2004 JAGUAR X-TYPE Recall
- Campaign:
- 04V460000 on 09/20/2004
- Component:
- Fuel system, gasoline:storage:tank assembly:filler pipe and cap
- Manufactured:
- 12/31/2003 - 02/26/2004
- Affected:
- 1,147
- Defect:
- On certain passenger vehicles, when replace the fuel filler cap to the vehicle's fuel tank filler neck, it is possible to over-tighten the cap inducing a poor seal. in the event of a vehicle roll-over, it is possible for fuel to leak past the fuel filler cap.
- Consequence:
- Fuel leakage, in the presence of an ignition source, could result in a fire.
- Correction:
- Dealers will remove the fuel cap seals and fit better quality seals onto the vehicle. the recall began on october 1, 2004. customers may also contact jaguar at 1-800-452-4827.
- Notes:
- Jaguar recall no r955.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
2004 JAGUAR X-TYPE TSBs (43)
- Bulletin:
- 50110
- Component:
- 170000 latches/locks/linkages
- Summary:
- Remote transmitter not functioning internal chip fault replace transmitter. *eh replace service bulletin xt501-10 dated 01/04. *eh
- Bulletin:
- 21101
- Component:
- 015000 steering:hydraulic power assist system
- Summary:
- Squeaking noise power steering system flush system. *eh
- Bulletin:
- 50115
- Component:
- 162600 structure:body:hatchback/liftgate
- Summary:
- Liftgate glass hard to close rear wiper inoperative check adjustment procedure. *eh
- Bulletin:
- 50115
- Component:
- 162000 structure:body
- Summary:
- Washer fluid leak at elbows repair procedure. *eh
- Bulletin:
- 10008
- Component:
- 105300 power train:driveline:driveshaft
- Summary:
- Driveshaft vibration diagnostic method repair. *eh update. *tt amended version 09/04. *tt
- Bulletin:
- 50117
- Component:
- 162000 structure:body
- Summary:
- Inability to open close luggage compartment lid actuator binding revised actuator available. *eh
- Bulletin:
- 50116
- Component:
- 162600 structure:body:hatchback/liftgate
- Summary:
- Creak squeak when opening liftgate or glass lubricate clevis pins repair procedure. *eh
- Bulletin:
- 10009
- Component:
- 105300 power train:driveline:driveshaft
- Summary:
- Driveline whine preliminary checks. *eh
- Bulletin:
- 501952
- Component:
- 162600 structure:body:hatchback/liftgate
- Summary:
- Liftgate spoiler contacting roof high ambient temperatures canadian vehicles service action s952. *eh replace service bulletin xt501s952 dated 06/04. *eh
- Bulletin:
- 50118
- Component:
- 162000 structure:body
- Summary:
- Water leaks in rear of wagon vehicles possible causes of water entry repair techniques. *eh
- Bulletin:
- 41702
- Component:
- 121000 exterior lighting:headlights
- Summary:
- Condensation in headlamps revised cap available repair procedure. *eh
- Bulletin:
- 50120
- Component:
- 162310 structure:body:door:hinge and attachments
- Summary:
- Luggage compartment lid not opening correctly spring actuators install revised parts. *eh
- Bulletin:
- 50114
- Component:
- 136000 visibility:windshield wiper/washer
- Summary:
- Washer fluid leakage at front fender leak at elbows repair procedure. *eh
- Bulletin:
- 50121
- Component:
- 220000 seats
- Summary:
- Premature front seat backrest wear on classic style seats - outer bolster support wire - modification procedure. update. *tt original. *tt
- Bulletin:
- 30806
- Component:
- 102000 power train:manual transmission
- Summary:
- Difficult engaging first or reverse gear, especially when the vehicle is cold. *tt
- Bulletin:
- 303953
- Component:
- 103000 power train:automatic transmission
- Summary:
- Driveline shudder/hesitation - 30 - 50 mph - automatic transmission vehicles - reprogram ecm - service action s953. *tt
- Bulletin:
- 30315
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Coolant leak from thermostat housing - supplemental repair to service action s939. *tt
- Bulletin:
- 41202
- Component:
- 138000 visibility:defroster/defogger system
- Summary:
- Vehicle fogging/climate control slow to cool vehicle - air blend door loose - repair procedure. *tt
- Bulletin:
- 310947
- Component:
- 071100 fuel system, gasoline:storage:tank assembly
- Summary:
- Inspection of fuel tank harness - possible connector damage - service action s947. *tt
- Bulletin:
- 50113
- Component:
- 174200 latches/locks/linkages:hatchback/liftgate:lock
- Summary:
- Installation of latch for liftgate glass - lubricate replacement latches - lubrication method. *tt
- Bulletin:
- 501951
- Component:
- 221600 seats:front assembly:power adjust
- Summary:
- Memory seats - front seat harness interference with adjuster mechanism - service action s951. *tt
- Bulletin:
- 21101
