2002 JAGUAR X-TYPE Recalls (2)
- Campaign:
- 03V011000 on 02/04/2003
- Component:
- Exterior lighting:turn signal
- Manufactured:
- 01/31/2001 - 10/30/2002
- Affected:
- 49,174
- Defect:
- On certain passenger sedans, the power circuit which feeds the direction indicator system could fail. this could result in the driver being unaware that the external turning indicators are not operating because the internal "tell-tail" light on the driver's instrument panel continues to work normally.
- Consequence:
- The loss of rear turn signals could fail to warn a following driver that the vehicle is turning and could result in a crash.
- Correction:
- Dealers will replace the general electric module. owner notification began april 1, 2003. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact jaguar at 1-201-818-8500.
- Notes:
- Jaguar recall no. r935. customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 04V487000 on 10/13/2004
- Component:
- Parking brake
- Manufactured:
- 02/12/2001 - 08/18/2002
- Affected:
- 3,856
- Defect:
- On certain passenger vehicles equipped with lhd manual transmissions, the hand brake, which applies the parking brake, may not apply sufficient pressure to the brake pads to prevent the vehicle from moving if the manual transmission was left in the neutral position. the automatic adjuster within the hand brake may not work properly causing the hand brake lever to travel outside the recommended range.
- Consequence:
- If the vehicle travels outside the recommended range, the vehicle may roll away and a crash may occur.
- Correction:
- Dealers will replace the existing automatic adjustment hand brake lever system on the affected vehicles with a manual hand brake lever system. the recall began on january 14, 2005. owners should contact jaguar at 1-800-452-4827.
- Notes:
- Jaguar recall no. r957.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
2002 JAGUAR X-TYPE TSBs (116)
- Bulletin:
- 30701
- Component:
- 103000 power train:automatic transmission
- Summary:
- Difficulty selecting transmission ranges gearbox fault message reset j-gate. *yh
- Bulletin:
- XT20501
- Component:
- 105500 power train:driveline:differential unit
- Summary:
- Information regarding some vehicles may experience a whining noise from the differential on deceleration at speeds of around 112 km/h70mph. this bulletin provides a procedure to retune the differential monting bracket by adding mass (weight
- Bulletin:
- 20416
- Component:
- 021100 suspension:front:stabilizer bar
- Summary:
- Replacement stabilizer bar bushings lubricate before installing. *yh
- Bulletin:
- X13
- Component:
- 350000 equipment
- Summary:
- Subject regarding digital cellular phone program. *tt
- Bulletin:
- X13
- Component:
- 353000 equipment:electrical
- Summary:
- Information on digital cellular phone program.**jb
- Bulletin:
- 20601
- Component:
- 033000 service brakes, hydraulic:power assist
- Summary:
- Removing the brake vacuum pump used on certain early model vehicles in the event of a malfunction. *tt
- Bulletin:
- 20401
- Component:
- 022000 suspension:rear
- Summary:
- Creaking noise coming from the rear suspension. *tt
- Bulletin:
- 31001
- Component:
- 353000 equipment:electrical
- Summary:
- Some vehicles may run out of fuel while the message center still indicates range available. *tt
- Bulletin:
- XT30301
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding diagnostic trouble code stored, flight recorder data clarification for 2002 my - on.*jb
- Bulletin:
- XT3032
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Customers may complain of engine misfire/malfunction indicator lamp illumination.*jb
- Bulletin:
- 418S918
- Component:
- 115000 electrical system:fuses and circuit breakers
- Summary:
- Information on fuse rating change from 30 to 15 amp.*jb
- Bulletin:
- 419S920
- Component:
- 110000 electrical system
- Summary:
- General electronic control module (mecm) service action s 920. *jb
- Bulletin:
- 50104
- Component:
- 354300 equipment:mechanical:carrier/rack
- Summary:
- Difficulty closing luggage compartment lid.*jb revised latch mechanism - modification procedure. *tt
- Bulletin:
- XT30303
- Component:
- 070000 fuel system, gasoline
- Summary:
- Subject on evaporative system for model 2002 my - on.*jb
- Bulletin:
- XT10003
- Component:
- 105500 power train:driveline:differential unit
- Summary:
- Vehicles may experience a boom at 2900 rpm, at the rear differential.*jb
- Bulletin:
- 20403
- Component:
- 020000 suspension
- Summary:
- Subject pertaining to wheel alignment for model 2002 my - on.*jb
