2001 FORD F-150 Recalls (19)
- Campaign:
- 00V348000 on 10/30/2000
- Component:
- Seat belts:front:retractor
- Manufactured:
- 09/29/2000 - 10/10/2000
- Affected:
- 830
- Defect:
- Vehicle description: regular cab pickup trucks. the driver side seat belt retractor may not fully retract the belt.
- Consequence:
- This could cause slack in the seat belt when worn, increasing the risk of personal injury to the seat occupant, in the event of a crash.
- Correction:
- Dealers will replace the driver's side seat belt assembly.
- Notes:
- Owner notification began november 9, 2000.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 00V396000 on 11/28/2000
- Component:
- Equipment:other:owners/service/other manual
- Manufactured:
- 04/17/2000 - 09/21/2000
- Affected:
- 495,000
- Defect:
- Vehicle description: certain sport utility vehicles, pickup trucks, and passenger vehicles fail to comply with the requirements of fmvss 225, "child restraint anchorage systems." the affected expedition/navigator owner guides do not identify the locations of seating positions equipped with tether anchorages, and do not provide instructions for securing child seats to these tether anchorages. the f150 sc owner guides do not provide the procedure for securing child seats to the tether anchorages. the taurus/sable owner guides do not identify the center rear seating position as having latch compatible lower anchorages.
- Consequence:
- In the event of a crash, the child seat may not be properly attached increasing the risk of injury to the child.
- Correction:
- Owners will be provided with owner guide inserts revised to provide the required information, and instructions for affixing these inserts to their owner guides. customers will also be advised that if they prefer, their dealer will affix the inserts to their owner guides.
- Notes:
- Owner notification began march 6, 2001. owners who do not receive the free label and installation instructions within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 01V082000 on 03/20/2001
- Component:
- Air bags:frontal
- Manufactured:
- 02/25/2001 - 02/27/2001
- Affected:
- 268
- Defect:
- Vehicle description: passenger and sport utility vehicles. the inflator canister in the driver air bag module may have an inadequate weld near the igniter.
- Consequence:
- In the event of a vehicle crash, the driver air bag may not deploy as intended, potentially resulting in reduced occupant protection, or a burn injury.
- Correction:
- Dealers will install a driver air bag module. owner notification began march 19, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.
- Notes:
- Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 01V095000 on 03/22/2001
- Component:
- Service brakes, hydraulic:foundation components:hoses, lines/piping, and fittings
- Manufactured:
- 12/12/2000 - 02/19/2001
- Affected:
- 670
- Defect:
- Vehicle description: light duty pickup trucks. the left front brake hose was damaged during final assembly.
- Consequence:
- If the hose is damaged, brake fluid could leak and stopping distances may be increased.
- Correction:
- Dealers will install a new left front brake hose assembly. owner notification began march 20, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-248-0186 or 1-800-392-3673.
- Notes:
- Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 01V227001 on 07/16/2001
- Component:
- Seat belts:front:buckle assembly
- Manufactured:
- 04/17/2000 - 06/08/2001
- Affected:
- 1,400,000
- Defect:
- Vehicle description: passenger and sport utility vehicles, pickup trucks, and minivans. equipped with seat belts supplied by trw. it is possible that the driver's and/or front passenger's outboard seat belt buckle may not fully latch. ford crown victoria built at st. thomas assembly plant from 4/17/00 - 5/29/01 mercury grand marquis built at st. thomas assembly plant from 4/17/00 - 5/29/01. lincoln town cars built at wixom assembly plant from 3/27/00 - 5/30/01. lincoln navigators built at michigan truck plant from 4/11/00 - 5/31/01. ford windstars built at oakville assembly plant from 3/23/00 - 5/30/01. ford rangers built at twin cities plant from 3/28/00 - 5/30/01, and also at the edison plant from 3/13/00 - 5/25/01. ford f-150 truck built at norfolk plant from 4/18/00 - 5/25/00; at ontario plant from 5/10/00 - 5/28/01; at kansas city plant from 9/11/99 - 5/25/01; and at cuautitlan plant from 5/16/00 - 6/9/01. ford super duty f-250, f-350, f-450, and f-550 trucks built at kentucky plant from 4/17/00 - 5/27/01; and at cuautitlan plant from 5/16/00 - 6/19/01. ford excursions built at kentucky plant from 4/17/00 - 10/2/00. ford expeditions built at michigan truck plant from 4/11/00 - 5/31/01.
- Consequence:
- In the event of a crash, the restraint system may not provide adequate occupant protection, increasing the risk of personal injury to the seat occupant.
- Correction:
- Dealers will inspect the front outboard seat belt buckles and if the buckle fails the inspection process, it will be replaced. owner notification began july 25, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-866-436-7332.
- Notes:
- Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 01V258000 on 08/22/2001
- Component:
- Visibility:windshield wiper/washer:motor
- Affected:
- 1,083,000
- Defect:
- Vehicle description: passenger cars, sport utility vehicles, and light and medium duty pickup trucks. a switch located in the plastic cover of the wiper motor gear case could malfunction and overheat, potentially resulting in loss of intermittent wiper function, loss of wiper park function, complete loss of wiper function, or ignition of the plastic cover material. switch malfunction is most likely to occur when the intermittent setting of the wipers is being used, or when snow or ice obstructs the blades from returning to the "parked" position at the bottom of the windshield. these vehicles were built at the following assembly plants: atlanta plant from 2/11/00 through 7/31/00; chicago plant from 2/14/00 through 8/4/00; kansas city plant from 2/26/00 to 9/4/00; kentucky truck plant from 2/18/00 to 8/31/00; michigan truck plant from 2/23/00 through 8/3/00; norfolk plant from 2/21/00 through 7/27/00; wayne stamping and assembly plant from 2/25/00 through 8/15/00; and wixom plant from 2/15/00 through 8/8/00.
- Consequence:
- Loss of visibility while driving increases the risk of a crash.
- Correction:
- Dealers will inspect the date code on the wiper motor. motors built with the suspect time frame will have the wiper motor gear case cover replaced. owner notification began august 20, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-866-436-7332.
