2004 VOLKSWAGEN GOLF Recalls (6)

Campaign:
04V586000 on 12/15/2004
Component:
Fuel system, diesel
Manufactured:
02/29/2004 - 08/28/2004
Affected:
19,284
Defect:
On certain passenger vehicles, the high pressure diesel pumps were produced with an improper fastener, which could allow diesel fuel to escape from the pump.
Consequence:
Fuel leakage in the presence of an ignition source may lead to a fire.
Correction:
Dealers will replace the diesel pump. the recall began on february 8, 2005. owners should contact volkswagen at 1-800-822-8987.
Notes:
Vw recall no. vy.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
07V063000 on 02/20/2007
Component:
Exterior lighting:brake lights:switch
Manufactured:
01/31/2000 - 07/30/2005
Affected:
1,002,000
Defect:
On certain passenger, wagon, and convertible vehicles equipped with or without cruise control, a brake light switch may malfunction if it was installed incorrectly.
Consequence:
The brake lights could become inoperative, or remain on. failure to provide the proper signal when braking could lead to a crash without warning.
Correction:
Dealers will install the newly designed brake light switch free of charge. the recall began on april 27, 2007, and will be conducted in several staggered mailings through september 21, 2007. vehicles within the make, model, and model year of this population may be involved in either this recall or 06v-183, but not both. the remedy is the same for each recall. volkswagen dealers will apply the remedy based on the vin number of the vehicle. owners may contact vw at 1-800-822-8987.
Notes:
Volkswagen recall no. n4.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
07E023000 on 03/28/2007
Component:
Service brakes, hydraulic:foundation components:master cylinder
Affected:
13,128
Defect:
Certain cardone master cylinders with part numbers 10-2925, 10-2987, 10-2987mza, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, and 11-3156, and with date codes lower than dca7078 sold as replacement equipment for use on the vehicles listed above. the seal on master cylinder can fail and leak brake fluid.
Consequence:
Loss of brake fluid can result in poor braking performance, possibly resulting in a vehicle crash.
Correction:
Cardone will notify owners and offer to repurchase any defective master cylinders. the recall began during april 2007. owners can contact cardone at 1-800-777-4780.
Notes:
This recall only pertains to aftermarket cardone master cylinders and has no relation to any original equipment installed on the vehicles listed above.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Campaign:
09E012000 on 04/06/2009
Component:
Exterior lighting
Affected:
16,270
Defect:
Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Consequence:
Decreased lighting visibility may result in a vehicle crash.
Correction:
Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on may 11, 2009. owners may contact sabersport at 1-909-598-7589.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by sabersport.the list can be found under "document search" located at the bottom of your screen.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
09E025000 on 05/10/2009
Component:
Exterior lighting:headlights
Affected:
42,540
Defect:
Dope, inc. is recalling 42,540 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Consequence:
Decreased lighting visibility may result in a vehicle crash.
Correction:
Dope, inc. will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on july 28, 2009. owners may contact dope, inc. at 1-626-272-1798.
Notes:
This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by dope, inc.the list can be found under "document search" located at the bottom of your screen. owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Campaign:
14E007000 on 03/11/2014
Component:
Engine and engine cooling:engine
Affected:
50
Defect:
The gates corporation (gates) is recalling certain aftermarket tru-flow water pumps, part number tfw 41127, sold at certain napa auto parts and/or installed by automotive service technicians after november 1, 2013 (and manufactured august 2013 through october 2013) that have a black-colored pulley/sprocket or do not have 'us9377' stamped on the water pump housing. these service replacement parts were sold for use in model year 1999-2005 audi a4, 2000-2006 audi tt, 1998-2005 volkswagen beetle, 1999-2006 golf, 1999-2008 and 2011-2013 volkswagen jetta, and 2000-2005 volkswagen passat. in the affected water pumps, the pulley or sprocket that turns the timing belt may develop microfractures causing the timing belt to fail.
Consequence:
A failure of the timing belt may cause the engine to shut down, potentially increasing the risk of a vehicle crash.
