1999 VOLKSWAGEN PASSAT Recalls (6)
- Campaign:
- 99V248000 on 09/27/1999
- Component:
- Steering:linkages:rod:relay:connecting
- Manufactured:
- 01/01/1998 - 07/30/1998
- Affected:
- 51,900
- Defect:
- Vehicle description: passenger vehicles. the tie rods of the steering assembly are protected on each side by a seal to prevent moisture and dust particles from entering the swivel bearing mechanism. it is possible that some tie rod seals may not seal properly.
- Consequence:
- If moisture and/or dust particles enter the swivel bearing mechanism, the swivel bearing could wear over time diminishing the steering control of the vehicle.
- Correction:
- Dealers will replace the tie rods.
- Notes:
- Vw recall no. ul/audi recall no. kw. owner notification began october 5, 1999. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact volkswagen at 1-800-822-8987 or audi at 1-800-822-2834.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 99V131001 on 01/20/2000
- Component:
- Service brakes, hydraulic:power assist:vacuum:hoses, lines/piping, and fittings
- Manufactured:
- 09/30/1997 - 02/27/1999
- Affected:
- 88,121
- Defect:
- Vehicle description: passenger vehicles equipped with automatic transmissions. a control valve in the vacuum hose connecting the brake booster to the intake manifold may not open or close fully at temperatures below -4 f under certain driving conditions.
- Consequence:
- This condition could cause insufficient vacuum to be provided to the brake booster.
- Correction:
- Dealers will install a vacuum by-pass system into vehicles operated in these states which is designed to provide sufficient vacuum for full brake assist under all weather conditions.
- Notes:
- Owner notification began october 9, 1999.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact vw at 1-800-822-8987 or audi at 1-800-822-2834.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 00V414000 on 12/11/2000
- Component:
- Steering:linkages:rod:relay:connecting
- Manufactured:
- 07/31/1998 - 04/29/1999
- Affected:
- 83,000
- Defect:
- Vehicle description: passenger vehicles. the tie rods of the steering assembly are protected on each side by a seal to prevent moisture and dust particles from entering the swivel bearing mechanism. it is possible that some tie rod seals may not seal properly.
- Consequence:
- If moisture and/or dust particles enter the swivel bearing mechanism, the swivel bearing could wear over time diminishing the steering control of the vehicle.
- Correction:
- Dealers will replace the tie rods.
- Notes:
- Owner notification began february 5, 2001.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact volkswagen at 1-800-822-8987 or audi at 1-800-822-2834.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 02V026000 on 01/25/2002
- Component:
- Fuel system, gasoline:storage:tank assembly:filler pipe and cap
- Manufactured:
- 03/31/1997 - 08/30/2002
- Affected:
- 487,284
- Defect:
- On some passenger vehicles, the fuel tank filler neck can suffer abrasion damage if the rear tire goes flat and the vehicle is driven until the tire disintegrates.
- Consequence:
- Fuel leakage can occur increasing the risk of a fire.
- Correction:
- Dealers will fit passat vehicles with a new wheel house liner that will better protect the car's filler neck. jetta vehicles will be fitted with a different metal shield designed to enhance abrasion protection in the event of tire disintegration. owner notification began june 13, 2003. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact volkswagen at 1-800-822-8987.
- Notes:
- Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 08V156000 on 04/06/2008
- Component:
- Fuel system, gasoline:delivery
- Manufactured:
- 05/31/1999 - 05/30/2005
- Affected:
- 412,000
- Defect:
- Volkswagen is recalling 412,000 my 1999-2005 passat (5th generation) vehicles equipped with automatic transmissions and produced after june 14, 1999. these vehicles may have an underbody heat shield that can become damaged. in addition, affected vehicles with automatic or manual transmissions may have a fuel line (1.8t engines only) or fuel tank ventilation valve (4motion/all wheel drive only) that can leak due to fracture.
- Consequence:
- a heat shield that may contact the exhaust system can result in a vehicle fire. in addition, a fuel leak from a fuel line or fuel tank ventilation valve, in the presence of an ignition source, can lead to a vehicle fire.
- Correction:
- Dealers will install additional underbody heat shields on vehicles with automatic transmissions to cover the possibly damaged areas and flash all 1.8t engines with a precautionary software update. dealers will also inspect and adjust the fuel line routing on 1.8t vehicles and the fuel tank ventilation valve on 4motion/all wheel drive vehicles, and replace components if necessary free of charge. the recall began on june 13, 2008. owners may contact volkswagen at 1-800-822-8987.