- Notes:
- Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 05V388000 on 09/06/2005
- Component:
- Vehicle speed control
- Affected:
- 4,500,000
- Defect:
- On certain pickup trucks and sport utility vehicles equipped with speed control, the speed control deactivation switch may overheat, smoke, or burn.
- Consequence:
- A fire at the switch could occur.
- Correction:
- By letter dated september 12, 2005, owners were instructed to return their vehicles to their dealers to have the speed control deactivation switch disconnected. owners who have had their speed control deactivated are being notified that parts will be available and advised to make an appointment to reconnect the speed control beginning in february 2006. owners who did not have their speed control deactivated are being notified to have their system remedied beginning in february 2006. owners are urged to avail themselves of the free disconnect service as soon as possible because of the significant risk of fire. owners may contact ford at 1-800-392-3673. (note: also see recalls 05v017 and 06v286)
- Notes:
- Ford recall no. 05s28.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
- Campaign:
- 06E023000 on 03/13/2006
- Component:
- Exterior lighting:headlights
- Affected:
- 292,000
- Defect:
- Certain anzo combination headlamp assemblies sold as replacement lamps for use on certain passenger vehicles. some combination lamps are not equipped with amber side reflectors which fail to conform to federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment."
- Consequence:
- Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash.
- Correction:
- Anzo will notify owners and replace the headlamps free of charge. the recall began may 9, 2006. owners may contact anzo usa at 909-468-3688.
- Notes:
- This recall only pertains to aftermarket headlamp assemblies manufactured by anzo and has no relation to any original equipment installed on the listed passenger vehicles.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 06E052000 on 06/11/2006
- Component:
- Exterior lighting:headlights
- Affected:
- 14,616
- Defect:
- Certain eagle eyes headlamps, p/nos. fr208-b101r, fr208-b101l, fr208-b001r, and fr208-b001l, sold for use as replacement equipment for the passenger vehicles listed above. these headlamps fail to conform to the photometric requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
- Consequence:
- Decreased lighting visibility may result in a vehicle crash.
- Correction:
- Sabry lee will notify owners and offer full credit for any noncompliant headlamp. the recall is expected to begin on june 14, 2006. owners may contact sabry lee account executive at 1-866-467-2279.
- Notes:
- This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles manufactured by the ford motor company.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 06E056000 on 06/22/2006
- Component:
- Fuel system, gasoline
- Affected:
- 58,640
- Defect:
- Certain aftermarket fuel filters sold under the purolator brand name, p/n f65277, shipped from january 16 through june 2, 2006, for use on the above listed passenger vehicles. due to incorrect design, the quick connectors may not fully seat with the tube interface, even though the person making the connection may believe that the quick connector is fully attached.
- Consequence:
- Failure of this connection could lead to fuel spillage and, in the presence of an ignition source, a fire could occur.
- Correction:
- Ufi will notify owners and replace the filters free of charge. the recall began on august 4, 2006. owners may contact ufi filters usa at 800-230-5876.
- Notes:
- This recall only pertains to ufi filters usa (purolator) aftermarket fuel filters and has no relation to any original equipment installed on the listed passenger vehicles.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 06E060000 on 06/28/2006
- Component:
- Exterior lighting
- Affected:
- 87,745
- Defect:
- Certain aai motorsports combination lamps sold as replacement lamps for use on the above list passenger vehicles. combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment."
- Consequence:
- Lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash
- Correction:
- Aai motorsports will notify owners and replace the lamps free of charge. the recall began on august 1, 2006. owners may contact aai motorsports at 909-923-9188.
- Notes:
- This recall only pertains to aai motorsports aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 06E065000 on 07/16/2006
- Component:
- Exterior lighting
- Affected:
- 3,593
- Defect:
- Certain aj motorsport combination lamps sold as replacement lamps for use on the above listed passenger vehicles. combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
- Consequence:
- Lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash.
- Correction:
- Aj motorsport will notify owners and offer reimbursement for the lamps. the recall began on july 31, 2006. owners may contact aj motorsport at 626-618-2026.
- Notes:
- This recall only pertains to aj motorsport aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 06E064000 on 07/16/2006
- Component:
- Exterior lighting
- Affected:
- 4,029
- Defect:
- Certain tradesonic combination lamps sold as replacement lamps for use on the above listed passenger vehicles. combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
- Consequence:
- Lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash.
- Correction:
- Tradesonic will notify owners and replace the lamps free of charge. the recall is expected to begin during july 2006. owners may contact tradesonic at 626-934-8884.
- Notes:
- This recall only pertains to tradesonic aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 06E067000 on 07/31/2006
- Component:
- Exterior lighting:headlights
- Affected:
- 19,413
- Defect:
- Certain maxzone headlight assemblies, depo brand, p/nos. 331-1129l-asn and 331-1129r-asn, sold for use as aftermarket equipment for the above listed passenger vehicles. these headlamps fail to conform to the photometric requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
- Consequence:
- Decreased lighting visibility may result in a vehicle crash.
- Correction:
- Maxzone will notify owners and offer reimbursement for any noncompliant headlights. the recall began on july 28, 2006. owners may contact maxzone at 909-822-3288.
- Notes:
- This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles manufactured by ford motor company.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 07E066000 on 08/28/2007
- Component:
- Equipment:electrical
- Affected:
- 175
- Defect:
- Certain cequent 90 degree 7-way right angle adaptors sold by distributors in tow packages for aftermarket sales to tow 5th wheel rv travel trailers. due to incorrect wiring of the harness, the trailer lights may not operate properly.
- Consequence:
- If the trailer lights are not working properly, a vehicle crash can occur.
- Correction:
- All of the defective tow packages are still at the distributor level and have not been sold to any consumers.