Correction:
Gates will notify owners, and dealers will replace the water pump, free of charge. the recall began during may 2014. owners may contact the gates corporation at 1-303-744-1911.
Notes:
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

2004 VOLKSWAGEN GOLF TSBs (108)

Bulletin:
0401
Component:
125100 exterior lighting:brake lights:switch
Summary:
New style brake light switch requires care during installation to prevent damage to switch. *tt
Bulletin:
0401
Component:
102000 power train:manual transmission
Summary:
Reverse gear, difficult to engage or disengage. *mr
Bulletin:
0409
Component:
061000 engine and engine cooling:engine
Summary:
Evaluating fuel mixture diagnostic trouble codes- how to perform effective diagnosis related to fuel system adaptation - system too rich/too lean. volkswagen. *mj
Bulletin:
0412
Component:
110000 electrical system
Summary:
Malfunction indicator light (mil) on, diagnostic trouble codes (dtcs) stored in diagnostic trouble code (dtc) memory. *mj
Bulletin:
0401
Component:
110000 electrical system
Summary:
Malfunction indicator lamp (mil) on with diagnostic trouble codes (dtc) p1347/17755 and p1340/17748 stored in memory. including various models volkswagen 2002-2003. *mj
Bulletin:
0403
Component:
061000 engine and engine cooling:engine
Summary:
Hard starting or no start when wet, runs rough on initial start, may be accompanied by light gray smoke. *mj
Bulletin:
0403
Component:
061000 engine and engine cooling:engine
Summary:
Engine, fluctuating idle or idle speed too low. *mj
Bulletin:
004
Component:
060000 engine and engine cooling
Summary:
Engine coolant temperature (ect) sensor. *tc
Bulletin:
0502
Component:
110000 electrical system
Summary:
Diagnostic trouble code (dtc) p1603 (18011) stored in dtc memory. *tt
Bulletin:
230501
Component:
061000 engine and engine cooling:engine
Summary:
Runs rough on initial start at temperatures below -7 degrees c (20 degrees f). *tt update. *tt update. *tt
Bulletin:
VV
Component:
221700 seats:front assembly:seat heater/cooler
Summary:
Comfort seats may have a seat heater element that can malfunction when the ignition switch is on. customer satisfaction campaign vv. *tt
Bulletin:
0405
Component:
061000 engine and engine cooling:engine
Summary:
Hard starting (extended cranking required) or no start when wet, runs rough on initial start, may be accompanied by light gray smoke. *tt
Bulletin:
0511
Component:
110000 electrical system
Summary:
Diagnostic trouble code (dtc) p0101 (16485) stored in dtc memory. *tt
Bulletin:
0501
Component:
132000 visibility:glass, side/rear
Summary:
Door window, separates from window regulator clamps. *jb
Bulletin:
11292005
Component:
060000 engine and engine cooling
Summary:
Engine pre-heater installation. calix. *tt
Bulletin:
0502
Component:
062000 engine and engine cooling:cooling system
Summary:
Customer states heater output seems insufficient. *tt
Bulletin:
M3
Component:
221700 seats:front assembly:seat heater/cooler
Summary:
Customer satisfaction campaign circular - seat heater element can malfunction when the ignition switch is on and the seat heater switch is on. the seat heater mat may temporarily overheat and become inoperative. install new passenger side
Bulletin:
VZ
Component:
221700 seats:front assembly:seat heater/cooler
Summary:
Comfort seats may have a seat heater element that can malfunction when the ignition switch is on. customer satisfaction campaign vz. *tt
Bulletin:
0601
Component:
221700 seats:front assembly:seat heater/cooler
Summary:
Heated seat bottom cover replacement. *kb
Bulletin:
0603
Component:
133000 visibility:power window devices and controls
Summary:
Door windows, may seperate from window regulator clamps. *kb
Bulletin:
010702
Component:
062300 engine and engine cooling:cooling system:hose
Summary:
Dtc's p1297 (17705) or p1557 (17965) stored in dtc memory. this may be caused by intake hoses leaking (during boost conditions) due to incorrect torque on clamps or improper placement, worn or torn intake hoses. *kb
Bulletin:
2010461
Component:
061000 engine and engine cooling:engine
Summary:
Hard starting (extended cranking required) or no start when wet, runs rough on initial start, may be accompanied by light gray smoke. *kb