- Notes:
- Vwoa recall no. 26e5/r5.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 09E025000 on 05/10/2009
- Component:
- Exterior lighting:headlights
- Affected:
- 42,540
- Defect:
- Dope, inc. is recalling 42,540 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
- Consequence:
- Decreased lighting visibility may result in a vehicle crash.
- Correction:
- Dope, inc. will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on july 28, 2009. owners may contact dope, inc. at 1-626-272-1798.
- Notes:
- This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by dope, inc.the list can be found under "document search" located at the bottom of your screen. owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
1999 VOLKSWAGEN PASSAT TSBs (70)
- Bulletin:
- 9903
- Component:
- 136000 visibility:windshield wiper/washer
- Summary:
- Concerns with intermittent windshield wiper, wipes across windshield once then stops. *tt
- Bulletin:
- 9907
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Subject regaring engine misfire. *tt
- Bulletin:
- 9902
- Component:
- 131000 visibility:windshield
- Summary:
- Important information regarding new vehicle windshield, rear and side glass, scratch, stress crack and distortion survey form. *tt
- Bulletin:
- 9903
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Subject regarding engine oil capacities. *tt
- Bulletin:
- 9907
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Conditions with poor am reception. *tt
- Bulletin:
- 9901
- Component:
- 061120 engine and engine cooling:engine:gasoline:turbo-charger
- Summary:
- Subject regarding vehicle's exhibiting failure of the turbocharger due to lack of lubrication on passat with 1.8l 5v turbo vehicles from 1998-1999 up to vin #xe000100. *ms
- Bulletin:
- 9903
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Information on radio serial number/code, sticker location on vehicle's begining with vin #'s: golf/ jetta (1999, 2000, 1h_xm215697), new golf/ new jetta (1999,2000 all), new beetle (1999-2000-1c_wm024452), cabrio (1999-2000- 1 h _xm215697),
- Bulletin:
- 9904
- Component:
- 134000 visibility:sun roof assembly
- Summary:
- Subject pertaining to the sunroof sliding headliner, replacing slides. *tt
- Bulletin:
- 0004
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding front floor mat fastener damage. *tt
- Bulletin:
- 0101
- Component:
- 220000 seats
- Summary:
- Subject regarding latch system lower anchors and tethers for children, installing / retrofitting. *tt
- Bulletin:
- 400101
- Component:
- 020000 suspension
- Summary:
- A condition may exist with noise from the front suspension. *tt
- Bulletin:
- 900101
- Component:
- 114200 electrical system:wiring:interior/under dash
- Summary:
- Subject regarding malfunctioning instrument cluster. *tt
- Bulletin:
- 0103
- Component:
- 114200 electrical system:wiring:interior/under dash
- Summary:
- Some vehicles may experience instrument cluster malfunction. *slc
- Bulletin:
- 092603
- Component:
- 015100 steering:hydraulic power assist:pump
- Summary:
- Zf vh recall of the zf steering pump, supplied to wd's for replacement of the audi a4 passat p/n 8d0 145 156fx instead of the correct zf p/n 7691 955 276zw. 2004 audi a4 also included. *tt
- Bulletin:
- 0409
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Evaluating fuel mixture diagnostic trouble codes- how to perform effective diagnosis related to fuel system adaptation - system too rich/too lean. volkswagen. *mj
- Bulletin:
- 0421
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Warranty extension covering certain oil sludge related repairs. *tt
- Bulletin:
- 0421
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Oil sludge - warranty extension for 1998-2004 model year volkswagen passat with 1.8l turbo engine us and canadian dealers. service circular. *tt
- Bulletin:
- 0401
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Engine oil specifications, oil capacity, oil filter. *tt
- Bulletin:
- 0402
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Low engine oil pressure light is on. *tt
- Bulletin:
- 0403
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Valve cover, diagnosing oil leakage from gaskets. *tt
- Bulletin:
- 004
- Component:
- 060000 engine and engine cooling
- Summary:
- Engine coolant temperature (ect) sensor. *tc
- Bulletin:
- VM
- Component:
- 021530 suspension:front:control arm:lower arm
- Summary:
- Check/replace front suspension lower control arms. *tc this supercedes the vm service action dated november 2004. *tt
- Bulletin:
- 0502
- Component:
- 110000 electrical system
- Summary:
- Diagnostic trouble code (dtc) p1603 (18011) stored in dtc memory. *tt
- Bulletin:
- 0517
- Component:
- 036100 service brakes, hydraulic:antilock:control unit/module
- Summary:
- Anti-lock brake system (abs) control module warranty repair process. *tt
- Bulletin:
- 010702
- Component:
- 062300 engine and engine cooling:cooling system:hose
- Summary:
- Dtc's p1297 (17705) or p1557 (17965) stored in dtc memory. this may be caused by intake hoses leaking (during boost conditions) due to incorrect torque on clamps or improper placement, worn or torn intake hoses. *kb
