1999 FORD F-150 Recalls (18)
- Campaign:
- 98V192000 on 08/26/1998
- Component:
- Vehicle speed control:cables
- Manufactured:
- 06/07/1998 - 08/04/1998
- Affected:
- 1,500
- Defect:
- Vehicle description: light duty pickup trucks. a speed control cable may not have fully seated into the accelerator bracket at time of installation. if the cable is not fully seated into this bracket, the cable could separate from the bracket.
- Consequence:
- A loose cable can result in the throttle not fully returning to idle and cause an increase in stopping distance.
- Correction:
- Dealers will add a retaining clip to the speed control cable fitting at the accelerator bracket.
- Notes:
- Ford is notifying dealers on or about august 11, 1998.these vehicles have not yet been released for sale to the public.
- Campaign:
- 98V194000 on 08/27/1998
- Component:
- Fuel system, gasoline:fuel injection system
- Manufactured:
- 03/22/1998 - 08/03/1998
- Affected:
- 1,700
- Defect:
- Vehicle description: light duty pickup trucks. the fuel pressure regulator o-ring may have been damaged when the fuel pressure regulator was installed in the engine fuel rail. if the o-ring is damaged, fuel vapor or leakage could occur.
- Consequence:
- If an ignition source is present, a fire could result.
- Correction:
- Dealers will replace the fuel pressure regulator.
- Notes:
- No owner notification is required at this time.all vehicles are still in dealer's possession.
- Campaign:
- 99V039000 on 03/01/1999
- Component:
- Equipment:other:labels
- Manufactured:
- 08/02/1998 - 02/08/1999
- Affected:
- 32,240
- Defect:
- Vehicle description: 4x4 vehicles with off road and high fgawr option packages, and 4x2 vehicles with sport option package. the tire and rim identification information is incorrect on the certification labels for these vehicles. this does not meet the requirements of fmvss no. 120, "tire selection and rims for motor vehicles other than passenger cars."
- Consequence:
- If incorrect tire information is given, underrated tires could be placed on the truck causing excessive tire wear or, in extreme cases, possible tire blowouts.
- Correction:
- Owners will be provided with a revised label overlay.
- Notes:
- Owner notification began june 9, 1999.owners who do not receive the free revised label within a reasonable time should contact ford at 1-800-392-3673.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 00V284000 on 09/21/2000
- Component:
- Equipment:other:labels
- Manufactured:
- 03/30/1998 - 09/19/2000
- Affected:
- 4,500
- Defect:
- Vehicle description: bi-fuel cng pickup trucks and bi-fuel cng vans, modified by cfi control systems, inc., fail to conform to the requirements of fmvss no. 303, "fuel system integrity of compressed natural gas vehicles." the label affixed to the fuel filler door by the vehicle modifier contains the inspection date and expiration date of the cng tank. however, it does not contain the statement "see instructions on the fuel container for inspection and service life."
- Consequence:
- These vehicles do not comply with the requirements.
- Correction:
- Owners will be provided a label with the required statement, along with instructions for affixing the label at the fuel filler door. owner notification began november 2, 2000. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.
- Notes:
- Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 02V008000 on 01/10/2002
- Component:
- Equipment:other:labels
- Manufactured:
- 08/03/1998 - 08/11/1999
- Affected:
- 393
- Defect:
- Certain light duty pickup trucks equipped with a heavy duty service package fail to comply with the requirements of fmvss no. 120, "tire selection and rims for motor vehicles other than passenger cars." a typographical error occurred resulting in an incorrect tire size and pressure on the safety certification label for these vehicles.
- Consequence:
- If the tires are inflated to the pressure indicated on the label, the customer will experience a harsher ride.
- Correction:
- Owners will be sent a corrected tire information label and installation instructions. the customer may also have the dealer install the label on the vehicle, if they so desire. owner notification began december 20, 2001. owners who do not receive the free label and installation instructions within a reasonable time should contact ford at 1-866-436-7332.
- Notes:
- Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 05V388000 on 09/06/2005
- Component:
- Vehicle speed control
- Affected:
- 4,500,000
- Defect:
- On certain pickup trucks and sport utility vehicles equipped with speed control, the speed control deactivation switch may overheat, smoke, or burn.
- Consequence:
- A fire at the switch could occur.