Bulletin:
2010462
Component:
061000 engine and engine cooling:engine
Summary:
Rough on initial start at temperatures below 20 degrees f. *kb
Bulletin:
VV
Component:
221700 seats:front assembly:seat heater/cooler
Summary:
Customer satisfaction campaign circular. install driver's side heater repair kit. seat heater may malfunction when the ignition switch is on. this could cause the heater mat to temporarily overheat and become inoperative. *kb
Bulletin:
VV-VV00
Component:
221700 seats:front assembly:seat heater/cooler
Summary:
Customer satisfaction campaign circular: certain vehicles equipped with comfort seats: install driver's side seat heater repair kit. *pe updated 3/23/09. revision to customer satisfaction campaign. *pe updated 3/17/10. *
Bulletin:
VZ-VZ00
Component:
221700 seats:front assembly:seat heater/cooler
Summary:
Volkswagen: certain vehicles equipped with comfort seats; install new passenger side seat heater switch. this include jetta wagon. *pe updated 3/23/09. revision to customer satisfaction campaigns for seat heaters. *pe up
Bulletin:
2015831
Component:
063000 engine and engine cooling:exhaust system
Summary:
Volkswagen: exhaust heat shield, replacement guidelines. heat shields are to be inspected after completion o any type of repair to the underbody (exhaust system transmission, etc.), and if damaged, replaced. *pe
Bulletin:
060910
Component:
221700 seats:front assembly:seat heater/cooler
Summary:
Volkswagen service campaign: see document search button for owner letter. revised expiration dates for seat heater customer satisfaction campaigns. affected vehicles may have a seat heater element than can malfunction when the ignition sw
Bulletin:
SB-28F3
Component:
061000 engine and engine cooling:engine
Summary:
Volkswagen: vehicles may have ignition coils that could malfunction under certain conditions. if this happens, the malfunction indicator lamp (mil) will illuminated to let you know that the vehicle may experience some deterioration in per
Bulletin:
SA-28F3
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Volkswagen: (revised) vehicles may have ignition coils that could malfunction under certain conditions. if this happens, the malfunction indicator lamp (mil) will illuminated to let you know that vehicle may experience some deterioration
Bulletin:
SA-60A7-S9
Component:
134000 visibility:sun roof assembly
Summary:
Volkswagen service campaign: see document search button for owner letter. inspect, clean and modify sunroof drains for certain volkswagen vehicles and revised maintenance schedule; sunroof drain inspection and cleaning. no models or model
Bulletin:
TB-01-10-13
Component:
118000 electrical system: software
Summary:
Volkswagen: update programming; engine runs rough on initial start at temperatures below-7%c (20%f). software update and new injectors. installing new injectors and engine control model update-programming (flashing) using software version
Bulletin:
TB-00-10-06
Component:
510000 child seat:latch connector
Summary:
Volkswagen: child restraint latch guidance fixture; compliance with fmvss 225 (usa only). update to existing technical bulletin. no production change required. all models. *pe
Bulletin:
SAC-28F3/P1-REV
Component:
061000 engine and engine cooling:engine
Summary:
Volkswagen: gasoline engine vehicles inspect, and if necessary, replace ignition coils. vehicles affected by this action may have ignition coils that could malfunction under certain conditions. models passat and wagon; golf; gti; jetta a
Bulletin:
SA-28F6
Component:
061200 engine and engine cooling:engine:diesel
Summary:
Volkswagen service campaign: see document search button for owner letter. engine software may cause the vehicle to exceed emissions standards. *rm
Bulletin:
TB-35-11-01
Component:
013000 steering:gear box (other than rack and pinion)
Summary:
Volkswagen: the gear box has a momentarily delay while accelerating. *rm
Bulletin:
TB-01-12-04
Component:
061000 engine and engine cooling:engine
Summary:
Volkswagen: gasoline engines have rough idle, have significant loss of power or stalling with reduced performance. *pe
Bulletin:
2038887
Component:
162300 structure:body:door
Summary:
Summary to be provided on a future date.