- Bulletin:
- 2013233
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Engine oil pressure too low, light is on, engine flush. *kb
- Bulletin:
- 2002419
- Component:
- 136000 visibility:windshield wiper/washer
- Summary:
- Intermittent windshield wiper, wipes across windshield once then stops. *kb
- Bulletin:
- 10172008
- Component:
- 061120 engine and engine cooling:engine:gasoline:turbo-charger
- Summary:
- Volkswagen service campaign: see document search button for owner letter. internal engine damage resulting from a broken timing belt. *pe
- Bulletin:
- 2015831
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Volkswagen: exhaust heat shield, replacement guidelines. heat shields are to be inspected after completion o any type of repair to the underbody (exhaust system transmission, etc.), and if damaged, replaced. *pe
- Bulletin:
- TB-07-09-06
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Volkswagen: engine oil pressure too low, light is on, engine flush. the low engine oil pressure condition may be caused by a restriction of the oil pump suction line strainer. *pe
- Bulletin:
- TT-45-06-54
- Component:
- 046100 service brakes, air:antilock:control unit/module
- Summary:
- Volkswagen: update to information. providing correct coding values for abs control modules on certain vehicles without can-bus. models 1998-2002 passat. *pe
- Bulletin:
- 2038999
- Component:
- 162000 structure:body
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TT45-06-54
- Component:
- 030000 brakes (pws)
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- TT 90-12-06
- Component:
- 091200 fuel system, other:storage:fuel gauge system
- Summary:
- Summary to be provided on a future date.
- Bulletin:
- V551613_2039446
- Component:
- 162000 structure:body
- Summary:
- To update model table to clarify jetta wagon applicability to tb content.
- Bulletin:
- V941403 2011521
- Component:
- 120000 exterior lighting
- Summary:
- Technical bulletin (exterior lights, moisture accumulation): this document informs of the condensation and or water droplets visible on inside of exterior light lenses. the document also informs how to service the issue.
- Bulletin:
- V871409 2019947
- Component:
- 353600 equipment:air conditioner
- Summary:
- Technical bulletin (air conditioning, cleaning of the refrigerant circuit): in cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or component is circ
- Bulletin:
- V171404 2012855
- Component:
- 060000 engine (pws)
- Summary:
- Technical bulletin (engine oils which meet volkswagen oil quality standard): this document informs of a sample list of products generally available in the north american market that meet the volkswagen oil quality standard
- Bulletin:
- V551603 2039446
- Component:
- 356000 equipment adaptive
- Summary:
- Document discusses corrosion that may be found on the folded edge of the hood. the corrosion may be found on this edge anywhere around the hood. it discusses how to service it, and document that service. it discusses where to find what appl
- Bulletin:
- V531601 2040536
- Component:
- 162200 structure:body:bumpers
- Summary:
- The document refers to corrosion being found where the rear bumper cover meets the quarter panel. it discusses how it can happen, and where to find warranty coverage to service the parts
- Bulletin:
- V271501 2011894
- Component:
- 111000 electrical system:battery
- Summary:
- Technical bulletin: battery, testing and charging using midtronics vas6161, mcr340v, incharge 940, or grx3000vas charger
- Bulletin:
- V941501 2011521
- Component:
- 120000 exterior lighting
- Summary:
- Technical bulletin: condensation and or water droplets becomming visible on inside of exterior light lenses issue is discussed in this document
- Bulletin:
- V641501 2039887
- Component:
- 162300 structure:body:door
- Summary:
- Technical bulletin (rear door glass inoperative issue diagnosis): the rear glass cannot be opened / closed, the rear glass may slide down into the door, or the rear glass motor operates but the glass does not move
- Bulletin:
- TT 64-14-02
- Component:
- 138200 visibility:defroster/defogger system:rear window
- Summary:
- Tech tips (heated rear window, one or more lines inoperative): to detect which line(s) is inoperative, utilize a volt meter to check for 0 v, which will be present after the open in the grid line. this document informs of how to diagnose t
- Bulletin:
- On-Car Analysis
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- On-car analysis list of customer complaints: mil?on with fault code p046c, untouched vehicles
- Bulletin:
- On-Car Analysis
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- On-car analysis list of customer complaints: mil?on with fault code p046c, untouched vehicles
- Bulletin:
- V641502 2039887
- Component:
- 132000 visibility:glass, side/rear
- Summary:
- Technical bulletin (rear door glass inoperative): the rear glass cannot be opened / closed, the rear glass may slide down into the door, or the rear glass motor operates but the glass does not move. this document contains the fault codes,
