2002 DODGE DAKOTA Recalls (12)
- Campaign:
- 03V389000 on 10/14/2003
- Component:
- Electrical system:wiring
- Manufactured:
- 06/30/2000 - 07/30/2003
- Affected:
- 50,082
- Defect:
- On certain pickup trucks equipped with manual transmissions, the headlamp and dash wiring harness may be chafed by the actuation of the clutch pedal. this could result in abnormal operation of the wipers, turn signals, horn or lighting systems.
- Consequence:
- This could affect driver visibility, could prevent a driver from sounding a warning by using the horn, and, when the turn signals are inoperative, the driver cannot use them to signal intent to turn, increasing the risk of a crash.
- Correction:
- Dealers will reroute the wire harness and repair the harness if necessary. owner notification began november 3, 2003. owners should contact daimlerchrysler at 1-800-992-1997.
- Notes:
- Daimlerchrysler recall no. c35.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 03V505000 on 12/10/2003
- Component:
- Equipment:other:labels
- Manufactured:
- 06/30/2000 - 07/30/2002
- Affected:
- 35,692
- Defect:
- On certain minivans and 4x2 pickup trucks, the vehicle certification label may have gross axle weight ratings (gawr) that exceed the maximum tire load capacity as defined in federal motor vehicle safety standard no. 120, "tire selection and rims for motor vehicles other than passenger cars."
- Consequence:
- Improperly loading your vehicle can cause tire failure and result in a crash.
- Correction:
- Owners will be provided with vehicle certification label overlays containing corrected information relative to vehicle gawr and tire size. owner notification began march 1, 2004. owners should contact daimlerchrysler at 1-800-992-1997.
- Notes:
- Daimlerchrysler recall no. c41.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 04V216000 on 05/09/2004
- Component:
- Visibility:windshield wiper/washer
- Manufactured:
- 04/23/2002 - 09/14/2003
- Affected:
- 320,188
- Defect:
- On certain pickup trucks and sport utility vehicles, the windshield wiper module motor may be susceptible to water intrusion that could cause internal corrosion and result in partial or complete loss of front windshield wiping capability.
- Consequence:
- Driver visibility could be reduced, which could result in a crash.
- Correction:
- Dealers will replace the front windshield wiper module. owner notification began on july 12, 2004. owners should contact daimlerchrysler at 1-800-853-1403.
- Notes:
- Daimlerchrysler recall no. d22.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 04V596000 on 12/20/2004
- Component:
- Suspension:front:control arm:upper ball joint
- Manufactured:
- 01/06/1999 - 12/30/2002
- Affected:
- 592,707
- Defect:
- On certain sport utility vehicles and pickup trucks equipped with four-wheel drive (4x4), if moisture leaks into the front suspension upper ball joint, evacuation of the lubricant and corrosion of the joint may cause the joint to wear over an extended period of time. this could cause a clunking noise in the front suspension, which may not always be heard by the vehicle occupants.
- Consequence:
- Excessive wear in the upper ball joint may allow it to separate, which could result in loss of control of the vehicle.
- Correction:
- Dealers will replace the front suspension upper ball joints. this safety improvement campaign began on december 21, 2004. owners can contact daimlerchrysler at 1-800-853-1403.
- Notes:
- This action is deemed a safety improvement campaign and is not being conducted under the safety act.
- Campaign:
- 06E011000 on 01/31/2006
- Component:
- Fuel system, gasoline:delivery:fuel pump
- Affected:
- 7,291
- Defect:
- Certain aftermarket airtex electric fuel pumps installed for use as replacement equipment for certain 1997-2004 jeep wrangler; 1997-2001 jeep cherokee; 1997-2004 jeep grand cherokee; and 2000-2003 dodge dakota vehicles. the plastic electrical grommet connectors at the top of the fuel pump module are not compatible with automotive fuels and may degrade causing a potential leak path for fuel.
- Consequence:
- In the presence of an ignition source, a fuel leak could result in a fire.
- Correction:
- Airtex will notify its customers and will replace the affected fuel pumps free of charge. the recall began on january 25, 2006. owners may contact airtex customer service department at 1-800-880-3056.