- Notes:
- This recall only pertains to aftermarket cequent tow packages and has no relation to any original equipment installed on daimlerchrysler, gmc, or ford vehicles.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 08E050000 on 08/13/2008
- Component:
- Exterior lighting:headlights
- Affected:
- 1,921
- Defect:
- K2 motor is recalling 1,921 aftermarket headlamps of various models sold for use on the above listed vehicles. these headlamps are missing the amber side reflex reflector which fails to conform with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment."
- Consequence:
- Without the amber side reflex reflectors, the lighting visibility may be affected, possibly resulting in a vehicle crash.
- Correction:
- K2 motor will notify owners and offer a full refund. the recall began on decemeber 17, 2008. owners may contact k2 motor at 1-909-839-2992.
- Notes:
- This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles manufactured by honda, ford, or chrysler llc. customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 09E012000 on 04/06/2009
- Component:
- Exterior lighting
- Affected:
- 16,270
- Defect:
- Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
- Consequence:
- Decreased lighting visibility may result in a vehicle crash.
- Correction:
- Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on may 11, 2009. owners may contact sabersport at 1-909-598-7589.
- Notes:
- This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by sabersport.the list can be found under "document search" located at the bottom of your screen.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
- Campaign:
- 09E025000 on 05/10/2009
- Component:
- Exterior lighting:headlights
- Affected:
- 42,540
- Defect:
- Dope, inc. is recalling 42,540 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
- Consequence:
- Decreased lighting visibility may result in a vehicle crash.
- Correction:
- Dope, inc. will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on july 28, 2009. owners may contact dope, inc. at 1-626-272-1798.
- Notes:
- This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by dope, inc.the list can be found under "document search" located at the bottom of your screen. owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
- Campaign:
- 11V385000 on 07/31/2011
- Component:
- Fuel system, gasoline:storage:tank assembly:mounting
- Manufactured:
- 06/19/1995 - 08/03/2004
- Affected:
- 1,100,000
- Defect:
- Ford is recalling certain 1997 through 2003 model year ford f-150, 2004 model year ford f-150 heritage, 1997 through 1999 model year f-250 less than 8,500 lbs. gross vehicle weight rating (gvwr), and 2002 and 2003 lincoln blackwood vehicles manufactured from june 20, 1995, through august 4, 2004, originally sold, or currently registered in, connecticut, delaware, illinois, indiana, iowa, kentucky, maine, maryland, massachusetts, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, west virginia, wisconsin, and the district of columbia. prolonged exposure to road deicing chemicals may cause severe corrosion of the fuel tank straps which secure the tank to the vehicle.
- Consequence:
- As a result of the corrosion, one or both straps may fail allowing the fuel lines to separate from the tank, or in some cases, causing the tank to contact the ground. either scenario may result in a fuel leak presenting a fire hazard.
- Correction:
- Ford will notify owners and instruct them to take their vehicles to a ford or lincoln dealer to have the fuel tank straps replaced with straps that have increased corrosion protection. early in this campaign, if replacement straps are not available, dealers may install a cable support under the strap as an interim repair or a steel reinforcement over the existing strap as a permanent repair. any repairs will be performed free of charge. the safety recall began on september 16, 2011. owners may contact ford motor company customer relationship center at 1-866-436-7332. ford's recall campaign number is 11s21
- Notes:
- Ford's recall campaign number is 11s21.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
2001 FORD F-150 TSBs (166)
- Bulletin:
- 14189
- Component:
- 017000 steering:linkages
- Summary:
- Concerns with squeaking noise from tie rod end. *tt
- Bulletin:
- 002310
- Component:
- 103600 power train:automatic transmission:cooling unit and lines
- Summary:
- Subject regarding contamination from prior transmission concerns or excess wear may be trapped in the transmission fluid cooling system. *tt
- Bulletin:
- 14595
- Component:
- 185000 vehicle speed control:cruise control
- Summary:
- Some vehicles may exhibit a higher than normal base idle speed of 1200 - 1400 rpm when the vehicle is initially received from the assembly plant. *tt
- Bulletin:
- 14609
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Subject regarding high idle and/or check engine light condition. *jb
- Bulletin:
- 00222
- Component:
- 015100 steering:hydraulic power assist:pump
- Summary:
- Information regarding power steering pump bolt-correct placement of bolts and washer-windsor built engines. *jb
- Bulletin:
- 0125
- Component:
- 151600 seat belts:front:warning light/devices
- Summary:
- Seat belt warning system - belt reminder function, operation and service tips. *tt
- Bulletin:
- 0162
- Component:
- 116300 electrical system:ignition:anti-theft controller
- Summary:
- Vehicles equipped with passive anti-theft system (pats) may not start or crank. *tt
- Bulletin:
- 0142
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles may exhibit the engine oil sending unit contacting the oil drip shield attached to the front axle. *tt
- Bulletin:
- 0147
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Subject regarding engine oil recommendations for use in 2001 vehicles - sae 5w-20 motor oil. *tt
- Bulletin:
- 0158
- Component:
- 103000 power train:automatic transmission
- Summary:
- Some vehicles equipped with the 4r70w automatic transmission may exhibit a ticking or clicking type noise in first gear. *tt
- Bulletin:
- 0191
- Component:
- 103000 power train:automatic transmission
- Summary:
- Some vehicles built before 3/1/2001 may exhibit a high speed driveline vibration that may cause possible transmission and / or driveshaft damage. this may result in the 4r70w transmission extension housing bushing to be spun out of the ex
