2002 GLAVAL APOLLO Recalls (4)
- Campaign:
- 02V179000 on 07/21/2002
- Component:
- Exterior lighting
- Manufactured:
- 10/18/2001 - 06/20/2002
- Affected:
- 233
- Defect:
- Certain buses fail to comply with requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices and associated devices." the universal bus changed from a wrap-around style rear tail and turn lamp to a flat stop/tail lamp. the wrap-around light had an integral side marker. the new flat lights do not have a side marker. the apollo and concorde models still use the wrap-around light except when led lights are ordered.
- Consequence:
- This does not meet the requirements of the standard.
- Correction:
- Glaval will provide to owners the necessary parts and installation instructions to install the rear side marker lights. owner notification began july 8, 2002. owners who do not receive the free remedy within a reasonable time should contact glaval at 1-800-445-2825.
- Notes:
- Also, customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 04V458000 on 09/22/2004
- Component:
- Equipment adaptive
- Manufactured:
- 12/31/1998 - 07/30/2004
- Affected:
- 95
- Defect:
- On certain buses equipped with sure-lok wheelchair securement systems, the sprocket teeth of the retractor assembly is out of alignment.
- Consequence:
- In the event of a vehicle crash, the wheelchair may not be adequately secured possibly resulting in injuries to the wheelchair occupant.
- Correction:
- Dealers will inspect and replace the wheelchair securement retractors as necessary. sure-lok is conducting the owner notification and remedy for this campaign. owners should contact sure-lock at 1-908-231-1804 or glaval bus at 1-800-445-2825.
- Notes:
- Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 09V421000 on 10/29/2009
- Component:
- Interior lighting
- Affected:
- 161
- Defect:
- Glaval bus is recalling certain model year 2001 through 2009 transit buses equipped with luminator horizon led side destination signs. the connector board can corrode due to an accumulation of moisture under the connector.
- Consequence:
- A short could occur, possibly causing smoke and fire.
- Correction:
- Glaval bus will notify owners and luminator will repair the buses free of charge. please see luminator's defect report 09e-054. the safety recall began on november 10, 2009. owners may contact luminator at 1-972-516-3033 or glaval bus at 1-574-262-2212.
- Notes:
- Glaval bus' recall campaign number is 17744.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
- Campaign:
- 10V618000 on 12/13/2010
- Component:
- Equipment
- Manufactured:
- 07/31/1999 - 07/30/2007
- Affected:
- 119
- Defect:
- Glaval is recalling certain model year 2002, 2003, 2006, 2007, and 2008 ford e350/e450 universal, chevy/gmc 4500/5500 titan and freightliner mb-55 apollo transit buses manufactured from august 1999 through july 2007, and equipped with a trans/air ta73 evaporator. the evaporator utilizes a power resistor to regulate blower speed. should a short occur in the "low or medium speed" circuit while the blower is in high speed, the short will cause the supply voltage to feedback through the resistor to ground, not drawing enough current to trip the fuse.
- Consequence:
- This would cause the resistor temperature to rise to a point where it will melt and possibly ignite the plastic blower housing to which it is mounted. the overheating can result in a fire.
- Correction:
- Glaval in cooperation with trans air will install a thermal shutdown device in series with the speed resistors. this service will be performed free of charge. the safety recall began on december 23, 2010. owners may contact trans air warranty and service center at 1-800-673-2446.
- Notes:
- Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
Home | Privacy