- Notes:
- This recall only pertains to aftermarket airtex electric fuel pumps and has no relation to any original equipment installed on jeep grand cherokee, cherokee, wrangler, or dodge dakota vehicles manufactured by daimlerchrysler.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 06E024000 on 03/16/2006
- Component:
- Engine and engine cooling
- Affected:
- 44,386
- Defect:
- Certain replacement k&n fuel performance kits, p/nos. 57-1509, 57-1511, 57-1511-1, 57-1517, 57-1517-1, 57-1527, and 57-1530. also, a small percentage of these kits were sold under the mopar performance parts brand name (p/nos. p5007069 and p5007070). all kits were manufactured from april 20, 1999, through september 23, 2004. these assemblies were manufactured as replacement equipment for certain dodge pickup trucks and suvs. a small piece of material from the tube wall could be sucked into the engine throttle body, which could cause the throttle to become jammed in the open position.
- Consequence:
- A jammed open throttle could cause unintended acceleration of the vehicle, possibly resulting in a crash or increased stoping distances when braking.
- Correction:
- K&n will provide owners with a free repair kit along with repair instructions. the recall began on april 20, 2006.
- Notes:
- This recall only pertains to replacement k&n fuel performance kits and has no relation to any original equipment installed on dodge vehicles manufactured by daimlerchrysler.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 06E026000 on 03/22/2006
- Component:
- Exterior lighting
- Affected:
- 61,944
- Defect:
- Certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
- Consequence:
- Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.
- Correction:
- Pro-a motors will notify owners and offer to repurchase the lamps. the recall began on april 3, 2006. owners may contact pro-a motors at 323-838-2988.
- Notes:
- This recall only pertains to pro-a motors aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 06E065000 on 07/16/2006
- Component:
- Exterior lighting
- Affected:
- 3,593
- Defect:
- Certain aj motorsport combination lamps sold as replacement lamps for use on the above listed passenger vehicles. combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
- Consequence:
- Lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash.
- Correction:
- Aj motorsport will notify owners and offer reimbursement for the lamps. the recall began on july 31, 2006. owners may contact aj motorsport at 626-618-2026.
- Notes:
- This recall only pertains to aj motorsport aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 07V555000 on 12/10/2007
- Component:
- Power train:automatic transmission:lever and linkage:column shift
- Manufactured:
- 06/30/2000 - 07/17/2002
- Affected:
- 576,418
- Defect:
- On certain van and pickup trucks equipped with automatic transmissions, the ignition/park shift interlock system may become inoperative. this can allow the shifter to be moved out of the "park" position with the ignition key removed (or in the "lock" position). this can also allow the ignition key to be removed when the shifter has not been placed in the "park" position.
- Consequence:
- Either of these conditions could allow the vehicle to roll away causing a crash without warning.
- Correction:
- Dealers will replace the gearshift blocker and bracket assembly free of charge. the recall is expected to begin during january 2008. owners may contact chrysler at 1-800-853-1403.
- Notes:
- Chrysler recall no. g28.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
- Campaign:
- 08E064000 on 10/19/2008
- Component:
- Suspension:front:hub
- Affected:
- 2,805
- Defect:
- Skf is recalling 2,805 hub units, part no. br930361, sold as a service part for 1997-2004 dodge dakota vehicles and 1999-2003 dodge durango vehicles equipped with 2-wheel drive & rear axle abs. due to a specification error, the rotor pilot for the hub unit may be too long. this results in the wheel to not be seated fully against the hub flange face during mounting.
- Consequence:
- Improper seating of the wheel can result in excessive vibration, brake rotor noise, difficulty removing the wheel after installation and operation of the vehicle, and possibly wheel-end separation during vehicle operation. should wheel-end separation occur, the driver could loose control of the vehicle, possibly resulting in a crash.
- Correction:
- Skf will notify owners and replace the defective hub units free of charge. the recall began on november 5, 2008. owners may contact skf vsm north america customer service at 1-800-644-8999.
