2002 FORD E-150 Recalls (3)
- Campaign:
- 07V336000 on 08/02/2007
- Component:
- Vehicle speed control
- Manufactured:
- 04/08/1996 - 08/01/2002
- Affected:
- 3,600,000
- Defect:
- On certain pickup trucks, passenger vehicles, sport utility vehicles, and motor homes chassis, the speed control deactivation switch may, under certain conditions, leak internally and then overheat, smoke, or burn.
- Consequence:
- This could result in an underhood fire.
- Correction:
- Dealers will install a fused wiring harness. owners of the passenger cars included in this campaign will be instructed to return their vehicles to their dealers to have the speed control deactivation switch disconnected as an interim repair. as soon as repair parts are available (expected october 2007), owners will be instructed to return to the dealers for installation of a fused wiring harness. the recall began on august 13, 2007, and mailing completed by september 19, 2007. owners may contact ford at 1-888-222-2751.
- Notes:
- Ford recall no. 05s28.customers may also contact the national highway traffic safety administration;s vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
- Campaign:
- 08V051000 on 02/03/2008
- Component:
- Vehicle speed control:cruise control
- Manufactured:
- 09/02/1991 - 09/14/2003
- Affected:
- 225,000
- Defect:
- Ford is recalling 225,000 my 1992-2003 econoline, my 1993-1995 taurus sho, my 1992-1998 crown victoria, my 1993 bronco, f-series, my 1995-1997 f-series super duty stripped chassis, my 1992-1998 mercury grand marquis, and my 1992-1995 lincoln town car vehicles. the affected vehicles were previously repaired using a wiring harness that is not compatible with the vehicle circuit polarity.
- Consequence:
- As a result, the fuse is located in the output circuit rather than in the intended input power feed circuit, and may not offer the intended protection in the event of an electrical short to ground.
- Correction:
- Dealers will install a new wiring harness, or replace the mating electrical component. the recall began on february 18, 2008. owners may contact ford at 1-800-392-3673.
- Notes:
- Ford recall no. 08s01.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
- Campaign:
- 09V399000 on 10/12/2009
- Component:
- Vehicle speed control
- Affected:
- 4,500,000
- Defect:
- Ford is recalling model years 1995-2003 windstar, 2000-2003 excursion diesel, 1993-1997 and 1999-2003 f-250 sd through f-550 sd diesel, 1992-2003 e-150 through e-550, 1995-2002 explorer, 1997 and 2002 mercury mountaineer, 1995-1997 and 2001-2003 ranger, and 1994 f53 vehicles equipped with the texas instruments speed control deactivation switch (scds). the scds may leak internally and then overheat, smoke, or burn.
- Consequence:
- A vehicle fire could occur with or without the engine running.
- Correction:
- Ford will notify owners that dealers will install a fused wiring harness in line with the scds. on 1999-2003 windstar vehicles with a leaking scds, dealers will also inspect the abs control module connector and repair as necessary. repairs will be completed free of charge. the safety recall began on october 27, 2009. owners may contact ford at 1-888-222-2751.
- Notes:
- Ford's recall campaign number is 09s09.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
2002 FORD E-150 TSBs (13)
- Bulletin:
- 14992
- Component:
- 105500 power train:driveline:differential unit
- Summary:
- Some vehicles equipped with 4r70w transmission (driveshaft >70 inch) may exhibit a driveline vibration / roughness on acceleration or under load at about 50 - 55 mph. *tt
- Bulletin:
- 15517
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Subject regarding exaggerated engine braking on deceleration. *yd
- Bulletin:
- 15799
- Component:
- 100000 power train
- Summary:
- Some vehicles equipped with 4r70w transmission (driveshaft >70 inch) may exhibit a vibration / roughness on acceleration or under load at about 50-55 mph. *tt
- Bulletin:
- 15923
- Component:
- 010000 steering
- Summary:
- Exhibiting a steering wheel vibration / shimmy. *tt
- Bulletin:
- 17104
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Ticking/tapping noise with the engine warmed up and the transmission in gear at idle. 2003 e150 included. *tt
- Bulletin:
- 17520
- Component:
- 021000 suspension:front
- Summary:
- Clunk from front suspension. *tt
- Bulletin:
- 17381
- Component:
- 034520 service brakes, hydraulic:foundation components:disc:pads
- Summary:
- Front brake pad wear. *tt
- Bulletin:
- 18250
- Component:
- 100000 power train
- Summary:
- Intermittent clunk on 3-2 downshift during coastdown/tip-in. oasis. to include 2005 f-150, e-series and expedition. *tt
- Bulletin:
- 18735
- Component:
- 121000 exterior lighting:headlights
- Summary:
- Headlight adjustment - chassis cab incomplete vehicles. *tt
- Bulletin:
- 05173
- Component:
- 060000 engine and engine cooling
- Summary:
- Malfunction indicator lamp on with diagnostic trouble code p1131 and/or p1151 - 4.2l engine. *tt
- Bulletin:
- 05248
- Component:
- 020000 suspension
- Summary:
- Vibration/harshness above 45 mph (72 km/h) after tire balance. *tt
- Bulletin:
- 19527
- Component:
- 121000 exterior lighting:headlights
- Summary:
- Headlight adjustment needed. *kb
- Bulletin:
- 071110
- Component:
- 040000 service brakes, air
- Summary:
- Brake booster system may exhibit a brake pedal kickback and/or grabbing condition when applying the brakes. *nj
Home | Privacy