2003 VOLVO VT TSBs (39)
- Bulletin:
- RTJ-16629
- Component:
- 071100 fuel system, gasoline:storage:tank assembly
- Summary:
- Volvo: leakage detection diagnostics improvements to remedy dtc's. all models from model years 2003-2008. diagnostic monitor for the evaporative emission system small leak, has used a software function that calculates leakage based on a pr
- Bulletin:
- SB-364-025
- Component:
- 101000 power train:clutch assembly
- Summary:
- Volvo truck; clutch switch clip; it has been found that vn, vhd and vt vehicles use a spring clip to retain the clutch switch, may have an issue with the clutch switch moving or detaching from it's mount. *pe
- Bulletin:
- SB-261-017
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Volvo truck: on some vehicles, coolant overflow out of the overflow tube occurs during the diesel particulate filter regeneration cycle. excessive coolant flow from the radiator top tank and thermostat vent lines prevents flow into the de-a
- Bulletin:
- SB-824-002
- Component:
- 160000 structure
- Summary:
- Volvo truck: to reduce the potential for cab water intrusion, a cab cowl seal has been released by engineering. the seal part number 8083305 is positioned above the top edge of the cowl panel to divert water flow onto the cowl panel rathe
- Bulletin:
- FSB-357-001
- Component:
- 121000 exterior lighting:headlights
- Summary:
- Mack trucks: there is revised mounting hardware for the exhaust manifold and turbocharger. *rm
- Bulletin:
- FSB-844-002
- Component:
- 132000 visibility:glass, side/rear
- Summary:
- Volvo: there may be leaks at the lower sleeper window. *rm
- Bulletin:
- FSB-255-023
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Volvo trucks: connector pin, replacement. severe fretting damage of the engine variable geometry turbocharger actuator (engine vgt actuator) harness and turbine shaft speed sensor (tss) connector may cause an unreliable signal to the engin
- Bulletin:
- FSB-357-002
- Component:
- 330000 interior lighting
- Summary:
- Volvo: light control module (lcm), reprogramming. on some volvo units equipped with clear led clearance lights in the sun visor, the may exhibit an active fault code mid 216 psid 49 fmi 5. this fault indicates a trailer marker open issue wh
- Bulletin:
- FSB-375-008
- Component:
- 114000 electrical system:wiring
- Summary:
- Volvo trucks: during operation of driver side swivel seat and i shift transmission, the harness rubbing or wires, are pulled out of connectors. this causes seat harness dropping or pulling away from clipping points. *pe
- Bulletin:
- FSB-221-011
- Component:
- 060000 engine (pws)
- Summary:
- Volvo: low oil pressure, on certain vehicles, during long hard pull conditions, diagnostic trouble codes (dtcs) pid 100 fm1, spn 100 fmi 1 or p252400, can log on, with or without engine shut down lamp. model vn, vt. no years listed. *pe
- Bulletin:
- FSB 210-001
- Component:
- 355100 equipment:other:labels
- Summary:
- Engine data label
- Bulletin:
- FSB 284-047
- Component:
- 114000 electrical system:wiring
- Summary:
- Oil level sensor harness wire splice
- Bulletin:
- FSB 284-046
- Component:
- 117000 digital instrument panel
- Summary:
- Instrument cluster reported fuel economy calibration
- Bulletin:
- FSB 432-014
- Component:
- 103000 power train:automatic transmission
- Summary:
- Transmission ecu compatibility
- Bulletin:
- FSB 293-024
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- Exhaust gas recirculation (egr) differential pressure sensor
- Bulletin:
- FSB 593-012
- Component:
- 113100 electrical system:starter assembly:solenoid
- Summary:
- Hill start assist solenoid, replacement
- Bulletin:
- FSB 216-001
- Component:
- 100000 power train
- Summary:
- Twin mass flywheel conversion, transmission removed
- Bulletin:
- FSB 431-010
- Component:
- 350000 equipment
- Summary:
- Range synchronizer, repair
- Bulletin:
- FSB 293-012
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- Exhaust gas recirculation, part update
- Bulletin:
- FSB 811-005
- Component:
- 350000 equipment
- Summary:
- Floor cracks repair (front panel)
- Bulletin:
- FSB 811-006
- Component:
- 350000 equipment
- Summary:
- Floor cracks repair (rear panel)
- Bulletin:
- FSB 284-038
- Component:
- 118000 electrical system: software
- Summary:
- Engine coolant thermostat software update
- Bulletin:
- FSB 215-002
- Component:
- 354000 equipment:mechanical
- Summary:
- Timing plate leak repair
- Bulletin:
- FSB 593-012
- Component:
- 113100 electrical system:starter assembly:solenoid
- Summary:
- Hill start assist solenoid, replacement
- Bulletin:
- FSB 262-005
- Component:
- 060000 engine and engine cooling
- Summary:
- Coolant bypass housing seal
- Bulletin:
- FSB 432-013
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Amt high range cone replacement
- Bulletin:
- FSB 801-003
- Component:
- 162300 structure:body:door
- Summary:
- Service door rust prevention
- Bulletin:
- FSB 593-012
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Hill start assist solenoid, replacement
- Bulletin:
- FSB 234-018
- Component:
- 070000 fuel system, gasoline
- Summary:
- Single fuel tank ventilation filter kit
- Bulletin:
- FSB 234-019
- Component:
- 070000 fuel system, gasoline
- Summary:
- Dual fuel tanks ventilation filter kit
- Bulletin:
- FSB 293-024
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- Exhaust gas recirculation (egr) differential pressure sensor
- Bulletin:
- FSB 293-026
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Exhaust gas recirculation (egr) differential pressure sensor
- Bulletin:
- FSB 284-059
- Component:
- 110000 electrical system
- Summary:
- Nox sensor signal
- Bulletin:
- FSB 593-012
- Component:
- 113100 electrical system:starter assembly:solenoid
- Summary:
- Hill start assist solenoid, replacement
- Bulletin:
- FSB 216-001
- Component:
- 350000 equipment
- Summary:
- Twin mass flywheel conversion
- Bulletin:
- K91214678
- Component:
- 100000 power train
- Summary:
- Automated manual transmission ( amt ) faults - diagnostic trouble codes ( dtcs ) p1052 - 18 , pid 33 fmi 5 intermittent fault in cold weatherupdated with new information and procedure
- Bulletin:
- SERVICE INSTRUCT
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Supplier service bulletin sent to customers regarding potential brake caliper issue.
- Bulletin:
- FSB216-002
- Component:
- 060000 engine (pws)
- Summary:
- Flywheel resurfacing guidelines, i-shift
- Bulletin:
- K52326370
- Component:
- 073100 fuel system, gasoline:fuel injection system:fuel rail
- Summary:
- Volvo chassis - diesel exhaust fluid ( def ) contamination in fuel system, inspection and repair - us10 to us14 ( non-common rail fuel system ) removed information for common rail chassis - now has its own solution.
Home | Privacy