- Bulletin:
- 50103
- Component:
- 220000 seats
- Summary:
- Front seat rocking.*jb seat track stabilizing kit - installation procedure. *tt
- Bulletin:
- 010402
- Component:
- 105500 power train:driveline:differential unit
- Summary:
- Customer complaint of a driveline howling noise when cold. *tt
- Bulletin:
- 50103
- Component:
- 220000 seats
- Summary:
- Front seat rocking seat track stabilizing kit installation procedure. this bulletin is replacing xt501-03 dated 11/03. *eh
- Bulletin:
- 30703
- Component:
- 060000 engine and engine cooling
- Summary:
- Scraping noise 1600 rpm 1800 2500 rpm install modified flexplate. *eh
- Bulletin:
- 501948
- Component:
- 220000 seats
- Summary:
- Front seat stabilization kit change of specification service action s948. *eh
- Bulletin:
- 50110
- Component:
- 170000 latches/locks/linkages
- Summary:
- Remote transmitter not functioning internal chip fault replace transmitter. *eh replace service bulletin xt501-10 dated 01/04. *eh
- Bulletin:
- 41907
- Component:
- 110000 electrical system
- Summary:
- Telematics issues check for latest software update procedure. *eh
- Bulletin:
- 303939
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Thermostat housing hose install additional hose clamp service action s939. *tt amended version. *eh
- Bulletin:
- 20408
- Component:
- 021000 suspension:front
- Summary:
- Creaking noise when braking over speed bumps front control arm hydrobush replace control arm. *eh this service bulletin replaces xt20408 dated 02/04. *eh this service bulletin replaces xt20408 dated 03/04. *kb
- Bulletin:
- 21101
- Component:
- 015000 steering:hydraulic power assist system
- Summary:
- Squeaking noise power steering system flush system. *eh
- Bulletin:
- 50112
- Component:
- 162300 structure:body:door
- Summary:
- Door difficult to close blocked seal evacuation holes repair procedure. *eh
- Bulletin:
- 50115
- Component:
- 162000 structure:body
- Summary:
- Washer fluid leak at elbows repair procedure. *eh
- Bulletin:
- 10008
- Component:
- 105300 power train:driveline:driveshaft
- Summary:
- Driveshaft vibration diagnostic method repair. *eh update. *tt amended version 09/04. *tt
- Bulletin:
- 30313
- Component:
- 060000 engine and engine cooling
- Summary:
- Hissing noise drivable issues dtc p0171 p0174 leaking imt o ring imt o ring available separately. *eh
- Bulletin:
- 10009
- Component:
- 105300 power train:driveline:driveshaft
- Summary:
- Driveline whine preliminary checks. *eh
- Bulletin:
- 50119
- Component:
- 135000 visibility:rearview mirrors/devices
- Summary:
- Sun visor mirror bulb now available separately replacement procedure. *eh
- Bulletin:
- 10011
- Component:
- 105300 power train:driveline:driveshaft
- Summary:
- Driveline noise sound transfer from transmission and driveline install sound deadening liner. *eh
- Bulletin:
- 50124
- Component:
- 135000 visibility:rearview mirrors/devices
- Summary:
- Interior rear view mirror (auto dimming) loose retaining springs repair procedure. *eh
- Bulletin:
- 50125
- Component:
- 171100 latches/locks/linkages:doors:latch
- Summary:
- Exterior door handle noisy when released install new rubber buffers. *eh
- Bulletin:
- 41909
- Component:
- 353500 equipment:electrical:navigational system(global positioning system)
- Summary:
- Navigation system diagnostic procedures. *eh
- Bulletin:
- 20410
- Component:
- 022000 suspension:rear
- Summary:
- Creak from rear stabilizer bar - stabilizer bar bushing movement - repair procedure. *eh
- Bulletin:
- 41702
- Component:
- 121000 exterior lighting:headlights
- Summary:
- Condensation in headlamps revised cap available repair procedure. *eh
- Bulletin:
- 50120
- Component:
- 162310 structure:body:door:hinge and attachments
- Summary:
- Luggage compartment lid not opening correctly spring actuators install revised parts. *eh
- Bulletin:
- 30803
- Component:
- 102000 power train:manual transmission
- Summary:
- Damage to clutch slave cylinder during installation revised procedure. *eh
- Bulletin:
- 50114
- Component:
- 136000 visibility:windshield wiper/washer
- Summary:
- Washer fluid leakage at front fender leak at elbows repair procedure. *eh
- Bulletin:
- 310936
- Component:
- 060000 engine and engine cooling
- Summary:
- Throttle pedal stop larger diameter service action s936. *eh
- Bulletin:
- 20409
- Component:
- 021500 suspension:front:control arm
- Summary:
- Front control arm removal/installation - new procedure sro time revision. *tt this bulletin replaces bulletin xt204-09, dated 02/04. *tt