Bulletin:
V501606_2011761
Component:
162200 structure:body:bumpers
Summary:
To update claim processing statement.
Bulletin:
TT 97-14-02
Component:
110000 electrical system
Summary:
Tech tip denoting potential for damage of the data link connector when using after market plug in devices or scan tools and subsequent diagnostic direction.
Bulletin:
V551613_2039446
Component:
162000 structure:body
Summary:
To update model table to clarify jetta wagon applicability to tb content.
Bulletin:
TT 50-14-01
Component:
190000 tires
Summary:
Tech tips (all vehicles-tire dressing for vehicle detailing): the use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle. this document informs that the use of non-water based products wil
Bulletin:
V941403 2011521
Component:
120000 exterior lighting
Summary:
Technical bulletin (exterior lights, moisture accumulation): this document informs of the condensation and or water droplets visible on inside of exterior light lenses. the document also informs how to service the issue.
Bulletin:
TT 32-14-01
Component:
103700 power train:automatic transmission:torque converter
Summary:
Tech tips (torque converter/flywheel/flexplate installation): incorrect torque converter or flywheel/flexplate installation can result in transmission damage. when installing an engine, flywheel or transmission, please follow the installat
Bulletin:
Quick Reference
Component:
118000 electrical system: software
Summary:
Quick reference update guide: this document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle
Bulletin:
V871409 2019947
Component:
353600 equipment:air conditioner
Summary:
Technical bulletin (air conditioning, cleaning of the refrigerant circuit): in cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or component is circ
Bulletin:
V171404 2012855
Component:
060000 engine (pws)
Summary:
Technical bulletin (engine oils which meet volkswagen oil quality standard): this document informs of a sample list of products generally available in the north american market that meet the volkswagen oil quality standard
Bulletin:
Elsa Newsletter
Component:
200000 wheels
Summary:
Summary of technical bulletin to include additional model and model year applicability. corrosion, front fenders, at upper wheel opening (u.s. only)
Bulletin:
V501601 2011761
Component:
162000 structure:body
Summary:
Information on areas surface corrosion or corrosion perforation can occur on various locations around the front wheel arch. also gives examples of how to calculate cost to repair or replace
Bulletin:
V551603 2039446
Component:
356000 equipment adaptive
Summary:
Document discusses corrosion that may be found on the folded edge of the hood. the corrosion may be found on this edge anywhere around the hood. it discusses how to service it, and document that service. it discusses where to find what appl
Bulletin:
V501602 2011761
Component:
162000 structure:body
Summary:
Document refers to surface corrosion or corrosion perforation that can occur on various locations around the front wheel arch. it gives examples on where to check for repair coverage from warranties, fixing possible issues, and how to docu
Bulletin:
V011602 2014815
Component:
070000 fuel system, gasoline
Summary:
Technical tips on what to do if improper gasoline has been added to the vehicle.