- Bulletin:
- 14916
- Component:
- 350000 equipment
- Summary:
- Some supercrews are equipped with a digital memo recorder mounted on the driver's side sun visor which allows memos to be recorded, then played back at a later time as a personal reminder. to ensure that any unintended messages are not le
- Bulletin:
- 14918
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- This bulletin states that on some vehicles (including 2002 blackwood) a battery disconnect or parameter reset is required during powertrain control module (pcm) or instrument cluster (vic / hec / icm) replacement. *tt
- Bulletin:
- 14931
- Component:
- 220000 seats
- Summary:
- Information on supercrews exhibiting a backwards inserted rear seat headrest. *tt
- Bulletin:
- 14880
- Component:
- 980000 unknown or other
- Summary:
- Some vehicles equipped with 5.4l engine may exhibit a diagnostic trouble code (dtc) p0300 in memory. *tt
- Bulletin:
- 14907
- Component:
- 980000 unknown or other
- Summary:
- Concerns with vehicles exhibiting the oil pressure gauge registering low or no oil pressure usually on initial start-up after several hours of cold soak. *tt
- Bulletin:
- 14397
- Component:
- 134000 visibility:sun roof assembly
- Summary:
- Certain supercrews and some vehicles may exhibit a wind noise / boom when driven at high speeds above 55 mph with the moon roof fully open, due to the moon roof wind deflector not deployed high enough above the roof line. *tt
- Bulletin:
- 01135
- Component:
- 103000 power train:automatic transmission
- Summary:
- Some vehicles equipped with 4r100 transmission, having a transmission build date between 7/27/2000 and 3/23/2001, may exhibit an intermittent, delayed or no second gear condition. *tt
- Bulletin:
- 01136
- Component:
- 070000 fuel system, gasoline
- Summary:
- Subject regarding overview of bi-fuel cng vehicle parameter identification data (pid), inputs and outputs as a diagnostic aid for bi-fuel vehicles. *tt
- Bulletin:
- 01137
- Component:
- 103000 power train:automatic transmission
- Summary:
- Some vehicles equipped with a 4r70w automatic transmission may exhibit a clunk noise during the 2-1 downshift event. *tt
- Bulletin:
- 01141
- Component:
- 104000 power train:transfer case (4-wheel drive)
- Summary:
- Some vehicles may exhibit inadvertent 4x4 hi or low shift events, 4x4 and / or low range indicator flashing or solid or vehicle stuck in 4l after uncommanded shift. *tt
- Bulletin:
- 01117
- Component:
- 103000 power train:automatic transmission
- Summary:
- Some vehicles equipped with a 4r70w automatic transmission exhibiting a no forward or a delayed engagement may have a damaged forward clutch. *tt
- Bulletin:
- 011112
- Component:
- 123000 exterior lighting:tail lights
- Summary:
- Some flareside and super crew models may exhibit water and dirt which can migrate into the tail lamp lens through the lens vent hole. *tt
- Bulletin:
- 14990
- Component:
- 162300 structure:body:door
- Summary:
- Concerns that some trucks may exhibit a loose / detached rear window halo trim gimp moulding. *tt
- Bulletin:
- 15022
- Component:
- 036400 service brakes, hydraulic:antilock:abs warning light
- Summary:
- Concerns that the anti-lock brake system (abs) lamp is on with diagnostic trouble codes c1230, c1229, or c1237. *tt
- Bulletin:
- 01153
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Some vehicles equipped with bi-fuel 5.4 l engines may exhibit a stall, rpm dip, or idle surge greater than 200 rpm immediately following tip-in from a stop, operating in alternative fuel mode. *slc
- Bulletin:
- 01155
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Some vehicles, bi fuel, may exhibit a no start condition in both the gasoline mode and the alt fuel mode, vehicles equipped with 5.4l or 6.8l bi fuel engines only. *slc
- Bulletin:
- 01156
- Component:
- 138120 visibility:defroster/defogger system:windshield:heater core
- Summary:
- Some vehicles may exhibit heater core leaks. *slc
- Bulletin:
- 01157
- Component:
- 980000 unknown or other
- Summary:
- Information regarding transmission fluid usage charts. *slc
- Bulletin:
- 01165
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Some vehicles may exhibit no start, long crank, or stall while operating in bi-fuel mode, vehicles with 5.4l cng bi-fuel engine only. *slc
- Bulletin:
- 15113
- Component:
- 091100 fuel system, other:storage:tank assembly
- Summary:
- Some vehicles may exhibit a fuel fill valve sealing condition. *yd
- Bulletin:
- 15145
- Component:
- 173100 latches/locks/linkages:tailgate:latch
- Summary:
- Some vehicles equipped with remote locking tailgates may exhibit a tailgate locking itself when the vehicle is being driven over rough roads or is slammed shut. *et
- Bulletin:
- 15187
- Component:
- 160000 structure
- Summary:
- Some vehicles may exhibit a loose/detached rear window halo gimp molding. *et
- Bulletin:
- 15253
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Information dfpe sensor location. *tt
- Bulletin:
- 01181
- Component:
- 103800 power train:automatic transmission:park/neutral start switch
- Summary:
- Brake shift interlock.*jb
- Bulletin:
- 15219
- Component:
- 980000 unknown or other
- Summary:
- Some vehicles may exhibit a condition where all the guages inthe instrument cluster will sweep at initial start up. *tt
- Bulletin:
- 15271
- Component:
- 091110 fuel system, other:storage:tank assembly:filling/charging
- Summary:
- Dedicated cng regulator bowl kit available. *jg
- Bulletin:
- 15259
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Concerns with the lower power in high ambient temepratures. *tt
- Bulletin:
- 01194
- Component:
- 110000 electrical system
- Summary:
- This aritlce is to provide information on replacement of old style hood lamp switch to the rvised mechanical hood lamp switch. *tt
- Bulletin:
- 01214
- Component:
- 180000 vehicle speed control
- Summary:
- Information to aid in diagnosis for clarification of lock-off solenoid and solenoid tank valve coil rsistances for bi-fuel vehicles. *tt
- Bulletin:
- 01215
- Component:
- 180000 vehicle speed control
- Summary:
