2002 VOLVO VN Recalls (5)
- Campaign:
- 02V317000 on 11/26/2002
- Component:
- Suspension:multiple axle
- Manufactured:
- 04/01/2002 - 09/24/2002
- Affected:
- 213
- Defect:
- On certain heavy duty class 8 trucks with volvo b-ride rear suspension, the forward and/or rear drive axle upper axle seat could break allowing the affected axle to shift out of alignment.
- Consequence:
- This condition could result in loss of axle stability, increasing the risk of a crash.
- Correction:
- Dealers will replace the upper axle seat on both rear drive axles. owner notification began january 14, 2003. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact volvo trucks at 1-800-528-6586.
- Notes:
- Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 04V077000 on 03/01/2004
- Component:
- Engine and engine cooling
- Manufactured:
- 11/13/2002 - 10/05/2003
- Affected:
- 2,112
- Defect:
- On certain heavy-duty class 8 trucks, the assembled engine pre-heater jumper wiring harness was incorrectly assembled.
- Consequence:
- The engine pre-heater could overheat resulting in damage to the pre-heater and other engine heat sensitive components near the pre-heater and the ability to re-start the engine could be compromised, increasing the risk of a crash.
- Correction:
- Dealers will repair the affected circuits in the jumper wiring harness connector. owner notification is expected to begin during march 2004. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact volvo trucks at 1-800-528-6586.
- Notes:
- Volvo truck recall no. rvxx0402.customer's can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 04V315000 on 07/05/2004
- Component:
- Trailer hitches:fifth wheel assembly
- Manufactured:
- 09/30/2002 - 03/30/2004
- Affected:
- 1,374
- Defect:
- On certain trucks, a malfunction in the solenoid valve may allow air to be released to fifth wheel latch when the park brake is engaged.
- Consequence:
- This condition could cause the fifth wheel latch to release inadvertently when the park brake is engaged, creating the potential for loss of the trailer. a crash could occur without prior warning.
- Correction:
- Dealers will add an additional solenoid valve in series with the existing pneumatic circuit for the fifth wheel air release. the recall began on august 9, 2004. owners should contact volvo at 1-800-528-6586.
- Notes:
- Recall no.rvxx0403.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 04V457000 on 09/21/2004
- Component:
- Visibility:windshield wiper/washer:motor
- Manufactured:
- 06/30/2000 - 06/10/2004
- Affected:
- 56,154
- Defect:
- On certain trucks equipped with valeo wiper systems, the wiper motor may be susceptive to salt intrusion that could possibly lead to a condition where the connector overheats to a point where the connector could ignite.
- Consequence:
- If this occurs, excessive heat and smoke could result in an under hood fire.
- Correction:
- Dealers will inspect and replace the connector plate on the windshield wiper motor. phase 2 of the recall began on november 1, 2004. owners should contact volvo trucks at 1-800-528-6586.
- Notes:
- Volvo trucks recall no.rvxx0406.customers can also contact the national highway traffic safety administration?s auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 12V510000 on 10/21/2012
- Component:
- Seat belts
- Manufactured:
- 08/03/2000 - 06/21/2012
- Affected:
- 1,496
- Defect:
- Volvo is recalling certain model year 2002-2013 vhd and vn trucks, manufactured from august 4, 2000, through june 22, 2012, and equipped with bench passenger seats. the seat belt d-ring weld may not be sufficient enough to meet the seat belt pull test. therefore, these vehicles fail to conform to the requirements of federal motor vehicle safety standard no. 210, "seat belt assembly anchorages."
- Consequence:
- In the event of a crash, an insufficient seat belt weld may prevent the seat belt from properly restraining the occupant. this increases the risk of injury to the seat occupant.
- Correction:
- Volvo trucks of america will notify owners, and dealers will replace the suspected d-ring, free of change. the safety recall began on may 10, 2013. owners may contact volvo at 1-336-393-2000.
- Notes:
- Volvo's recall campaign number is rvxx1204.owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153), or go to www.safercar.gov.
