2002 TOYOTA HIGHLANDER Recalls (2)

Campaign:
02V208000 on 07/31/2002
Component:
Fuel system, gasoline:storage:tank assembly:mounting
Manufactured:
11/16/2000 - 05/30/2002
Affected:
154,593
Defect:
On sport utility vehicles, there is a breather hose that attaches to the nozzle of the on-board refueling vapor recovery (orvr) valve, which is located on the topside of the fuel tank. the breather hose is attached with a clamp, whose "tabs" face in the upward direction. when the vehicle was crashed under the new car assessment program (ncap) test (i.e., 35 mph frontal barrier crash), the clamp "tabs" contacted the underside of the body due to movement of the fuel tank, causing the nozzle to break.
Consequence:
In the worst case, nozzle breakage could result in fuel leakage if the vehicle rolls-over after a high speed frontal crash.
Correction:
Dealers will rotate the specified clamp. owner notification began september 23, 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact toyota at 1-800-331-4331.
Notes:
Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Campaign:
04V181000 on 04/19/2004
Component:
Latches/locks/linkages:doors:latch
Manufactured:
11/16/2000 - 01/28/2004
Affected:
366,572
Defect:
Certain sport utility vehicles have a child protection lock (cpl) system on both of the rear side doors. when an operator of the vehicle closes the door very hard with the cpl lever set to the lock position, there is a possibility that the lever may contact the body panel, causing the cpl lever to move into the unlock position.
Consequence:
This condition could allow the door to be opened with the inside while the operator believes that the cpl was activated. if the door were opened from the inside while the vehicle was in motion, an occupant could fall out and be injured.
Correction:
Dealers will shorten the cpl lever. owner notification began may 7, 2004. owners should contact toyota at 1-800-331-4331.
Notes:
Toyota recall no. ssc 40b.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

2002 TOYOTA HIGHLANDER TSBs (80)

Bulletin:
TC02002
Component:
061100 engine and engine cooling:engine:gasoline
Summary:
Special policy adjustment regarding vehicles experiencing engine oil gelling or sludge. *tt
Bulletin:
EG00402
Component:
980000 unknown or other
Summary:
Subject regarding malfunction indicator light on diagnostic trouble code p0500.*jb
Bulletin:
AX00202
Component:
133000 visibility:power window devices and controls
Summary:
Subject regarding accessory trailer wire harness. *slc
Bulletin:
NV00802
Component:
220000 seats
Summary:
Technical information on diagnosing front seat back noise. *tt
Bulletin:
TC02013
Component:
070000 fuel system, gasoline
Summary:
Special service campaign to correct the position of the on-board refueling vapor recovery (orvr) valve breather hose clamp. *tt
Bulletin:
TMSNTC02146
Component:
070000 fuel system, gasoline
Summary:
Subject regarding orvr valve breather hose clamp. *tt
Bulletin:
00502
Component:
162800 structure:body:hood
Summary:
New accessory hood protector service replacement part now available. *tt
Bulletin:
00703
Component:
061000 engine and engine cooling:engine
Summary:
Malfunction indicator lamp on condition with diagnostic trouble code p1349, indicating a variable valve timing (vvti) malfunction. *tt *jb
Bulletin:
00103
Component:
106000 power train:axle assembly
Summary:
Right rear axle squeak noise. *tt *jb
Bulletin:
BO01603
Component:
162000 structure:body
Summary:
Front door opening weatherstrip. *tt
Bulletin:
EL01203
Component:
110000 electrical system
Summary:
Malfunction indicator lamp on condition with a diagnostic trouble code b1140 or b1141 stored in the center airbag ecu memory. *tt
Bulletin:
00503
Component:
162810 structure:body:hood:hinge and attachments
Summary:
Accessory hood protector with weatherstrip. revised. *tt
Bulletin:
00304
Component:
353600 equipment:air conditioner
Summary:
A/c compressor installation procedure. *mr
Bulletin:
01104
Component:
162800 structure:body:hood
Summary:
Engine hood release cable cable spring improvement. *mj
Bulletin:
00404
Component:
012000 steering:column
Summary:
Steering column squeak noise. *mj
Bulletin:
00504
Component:
103000 power train:automatic transmission
Summary:
Proper identification of the 5 solenoids used in the u240e/u241e automatic transaxles. *tt
Bulletin:
03704
Component:
061000 engine and engine cooling:engine
Summary:
Engine bank 1 and bank 2 a/f and 02 identification. various toyota models. *tt
Bulletin:
04004
Component:
061000 engine and engine cooling:engine
Summary:
Accessory drive belt squeal/ belt tensioner rattle. *nm
Bulletin:
04013
Component:
980000 unknown or other
Summary:
Owner renotification of non-completed special service campaigns and limited service campaigns. *tt
Bulletin:
01305
Component:
061000 engine and engine cooling:engine
Summary:
Fuel injector ticking noise. update. *tt original. *tt
Bulletin:
00205
Component:
162300 structure:body:door
Summary:
Wind noise coming from both the front and rear door window glass. *tt
Bulletin:
5037B
Component:
105500 power train:driveline:differential unit
Summary:
Repair manual correction - differential carrier assy rear (4wd). 00400-rm918-u2. *tt 00400-rm837-u2. *tt
Bulletin:
4584B
Component:
030000 service brakes, hydraulic
Summary:
'03 highlander front brake repair manual correction. 00400-rm987-u2. *tt '02 highlander. 00400-rm918-u2. *tt
Bulletin:
00805
Component:
100000 power train
Summary:
U140f transmission solenoid identification. *tt
Bulletin:
01605
Component:
162300 structure:body:door
Summary:
Front door opening weatherstrip becomes loose or comes off easily. *tt
Bulletin:
04105
Component:
061000 engine and engine cooling:engine
Summary:
Ecm calibration update. mil on dtc p0420 and/or p0430. *kb
Bulletin:
601
Component:
061000 engine and engine cooling:engine
Summary:
Reprogram the engine control module (ecm). *kb
Bulletin:
00207
Component:
980000 unknown or other
Summary:
Techstream ecu flash reprogramming procedure. *kb
Bulletin:
TSB-0064-10
Component:
061000 engine and engine cooling:engine
Summary:
Toyota: techstream ecu flash reprogramming procedure. flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures de
Bulletin:
SB-0015-11
Component:
060000 engine and engine cooling
Summary:
Toyota: there may be damaged cylinder head bolts threads. *rm
Bulletin:
TSB-0122-11
Component:
140000 air bags
Summary:
Toyota: information provided for replacing the seat covers for vehicles equipped with side airbags. *pe
Bulletin:
TSB-0087-12
Component:
181000 vehicle speed control:accelerator pedal
Summary:
Toyota: accelerator pedal sensor assembly information regarding the inspection, removal, and installation, if lubrication or oil, is applied. *pe
Bulletin:
T-SB-0141-13
Component:
050000 parking brake
Summary:
Summary to be provided on a future date.
Bulletin:
TC13-019
Component:
355200 equipment:other:owners/service/other manual
Summary:
Summary to be provided on a future date.
Bulletin:
T-SB-0012-13 REV
Component:
060000 engine (pws)
Summary:
"tsb: flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bul
Bulletin:
T-TT-0381-16
Component:
350000 equipment
Summary:
Tech tip: some customers may experience difficulty programming homelink.
Bulletin:
T-SB-0014-11 Rev
Component:
103000 power train:automatic transmission
Summary:
Tsb: the purpose of this service bulletin is to provide information regarding the installation of the correct torque converter bolts during automatic transmission/transaxle assembly replacement. incorrect torque converter bolts or missing w
Bulletin:
T-SB-0134-14
Component:
100000 power train
Summary:
Tsb: the purpose of this bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid mil "on" shifting issues and/or transmission damage. use the information in this bulletin when insta
Bulletin:
T-SB-0043-14 Rev
Component:
353000 equipment:electrical
Summary:
Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased. follow the procedures in this bulletin to
Bulletin:
T-SB-0083-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: the procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. refer to the applicable repair manual for vehicle specific repair procedures and parts.
