20, 2004. owners should contact daimlerchrysler at 1-800-853-1403.
- Notes:
- Daimlerchrysler recall no. d18.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 04V481000 on 10/11/2004
- Component:
- Service brakes, hydraulic:antilock
- Manufactured:
- 08/09/2004 - 09/02/2004
- Affected:
- 115
- Defect:
- Certain passenger vehicles equipped with 4-wheel antilock braking system (abs), 2.4l high output turbocharged engine, and 5-speed manual transaxle, may exhibit inadequate clearance between the left front brake tube and the transaxle housing.
- Consequence:
- Contact between the brake tube and the transaxle housing over an extended period of time may eventually lead to perforation of the brake tube, which could lead to a loss of braking force in the left front/right rear circuit of vehicle.
- Correction:
- Dealers will install revised brake tubes. the recall began october 25, 2004. owners should contact daimlerchrysler at 1-800-853-1403.
- Notes:
- Daimlerchrysler recall no. d45.customers can also contact the national highway traffic safety administration?s auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 07V149000 on 04/03/2007
- Component:
- Visibility:glass, side/rear
- Manufactured:
- 05/16/2005 - 08/31/2005
- Affected:
- 38,447
- Defect:
- On certain passenger vehicles, the rear quarter glass attaching fasteners may pull through their mounts and allow the glass to separate from the vehicle.
- Consequence:
- If the glass separates while driving, it could strike another vehicle or injure a pedestrian.
- Correction:
- Dealers will replace the rear quarter glass. the recall began on april 30, 2007. owners may contact daimlerchrysler at 1-800-853-1403.
- Notes:
- Daimlerchrysler recall no. g01.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 08E033000 on 04/16/2008
- Component:
- Suspension
- Affected:
- 6,903
- Defect:
- Federal mogul is recalling 6,903 aftermarket ball joint assemblies shipped between november 9, 2007 and march 26, 2008, which may have been packaged with incorrect nuts. the part numbers packaged with incorrect nuts are: k7147, k7329, k8683, and 104353. these parts were made for use on the various vehicles listed above.
- Consequence:
- The nuts included in the packaging for these ball joint assemblies are missing the intended prevailing torque (self-locking) feature. if the incorrect nut was to become loose, the joining members may loosen leading to a separation of the ball joint. this may result in loss of vehicle control, possibly resulting in a vehicle crash.
- Correction:
- Federal mogul will notify owners and replace the parts free of charge. the recall began on may 22, 2008. owners can contact federal mogul at 877-489-6659.
- Notes:
- This recall only pertains to aftermarket ball joint assemblies and has no relation to any original equipment installed on vehicles manufactured by the vehicle manufacturers.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 09E012000 on 04/06/2009
- Component:
- Exterior lighting
- Affected:
- 16,270
- Defect:
- Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
- Consequence:
- Decreased lighting visibility may result in a vehicle crash.
- Correction:
- Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on may 11, 2009. owners may contact sabersport at 1-909-598-7589.
- Notes:
- This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by sabersport.the list can be found under "document search" located at the bottom of your screen.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
2005 CHRYSLER PT CRUISER TSBs (40)
- Bulletin:
- 0802801
- Component:
- 121000 exterior lighting:headlights
- Summary:
- Moisture accumulation inside a vented headlamp assembly condition. *tt
- Bulletin:
- 1800604A
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Generic powertrain control module (pcm) procedure. *tt *mj this bulletin supersedes bulletin 18-006-04a dated 04/06/2004. *tt
- Bulletin:
- 2300704
- Component:
- 162000 structure:body
- Summary:
- Proper front seat belt routing and twist. convertible 2005. *tt
- Bulletin:
- 04001
- Component:
- 110000 electrical system
- Summary:
- Temporary change to dealer storage procedure. battery cable disconnection. *tt
- Bulletin:
- 2100804
- Component:
- 110000 electrical system
- Summary:
- Malfunction indicator lamp (mil) illumination -diagnostic trouble code (dtc) p1776 solenoid switch valve latched in lr position. *mj this bulletin replaces 21-008-04 dated june 1, 2004. *tt
- Bulletin:
- 1802404
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Idle fluctuation and or malfunction indicator lamp (mil) illumination diagnostic trouble codes p0300, p0301, p0302, p0303 or p0304. *tt
- Bulletin:
- 0901304
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Gasoline engine oil quality and viscosity grades. *tt
- Bulletin:
- 1803504
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Malfunction indicator lamp illumination with diagnostic trouble code p0339: flash. *tt this bulletin supersedes bulletin 18-035-04, dated september 1, 2004. *tt
- Bulletin:
- 1804204
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Driveability improvements or malfunction indicator lamp (mil) illumination with diagnostic trouble codes p2074. flash. *tt
- Bulletin:
- 1901004
- Component:
- 010000 steering
- Summary:
- Power steering fluid contamination. *tt
- Bulletin:
- 0801405
- Component:
- 110000 electrical system
- Summary:
- Mopar accessory remote starter inoperative due to hood switch. *tt
- Bulletin:
- 0600105
- Component:
- 102000 power train:manual transmission
- Summary:
- Transmission gear rattle sound at idle. *tt
- Bulletin:
- 2302105
- Component:
- 132000 visibility:glass, side/rear
- Summary:
- Wind noise at side window. *sc
- Bulletin:
- 0801505
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Powertrain control module initialization. *sc
- Bulletin:
- 0900105
- Component:
- 060000 engine and engine cooling
- Summary:
- Cylinder head bolt re-torque procedure. gpop - issue review system. *tt