2002 VOLVO VN TSBs (67)
- Bulletin:
- 92209
- Component:
- 211000 trailer hitches:fifth wheel assembly
- Summary:
- Fifth wheel service procedures. *tt
- Bulletin:
- 36303
- Component:
- 136000 visibility:windshield wiper/washer
- Summary:
- Windshield wiper system. *tt
- Bulletin:
- 50
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Enhanced idle shutdown retrofit. volvo vn, vhd version 2 from build date 11.2002. *mr
- Bulletin:
- SP-215-014
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Volvo trucks: engine update campaign for certain d13f engines (vn-2, vhd-2) consists of inspecting the camshaft and replacing the intake rocker arms, exhaust rocker arms, injector rocker arms, injector hold downs, and the injector sealing w
- Bulletin:
- FSB-873-014
- Component:
- 353600 equipment:air conditioner
- Summary:
- Volvo truck: reports prompted the release of a replacement connector for the cab hvac motor resistor. replacement connector is supplied as kit part, which contains the connector body and the necessary terminals. model years unknown.
- Bulletin:
- SB-364-025
- Component:
- 101000 power train:clutch assembly
- Summary:
- Volvo truck; clutch switch clip; it has been found that vn, vhd and vt vehicles use a spring clip to retain the clutch switch, may have an issue with the clutch switch moving or detaching from it's mount. *pe
- Bulletin:
- SB-261-017
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Volvo truck: on some vehicles, coolant overflow out of the overflow tube occurs during the diesel particulate filter regeneration cycle. excessive coolant flow from the radiator top tank and thermostat vent lines prevents flow into the de-a
- Bulletin:
- SB-824-002
- Component:
- 160000 structure
- Summary:
- Volvo truck: to reduce the potential for cab water intrusion, a cab cowl seal has been released by engineering. the seal part number 8083305 is positioned above the top edge of the cowl panel to divert water flow onto the cowl panel rathe
- Bulletin:
- FSB-373-012
- Component:
- 114000 electrical system:wiring
- Summary:
- Volvo trucks: some engines leak oil through the grommet. information on the wiring harness, unit injector replacement. *rm updated 9/9/11. *pe
- Bulletin:
- FSB-891-013
- Component:
- 160000 structure
- Summary:
- Volvo trucks: vehicles with partial chassis fairings may experience damage to the fairing's lower support rail. it can be caused by vibration of the fairing against the fiberglass rail. a procedure has been developed to improve the situatio
- Bulletin:
- SP-891-004
- Component:
- 162900 structure:body:roof and pillars
- Summary:
- Volvo: trucks built prior to 18/8/2011 were shipped without four (4) spring nuts pre-installed from the factory. *js
- Bulletin:
- FSB-255-023
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Volvo trucks: connector pin, replacement. severe fretting damage of the engine variable geometry turbocharger actuator (engine vgt actuator) harness and turbine shaft speed sensor (tss) connector may cause an unreliable signal to the engin
- Bulletin:
- FSB-212-002
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Volvo trucks: oil seepage at flywheel housing. this problem has already been solved in production, but the production solution is not compatible with previous generation flywheel housings. *js
- Bulletin:
- FSB-357-002
- Component:
- 330000 interior lighting
- Summary:
- Volvo: light control module (lcm), reprogramming. on some volvo units equipped with clear led clearance lights in the sun visor, the may exhibit an active fault code mid 216 psid 49 fmi 5. this fault indicates a trailer marker open issue wh
- Bulletin:
- SP-514-005
- Component:
- 043000 service brakes, air:slack adjusters
- Summary:
- Volvo trucks: on the steering axle of the volvo trucks, the zerk fitting on the meritor slack adjuster comes into contact with the bolt head of the steering arm causing the fitting to break. *js updated 8/17/12. *pe
- Bulletin:
- FSB-375-008
- Component:
- 114000 electrical system:wiring
- Summary:
- Volvo trucks: during operation of driver side swivel seat and i shift transmission, the harness rubbing or wires, are pulled out of connectors. this causes seat harness dropping or pulling away from clipping points. *pe
- Bulletin:
- FSB-221-011
- Component:
- 060000 engine (pws)
- Summary:
- Volvo: low oil pressure, on certain vehicles, during long hard pull conditions, diagnostic trouble codes (dtcs) pid 100 fm1, spn 100 fmi 1 or p252400, can log on, with or without engine shut down lamp. model vn, vt. no years listed. *pe
- Bulletin:
- FSB-51-001
- Component:
- 045000 service brakes, air:disc
- Summary:
- Volvo: the air disc brake, on some trucks, may experience thermal overload due to an over adjustment of normal pad wear compensation that maintains clearance running between brake pad and rotor. models vah, vhd, vn. no years listed.