- A condition may exist, where throttle sticking may occur on a few vehicles in very cold ambient temperatures after operating at steady speed or extended idle for a period of time. *tt
- Bulletin:
- 012113
- Component:
- 116100 electrical system:ignition:switch
- Summary:
- Some ignition switch lock cylinder assemblies may exhibit rougness and / or excess effort in turning, key does not fully return from start, a malfunction indicator lamp may illuminate with p0500, p1502 and u1039 stored in powertrian control
- Bulletin:
- 01205
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles may exhibit vacuum or air leaks in the intake manifold and / or engine system causing diagnostic trouble codes p0171 and or p0174. *tt
- Bulletin:
- 0214
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some engine assemblies with aluminum cylinder heads repaired in-vehile have been found to leak coolant and/or oil from the cylinder head gasket area. *tt
- Bulletin:
- 15570
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles may exhibit various driveability conditions including lacks power, hesitates, hard to start, and/or malfunction indicator lamp (mil) illuminated and produce possible diagnostic trouble codes p0103, p0172 and p0175. *tt
- Bulletin:
- 15356
- Component:
- 034500 service brakes, hydraulic:foundation components:disc
- Summary:
- Some supercrew 4x4s may exhibit noise emanating from the front brakes. *tt
- Bulletin:
- 15285
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles equipped with a 4.6l or 5.4l engine may exhibit an engine vibration / rough engine at idle. *tt
- Bulletin:
- 01221
- Component:
- 070000 fuel system, gasoline
- Summary:
- Some dedicated compressed natural gas (cng) vehicles may exhibit a rough idle, or no start in cold conditions. *tt
- Bulletin:
- 01231
- Component:
- 070000 fuel system, gasoline
- Summary:
- Some compressed natural gas (cng) vehicles may exhibit rough idle or no start when cold. *tt
- Bulletin:
- 15431
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Exhibiting lack of power condition when vehicle is operated in ambient temperatures. *tt
- Bulletin:
- 01241
- Component:
- 101100 power train:clutch assembly:pedal/linkage
- Summary:
- Some vehicles may exhibit a condition of not being able to disengage clutch as the clutch pedal is stroked or the clutch pedal remains on floor. *tt
- Bulletin:
- 01243
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some bi-fuel equipped vehicles may exhibit reduced engine power, rpm dip or idle surge greater than 200 rpm immediately following tip-in from a stop operating in alternative fuel mode. *tt
- Bulletin:
- 01244
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some cng bi-fuel vehicles may exhibit a no start, long crank, hesitation or reduced engine power while operating in bi-fuel mode only. *tt
- Bulletin:
- 01246
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Engine oil system priming procedures, service tips for reports of premature engine failure. *tt
- Bulletin:
- 01248
- Component:
- 162000 structure:body
- Summary:
- Some vehicles equipped with seat integrated restraint seats may exhibit a seat vibration or shake while at idle in gear. *tt
- Bulletin:
- 01253
- Component:
- 138000 visibility:defroster/defogger system
- Summary:
- Concerns with white flakes coming from the air conditioner vents when the blower motor is engaged. *tt
- Bulletin:
- 01255
- Component:
- 033000 service brakes, hydraulic:power assist
- Summary:
- Some lightning model vehicles may exhibit a reduced power assist after the first two or three brake applications during operating in freezing ambient temperatures. *tt
- Bulletin:
- 01E16
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- Emissions recall 01e16 to replace incorrect hego sensor, the incorrect hego sensor may cause applicable exhaust emissions standards to be exceeded due to the potential for incorrect fuel/air ratios. *tt
- Bulletin:
- 01T06
- Component:
- 070000 fuel system, gasoline
- Summary:
- On some vehicles, the calibration in the alternate fuel control module has incorrect volumetric values for certain drive conditions, this incorrect value may cause a buck and jerk condition at highway speeds. *tt
- Bulletin:
- 15502
- Component:
- 021000 suspension:front
- Summary:
- Concerns with pop/clunk/click noise from the front suspension when making low-speed turns in forward or reverse gears. *tt
- Bulletin:
- 15645
- Component:
- 070000 fuel system, gasoline
- Summary:
- Some vehicles may exhibit a crank no start condition while operating in bi-fuel mode, vehicle will start on gasoline. *tt
- Bulletin:
- 01B83
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding customer satisfaction program, vehicles with heavy duty electrical/cooling group, publications error. *slc
- Bulletin:
- 01E15
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- Field action to replace the heated exhaust gas oxygen (hego) sensor. *tt
- Bulletin:
- 0271
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles built at the cuautitlan assembly plant equipped with the 4.2l engine and automatic transmission, may exhibit a vibration condition when the engine is at idle in drive and / or reverse with the air conditioner turned on. *tt
- Bulletin:
- 0253
- Component:
- 091100 fuel system, other:storage:tank assembly
- Summary:
- Subject regarding alternative fuel vehicle compressed natural gas tank inspection. *tt
- Bulletin:
- 0258
- Component:
- 100000 power train
- Summary:
- Inoperative or inacurrate speedometer, 4x4 lamp illuminatd, and / or diagnostic trouble code p1635 or p1639. *tt
- Bulletin:
- 0241
- Component:
- 017300 steering:linkages:arm:idler and attachment
- Summary:
- Subject regarding idler arm replacement specifications. *tt
- Bulletin:
- 0245
- Component:
- 111000 electrical system:battery
- Summary:
- Information regarding discharged battery charging service tips and guidelines. *tt
- Bulletin:
- 02103
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some bi-fuel cng vehicles may exhibit a crank no start condition while operating in alternate fuel mode, with the alt fuel light on. *tt
- Bulletin:
- 02104
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some bi-fuel lpg vehicles may exhibit a no start, rolling idle, surging idle and / or surge at cruise condition in lpg mode with alt fuel green light on. *tt