Bulletin:
T-SB-0101-11 Rev
Component:
110000 electrical system
Summary:
Tsb: when servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. many lubricants, cleaners, and automotive chemicals contain silicone or othe
Bulletin:
T-SB-0101-11 Rev
Component:
110000 electrical system
Summary:
Tsb: when servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. many lubricants, cleaners, and automotive chemicals contain silicone or othe
Bulletin:
T-SB-0043-14 Rev
Component:
353000 equipment:electrical
Summary:
Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased. follow the procedures in this bulletin to
Bulletin:
T-SB-0083-13 Rev
Component:
353600 equipment:air conditioner
Summary:
Tsb: the procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. refer to the applicable repair manual for vehicle specific repair procedures and parts.
Bulletin:
T-SB-0304-17
Component:
162300 structure:body:door
Summary:
Tsb: vehicle replacement certification labels (the vinyl label installed on the driver door or door post) and vin plates (the metal plate riveted to dashboard) may be available from toyota, provided the request meets one of the criteria lis
Bulletin:
T-SB-0134-16_Rev
Component:
355200 equipment:other:owners/service/other manual
Summary:
Tsb: revision notice october 30, 2017 rev1: * applicability has been updated to include 2018 model year vehicles. supersession notice the information contained in this bulletin supersedes sb no. t-sb-0012-13. flash reprogramming allows the
Bulletin:
T-SB-0304-17_Rev
Component:
350000 equipment
Summary:
Tsb: supersession notice the information contained in this bulletin supersedes service bulletin nos. pg021-88, pg015-89, pg0015-90, pg002-91, pg002-93, pg005-97, pg007-01, pg007-07, and t-sb-0144-08. service bulletin nos. pg021-88, pg015-89
Bulletin:
T-TT-0132-11
Component:
030000 service brakes, hydraulic
Summary:
A key part to maintain the proper function and safe operation of the vehicle's braking system is to perform a visual inspection when installing brake pads, calipers, and discs. the following recommendations are intended to provide general
Bulletin:
T-TT-0213-13
Component:
140000 air bags
Summary:
Toyota vehicles are equipped with supplemental restraint systems (srs), including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. if a customer expresses any concerns that the
Bulletin:
T-SB-0141-13
Component:
050000 parking brake
Summary:
A new special service tool (sst 09709-00002) has been introduced to aid in the inspection procedure for certain vehicles equipped with a floor pedal-type parking brake system. this bulletin references the correct method for installing the b
Bulletin:
T-SB-0185-13
Component:
130000 visibility
Summary:
The following procedures are recommended during routine maintenance or in the event of a customer concern for wiper performance.
Bulletin:
TS-BO030-01 Obso
Component:
130000 visibility/wiper (pws)
Summary:
This bulletin is now obsolete. please see t-sb-0185-13.
Bulletin:
T-SB-0122-11 Rev
Component:
140000 air bags
Summary:
Beginning in 1998, toyota introduced side airbags as optional equipment. toyota does not recommend replacement of original seat covers with non-toyota leather or other seat cover materials on vehicles due to the following: seat covers not
Bulletin:
T-SB-0071-11 Rev
Component:
100000 power train
Summary:
The purpose of this service bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid mil ?on,? shifting issues, and/or transmission damage. use the information in this bulletin when
Bulletin:
T-TT-0269-13
Component:
132000 visibility:glass, side/rear
Summary:
The appearance of spots in tempered glass (when viewed at certain angles) is the result of the heat treating and quick quenching process during manufacturing.
Bulletin:
T-SB-0054-13
Component:
350000 equipment
Summary:
California (ca), federal (fed), and 50 state certified emission control underhood labels (emission labels) may be obtained through your dealership?s parts department utilizing standard replacement parts ordering procedures. follow the guide
Bulletin:
T-PG006-00 Obsol
Component:
355100 equipment:other:labels
Summary:
This bulletin is now obsolete. please see t-sb-0054-13.
Bulletin:
T-SB-0218-17_Rev
Component:
140000 air bags
Summary:
Tsb: revision notice july 20, 2017 rev1: applicability has been updated to exclude 2007 ? 2017 model year avanza vehicles. some hazardous material treatment and handling regulations at the state and local level define the pre-disposal deplo
Bulletin:
T-SB-0043-14
Component:
353100 equipment:electrical:anti-theft devices
Summary:
Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased.