Bulletin:
TT 97-14-02ss1
Component:
110000 electrical system
Summary:
Tech tips damage to data link connector (dlc) from aftermarket devices (cannot communicate with vehicle obd system)
Bulletin:
V501604 2014370
Component:
162000 structure:body
Summary:
Technical bulletin about paint finish, reducing swirl marks and fine scratches new vehicles (prior to retail delivery) with swirl marks and or fine scratches from polishing or cleaning. the document also have infromation about where to fi
Bulletin:
V271501 2011894
Component:
111000 electrical system:battery
Summary:
Technical bulletin: battery, testing and charging using midtronics vas6161, mcr340v, incharge 940, or grx3000vas charger
Bulletin:
V551501 2039446
Component:
355200 equipment:other:owners/service/other manual
Summary:
Technical bulletin (corrosion hood edge ): document discusses diagnosis, and potential remedy of issue. the document also has example claim forms for repears. the diagnosis codes for checking warranty coverage for servicing the vehicle are
Bulletin:
V501501 2011761
Component:
355200 equipment:other:owners/service/other manual
Summary:
Technical bulletin corrosion, front fenders, at upper wheel opening (u.s. only) ): document discusses diagnosis, and potential remedy of issue. the diagnosis codes for checking warranty coverage for servicing the vehicle are also available
Bulletin:
V011503 2014815
Component:
070000 fuel system, gasoline
Summary:
Discusses the issues associated with using contaiminated gasoline. there are recommendations to use top tier gasoline retailers
Bulletin:
V941501 2011521
Component:
120000 exterior lighting
Summary:
Technical bulletin: condensation and or water droplets becomming visible on inside of exterior light lenses issue is discussed in this document
Bulletin:
V641501 2039887
Component:
162300 structure:body:door
Summary:
Technical bulletin (rear door glass inoperative issue diagnosis): the rear glass cannot be opened / closed, the rear glass may slide down into the door, or the rear glass motor operates but the glass does not move
Bulletin:
V271503 2016076
Component:
111000 electrical system:battery
Summary:
Technical bulletin: battery, discharged, diagnosis for excessive static current draw
Bulletin:
TT 20-13-01
Component:
091200 fuel system, other:storage:fuel gauge system
Summary:
Tech tips (ecm fault p1250 "fuel level too low" will not clear): this document informs to clear static ecm fault p1250 "fuel level too low", add fuel to vehicle and complete a road test of at least 10 miles. simply adding fuel without co
Bulletin:
TT 64-14-02
Component:
138200 visibility:defroster/defogger system:rear window
Summary:
Tech tips (heated rear window, one or more lines inoperative): to detect which line(s) is inoperative, utilize a volt meter to check for 0 v, which will be present after the open in the grid line. this document informs of how to diagnose t
Bulletin:
V851401 2012432
Component:
353600 equipment:air conditioner
Summary:
Technical bulletin (temperature output control cannot be adjusted): customer states cannot adjust temperature and/or a/c is not cold. the blend door control lever moves freely, but the blend door does not operate. a bushing that fits on t
Bulletin:
PDI - GOLF GTI T
Component:
355200 equipment:other:owners/service/other manual
Summary:
Golf/gti perfect delivery inspection (pdi) - technician and detailer inspections:
Bulletin:
V571405 2038887
Component:
162000 structure:body
Summary:
Technical bulletin (corrosion on the fold of the front inner door): this document informs of the method to repair corrosion under the door fold in the area of the extra seal and the poly vinyl chloride (pvc) foil. this document discusses
Bulletin:
TT 00-14-03
Component:
118000 electrical system: software
Summary:
Tech tips (svm update instructions): this document informs when performing svm updates, the scan tool should be hardwired to the vehicle and the bluetooth physically turned off. a hard wired internet connection is also recommended.