- Correction:
- By letter dated september 12, 2005, owners were instructed to return their vehicles to their dealers to have the speed control deactivation switch disconnected. owners who have had their speed control deactivated are being notified that parts will be available and advised to make an appointment to reconnect the speed control beginning in february 2006. owners who did not have their speed control deactivated are being notified to have their system remedied beginning in february 2006. owners are urged to avail themselves of the free disconnect service as soon as possible because of the significant risk of fire. owners may contact ford at 1-800-392-3673. (note: also see recalls 05v017 and 06v286)
- Notes:
- Ford recall no. 05s28.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
- Campaign:
- 06E023000 on 03/13/2006
- Component:
- Exterior lighting:headlights
- Affected:
- 292,000
- Defect:
- Certain anzo combination headlamp assemblies sold as replacement lamps for use on certain passenger vehicles. some combination lamps are not equipped with amber side reflectors which fail to conform to federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment."
- Consequence:
- Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash.
- Correction:
- Anzo will notify owners and replace the headlamps free of charge. the recall began may 9, 2006. owners may contact anzo usa at 909-468-3688.
- Notes:
- This recall only pertains to aftermarket headlamp assemblies manufactured by anzo and has no relation to any original equipment installed on the listed passenger vehicles.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 06E052000 on 06/11/2006
- Component:
- Exterior lighting:headlights
- Affected:
- 14,616
- Defect:
- Certain eagle eyes headlamps, p/nos. fr208-b101r, fr208-b101l, fr208-b001r, and fr208-b001l, sold for use as replacement equipment for the passenger vehicles listed above. these headlamps fail to conform to the photometric requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
- Consequence:
- Decreased lighting visibility may result in a vehicle crash.
- Correction:
- Sabry lee will notify owners and offer full credit for any noncompliant headlamp. the recall is expected to begin on june 14, 2006. owners may contact sabry lee account executive at 1-866-467-2279.
- Notes:
- This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles manufactured by the ford motor company.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 06E056000 on 06/22/2006
- Component:
- Fuel system, gasoline
- Affected:
- 58,640
- Defect:
- Certain aftermarket fuel filters sold under the purolator brand name, p/n f65277, shipped from january 16 through june 2, 2006, for use on the above listed passenger vehicles. due to incorrect design, the quick connectors may not fully seat with the tube interface, even though the person making the connection may believe that the quick connector is fully attached.
- Consequence:
- Failure of this connection could lead to fuel spillage and, in the presence of an ignition source, a fire could occur.
- Correction:
- Ufi will notify owners and replace the filters free of charge. the recall began on august 4, 2006. owners may contact ufi filters usa at 800-230-5876.
- Notes:
- This recall only pertains to ufi filters usa (purolator) aftermarket fuel filters and has no relation to any original equipment installed on the listed passenger vehicles.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 06E060000 on 06/28/2006
- Component:
- Exterior lighting
- Affected:
- 87,745
- Defect:
- Certain aai motorsports combination lamps sold as replacement lamps for use on the above list passenger vehicles. combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment."
- Consequence:
- Lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash
- Correction:
- Aai motorsports will notify owners and replace the lamps free of charge. the recall began on august 1, 2006. owners may contact aai motorsports at 909-923-9188.
- Notes:
- This recall only pertains to aai motorsports aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 06E065000 on 07/16/2006
- Component:
- Exterior lighting
- Affected:
- 3,593
- Defect:
- Certain aj motorsport combination lamps sold as replacement lamps for use on the above listed passenger vehicles. combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
- Consequence:
- Lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash.
- Correction:
- Aj motorsport will notify owners and offer reimbursement for the lamps. the recall began on july 31, 2006. owners may contact aj motorsport at 626-618-2026.
- Notes:
- This recall only pertains to aj motorsport aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 06E064000 on 07/16/2006
- Component:
- Exterior lighting
- Affected:
- 4,029
- Defect:
- Certain tradesonic combination lamps sold as replacement lamps for use on the above listed passenger vehicles. combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
- Consequence:
- Lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash.
- Correction:
- Tradesonic will notify owners and replace the lamps free of charge. the recall is expected to begin during july 2006. owners may contact tradesonic at 626-934-8884.
- Notes:
- This recall only pertains to tradesonic aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 06E067000 on 07/31/2006
- Component:
- Exterior lighting:headlights
- Affected:
- 19,413
- Defect:
- Certain maxzone headlight assemblies, depo brand, p/nos. 331-1129l-asn and 331-1129r-asn, sold for use as aftermarket equipment for the above listed passenger vehicles. these headlamps fail to conform to the photometric requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
- Consequence:
- Decreased lighting visibility may result in a vehicle crash.