- Notes:
- Skf's recall no. skf pro 08-029us/ca.this recall only pertains to aftermarket skf hub units and has no relation to any original equipment installed on dodge dakota or durango vehicles manufactured by chrysler.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 09E012000 on 04/06/2009
- Component:
- Exterior lighting
- Affected:
- 16,270
- Defect:
- Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
- Consequence:
- Decreased lighting visibility may result in a vehicle crash.
- Correction:
- Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on may 11, 2009. owners may contact sabersport at 1-909-598-7589.
- Notes:
- This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by sabersport.the list can be found under "document search" located at the bottom of your screen.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
- Campaign:
- 09E025000 on 05/10/2009
- Component:
- Exterior lighting:headlights
- Affected:
- 42,540
- Defect:
- Dope, inc. is recalling 42,540 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
- Consequence:
- Decreased lighting visibility may result in a vehicle crash.
- Correction:
- Dope, inc. will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on july 28, 2009. owners may contact dope, inc. at 1-626-272-1798.
- Notes:
- This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by dope, inc.the list can be found under "document search" located at the bottom of your screen. owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
2002 DODGE DAKOTA TSBs (39)
- Bulletin:
- 0801001
- Component:
- 110000 electrical system
- Summary:
- Subject regarding airbag / clock spring service for various models including 2002 model year jeep liberty. *tt
- Bulletin:
- 1801201
- Component:
- 350000 equipment
- Summary:
- Subject regarding generic scan tool (gst), publication no. 81-170-00008 provided with this technical service bulletin to provide reference information when using generic scan tool on obdii vehicles. *tt
- Bulletin:
- 2100601
- Component:
- 103000 power train:automatic transmission
- Summary:
- Automatic transmission fluid usage atf+4. *tt *mj
- Bulletin:
- 1900701
- Component:
- 015300 steering:hydraulic power assist:power steering fluid
- Summary:
- Information on new power steering fluid.*slc
- Bulletin:
- 0801601
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Information regarding vehicles equipped with radios will have a new locking radio antenna connector. *slc
- Bulletin:
- 0801701
- Component:
- 110000 electrical system
- Summary:
- Subject regarding safety systems - vehicle modifications / repair. *tt
- Bulletin:
- 2302701
- Component:
- 135200 visibility:rearview mirrors/devices:exterior
- Summary:
- Subject regarding outside rearview mirror glass replacement. *tt
- Bulletin:
- 01016
- Component:
- 103000 power train:automatic transmission
- Summary:
- Some vehicles may exhibit a transmission filler tube rattle condition. *tt
- Bulletin:
- 01016A
- Component:
- 103000 power train:automatic transmission
- Summary:
- Rapid reponse transmittal regarding transmission filler tube rattle condition. *tt
- Bulletin:
- 0500601
- Component:
- 035000 service brakes, hydraulic:fluid
- Summary:
- Subject regarding discolored brake fluid. *tt
- Bulletin:
- 02005
- Component:
- 350000 equipment
- Summary:
- Missing tonneau cover. *slc
- Bulletin:
- 02007
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Subject regarding 4.7l crankshaft to bedplate interference. *slc
- Bulletin:
- 1801602
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding flash: malfunction indicator lamp illumination for erroneous diagnostic trouble code p0456, evap monitor small leak detected. *slc
- Bulletin:
- 2301502
- Component:
- 135200 visibility:rearview mirrors/devices:exterior
- Summary:
- Subject regarding outside rearview mirror glass replacement. *slc
- Bulletin:
- 2200102
- Component:
- 980000 unknown or other
- Summary:
- Chrome wheel care. *slc
- Bulletin:
- 0800702
- Component:
- 110000 electrical system
- Summary:
- Subject regarding remote keyless entry programming procedures. *slc
- Bulletin:
- 1400102
- Component:
- 071110 fuel system, gasoline:storage:tank assembly:filler pipe and cap
- Summary:
- Subject regarding fuel cap difficult to remove. *slc
- Bulletin:
- 1802002
- Component:
- 980000 unknown or other
- Summary:
- Flash programming failure recovery. *slc
- Bulletin:
- 2100202
- Component:
- 103000 power train:automatic transmission
- Summary:
- Subject regarding revision in diagnostic procedures and labor operation times for re transmissions. *tt
- Bulletin:
- 1400102A
- Component:
- 071110 fuel system, gasoline:storage:tank assembly:filler pipe and cap
- Summary:
- Fuel cap difficult to remove. *tt
- Bulletin:
- 1800103
- Component:
- 100000 power train
- Summary:
- Customers may complain the vehicle will not shift out of 2nd gear while climbing a grade. update to transmission calibrations. *tt
- Bulletin:
- 1800203
- Component:
- 330000 interior lighting
- Summary:
- The malfunction indicator lamp (mil) may illuminate due to erroneous detection of a small leak in the vehicle's evaporative system. *tt
- Bulletin:
- 1800103A
- Component:
- 100000 power train
- Summary:
- Customers may complain the vehicle will not shift out of 2nd gear while climbing a grade. update to transmission calibrations.
