2004 NISSAN XTERRA Recalls (3)
- Campaign:
- 04V581000 on 12/13/2004
- Component:
- Trailer hitches
- Manufactured:
- 07/12/2004 - 07/19/2004
- Affected:
- 131
- Defect:
- On certain sport utility vehicles, the accessory tow hitch attachment bolts may not have been tightened to the proper specification.
- Consequence:
- This could cause the tow hitch to loosen or separate from the vehicle which could result in a crash without warning.
- Correction:
- Dealers will tighten the tow hitch. the recall began on january 3, 2005. owners should contact nissan at 1-800-647-7261.
- Notes:
- Nissan recall no. pb124.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 07E046000 on 07/05/2007
- Component:
- Equipment
- Affected:
- 3,500
- Defect:
- Certain hopkins aftermarket trailer brake control connection harnesses sold for use on certain models of nissan vehicles which are listed above. the internal part numbers within hopkins are: 1010476025, 1040376025, 1110476025, 1170376025, 1290376025, 1010476035, 1040376035, 1110476035, 1170376035, and 1290376035. a wire may have been placed in an incorrect position in the electrical connector housing. this results in an incorrect routing of wires between the trailer brake controller and the towing vehicle wiring system.
- Consequence:
- This harness would result in power from the trailer brake controller going to the towing vehicle dash light circuit rather than the trailer brakes. this result would be the lack of trailer braking when the towing vehicle brakes were applied. it would also result in the towing vehicles dash lights being activated when the vehicle brakes were applied. the failure of the application of the trailer brake could result in reduced ability to stop and contribute to a possible crash.
- Correction:
- Hopkins will notify owners and replace the original harness with a revised harness free of charge. the recall began august 17, 2007. owners can contact hopkins at 800-835-0129.
- Notes:
- This recall only pertains to aftermarket harnesses and has no relation to any original equipment installed on vehicles manufactured by nissan.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 10V554000 on 11/11/2010
- Component:
- Steering:column
- Manufactured:
- 07/08/2001 - 01/05/2005
- Affected:
- 500,552
- Defect:
- Nissan is recalling certain model year 2002-2004 frontier vehicles manufactured from july 9, 2001 through october 20, 2004, and model year 2002-2004, xterra vehicles manufactured from july 9, 2001, through january 6, 2005. over time corrosion may form in the lower steering column joint and limit movement of the joint. the limited movement of this joint may create excessive load on the lower steering column shaft. if the vehicle continues to be driven in this condition, it may lead to cracking of the shaft during low speed maneuvers that require large steering inputs.
- Consequence:
- The shaft may break which could result in loss of steering control during these low speed maneuvers increasing the risk of a crash.
- Correction:
- The steering column shaft and joint will be replaced with a shaft of a different design. this service will be performed free of charge. the recall began on december 13, 2010. owners may contact nissan at 1-800-647-7261.
- Notes:
- Nissan safety recal no. r1037.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
2004 NISSAN XTERRA TSBs (19)
- Bulletin:
- 02120A
- Component:
- 036000 service brakes, hydraulic:antilock
- Summary:
- Antilock braking system (abs) light on and / or diagnostic trouble code for abs wheel speed sensor. *tt
- Bulletin:
- 04083
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Supercharger noise at idle and lack of power. *tt
- Bulletin:
- 04091
- Component:
- 021220 suspension:front:springs:torsion bar
- Summary:
- Torsion bar spring caution. *tt
- Bulletin:
- 04095
- Component:
- 105500 power train:driveline:differential unit
- Summary:
- Front differential side mounting bolt service campaign. *nm service campaign bulletin dated september 1, 2004. *tt
- Bulletin:
- 04133
- Component:
- 135000 visibility:rearview mirrors/devices
- Summary:
- Auto-dimming electrochromic (ec) mirror diagnosis. *tt
- Bulletin:
- 05120
- Component:
- 103000 power train:automatic transmission
- Summary:
- No a/t upshift after hill with ascd (automatic speed control device) on. *tt
- Bulletin:
- 06009
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Malfunction indicator lamp on with diagnostic trouble code u1000 or u1010 stored in engine control unit. *ak
- Bulletin:
- 03030
- Component:
- 120000 exterior lighting
- Summary:
- Exterior lamp fogging. *kb
- Bulletin:
- NTB08-049
- Component:
- 103000 power train:automatic transmission
- Summary:
- Nissan; special automatic transmission fluid requirement. 2004 to current nissan vehicles. *nj
- Bulletin:
- NTB08-062
- Component:
- 220000 seats
- Summary:
- Seat back board removal/installation. *nj
- Bulletin:
- NTB-08-055-A
- Component:
- 141100 air bags:frontal:sensor/control module
- Summary:
- Nissan: srs precautions during service;improper maintenance, including incorrect removal and installation of the srs, can lead to a serious injury or death caused by unintentional activation of the srs on all nissan models with the srs sys
- Bulletin:
- NTB-09-030
- Component:
- 110000 electrical system
- Summary:
- Nissan: the 12 volt battery is an important part of the vehicle electrical system and is required to stay connected when the engine is running. to prevent damage to vehicle electronic components follow the instructions/cautions. no mod
- Bulletin:
- NTB-09-101
- Component:
- 199000 tires:pressure monitoring and regulating systems
- Summary:
- Nissan: tire pressure monitoring system (tpms) warning light on/flashing. no models or model years listed. *pe updated on 08-11-2011. *kb
- Bulletin:
- NTB-03-074-C
- Component:
- 120000 exterior lighting
- Summary:
- Nissan: exterior lamp fogging. occasionally water is noticed in the exterior lamps. this is generally not due to a defect. all current exterior lamp assemblies are vented to the atmosphere (not sealed). this is necessary to allow for e
- Bulletin:
- NTB-09-129
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Nissan: vent control valve replacement. when replacing the evap canister vent control valve for reason: use the one listed on page 2; for vent control valve replacement procedure, refer to the appropriate section of the electronic service
- Bulletin:
- NTB-10-052
- Component:
- 021600 suspension:front:wheel bearing
- Summary:
- Nissan: the propeller shaft u joint (journal/journal bearings) is the source of noise and/or vibration on an applied vehicle. diagnose by evaluating the u joint with the propeller shaft removed. replace the u joint (journal/journal beari
- Bulletin:
- NTB12-035
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Nissan: ecm replacement procedures with consult iii plus. applies to all 2004 and later (does not apply to leaf/ev) vehicles. *js
- Bulletin:
- NTB-13-038
- Component:
- 170000 latches/locks/linkages
- Summary:
- Nissan: lock/unlock request button on outside handle does not respond. *js
- Bulletin:
- NTB17-026
- Component:
- 021000 suspension:front
- Summary:
- Ball joint axial end play procedure service information when working on the front suspension, use the updated service information in this bulletin along with the electronic service manual (esm). the updated information in this bulletin
Home | Privacy