- Bulletin:
- 2304304
- Component:
- 980000 unknown or other
- Summary:
- Transit film removal. 2006 chrysler pt cruiser, and 2005-2006 ram truck *sc
- Bulletin:
- 05008
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Rapid response transmittal service action #05-008a. turbo engine bent valve or valves. *tt
- Bulletin:
- 1900805
- Component:
- 010000 steering
- Summary:
- Revised power steering system bleeding procedures. *sc
- Bulletin:
- 1800707
- Component:
- 102000 power train:manual transmission
- Summary:
- Driveability improvements. reprogramming the powertrain control module (pcm) with new software. *kb
- Bulletin:
- 0803006
- Component:
- 103000 power train:automatic transmission
- Summary:
- Powertrain control module initialization. *kb
- Bulletin:
- 0800107
- Component:
- 140000 air bags
- Summary:
- Passenger air bag deactivation. *kb
- Bulletin:
- 1802907
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Generic powertrain control module (pcm) procedure. *kb
- Bulletin:
- 18-016-13
- Component:
- 118000 electrical system: software
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- 9003623
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Wiper if mopar oe wipers are unavailable, the below alternatives can be offered instead. 05066964a$ = wbrw0011a$ 05066973a$ = wb000019a$ or wbf00019a$ 05096134a$ = wb000027a$ or wbf00028a$ 55154762a$ = wb000013a$ 68001330a$ = wb000019
- Bulletin:
- RL108213A$
- Component:
- 060000 engine and engine cooling
- Summary:
- Nag1 (5a580) valve body as per warranty bulletin d-13-22, please use r2108213a$ valve body for all warranty (w), mopar (m) and mopar vehicle protection (f) claims.~ assembly also includes filter (52108325aa) and gasket (52108332aa).~
- Bulletin:
- 9002850
- Component:
- 162000 structure:body
- Summary:
- 05127352a$ - headliner, convertible convertible pt cruiser headliners 05127352ab and 05127352ac do not come with the welt that goes around the rear glass opening. the welt will need to be removed from the existing headliner, and sewn on
- Bulletin:
- 9002519
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- 82212076, 82203694 - fabric cleaner this "fabric cleaner" is not intended for sale in california, the otc states (connecticut, delaware, massachusetts, maine, new hampshire, new jersey, new york, pennsylvania, virginia, and washington dc
- Bulletin:
- 20616
- Component:
- 110000 electrical system
- Summary:
- P/n cbszr068aa: inspect & return: module kit - occupant restraint you have been identified as either having stock, or have stock in transit to your dealership. please return part number cbszr068aa as per the qir attached. replacement par
- Bulletin:
- 22892
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Return: lamp assy - chmsl& cargo light you have been identified as either having stock, or have stock in transit to your dealership. please return all stock of follow ing part numbers:55372082ae, 55372082ad, 55372082ac, 55372082ab, 553720
- Bulletin:
- 22867
- Component:
- 110000 electrical system
- Summary:
- Inspect and return: solenoid module - transmission you have been identified as either having stock, or have stock in transit to your dealership. please return suspect stock of follow ing part numbers:52120000aa, 52119435af, 05078709ab. s
- Bulletin:
- 22958
- Component:
- 117000 digital instrument panel
- Summary:
- 1nt30xdvac - inspect and return: panel - instrument panel you have been identified as either having stock, or have stock in transit to your dealership. please return suspect stock of part number 1n t30xdvac. see attachments for identifyin
- Bulletin:
- 20244
- Component:
- 350000 equipment
- Summary:
- Cbxdp361aa return: spacer kit - visor you have been identified as either having stock, or have stock in transit to your dealership. please return stock of part number cbxdp361aa. replacement part number is cbxdp361ab w hich is in stock a
- Bulletin:
- Volume 2, Issue
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Warranty operations newsletter updates from warranty operations
- Bulletin:
- Volume 2, Issue
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Warranty operations newsletter updates from warranty operations
- Bulletin:
- 23137
- Component:
- 350000 equipment
- Summary:
- Inspect and return: trim cover assy - a-pillar rt/lt you have been identified as either having stock, or have stock in transit to your dealership. please return suspect stock of part numbers: 1za04dx9ae, 1za05dx9ae. see attachments for id
- Bulletin:
- 23104
- Component:
- 120000 lighting (pws)
- Summary:
- 05182535ad - lamp assy ?tail light lt you have been identified as either having stock, or have stock in transit to your dealership. please return suspect stock of part number 05182535ad . see attachments for identifying suspect stock. pl
- Bulletin:
- 23027
- Component:
- 114000 electrical system:wiring
- Summary:
- Return: wiring assy - engine you have been identified as either having stock, or have stock in transit to your dealership. please return stock packaged before 2016/07/31 (31 july, 2016)of follow ing part numbers:68176457af, 68176459af. p
- Bulletin:
- 9002850
- Component:
- 162900 structure:body:roof and pillars
- Summary:
- 05127352a$ - headliner, convertible convertible pt cruiser headliners 05127352ab and 05127352ac do not come with the welt that goes around the rear glass opening. the welt will need to be removed from the existing headliner, and sewn on
- Bulletin:
- 9002850
- Component:
- 160000 structure
- Summary:
- 05127352a$ - headliner, convertible convertible pt cruiser headliners 05127352ab and 05127352ac do not come with the welt that goes around the rear glass opening. the welt will need to be removed from the existing headliner, and sewn on
- Bulletin:
- 18-042-14
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Generic powertrain control module (pcm) procedure this bulletin involves programming a generic pcm with software.
Home | Privacy