- Bulletin:
- TT 64-14-02
- Component:
- 110000 electrical system
- Summary:
- Tech tips (heated rear window, one or more lines inoperative): to detect which line(s) is inoperative, utilize a volt meter to check for 0 v, which will be present after the open in the grid line. the check must be performed with the engin
- Bulletin:
- V921502 2026253
- Component:
- 130000 visibility
- Summary:
- Technical bulletin (windshield wipers streak or smear): windshield or rear window is streaked, has a snakeskin appearance, or the surface feels rough. to avoid unnecessary replacement of wiper blades, the condition and cleanliness of the w
- Bulletin:
- V871506 2019947
- Component:
- 060000 engine and engine cooling
- Summary:
- Technical bulletin (air conditioning, cleaning of the refrigerant circuit (u.s.only)): in cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or compon
- Bulletin:
- V941402 2011521
- Component:
- 121000 exterior lighting:headlights
- Summary:
- Technical bulletin (exterior lights, moisture accumulation): exterior light assemblies (headlights, taillights, fog lights, turn signals) are vented and may collect moisture on their inner surfaces, depending on humidity and other climatic
- Bulletin:
- V001404 2010380
- Component:
- 350000 equipment
- Summary:
- Technical bulletin (squeaks, rattles, noise, repair materials): this doucment contains a list of components and applications developed to repair concerns of squeaks, rattles, noise and trim fit conditions.
- Bulletin:
- TT 24-08-01
- Component:
- 060000 engine (pws)
- Summary:
- Tech tips (models with 1.8t engine - pressure loss issues): fault code p1297 may be set and fuel mixtures may go lean if the vehicle is driven under load or revved up and then returned to idle. this document informs of what to do should th
- Bulletin:
- 561 065 760 A as
- Component:
- 110000 electrical system
- Summary:
- Assembly instructions: installation of original remote start feature accessory, volkswagen passat.
- Bulletin:
- TT 200901
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Update to existing tip for fuel quality checking.
- Bulletin:
- PDI - PASSAT TEC
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Passat perfect delivery inspection (pdi) - technician and detailer inspections: a checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has purc
- Bulletin:
- PDI - PASSAT TEC
- Component:
- 350000 equipment
- Summary:
- Passat perfect delivery inspection (pdi) - technician and detailer inspections: a checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has purc
- Bulletin:
- V691601 2010479
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Update model year applicability to include 2017.
- Bulletin:
- V871622 2019947
- Component:
- 353600 equipment:air conditioner
- Summary:
- Update to model year applicability.
- Bulletin:
- TT 97-12-02
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- data link connector pin assignment chart that is applicable to all models. update model year applicability.
- Bulletin:
- 1-2017 Update
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This communication is to update our profi dealers of the current status of the latest inbound and outbound profi requests.
- Bulletin:
- Elsa 6-22-15
- Component:
- 350000 equipment
- Summary:
- This document contains the vw elsa newsletter that contains a general overview of wiring diagrams updates, elsapro infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, tech
- Bulletin:
- Elsa 6-29-15
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- This document contains the vw elsa newsletter that contains a general overview of wiring diagrams updates, technical bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions.
- Bulletin:
- V551608-2038999
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- To update claim process statement.
- Bulletin:
- V551612-2039446
- Component:
- 162800 structure:body:hood
- Summary:
- Corrosion may be found on the folded edge of the hood. supersedes tb v551603
- Bulletin:
- V531602-2040536
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- To update claim processing statement.
- Bulletin:
- V171701 2012855
- Component:
- 060000 engine and engine cooling
- Summary:
- 17 17 01 july 5, 2017 2012855 supersedes technical bulletin 17-16-02 (v171602) dated april 29, 2016 due to updated oil standards lists to current specifications. engine oils which meet volkswagen oil quality standards
- Bulletin:
- TT001703
- Component:
- 118000 electrical system: software
- Summary:
- Tip for scan tool concerns that may occur duing a test plan
- Bulletin:
- On-car Analysis
- Component:
- 353000 equipment:electrical
- Summary:
- On-car analysis list of customer complaints: mil?on with fault code p046c, untouched vehicles
- Bulletin:
- On-car Analysis
- Component:
- 353000 equipment:electrical
- Summary:
- On-car analysis list of customer complaint: mil?on with fault code p046c, untouched vehicles
Home | Privacy