- Bulletin:
- 30505
- Component:
- 102000 power train:manual transmission
- Summary:
- Manual transaxle selector mechanism remove/install. new procedure. *tt
- Bulletin:
- 20402
- Component:
- 190000 tires
- Summary:
- Vibration shimmy tire radial force variation optimizing wheels and tires. *eh
- Bulletin:
- 91002
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Squeaks & rattles service kit guidelines for usage. *eh
- Bulletin:
- 307941
- Component:
- 103000 power train:automatic transmission
- Summary:
- Jatco jf506e transmission replacement. reverse clutch piston durability. service action s941. *tt
- Bulletin:
- 303932
- Component:
- 062200 engine and engine cooling:cooling system:fan
- Summary:
- Overheating - cooling fans inoperative - replace module prior to retailing - service action s932. *tt
- Bulletin:
- 501940
- Component:
- 121000 exterior lighting:headlights
- Summary:
- Headlamp washer jet cover pivot link change of specification. *eh
- Bulletin:
- 20406
- Component:
- 204000 wheels:cap/cover/hub
- Summary:
- Corrosion prevention - wheels & hubs - grease contact surfaces. *tt
- Bulletin:
- 501934
- Component:
- 140000 air bags
- Summary:
- Change in specification reprogram rcm. *eh
- Bulletin:
- 50109
- Component:
- 121000 exterior lighting:headlights
- Summary:
- Loss of headlamp washer jet cover poor retention install pre painted covers revised link. *eh
- Bulletin:
- 50107
- Component:
- 170000 latches/locks/linkages
- Summary:
- Locking or unlatching issues diagnostic information. *eh
- Bulletin:
- 20604
- Component:
- 030000 service brakes, hydraulic
- Summary:
- Noise or odor from rear brakes - rear brake pads sticking in anchor plate - repair procedure. *tt
- Bulletin:
- 30304
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Hard starting/poor idle/restricted performance - engine management diagnosis - flowcharts. *tt
- Bulletin:
- 30802
- Component:
- 102000 power train:manual transmission
- Summary:
- Clutch pedal sticking down install additional spring repair. *eh
- Bulletin:
- 937
- Component:
- 103000 power train:automatic transmission
- Summary:
- The automatic transmission have the potential to contain a manufacturing flaw in the reverse clutch pack that may lead to transmission slippage and ultimately transmission failure. service action s926. this service action is superseded by
- Bulletin:
- 303928
- Component:
- 063110 engine and engine cooling:exhaust system:emission control:crankcase (pcv)
- Summary:
- The crankcase breather valve is wearing prematurely due to resonance in the pintle spring. revised specification valve. service action s928. *tt this bulletin replaces previous bulletin dated 10/02. *tt
- Bulletin:
- 31002
- Component:
- 090000 fuel system, other
- Summary:
- Diagnostic information for the vehicle fuel system. *tt
- Bulletin:
- 30305
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Misfire or hesitation when cold, along with possible illumination of the malfunction indicator lamp (mil). diagnostic trouble codes (dtcs) p0300-p0306 may be present. *tt
- Bulletin:
- 31003
- Component:
- 071100 fuel system, gasoline:storage:tank assembly
- Summary:
- Fuel tank removal installation revised procedure. *eh
- Bulletin:
- 30306
- Component:
- 110000 electrical system
- Summary:
- Driveability issues along with an illuminated malfunction indicator lamp (mil). chafed wires at air conditioning pressure switch. repair procedure. *tt
- Bulletin:
- 30307
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Engine control module (ecm) replacement. engine management questionnaire. reporting requirements. *tt
- Bulletin:
- 91001
- Component:
- 980000 unknown or other
- Summary:
- Squeaks & rattles. *tt
- Bulletin:
- 418921
- Component:
- 110000 electrical system
- Summary:
- Internal connection issue. as a result, some circuits could operate intermittently and the vehicle could go into limp home mode. replace 20 amp micro relay. service action s921. *tt
- Bulletin:
- 41902
- Component:
- 353100 equipment:electrical:anti-theft devices
- Summary:
- Passive anti-theft system (pats) diagnostic flowcharts. *tt
- Bulletin:
- 41903
- Component:
- 353500 equipment:electrical:navigational system(global positioning system)
- Summary:
- The radio or navigation screen intermittently displays no phone / no phone fitted message displayed. revised pse module. repair procedure. *tt
- Bulletin:
- 41905
- Component:
- 353500 equipment:electrical:navigational system(global positioning system)
- Summary:
- Telematics concerns. navigation system software. installing latest level. *tt
- Bulletin:
- 50102
- Component:
- 162300 structure:body:door
- Summary:
- Squeaks & rattles from doors. install modification kit. modification procedure. *tt
- Bulletin:
- 50105
- Component:
- 162900 structure:body:roof and pillars
- Summary:
- Sliding roof does not close properly/bounces open. loss of calibration. *tt
- Bulletin:
- 31005
- Component:
- 090000 fuel system, other
- Summary:
- Fuel gauge failure or intermittent operation fuel level sender available separately replacement procedure. *eh
- Bulletin:
- 1186
- Component:
- 110000 electrical system
- Summary:
- Using wds to program configure control modules common issues solutions vid block background information. this also includes 2003 xj series. *eh
- Bulletin:
- 31005
- Component:
- 091200 fuel system, other:storage:fuel gauge system
- Summary:
- Fuel gauge failure or intermittent operation-fuel level sender available separately-replacement procedure. *sc
- Bulletin:
- 50121
- Component:
- 220000 seats
- Summary:
- Premature front seat backrest wear on classic style seats - outer bolster support wire - modification procedure. update. *tt original. *tt
- Bulletin:
- 50128
- Component:
- 162300 structure:body:door
- Summary:
- Exterior front door handle hard to open - deflection of link rod - replace link rod. update. *tt
- Bulletin:
- 30311
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Check engine malfunction indication lamp (mil) illuminating with diagnostic trouble code (dtc) p0341 (cmp sensor-bank) or p1341 (cmp sensor-bank2) stored. *tt
- Bulletin:
- 30806
- Component:
- 102000 power train:manual transmission
- Summary:
- Difficult engaging first or reverse gear, especially when the vehicle is cold. *tt
- Bulletin:
- 50130
- Component:
- 136000 visibility:windshield wiper/washer
- Summary:
- Concerns of the windshield wiper blade(s) squeaking, smearing, or juddering. *tt
- Bulletin:
- 20412
- Component:
- 022000 suspension:rear
- Summary:
- Rear suspension - remove/install front lower control arm. new workshop procedure. *tt
- Bulletin:
- 20608
- Component:
- 051120 parking brake:conventional:mechanical:linkage and cable
- Summary:
- Parking brake cable adjustment - revised specification. *tt
- Bulletin:
- 30321
- Component:
- 110000 electrical system
- Summary:
- Electronic throttle body-cleaning prohibited. *sc
- Bulletin:
- 50129
- Component:
- 140000 air bags
- Summary:
- Supplemental restraint system (srs) - flash codes & pid code definitions - diagnostics. *tt
- Bulletin:
- 30315
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Coolant leak from thermostat housing - supplemental repair to service action s939. *tt
- Bulletin:
- 30309
- Component:
- 110000 electrical system
- Summary:
- False flagging of dtg p0456 - no evaporative leak present - repair procedure. *tt
- Bulletin:
- 30302
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Engine misfire/malfunction indicator lamp illumination - engine harness chafing - repair procedure. *tt
- Bulletin:
- 307929
- Component:
- 100000 power train
- Summary:
- Harsh shift that will lead to transmission slippage and ultimately transmission failure. valve body durability - replace transmission - service action s929. *tt
- Bulletin:
- 30804
- Component:
- 100000 power train
- Summary:
- Transmission whine - sound transmitted by shift cables - revised shift cables available. *tt
- Bulletin:
- 41202
- Component:
- 138000 visibility:defroster/defogger system
- Summary:
- Vehicle fogging/climate control slow to cool vehicle - air blend door loose - repair procedure. *tt
- Bulletin:
- 20407
- Component:
- 020000 suspension
- Summary:
- Vehicle drifts left or right with brakes released - diagnosis. *tt
- Bulletin:
- 307926
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Enhancements to vehicle operation - reprogram ecm/tcm - service action s937. *tt
- Bulletin:
- 412931
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Enhancements to vehicle operation - reprogram ecm/tcm - service action s937. *tt
- Bulletin:
- 307926
- Component:
- 103000 power train:automatic transmission
- Summary:
- Degradation of shift quality - reprogram tcm -service action s926. *tt
- Bulletin:
- 310933
- Component:
- 071100 fuel system, gasoline:storage:tank assembly
- Summary:
- Replacement fuel tanks - long term durability - service action s933. *tt
- Bulletin:
- 31002
- Component:
- 090000 fuel system, other
- Summary:
- Fuel system - drivability/starting issues - customer complaints - diagnostic procedures. *tt
- Bulletin:
- 205930
- Component:
- 106000 power train:axle assembly
- Summary:
- Front axle shafts - check retention in cv joint - service action s930. *tt
- Bulletin:
- 20603
- Component:
- 051120 parking brake:conventional:mechanical:linkage and cable
- Summary:
- Excessive travel of parking brake lever - internal clutch mechanism wear - modification procedure. *tt
- Bulletin:
- 20605
- Component:
- 030000 service brakes, hydraulic
- Summary:
- Brake booster performance - check valve deterioration - inspect & repair. *tt
- Bulletin:
- 20413
- Component:
- 021100 suspension:front:stabilizer bar
- Summary:
- Remove/install front suspension stabilizer bar bushing - new workshop procedure. *tt
- Bulletin:
- 21101
- Component:
- 015000 steering:hydraulic power assist system
- Summary:
- Squeaking noise power steering repair procedure. *ak
- Bulletin:
- 501036
- Component:
- 131000 visibility:windshield
- Summary:
- Windshield heater inoperative. *kb
- Bulletin:
- JTB00093
- Component:
- 015300 steering:hydraulic power assist:power steering fluid
- Summary:
- Power assist steering leak/heavy/noisy - diagnostic aid. *nj
- Bulletin:
- TB-XT501-S934
- Component:
- 140000 air bags
- Summary:
- Jaguar: during standard calibration testing of a replacement adaptive restraints control module (rcm). the deployment time for side airbag and side curtain airbag was not optimized for one specific potential deployment scenario. *pe
- Bulletin:
- SSM-68358
- Component:
- 350000 equipment
- Summary:
- This ssm has been released to address the high number of speaker assemblies returned, many of which are deemed as 'n fault found'. cause: incorrect diagnosis."
- Bulletin:
- SSM-72805
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- Issue: a customer may raise a concern of their vehicle not passing state inspection in california and there is no warning light or other suggestion of a fault.
- Bulletin:
- SSM63597
- Component:
- 118000 electrical system: software
- Summary:
- "issue: jaguar land rover north america service diagnostics would like to make all sdd users aware of an emerging concern being tracked via the epqr system. users report dvd133 is unable to fully communicate with pcm on legacy jaguar veh
- Bulletin:
- SSM71361
- Component:
- 118000 electrical system: software
- Summary:
- "issue: da-dongle/da-vina/da-st512 - j2534 vehicle communication interface device (vci) software requires updating to the latest level. da j2534 software driver level ' v4.0 (must be updated to this level on all sdd machines that use thi
- Bulletin:
- SSM51357
- Component:
- 091200 fuel system, other:storage:fuel gauge system
- Summary:
- "issue: when investigating customer reports for incorrect fuel gauge concerns the dealer technician may diagnose that the fuel senders are open circuit. this diagnosis may be incorrect depending on the multimeter settings selected by the
- Bulletin:
- SSM37157
- Component:
- 110000 electrical system
- Summary:
- "re-issued dec 2015. please note that as yet jaguar vehicles with bulb failure monitoring systems for trailer light failure sensing are not compatible with trailer light boards that have led based illumination. as a result of this the le
- Bulletin:
- SSM39290
- Component:
- 110000 electrical system
- Summary:
- "help with diagnosing any issues / faults can be gained by phoning your jaguar technical helpline to help us with our analysis please ensure that you have the following information available before contacting jaguar cars: vin vehicle t
- Bulletin:
- 68358
- Component:
- 350000 equipment
- Summary:
- "issue: this ssm has been released to address the high number of speaker assemblies returned, many of which are deemed as 'no fault found'. cause: incorrect diagnosis."
- Bulletin:
- SFCC_14DEC17
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Presentation from dealer shop foreman conference call
- Bulletin:
- SFCC_08MAR18
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Jaguar land rover shop foreman conference call
- Bulletin:
- SFCC_09AUG18_REV
- Component:
- 350000 equipment
- Summary:
- Incontrol touch pro phase 4 customer letter
- Bulletin:
- SFCC_09AUG18_REV
- Component:
- 350000 equipment
- Summary:
- Sim card activation issues
- Bulletin:
- SFCC_09AUG18_REV
- Component:
- 110000 electrical system
- Summary:
- 18c - new face of incontrol touch pro and 18c software improvements
- Bulletin:
- SFCC_09AUG18_REV
- Component:
- 110000 electrical system
- Summary:
- A customer may report "hood open" message displays on ip with hood closed.
Home | Privacy