- Correction:
- Maxzone will notify owners and offer reimbursement for any noncompliant headlights. the recall began on july 28, 2006. owners may contact maxzone at 909-822-3288.
- Notes:
- This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles manufactured by ford motor company.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 07E066000 on 08/28/2007
- Component:
- Equipment:electrical
- Affected:
- 175
- Defect:
- Certain cequent 90 degree 7-way right angle adaptors sold by distributors in tow packages for aftermarket sales to tow 5th wheel rv travel trailers. due to incorrect wiring of the harness, the trailer lights may not operate properly.
- Consequence:
- If the trailer lights are not working properly, a vehicle crash can occur.
- Correction:
- All of the defective tow packages are still at the distributor level and have not been sold to any consumers.
- Notes:
- This recall only pertains to aftermarket cequent tow packages and has no relation to any original equipment installed on daimlerchrysler, gmc, or ford vehicles.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 08E050000 on 08/13/2008
- Component:
- Exterior lighting:headlights
- Affected:
- 1,921
- Defect:
- K2 motor is recalling 1,921 aftermarket headlamps of various models sold for use on the above listed vehicles. these headlamps are missing the amber side reflex reflector which fails to conform with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment."
- Consequence:
- Without the amber side reflex reflectors, the lighting visibility may be affected, possibly resulting in a vehicle crash.
- Correction:
- K2 motor will notify owners and offer a full refund. the recall began on decemeber 17, 2008. owners may contact k2 motor at 1-909-839-2992.
- Notes:
- This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles manufactured by honda, ford, or chrysler llc. customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 09E012000 on 04/06/2009
- Component:
- Exterior lighting
- Affected:
- 16,270
- Defect:
- Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
- Consequence:
- Decreased lighting visibility may result in a vehicle crash.
- Correction:
- Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on may 11, 2009. owners may contact sabersport at 1-909-598-7589.
- Notes:
- This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by sabersport.the list can be found under "document search" located at the bottom of your screen.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
- Campaign:
- 09E025000 on 05/10/2009
- Component:
- Exterior lighting:headlights
- Affected:
- 42,540
- Defect:
- Dope, inc. is recalling 42,540 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
- Consequence:
- Decreased lighting visibility may result in a vehicle crash.
- Correction:
- Dope, inc. will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on july 28, 2009. owners may contact dope, inc. at 1-626-272-1798.
- Notes:
- This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by dope, inc.the list can be found under "document search" located at the bottom of your screen. owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
- Campaign:
- 11V385000 on 07/31/2011
- Component:
- Fuel system, gasoline:storage:tank assembly:mounting
- Manufactured:
- 06/19/1995 - 08/03/2004
- Affected:
- 1,100,000
- Defect:
- Ford is recalling certain 1997 through 2003 model year ford f-150, 2004 model year ford f-150 heritage, 1997 through 1999 model year f-250 less than 8,500 lbs. gross vehicle weight rating (gvwr), and 2002 and 2003 lincoln blackwood vehicles manufactured from june 20, 1995, through august 4, 2004, originally sold, or currently registered in, connecticut, delaware, illinois, indiana, iowa, kentucky, maine, maryland, massachusetts, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, west virginia, wisconsin, and the district of columbia. prolonged exposure to road deicing chemicals may cause severe corrosion of the fuel tank straps which secure the tank to the vehicle.
- Consequence:
- As a result of the corrosion, one or both straps may fail allowing the fuel lines to separate from the tank, or in some cases, causing the tank to contact the ground. either scenario may result in a fuel leak presenting a fire hazard.
