1999 NEOPLAN AN460 Recalls (4)
- Campaign:
- 99V027001 on 02/25/1999
- Component:
- Suspension
- Manufactured:
- 11/30/1998 - 02/27/1999
- Affected:
- 238
- Defect:
- Vehicle description: articulated transit buses. the rear section of the bus could become unstable at high speed if electric power is lost to the electronic control unit for the articulated stabilization system.
- Consequence:
- Loss of vehicle control could occur, increasing the risk of a crash.
- Correction:
- Dealers will install an additional hydraulic safety-dampening unit to the bus articulation hydraulic system.
- Notes:
- Owner notification began february 2, 1999.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact neoplan at 1-719-336-3256.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 99V242003 on 05/02/2000
- Component:
- Unknown or other
- Manufactured:
- 11/30/1998 - 01/30/1999
- Affected:
- 319
- Defect:
- Vehicle description: transit buses. failure of a soft seat check valve in wheelchair lifts provided by lift-u, may allow the front and rear platform barriers to return to a horizontal position from the vertical position they are supposed to be locked in.
- Consequence:
- This could allow a mobility aid to roll off of the lift platform injuring its occupant. lift-u will replace the soft seat check valves.
- Correction:
- Lift-u will replace the soft seat check valves.
- Notes:
- Owner notification is being handled by lift-u. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact lift-u at 1-209-838-2400 or neoplan at 1-719-336-3256. also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 01V033007 on 07/31/2001
- Component:
- Electrical system:battery
- Manufactured:
- 01/31/1999 - 12/30/2000
- Affected:
- 669
- Defect:
- Vehicle description: transit buses equipped with vanner 60 series battery equalizers. the equalizer could fail to operate properly and cause malfunction of the battery charging system.
- Consequence:
- Without fusing, the equalizer may melt, burn, or smoke, possibly resulting in a fire or a smoke filled bus, thus necessitating a passenger evacuation of the bus. the failure mode can cause operator distraction, and/or possible personal injury.
- Correction:
- Dealers will inspect the buses for certain equalizers by the date code. the affected equalizers will be replaced by vanner. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact vanner at 1-800-227-6937 or neoplan at 1-719-336-3256.
- Notes:
- Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 05V290000 on 06/20/2005
- Component:
- Engine and engine cooling:engine:other fuel types:turbo-charger
- Manufactured:
- 11/30/1998 - 04/29/1999
- Affected:
- 465
- Defect:
- On certain standard floor, low floor and articulated transit buses built with detroit diesel series 50 engines, the turbocharger compressor wheel can break, resulting in shaft imbalance and lubricating oil passes into the exhaust system.
- Consequence:
- This can result in an engine compartment fire, possibly resulting in personal injuries.
- Correction:
- Neoplan is working with detroit diesel to notify owners and have the repair performed on their vehicles. dealers will install an exhaust temperature sensor and reprogram the emc calibration. owners may contact neoplan at 719-336-3256 or detroit diesel at 313-592-3708.
- Notes:
- Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
Home | Privacy