- Component:
- 015000 steering:hydraulic power assist system
- Summary:
- Squeaking noise power steering repair procedure. *ak
- Bulletin:
- 501036
- Component:
- 131000 visibility:windshield
- Summary:
- Windshield heater inoperative. *kb
- Bulletin:
- 00010
- Component:
- 192000 tires:sidewall
- Summary:
- Permanent high spot marking to tire inboard sidewall. *kb
- Bulletin:
- 501026
- Component:
- 980000 unknown or other
- Summary:
- Tonneau cover bar- locating pegs loose/sheared. *kb
- Bulletin:
- JTB00007
- Component:
- 251000 electronic stability control:automatic (asc)
- Summary:
- Dynamic stability control (dsc) lamp illuminated after cranking. *kb updated 4/28/08. *nj
- Bulletin:
- JTB00093
- Component:
- 015300 steering:hydraulic power assist:power steering fluid
- Summary:
- Power assist steering leak/heavy/noisy - diagnostic aid. *nj
- Bulletin:
- S-527
- Component:
- 342000 communications:back up alarm
- Summary:
- Jaguar: key fob remote corrective modification. the remote control key fob fails to operate leading to customers using the mechanical key blade to lock/unlock the vehicle, and to turn off the alarm. csc letter was received. *pe
- Bulletin:
- TSB-J004
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- Jaguar: non compliance issues relating to on board diagnostic (obd) system function covering thermostat diagnostic, calibration verification, in use monitor performance ratio, and an emission issue relating to open loop smoothing have been
- Bulletin:
- SSM-68358
- Component:
- 350000 equipment
- Summary:
- This ssm has been released to address the high number of speaker assemblies returned, many of which are deemed as 'n fault found'. cause: incorrect diagnosis."
- Bulletin:
- SSM-72805
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- Issue: a customer may raise a concern of their vehicle not passing state inspection in california and there is no warning light or other suggestion of a fault.
- Bulletin:
- SSM63597
- Component:
- 118000 electrical system: software
- Summary:
- "issue: jaguar land rover north america service diagnostics would like to make all sdd users aware of an emerging concern being tracked via the epqr system. users report dvd133 is unable to fully communicate with pcm on legacy jaguar veh
- Bulletin:
- SSM71361
- Component:
- 118000 electrical system: software
- Summary:
- "issue: da-dongle/da-vina/da-st512 - j2534 vehicle communication interface device (vci) software requires updating to the latest level. da j2534 software driver level ' v4.0 (must be updated to this level on all sdd machines that use thi
- Bulletin:
- SSM51357
- Component:
- 091200 fuel system, other:storage:fuel gauge system
- Summary:
- "issue: when investigating customer reports for incorrect fuel gauge concerns the dealer technician may diagnose that the fuel senders are open circuit. this diagnosis may be incorrect depending on the multimeter settings selected by the
- Bulletin:
- SSM37157
- Component:
- 110000 electrical system
- Summary:
- "re-issued dec 2015. please note that as yet jaguar vehicles with bulb failure monitoring systems for trailer light failure sensing are not compatible with trailer light boards that have led based illumination. as a result of this the le
- Bulletin:
- SSM39290
- Component:
- 110000 electrical system
- Summary:
- "help with diagnosing any issues / faults can be gained by phoning your jaguar technical helpline to help us with our analysis please ensure that you have the following information available before contacting jaguar cars: vin vehicle t
- Bulletin:
- 68358
- Component:
- 350000 equipment
- Summary:
- "issue: this ssm has been released to address the high number of speaker assemblies returned, many of which are deemed as 'no fault found'. cause: incorrect diagnosis."
- Bulletin:
- SFCC_14DEC17
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Presentation from dealer shop foreman conference call
- Bulletin:
- SFCC_08MAR18
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Jaguar land rover shop foreman conference call
- Bulletin:
- SFCC_09AUG18_REV
- Component:
- 350000 equipment
- Summary:
- Incontrol touch pro phase 4 customer letter
- Bulletin:
- SFCC_09AUG18_REV
- Component:
- 350000 equipment
- Summary:
- Sim card activation issues
- Bulletin:
- SFCC_09AUG18_REV
- Component:
- 110000 electrical system
- Summary:
- 18c - new face of incontrol touch pro and 18c software improvements
- Bulletin:
- SFCC_09AUG18_REV
- Component:
- 110000 electrical system
- Summary:
- A customer may report "hood open" message displays on ip with hood closed.
Home | Privacy