- Bulletin:
- 02105
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some bi-fuel cang and lpg vehicles may exhibit a no start condition. *tt
- Bulletin:
- 02108
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles equipped with the 5.4l 2v engine may exhibit a whistling noise fromthe formed nylon tube inthe idle-air bypass flow circuit. *tt
- Bulletin:
- 16170
- Component:
- 980000 unknown or other
- Summary:
- Some vehicles equipped with a 4r100 transmission and built between january 1, 2001 and may 1, 2002 may exhibit flashing transmission control indicator lamp and any or all torque converter clutch diagnostic trouble codes p0740, p0741, p0743,
- Bulletin:
- 16172
- Component:
- 034400 service brakes, hydraulic:foundation components:drum
- Summary:
- Some vehicles with 4-wheel disc brakes may exhibit a moan from the rear brakes on light brake applications. *tt
- Bulletin:
- 16019
- Component:
- 980000 unknown or other
- Summary:
- Some lightning and harley davidson supercrews may exhibit check engine light illumination with diagnostic trouble codes p0171 or p0174. *tt
- Bulletin:
- 16033
- Component:
- 103400 power train:automatic transmission:lever and linkage:column shift
- Summary:
- Some vehicles with electronic shift-on-the fly may exhibit an inadvertent 4x4 low engagement while driving. *tt
- Bulletin:
- 16087
- Component:
- 980000 unknown or other
- Summary:
- Some vehicles may exhibit a flashing transmission control indicator lamp (tcil) and diagnostic trouble codes p0740, p0741, p0743, and p1744 (torque converter clutch). *tt
- Bulletin:
- 15692
- Component:
- 020000 suspension
- Summary:
- Some vehicles may exhibit a squeak, snap, rattle, or clunk in the front end when turning or going over bumps. *tt
- Bulletin:
- 15707
- Component:
- 075000 fuel system, gasoline:carburetor system
- Summary:
- Information on vehicle exhibiting evidence of oil in the air intake system. *tt
- Bulletin:
- 15711
- Component:
- 102000 power train:manual transmission
- Summary:
- Some vehicles equipped with a 5-speed mazda r2 manual transmission may exhibit a high effort condition when shifting any gear. *tt
- Bulletin:
- 15742
- Component:
- 070000 fuel system, gasoline
- Summary:
- Information on vehicles exhibiting a perceived poor fuel range / economy, and or a faulty fuel gauge. *tt
- Bulletin:
- 15758
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Snow packing of the air filter when driving in severe snow conditions may exhibit loss of power and / or the malfunction indicator lamp illuminating. *tt
- Bulletin:
- 020503
- Component:
- 071100 fuel system, gasoline:storage:tank assembly
- Summary:
- Guidance for cng tank inspection for vehicles produced after december 2, 1996. *tt update. *tt
- Bulletin:
- 15793
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Some vehicles may exhibit a slight oil leak at the cylinder head to block joint. *tt
- Bulletin:
- 15805
- Component:
- 220000 seats
- Summary:
- Some super crew vehicles may exhibit loose, poor fitting, or wrinkled seat cover upholstery. *tt
- Bulletin:
- 15817
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles equipped with bi-fuel (cng/lpg) alternate fuel engines may exhibit hard / no start, runs rough or misses after starting, and or hesitation on acceleration when operated in the bi-fuel mode. *tt
- Bulletin:
- 15850
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles equipped with a 4.6l romeo engine may exhibit a slight oil leak or weep at the cylinder head to block joint. *tt
- Bulletin:
- 15869
- Component:
- 101100 power train:clutch assembly:pedal/linkage
- Summary:
- Some vehicles may exhibit an intermittent soft clutch pedal which may cause difficulty in shifting gears (a notchy feel). *tt
- Bulletin:
- 15913
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles equipped with 5.4l v8 engine may exhibit air induction system conditions as well as engine hesitation / surge and / or a malfunction indicator lamp illuminated. *tt
- Bulletin:
- 15932
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles equipped with 4.2l, 4.6l and 5.4l engine may exhibit a lack of power condition. *tt
- Bulletin:
- 021003
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some bi-fuel cng vehicles may exhibit a crank no start condition while operating in alternate fuel mode with the alt fuel light on. *tt
- Bulletin:
- 02121
- Component:
- 353600 equipment:air conditioner
- Summary:
- White flakes coming from the air conditioner vents when the blower motor is engaged. *tt
- Bulletin:
- 870197
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Incorrectly installed gear driven camshaft position (cmp) sensor synchronizer assemblies causing surge, lost of power, malfunction indicator lamp on and diagnostic trouble codes p1336, p1309 and p0340. *tt
- Bulletin:
- 0361
- Component:
- 060000 engine and engine cooling
- Summary:
- Malfunction indicator lamp on with or without rough running, lack of power, surge or poor fuel economy with diagnostic trouble codes p0401, p0402, p1400, p1401. *tt *jb
- Bulletin:
- 03610
- Component:
- 017500 steering:linkages:tie rod assembly
- Summary:
- Tie rod end inspection procedure. canada vehicles only. *tt *jb
- Bulletin:
- 0342
- Component:
- 090000 fuel system, other
- Summary:
- Possible fuel leak may occur at the fuel fill valve, on some dedicated cng vehicles. *tt *jb
- Bulletin:
- 0322
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Streamlined diagnostic procedure for vehicles with malfunction indicator lamp (mil) on and diagnostic trouble codes (dtcs) p0401, p0402, p1400 or p1401, or runs rough, lacks power, surge, poor fuel economy, and the above listed dtcs without
- Bulletin:
- 0324
- Component:
- 133000 visibility:power window devices and controls
- Summary:
- Driver's side door glass that binds when operated. *tt
- Bulletin:
- 16602
- Component:
- 173100 latches/locks/linkages:tailgate:latch
- Summary:
- Locking tailgate locks itself. *tt
- Bulletin:
- 16605
- Component:
- 010000 steering
- Summary:
- Reduced power steering assist and/or power steering leaks when driven in temperatures equal to or less than -25 degrees celcius. *tt
- Bulletin:
- 030402
- Component:
- 090000 fuel system, other
- Summary:
- On some dedicated cng vehicles, a possible fuel leak may occur at the fuel fill valve. revised service parts. *tt
- Bulletin:
- 16928
- Component:
- 110000 electrical system
- Summary:
- Various intermittent electrical concerns including but not limited to some accessories remaining powered up with the key out of the ignition, multiple system warning lights with short to power or low battery voltage diagnostic trouble codes
- Bulletin:
- 16776
- Component:
- 126200 exterior lighting:turn signal:switch
- Summary:
- Servicing multifunction switch wiring interference. *tt
- Bulletin:
- 16818
- Component:
- 180000 vehicle speed control
- Summary:
- Throttle control splash shield installation requirements. *tt
- Bulletin:
- 16835
- Component:
- 173100 latches/locks/linkages:tailgate:latch
- Summary:
- Tailgate locking by itself when slammed shut or when the vehicle is being driven over rough roads. *tt
- Bulletin:
- 03102
- Component:
- 070000 fuel system, gasoline
- Summary:
- Compressed natural gas (cng). rough idle or no start when cold. vehicles equipped with cng bi-fuel engine only. *tt
- Bulletin:
- 03103
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Vehicles without the coolant lock-off may exhibit a no start condition. *tt
- Bulletin:
- 0398
- Component:
- 090000 fuel system, other
- Summary:
- Malfunction indicator lamp (mil) illumination with diagnostic trouble codes p0442, p0455, p0456, p0457, p1442 or check fuel cap lamp illuminated with diagnostic trouble code p0457. *tt
- Bulletin:
- 0399
- Component:
- 010000 steering
- Summary:
- Tie rod end inspection procedure. *tt
- Bulletin:
- 03910
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Vibration and/or rattle condition when the engine is at idle in gear or when accelerating from a slow speed (20 mph, 32 km/h). *tt
- Bulletin:
- 03164
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Some vehicles, equipped with the 4.6l 2v engine, with an engine build date prior to 8/29/03 may exhibit an engine tick noise that is present at all temperatures during idle. 2004 models included. *tt
- Bulletin:
- 17009
- Component:
- 110000 electrical system
- Summary:
- Malfunction indicator lamp (mil) illumination with no hard fault. *tt
- Bulletin:
- 17063
- Component:
- 110000 electrical system
- Summary:
- Malfunction indicator lamp (mil) on with diagnostic trouble codes (dtc) p0171, or p0174. f150 lighting and f150 harley davidson supercrew. *tt
- Bulletin:
- 17087
- Component:
- 106000 power train:axle assembly
- Summary:
- Whine/howl from rear axle 40 to 60 mph. *tt
- Bulletin:
- 031513
- Component:
- 017500 steering:linkages:tie rod assembly
- Summary:
- Tie rod end inspection procedure. *tt
- Bulletin:
- 03144
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Engine misfire or rough running condition with coil on plug (cop) ignition systems may be more accurately diagnosed using the optional worldwide diagnostic system (wds) coil on plug (cop) kit. 2003 super duty f series included. *tt
- Bulletin:
- 03148
- Component:
- 103600 power train:automatic transmission:cooling unit and lines
- Summary:
- New transmission cooler flusher - service tips. 2003 escort and super duty f series included. *tt
- Bulletin:
- 16969
- Component:
- 120000 exterior lighting
- Summary:
- Damaged rear license plate lamps due to rocks and/or gravel hitting the lamp assemblies. *tt
- Bulletin:
- 03183
- Component:
- 180000 vehicle speed control
- Summary:
- Dedicated compressed natural gas (cng) rough idle or no start when cold vehicles equipped with dedicated 4.6l or 5.4l cng engine only. *tt
- Bulletin:
- 03206
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Some dedicated cng vehicles may exhibit various driveability conditions due to a loss of injector performance, resulting from fuel quality. loss of power at heavy load, diagnostic trouble codes (dtcs) for lean fuel, rough idle, hard start,
- Bulletin:
- 03207
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- A vibration and/or rattle condition when the engine is at idle in gear or when accelerating from a slow speed 32 km/h (20 mph). *tt
- Bulletin:
- 17259
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Rough idle and/or misfire with diagnostic trouble code p0316 after an overnight soak in extreme cold and high humidity conditions. *tt
- Bulletin:
- 0416
- Component:
- 105000 power train:driveline
- Summary:
- Driveline clunking/grunting noise or shudder sensation during light to moderate accelreation and/or braking. *tt
- Bulletin:
- 03223
- Component:
- 110000 electrical system
- Summary:
- Streamlined diagnostic procedure for vehicles with malfunction indicator lamp on and diagnostic trouble codes (dtcs) p0401, p0402, p1400 or p1401. additional symptoms may include runs rough, lacks power, surge, poor fuel economy. *tt
- Bulletin:
- 0422
- Component:
- 162000 structure:body
- Summary:
- Windnoise and/or a water leak from the sliding back glass area. *tt
- Bulletin:
- 17655
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Evidence of oil in the air intake system. *tt
- Bulletin:
- 03235
- Component:
- 162000 structure:body
- Summary:
- Bed extender component replacement service tip. *tt
- Bulletin:
- 99263
- Component:
- 203000 wheels:lugs/nuts/bolts
- Summary:
- Correct lug nut torque specifications - increase wheel nut and stud size - service tip. *tt
- Bulletin:
- 17316
- Component:
- 090000 fuel system, other
- Summary:
- Fuel signal to instrument cluster service tip. *tt
- Bulletin:
- 17320
- Component:
- 063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
- Summary:
- Broken exhaust manifold studs. *tt
- Bulletin:
- 17346
- Component:
- 017300 steering:linkages:arm:idler and attachment
- Summary:
- Steering idler arm noise. *tt
- Bulletin:
- 17702
- Component:
- 106000 power train:axle assembly
- Summary:
- Axle whine 40-60 mph. *tt
- Bulletin:
- 17731
- Component:
- 015000 steering:hydraulic power assist system
- Summary:
- Whine from power steering. *tt
- Bulletin:
- 04111
- Component:
- 110000 electrical system
- Summary:
- Streamlined diagnostic procedure for vehicles with malfunction indicator lamp (mil) on and diagnostic trouble codes (dtcs) p0401, p0402, p1400 or p1401. additional symptoms may include runs rough, lacks power, surge, poor fuel economy.