Bulletin:
V641502 2039887
Component:
132000 visibility:glass, side/rear
Summary:
Technical bulletin (rear door glass inoperative): the rear glass cannot be opened / closed, the rear glass may slide down into the door, or the rear glass motor operates but the glass does not move. this document contains the fault codes,
Bulletin:
TT 64-14-02
Component:
110000 electrical system
Summary:
Tech tips (heated rear window, one or more lines inoperative): to detect which line(s) is inoperative, utilize a volt meter to check for 0 v, which will be present after the open in the grid line. the check must be performed with the engin
Bulletin:
V921502 2026253
Component:
130000 visibility
Summary:
Technical bulletin (windshield wipers streak or smear): windshield or rear window is streaked, has a snakeskin appearance, or the surface feels rough. to avoid unnecessary replacement of wiper blades, the condition and cleanliness of the w
Bulletin:
V871508 2005566
Component:
060000 engine and engine cooling
Summary:
Technical bulletin (hvac, unpleasant odor): unpleasant odor is coming from heating and ventilation system. odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first start
Bulletin:
V871506 2019947
Component:
060000 engine and engine cooling
Summary:
Technical bulletin (air conditioning, cleaning of the refrigerant circuit (u.s.only)): in cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or compon
Bulletin:
V571503 2038887
Component:
160000 structure
Summary:
Technical bulletin (corrosion on the fold of the front inner door): corrosion under the door fold in the area of the extra seal and the poly vinyl chloride (pvc) foil. this document contains information on how to diagnose, and service this
Bulletin:
V941402 2011521
Component:
121000 exterior lighting:headlights
Summary:
Technical bulletin (exterior lights, moisture accumulation): exterior light assemblies (headlights, taillights, fog lights, turn signals) are vented and may collect moisture on their inner surfaces, depending on humidity and other climatic
Bulletin:
V871401 2005566
Component:
353600 equipment:air conditioner
Summary:
Technical bulletin (hvac, unpleasant odor): unpleasant odor is coming from heating and ventilation system. odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first start
Bulletin:
V011408 2014815
Component:
060000 engine (pws)
Summary:
Technical bulletin the use of contaminated gasoline, seasonal fuel changes (summer/winter fuel) or gasoline with a low content of deposit control additives may result in one or more of the following conditions: -excessive accumulation of
Bulletin:
V011407 2014603
Component:
118000 electrical system: software
Summary:
Technical bulletin this technical bulletin details the general process for carrying out a software version management (svm) software update for any technical bulletin (tsb) / required vehicle update (rvu).
Bulletin:
V871402 2005566
Component:
353600 equipment:air conditioner
Summary:
Technical bulletin (hvac, unpleasant odor): condensation, which is a normal condition in all a/c systems, can cause a musty odor. if the odor is noticeable in the vehicle when the engine is not turned on, the cause may be mold and mildew i
Bulletin:
V001404 2010380
Component:
350000 equipment
Summary:
Technical bulletin (squeaks, rattles, noise, repair materials): this doucment contains a list of components and applications developed to repair concerns of squeaks, rattles, noise and trim fit conditions.
Bulletin:
Reference - Refl
Component:
118000 electrical system: software
Summary:
Quick reference update guide: this document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle
Bulletin:
TT 24-08-01
Component:
060000 engine (pws)
Summary:
Tech tips (models with 1.8t engine - pressure loss issues): fault code p1297 may be set and fuel mixtures may go lean if the vehicle is driven under load or revved up and then returned to idle. this document informs of what to do should th
Bulletin:
V171403 2017813
Component:
060000 engine (pws)
Summary:
Technical bulletin (oil consumption measurement): customer states oil consumption is higher than the volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. in order to provide effective lubricati
Bulletin:
TT 87-10-05
Component:
353600 equipment:air conditioner
Summary:
Tech tips (air conditioning does not operate): this document informs of concerns of no or intermittent a/c operation where pressure diagnosis does not lead to a cause, be sure to check the n25 a/c clutch coil. the fan control module may se
Bulletin:
TT 20-09-06
Component:
061120 engine and engine cooling:engine:gasoline:turbo-charger
Summary:
Tech tips (tdi engine - n75 solenoid valve diagnosis): this document informs with graphical aid the testing of the n75 solenoid valve in the event of a turbocharger fault code such as p0299 or p0234. this applies to mechanical injection st
Bulletin:
TT 00-13-02
Component:
355200 equipment:other:owners/service/other manual
Summary:
Tech tips (technician helpline vehicle check sheets): when it becomes necessary to open a vw technician helpline vta case while performing diagnosis for a diesel particulate filter, manual transmission repair, or turbocharger concern, it
Bulletin:
TT 200901
Component:
355200 equipment:other:owners/service/other manual
Summary:
Update to existing tip for fuel quality checking.