Bulletin:
T-SB-0043-14 Rev
Component:
353100 equipment:electrical:anti-theft devices
Summary:
Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased.
Bulletin:
T-SB-003-01 - OB
Component:
980000 unknown or other
Summary:
Tsb: obsolete notice: july 7, 2014: this bulletin is now obsolete.
Bulletin:
T-SB-0012-13 Rev
Component:
118000 electrical system: software
Summary:
Tsb: flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bullet
Bulletin:
T-TT-0010-10 Rev
Component:
060000 engine (pws)
Summary:
Tech tip: low battery voltage can contribute to a mil "on" condition for p0335 (crankshaft position
Bulletin:
T-SB-0012-13 Rev
Component:
118000 electrical system: software
Summary:
Tsb: obsolete notice: september 14, 2016: this bulletin is now obsolete. please see t-sb-0134-16.
Bulletin:
T-SB-0144-08_Obs
Component:
350000 equipment
Summary:
Tsb: obsolete notice november 21, 2017: this bulletin is now obsolete. please see t-sb-0304-17.
Bulletin:
T-SB-0229-12_Rev
Component:
110000 electrical system
Summary:
Tsb: revision notice november 22, 2017 rev1: ? applicability has been updated to include 2014 ? 2018 model year vehicles. any previous printed versions of this bulletin should be discarded. in the event that a toyota vehicle becomes submerg
Bulletin:
T-SB-0391-08 Rev
Component:
100000 power train
Summary:
This bulletin contains general vehicle pulling diagnosis and repair procedures along with specific information to help correct pulling complaints.
Bulletin:
T-TT-0226-13
Component:
110000 electrical system
Summary:
The customer is having difficulty changing the multi-display screen from day mode. if the multi-display screen is set to day mode when the headlights are on, the setting we be memorized when the engine is turned off.
Bulletin:
SST Requirements
Component:
355200 equipment:other:owners/service/other manual
Summary:
Ssts are key elements to provide your customers with swift and accurate repairs resulting in superior customer satisfaction.
Bulletin:
T-SB-0064-10 Rev
Component:
118000 electrical system: software
Summary:
Flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bulletin de
Bulletin:
T-SB-0012-13
Component:
118000 electrical system: software
Summary:
Flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bulletin de
Bulletin:
T-SB-0064-10 Rev
Component:
355200 equipment:other:owners/service/other manual
Summary:
This bulletin is now obsolete. please see t-sb-0012-13.
Bulletin:
T-TT-0213-13
Component:
140000 air bags
Summary:
Toyota vehicles are equipped with srs, including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. if a customer expresses any concerns that the srs airbags or pretensioner devi
Bulletin:
TSB-0012-13 Rev2
Component:
060000 engine (pws)
Summary:
Tsb: flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bull
Bulletin:
T-TT-0381-16
Component:
118000 electrical system: software
Summary:
Tech tip: some customers may experience difficulty programming homelink.
Bulletin:
T-SB-0057-18
Component:
350000 equipment
Summary:
Tsb: supersession notice the information contained in this bulletin supersedes service bulletin no. t-sb-0043-14. ? applicability has been updated to include 2017 ? 2018 model year toyota vehicles. service bulletin no. t-sb-0043-14 is obso
Bulletin:
T-SB-0304-17_Rev
Component:
350000 equipment
Summary:
Tsb: revision notice july 31, 2018 rev2: ? the supersession notice has been updated. january 11, 2018 rev1: ? the supersession notice has been updated. any previous printed versions of this bulletin should be discarded. supersession notice
Bulletin:
PG004-97-Obsolet
Component:
350000 equipment
Summary:
Technical service bulletin: obsolete notice: july 31, 2018: this bulletin is now obsolete. please see t-sb-0304-17.
Bulletin:
PG006-01-Obsolet
Component:
350000 equipment
Summary:
Technical service bulletin: obsolete notice: july 31, 2018: this bulletin is now obsolete. please see t-sb-0304-17.
Bulletin:
Safety Recall an
Component:
350000 equipment
Summary:
Update on technician certification requirements.

Home | Privacy