- Bulletin:
- 03256
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Engine-romeo built 4.6l 2v-tick noise from engine-engines built before 9/17/2003. *mj
- Bulletin:
- 17372
- Component:
- 106000 power train:axle assembly
- Summary:
- Heritage f-150 4x2 with 8.8 inch rear axle - whine/howl noise from rear axle. *mj
- Bulletin:
- 02221
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Engine-gear driven synchronizers-incorrect installation-camshaft position synchronizer (cmp) installation tool correct application. *mj
- Bulletin:
- 02227
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Engine-cylinder head deck leak-4.6 and 5.4l engines-new service-only gasket and cylinder head kits availability. *mj
- Bulletin:
- 16416
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- No/hard start in cold ambients / new two-piece block heater cord released. *mj
- Bulletin:
- 0457
- Component:
- 130000 visibility
- Summary:
- Pop/thump noise at end of window movement and/or driver's window bounce back and reverse to mid-position. *tt
- Bulletin:
- 0483
- Component:
- 110000 electrical system
- Summary:
- Splicing new wire(s) into existing electrical harness. service procedure. *tt
- Bulletin:
- 17777
- Component:
- 022140 suspension:rear:springs:leaf spring assembly
- Summary:
- Rear leaf spring noise. *tt
- Bulletin:
- 17823
- Component:
- 015200 steering:hydraulic power assist:hose, piping, and connections
- Summary:
- Power steering leak - service tip. *tt
- Bulletin:
- 02193
- Component:
- 073000 fuel system, gasoline:fuel injection system
- Summary:
- Driveability-idle-high idle speeds-throttle sticks after steady state driving in extreme cold ambient temperatures-vehicles built through 12/31/01 equipped with 4.6l engine. *mj
- Bulletin:
- 04L19
- Component:
- 017500 steering:linkages:tie rod assembly
- Summary:
- Customer maintenance reminder - literature program 04l19 - tie rod inspection procedure. *tt
- Bulletin:
- 18217
- Component:
- 090000 fuel system, other
- Summary:
- Multiple vehicles - fuel level indication concerns - service tip. various models including 2005 super duty f-series, excursion, expedition, explorer, mountaineer and aviator. *tt
- Bulletin:
- 18250
- Component:
- 100000 power train
- Summary:
- Intermittent clunk on 3-2 downshift during coastdown/tip-in. oasis. to include 2005 f-150, e-series and expedition. *tt
- Bulletin:
- 031404
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Engine misfire or running - coil on plug (cop) ignition systems - wds cop kit diagnostic tips. to include various 2005 models. * ar this article 04161 supersedes tsb 03-14-04.
- Bulletin:
- 02215
- Component:
- 110000 electrical system
- Summary:
- Heavy static or signal loss on two way radio communication . bi fuel lpg vehicle only. *eh
- Bulletin:
- 04217
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- General power train control module (pcm) programming procedures. *tt
- Bulletin:
- 042107
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- General (pcm) power train control module programming procedures. *tt
- Bulletin:
- 042421
- Component:
- 151300 seat belts:front:retractor
- Summary:
- Safety belt retraction speed. *tt
- Bulletin:
- 04251
- Component:
- 162000 structure:body
- Summary:
- Aluminum corrosion - service tip. *tt
- Bulletin:
- 04266
- Component:
- 105000 power train:driveline
- Summary:
- A driveline clunk or bump when starting from a stop. *tt
- Bulletin:
- 18466
- Component:
- 106000 power train:axle assembly
- Summary:
- Axle whine howl. this includes 1997-05 ford vehicles. *eh
- Bulletin:
- 05417
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- Intermittent rough idle - non-commanded egr (exhaust gas recirculation valve) flow. *tt
- Bulletin:
- 0554
- Component:
- 063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
- Summary:
- Use of stainless steel exhaust studs in service for 5.4l 2v engine. *tt
- Bulletin:
- 050618
- Component:
- 022000 suspension:rear
- Summary:
- Rear axle noise repair. *sc
- Bulletin:
- 05618
- Component:
- 106000 power train:axle assembly
- Summary:
- Rear axle noise repair. *tt
- Bulletin:
- 05173
- Component:
- 060000 engine and engine cooling
- Summary:
- Malfunction indicator lamp on with diagnostic trouble code p1131 and/or p1151 - 4.2l engine. *tt
- Bulletin:
- 041601
- Component:
- 060000 engine and engine cooling
- Summary:
- Wds cop kit diagnostic tip - coil on plug (cop) ignition systems - engine misfire or rough running. *tt
- Bulletin:
- 07212
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Some 1997-2008 vehicles equipped with a 4.6l 2v, 5.4l 2v, or 6.8l 2v engine--spark plug thread repair procedure--not covered under new vehicle limited warranty. *nj this includes f-53 motorhome chassis. updated 2/23/10. *pe
- Bulletin:
- 20228
- Component:
- 061320 engine and engine cooling:engine:other fuel types:turbo-charger
- Summary:
- 1999-2008 7.3l/6.0l/6.4l/4.5l diesel f-super duty - clean the charge air cooler (cac) system after certain turbo or engine failures - service tip. *nj
- Bulletin:
- CSP-08B01
- Component:
- 063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
- Summary:
- Ford: certain 1999-2001 model year vehicles up to 6000 lb gvwr registered in new york and certain 2001 vehicles up to 6000 lb gvwr registered in the state of maine, certified for sale in california-federal emission warranty refund. *pe
- Bulletin:
- TSB-14-0147
- Component:
- 071100 fuel system, gasoline:storage:tank assembly
- Summary:
- Ford/lincoln: safety recall issued due to one or both fuel tank straps fracturing due to being in high corrosion areas for an extended period and dislodging fuel tank. model 1997-99 f250, 1997-03 f150, 2004 f150 heritage, 2002-2003 blackw
- Bulletin:
- TSB-14-0164
- Component:
- 071100 fuel system, gasoline:storage:tank assembly
- Summary:
- Ford/lincoln: safety recall regarding high corrosion areas for operating, for an extended time, vehicles where both or one strap of fuel tank can fracture, after contacting ground. model 1997-99 f250 ld, 1997-03 f150, 2004 f150 heritage,
Home | Privacy