Bulletin:
V171302 2017813
Component:
060000 engine and engine cooling
Summary:
Technical bulletin (oil consumption measurement): customer states oil consumption is higher than the volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. in order to provide effective lubrica
Bulletin:
PDI - GOLF GTI T
Component:
355200 equipment:other:owners/service/other manual
Summary:
golf perfect delivery inspection (pdi) - technician and detailer inspections: a checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has purch
Bulletin:
TT 37-06-06
Component:
100000 power train
Summary:
Tech tips (vehicles with 09g or 09a transmission -- replacing transmission): this document informs if you replace one of these transmissions, check etka to see if you must also replace the transmission control module (tcm) at the same ti
Bulletin:
TT 21-13-01
Component:
061120 engine and engine cooling:engine:gasoline:turbo-charger
Summary:
Tech tips (equipped with turbocharged engine turbocharger replacement tip): if mechanical damage is found to the turbocharger (e.g. damaged compression wheel, loose or broken shaft), it is not enough to just replace the turbocharger. thi
Bulletin:
PDI - GOLF GTI T
Component:
355200 equipment:other:owners/service/other manual
Summary:
Golf perfect delivery inspection (pdi) - technician and detailer inspections: a checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has purcha
Bulletin:
V871620 2005566
Component:
355200 equipment:other:owners/service/other manual
Summary:
Update model and model year applicability.
Bulletin:
V691601 2010479
Component:
355200 equipment:other:owners/service/other manual
Summary:
Update model year applicability to include 2017.
Bulletin:
V871622 2019947
Component:
353600 equipment:air conditioner
Summary:
Update to model year applicability.
Bulletin:
V011615 2014815
Component:
060000 engine (pws)
Summary:
Update to include additional model year applicability.
Bulletin:
TT 00-16-02
Component:
350000 equipment
Summary:
Reminder for dealers to reference the repair manual and replace all necessary fasteners (bolts, nuts) that cannot be re-used
Bulletin:
Update 02122016
Component:
118000 electrical system: software
Summary:
Quick reference of vehicle concerns. includes a list of software versions and the technical bulletin numbers that referred to the concerns updated
Bulletin:
TT 97-12-02
Component:
355200 equipment:other:owners/service/other manual
Summary:
data link connector pin assignment chart that is applicable to all models. update model year applicability.
Bulletin:
1-2017 Update
Component:
355200 equipment:other:owners/service/other manual
Summary:
This communication is to update our profi dealers of the current status of the latest inbound and outbound profi requests.
Bulletin:
Ref. - Reflash U
Component:
118000 electrical system: software
Summary:
Quick reference update guide of the vehicles expected upgraded software level. the latest corresponding technical bulletins that address the issues, and concerns that have been had with the vehicles.
Bulletin:
Elsa 6-22-15
Component:
350000 equipment
Summary:
This document contains the vw elsa newsletter that contains a general overview of wiring diagrams updates, elsapro infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, tech
Bulletin:
Elsa 6-29-15
Component:
355200 equipment:other:owners/service/other manual
Summary:
This document contains the vw elsa newsletter that contains a general overview of wiring diagrams updates, technical bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions.
Bulletin:
V571605-2038887
Component:
355200 equipment:other:owners/service/other manual
Summary:
To update claim processing statement.
Bulletin:
V551612-2039446
Component:
162800 structure:body:hood
Summary:
Corrosion may be found on the folded edge of the hood. supersedes tb v551603
Bulletin:
Quick Reference
Component:
118000 electrical system: software
Summary:
Quick reference of vehicle concerns. includes a list of software versions and the technical bulletin numbers that referred to the concerns updated
Bulletin:
V171701 2012855
Component:
060000 engine and engine cooling
Summary:
17 17 01 july 5, 2017 2012855 supersedes technical bulletin 17-16-02 (v171602) dated april 29, 2016 due to updated oil standards lists to current specifications. engine oils which meet volkswagen oil quality standards
Bulletin:
TT001703
Component:
118000 electrical system: software
Summary:
Tip for scan tool concerns that may occur duing a test plan
Bulletin:
A971861 2013504-
Component:
110000 electrical system
Summary:
This information bulletin contains instructions for checking the pins/terminals for contacts and nano contacts.

Home | Privacy