- Bulletin:
- FSB-512-002
- Component:
- 045000 service brakes, air:disc
- Summary:
- Volvo: on some trucks, air disc brake may experience a condition of thermal overload. thermal overload reduces running clearance between pad and rotor below desired level which is an over adjustment of normal pad wear compensation. model
- Bulletin:
- FSB 213-002, Exh
- Component:
- 060000 engine and engine cooling
- Summary:
- In some instances the exhaust rocker piston cap screw may become loose and back out causing loss of engine compression, or a mechanical injector diagnostic trouble code (dtc).
- Bulletin:
- FSB 293-016
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- Exhaust gas recirculation (egr) valve oil supply line, updated part
- Bulletin:
- FSB 284-047
- Component:
- 114000 electrical system:wiring
- Summary:
- Oil level sensor harness wire splice
- Bulletin:
- FSB 284-046
- Component:
- 117000 digital instrument panel
- Summary:
- Instrument cluster reported fuel economy calibration
- Bulletin:
- SP 284-049
- Component:
- 118000 electrical system: software
- Summary:
- Engine control module (ecm) software update
- Bulletin:
- FSB 432-014
- Component:
- 103000 power train:automatic transmission
- Summary:
- Transmission ecu compatibility
- Bulletin:
- FSB 371-049
- Component:
- 111100 electrical system:battery:cables
- Summary:
- Battery cable, routing
- Bulletin:
- SP 386-004
- Component:
- 118000 electrical system: software
- Summary:
- Fuel management module, replacement, incorrect calibration
- Bulletin:
- FSB 375-010
- Component:
- 220000 seats
- Summary:
- Seat harness routing (non-swivel) wires pulling away from clipping points
- Bulletin:
- FSB 375-011
- Component:
- 220000 seats
- Summary:
- Seat harness routing (swivel) wires pulling away from clipping points
- Bulletin:
- FSB 293-024
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- Exhaust gas recirculation (egr) differential pressure sensor
- Bulletin:
- FSB 593-012
- Component:
- 113100 electrical system:starter assembly:solenoid
- Summary:
- Hill start assist solenoid, replacement
- Bulletin:
- FSB 216-001
- Component:
- 100000 power train
- Summary:
- Twin mass flywheel conversion, transmission removed
- Bulletin:
- FSB 293-027
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- Egr mass flow rate low, diagnostic trouble code
- Bulletin:
- FSB 431-010
- Component:
- 350000 equipment
- Summary:
- Range synchronizer, repair
- Bulletin:
- FSB 293-012
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- Exhaust gas recirculation, part update
- Bulletin:
- FSB 811-005
- Component:
- 350000 equipment
- Summary:
- Floor cracks repair (front panel)
- Bulletin:
- FSB 811-006
- Component:
- 350000 equipment
- Summary:
- Floor cracks repair (rear panel)
- Bulletin:
- FSB 284-038
- Component:
- 118000 electrical system: software
- Summary:
- Engine coolant thermostat software update
- Bulletin:
- FSB 215-002
- Component:
- 354000 equipment:mechanical
- Summary:
- Timing plate leak repair
- Bulletin:
- FSB 593-012
- Component:
- 113100 electrical system:starter assembly:solenoid
- Summary:
- Hill start assist solenoid, replacement
- Bulletin:
- FSB 215-003
- Component:
- 350000 equipment
- Summary:
- Timing plate flange screw
- Bulletin:
- FSB 284-057
- Component:
- 060000 engine (pws)
- Summary:
- High soot output