- Bulletin:
- 0802303
- Component:
- 110000 electrical system
- Summary:
- Intermittent locking/unlocking of doors without activating the power door lock switch. *tt
- Bulletin:
- 0703
- Component:
- 162000 structure:body
- Summary:
- Disconnecting the park brake release handle when servicing the steering column opening cover. *tt
- Bulletin:
- 1801504
- Component:
- 180000 vehicle speed control
- Summary:
- Idle fluctuation while turning. *tt
- Bulletin:
- 2301004
- Component:
- 162000 structure:body
- Summary:
- Passenger compartment floor water leak. *tt this bulletin supersedes bulletin 23-010-04 dated 04-29-04. *tt
- Bulletin:
- 10023
- Component:
- 012000 steering:column
- Summary:
- Steering column service. information. service information tuneups. *tt
- Bulletin:
- 0201004
- Component:
- 020000 suspension
- Summary:
- Upper ball joint extended warranty. *tt
- Bulletin:
- 0801505
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Powertrain control module initialization. *sc
- Bulletin:
- 2401305
- Component:
- 353600 equipment:air conditioner
- Summary:
- Air conditioning (a/c) cooling coil odor. *tt
- Bulletin:
- 2101505
- Component:
- 100000 power train
- Summary:
- 45rfe/545rfe trans - delayed engagement due to cooler return filter replacement. *sc
- Bulletin:
- 0803006
- Component:
- 103000 power train:automatic transmission
- Summary:
- Powertrain control module initialization. *kb
- Bulletin:
- 9002519
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- 82212076, 82203694 - fabric cleaner this "fabric cleaner" is not intended for sale in california, the otc states (connecticut, delaware, massachusetts, maine, new hampshire, new jersey, new york, pennsylvania, virginia, and washington dc
- Bulletin:
- 9002872
- Component:
- 116100 electrical system:ignition:switch
- Summary:
- 56045489a$ - neutral safety switch - trans assy 06036369aa screw and washer is now available as a service part , 2 required to attach neutral start switch
- Bulletin:
- 9002872
- Component:
- 100000 power train
- Summary:
- 56045489a$ - neutral safety switch - trans assy 06036369aa screw and washer is now available as a service part , 2 required to attach neutral start switch
- Bulletin:
- 9002901
- Component:
- 100000 power train
- Summary:
- Part description: seal - shift shaft on rfe transmissions issue description: this seal (04799346) is replaceable with seal kit (68235551aa), which includes a seal and retainer. the seal kit is applicable to all (5)45rfe transmissions.
- Bulletin:
- 9002828
- Component:
- 160000 structure
- Summary:
- Part description: insulator in lever assembly - valve body - trans issue description: the manual valve insulator, attaching rivet and an instruction sheet are now available as a kit. if the insulator requires replacement lease order 68253
- Bulletin:
- 9002849
- Component:
- 160000 structure
- Summary:
- Part description: insulator on lever assy manual valve - valve body - rwd transmission issue description: the manual valve insulator, attaching rivet and instruction sheet are now available as a kit. if the insulator requires replacement
Home | Privacy