- Correction:
- Ford will notify owners and instruct them to take their vehicles to a ford or lincoln dealer to have the fuel tank straps replaced with straps that have increased corrosion protection. early in this campaign, if replacement straps are not available, dealers may install a cable support under the strap as an interim repair or a steel reinforcement over the existing strap as a permanent repair. any repairs will be performed free of charge. the safety recall began on september 16, 2011. owners may contact ford motor company customer relationship center at 1-866-436-7332. ford's recall campaign number is 11s21
- Notes:
- Ford's recall campaign number is 11s21.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
1999 FORD F-150 TSBs (292)
- Bulletin:
- 98259
- Component:
- 980000 unknown or other
- Summary:
- Some vinyl covered items such as dash panels, door trim panels, consoles, etc., may exhibit a small dent, scuff, abrasion and/ or discoloration resulting from assembly, transit, dealer prep and/or customer usage. *yc
- Bulletin:
- 982010
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Experiencing a " buzzing " or " rattling " noise from the exhaust system. *yc
- Bulletin:
- 98246
- Component:
- 110000 electrical system
- Summary:
- Ford motor company has released a new electrical grease ( f8az - 19g208-aa ) to reduce the possibility of moisture corrosion at the terminals. *yc
- Bulletin:
- 9943
- Component:
- 100000 power train
- Summary:
- Information regarding reprogramming powertrain control modules (pcms). *tt
- Bulletin:
- 99411
- Component:
- 030000 service brakes, hydraulic
- Summary:
- Vehicles experiencing increased brake pedal effort and / or false abs cycling at low speeds, or abs lamp illumination. *tt
- Bulletin:
- 9946
- Component:
- 103000 power train:automatic transmission
- Summary:
- Concerns with transmission fluid leaking at radiator. *tt
- Bulletin:
- 5856
- Component:
- 116300 electrical system:ignition:anti-theft controller
- Summary:
- Information on diagnosing passive anti-theft system (pats) issues. *tt
- Bulletin:
- 5955
- Component:
- 105500 power train:driveline:differential unit
- Summary:
- Subject regarding front differential noise investigation. *tt
- Bulletin:
- 12591
- Component:
- 103600 power train:automatic transmission:cooling unit and lines
- Summary:
- Some vehicles equipped with the 5.4l engine, 4r100 transmission an auxiliary transmission oil cooler may exhibit a coastdown moaning noise. *tt
- Bulletin:
- 12601
- Component:
- 162000 structure:body
- Summary:
- Experiencing whistling noise coming from the front of the vehicle at highway speeds. *tt
- Bulletin:
- 99812
- Component:
- 162000 structure:body
- Summary:
- Concerns with the storage bin inside the console may fall down inside the console basecd on some vehicles. *tt
- Bulletin:
- 99816
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Ford motor company now recommends sae 5w-30 viscosity grade for servicing any ford gasoline-powered vehicle regardless of model year. *tt
- Bulletin:
- 99124
- Component:
- 103000 power train:automatic transmission
- Summary:
- Experiencing a 4-3 coastdown clunk when decelerating from 48-32 km/h (30-20 mph). *tt
- Bulletin:
- 99128
- Component:
- 353600 equipment:air conditioner
- Summary:
- Some vehicles may exhibit a whistling noise while driving with a/c in the off position at speeds above 64 km/h (40 mph). *tt
- Bulletin:
- 99129
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Experiencing a whine / buzz type noise in the speakers of the entertainment radio or two-way radio on vehicles with an in-tank electric fuel pump. *tt
- Bulletin:
- 99107
- Component:
- 034400 service brakes, hydraulic:foundation components:drum
- Summary:
- Conditions on rear drum grabbing during first few brake applications while brakes are cold. *tt
- Bulletin:
- 99139
- Component:
- 125000 exterior lighting:brake lights
- Summary:
- Conditions with the brake lamps inadvertently disabling the brake shift interlock. *tt
- Bulletin:
- 991313
- Component:
- 036000 service brakes, hydraulic:antilock
- Summary:
- Subject regarding anti-lock brake lamp illumination, increased break pedal effort and / or false anti-lock brake system (abs) cycling at low speeds. *tt
- Bulletin:
- 9946
- Component:
- 103600 power train:automatic transmission:cooling unit and lines
- Summary:
- Concerns with transmission fluid leaking at the radiator. *tt
- Bulletin:
- 6315
- Component:
- 036000 service brakes, hydraulic:antilock
- Summary:
- Vehicles may exhibit an anti-lock brake system (abs) indicator lamp with no diagnostic trouble code (dtc) detected. *tt
- Bulletin:
- 6407
- Component:
- 136000 visibility:windshield wiper/washer
- Summary:
- Exhibiting front windshield wiper activation without command. *tt
- Bulletin:
- 6477
- Component:
- 022141 suspension:rear:springs:leaf spring assembly:leaf
- Summary:
- Subject regarding rear spring rattle. *tt
- Bulletin:
- 12826
- Component:
- 136000 visibility:windshield wiper/washer
- Summary:
- Experiencing front wipers activation without command. *tt
- Bulletin:
- 12905
- Component:
- 106000 power train:axle assembly
- Summary:
- Some vehicles may experience axle wind up and / or clunking, popping, ratcheting type noises when making cornering maneuvers on vehicles equipped with a four wheel drive hi or low range mode. *tt
- Bulletin:
- 12911
- Component:
- 136000 visibility:windshield wiper/washer
- Summary:
- Some vehicles may exhibit activation of front wipers without command. *tt
- Bulletin:
- 996034
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Experiencing a engine knock at cold start-up. *tt
- Bulletin:
- 996042
- Component:
- 135000 visibility:rearview mirrors/devices
- Summary:
- Information on using 1999 procedures manual for side mirror replacement. *tt
- Bulletin:
- 996113
- Component:
- 105000 power train:driveline
- Summary:
- Experiencing front differential noise. *tt
- Bulletin:
- 996139
- Component:
- 105000 power train:driveline
- Summary:
- Concerns with front differential noise. *tt
- Bulletin:
- 983315
- Component:
- 102000 power train:manual transmission
- Summary:
- The 4r100 transmission will have an orange "prior to repair" tag on the fluid pan. *tt
- Bulletin:
- 99164
- Component:
- 116000 electrical system:ignition
- Summary:
- Concerns with a hard to turn ignition key and / or a hard to remove key from ignition cylinder. *tt
- Bulletin:
- 99143
- Component:
- 105500 power train:driveline:differential unit
- Summary:
- Some 4x4 vehicles built with center disconnect front axles may exhibit a moaning noise from the front differential while operating in 4x2 mode. *tt
- Bulletin:
- 99147
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Information on using the service bay technical system (sbts) and new generation star (ngs) tester, and to update the powertrain control module (pcm) information charts. *tt
- Bulletin:
- 991410
- Component:
- 180000 vehicle speed control
- Summary:
- Some vehicles may exhibit an induction backfire on accelerations and decelerations during all ambient temperatures. *tt
- Bulletin:
- 996780
- Component:
- 133000 visibility:power window devices and controls
- Summary:
- This online service bulletin involves vehicles exhibiting windnoise at the top of the door glass seal / weatherstrip molding area. *tt
- Bulletin:
- 996804
- Component:
- 135000 visibility:rearview mirrors/devices
- Summary:
- Concerns with outside passenger or driver side mirror slightly fulttering / shaking at highway speeds. *tt
- Bulletin:
- 996870
- Component:
- 980000 unknown or other
- Summary:
- This online service bulletin mentions that late built regular cabs will not offer a tool box tray located behind the seat, the tool box tray is discontinued and is no longer available as an option. *tt
- Bulletin:
- 996871
- Component:
- 110000 electrical system
- Summary:
- Vehicles built after 7/31/99 will no longer be equipped with a shield covering the starter relay and c120 / c172 electrical connectors located on the passenger side of the engine compartment. *tt
- Bulletin:
- 996876
- Component:
- 162200 structure:body:bumpers
- Summary:
- Information pertaining to conditions with red staining (spots) on the front bumper wing ends. *tt
- Bulletin:
- 9913072
- Component:
- 135200 visibility:rearview mirrors/devices:exterior
- Summary:
- Vehicles may exhibit an outside passenger or driver side mirror slight flutter / shake at highway speeds. *tt
- Bulletin:
- 9913125
- Component:
- 103000 power train:automatic transmission
- Summary:
- Sone police vehicles and other vehicles with 4r70w may exhibit a vibration and / or transmission extension housing bushing damage from sustained high speed operation. *tt
- Bulletin:
- 99213
- Component:
- 162300 structure:body:door
- Summary:
- A condition with the auto-lock functions not operation properly on vehicles built from 6/3/1999 through 6/8/1999. *tt
- Bulletin:
- 99222
- Component:
- 114000 electrical system:wiring
- Summary:
- Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses. *tt
- Bulletin:
- 99224
- Component:
- 136000 visibility:windshield wiper/washer
- Summary:
- Subject regarding front wipers operating while switch is in off position. *tt
- Bulletin:
- 99185
- Component:
- 980000 unknown or other
- Summary:
- Vehicles built between 3/15/1997 and 12/31/1998 and with 4r70w transmissions may experience delayed or no 2-3 upshift, transmission control indicator lamp illuminated with diagnostic trouble code p0782 stored in memory. *tt