- Bulletin:
- FSB 222-004
- Component:
- 060000 engine (pws)
- Summary:
- Oil filter housing
- Bulletin:
- FSB 262-005
- Component:
- 060000 engine and engine cooling
- Summary:
- Coolant bypass housing seal
- Bulletin:
- FSB 432-013
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Amt high range cone replacement
- Bulletin:
- FSB 801-003
- Component:
- 162300 structure:body:door
- Summary:
- Service door rust prevention
- Bulletin:
- FSB 593-012
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Hill start assist solenoid, replacement
- Bulletin:
- FSB 234-018
- Component:
- 070000 fuel system, gasoline
- Summary:
- Single fuel tank ventilation filter kit
- Bulletin:
- FSB 234-019
- Component:
- 070000 fuel system, gasoline
- Summary:
- Dual fuel tanks ventilation filter kit
- Bulletin:
- SP 293-027
- Component:
- 060000 engine and engine cooling
- Summary:
- Coolant hose, egr cooler, replacement
- Bulletin:
- FSB 293-024
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- Exhaust gas recirculation (egr) differential pressure sensor
- Bulletin:
- FSB 293-026
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Exhaust gas recirculation (egr) differential pressure sensor
- Bulletin:
- FSB 252-031
- Component:
- 061120 engine and engine cooling:engine:gasoline:turbo-charger
- Summary:
- Turbocharger outlet pipe
- Bulletin:
- FSB 258-035
- Component:
- 070000 fuel system, gasoline
- Summary:
- Aftertreatment def tank vent filter
- Bulletin:
- FSB 258-036
- Component:
- 353000 equipment:electrical
- Summary:
- Def sensor assembly routing
- Bulletin:
- FSB 284-059
- Component:
- 110000 electrical system
- Summary:
- Nox sensor signal
- Bulletin:
- FSB 210-045
- Component:
- 110000 electrical system
- Summary:
- Regeneration in pto mode
- Bulletin:
- FSB 222-004
- Component:
- 060000 engine (pws)
- Summary:
- Oil filter housing
- Bulletin:
- FSB 593-012
- Component:
- 113100 electrical system:starter assembly:solenoid
- Summary:
- Hill start assist solenoid, replacement
- Bulletin:
- FSB 293-022
- Component:
- 060000 engine (pws)
- Summary:
- In the event that an egr temperature sensor replacement is required on a volvo d13h engine, a new routing configuration is required.
- Bulletin:
- SP 398-001
- Component:
- 110000 electrical system
- Summary:
- On some trucks with the telematics gateway (tgw) system, the tgw control unit may not correctly communicate with the vehicle systems after restarting.
- Bulletin:
- SP2 284-036
- Component:
- 118000 electrical system: software
- Summary:
- Software update, revise document
- Bulletin:
- SP 431-021
- Component:
- 118000 electrical system: software
- Summary:
- Transmission ecu programming
- Bulletin:
- FSB 216-001
- Component:
- 350000 equipment
- Summary:
- Twin mass flywheel conversion
- Bulletin:
- K91214678
- Component:
- 100000 power train
- Summary:
- Automated manual transmission ( amt ) faults - diagnostic trouble codes ( dtcs ) p1052 - 18 , pid 33 fmi 5 intermittent fault in cold weatherupdated with new information and procedure
- Bulletin:
- SERVICE INSTRUCT
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Supplier service bulletin sent to customers regarding potential brake caliper issue.
- Bulletin:
- FSB216-002
- Component:
- 060000 engine (pws)
- Summary:
- Flywheel resurfacing guidelines, i-shift
Home | Privacy