- Bulletin:
- 99186
- Component:
- 980000 unknown or other
- Summary:
- Some vehicles may exhibit an intermittent transmission control indicator lamp or malfunction indicator lamp illumination. *tt
- Bulletin:
- 99188
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Vehicles with 4.2l engine (canadian) may backfire on acceleration at all ambient temperature. *tt
- Bulletin:
- 99194
- Component:
- 034000 service brakes, hydraulic:foundation components
- Summary:
- Information for servicing and diagnosing brake vibration, brake inspection, and brake friction material replacement. *tt
- Bulletin:
- 99196
- Component:
- 353600 equipment:air conditioner
- Summary:
- Information on identifying non-approved / alternate refrigerants which could cause safety, and performance concerns if installed in ford a/c systems. *tt
- Bulletin:
- 99197
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding intermittent transmission control indicator lamp or malfunction indicator lamp illumination. *tt
- Bulletin:
- 99234
- Component:
- 980000 unknown or other
- Summary:
- Information on diagnosing a vehicle with malfunction indicator lamp illuminated and diagnostic trouble codes p0442 and p0455 stored in continuous memory. *tt
- Bulletin:
- 99241
- Component:
- 106100 power train:axle assembly:banjo housing
- Summary:
- On 4x2 vehicles with 4r70w and 139 inch wheelbase, a vibration from transmission and / or a transmission fluid leak from the extension housing seal may occur. *tt
- Bulletin:
- 99242
- Component:
- 162300 structure:body:door
- Summary:
- Information on replacing and / or repairing malfunctioning (door, ignition and decklid) locks. *tt
- Bulletin:
- 99243
- Component:
- 126200 exterior lighting:turn signal:switch
- Summary:
- On some vehicles, the front windshield wipers may operate while the multifunction switch is in the off position. *tt
- Bulletin:
- 6914
- Component:
- 116000 electrical system:ignition
- Summary:
- Some vehicles may exhibit a diagnostic trouble code b1845 (ignition tamper switch failure) when retrieving diagnostic trouble codes from the remote anti-theft personality (rap) module. *tt
- Bulletin:
- 6917
- Component:
- 160000 structure
- Summary:
- Some trucks may exhibit a loose / detached gimp moulding at the rear window. *tt
- Bulletin:
- 6996
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Information regarding a change in the torque values of the engine front cover water pump bolts. *tt
- Bulletin:
- 7022
- Component:
- 162000 structure:body
- Summary:
- Information regarding outward dents in pickup box wheel wells. *mjs
- Bulletin:
- 7080
- Component:
- 014100 steering:rack and pinion:pinion shaft
- Summary:
- Information regarding steering gear leaks from input shaft seals. *mjs
- Bulletin:
- 7100
- Component:
- 103000 power train:automatic transmission
- Summary:
- Information regarding transmission trouble codes. *mjs
- Bulletin:
- 7106
- Component:
- 980000 unknown or other
- Summary:
- Information regarding the winners of the edsr of the month quality awards for the month of august. *mjs
- Bulletin:
- 13186
- Component:
- 060000 engine and engine cooling
- Summary:
- Information regarding front cover & water pump bolts-torque valve revision/3.8-4.2l. *mjs
- Bulletin:
- 13203
- Component:
- 162000 structure:body
- Summary:
- Information regarding outward dents in pickup box wheel wells. *mjs
- Bulletin:
- 13212
- Component:
- 106100 power train:axle assembly:banjo housing
- Summary:
- Information regarding extension housing bushing leak./spin-ou. *mjs
- Bulletin:
- 13219
- Component:
- 014100 steering:rack and pinion:pinion shaft
- Summary:
- Information regarding steering gear leaks from input shaft seals. *mjs
- Bulletin:
- 13238
- Component:
- 162300 structure:body:door
- Summary:
- Information regarding vehicles that exhibit cracks in the door sheet metal. *mjs
- Bulletin:
- 13239
- Component:
- 106100 power train:axle assembly:banjo housing
- Summary:
- Information regarding extension housing bushing leak/spin out. *mjs
- Bulletin:
- 13253
- Component:
- 136000 visibility:windshield wiper/washer
- Summary:
- (continued from 13251 and 13252) uncommanded front wiper function. *mjs
- Bulletin:
- 7118
- Component:
- 106100 power train:axle assembly:banjo housing
- Summary:
- Some vehicles may exhibit a vibration and transmission fluid leak or bushing spin and / or walk-out during sustained high speed operation. *tt
- Bulletin:
- 13412
- Component:
- 103000 power train:automatic transmission
- Summary:
- Some vehicles may exhibit a condition of no 4x4 low range engagement or a stuck in 4x4 low range, with no (dtc) diagnostic trouble code stored in the gem. *tt
- Bulletin:
- 6621
- Component:
- 106100 power train:axle assembly:banjo housing
- Summary:
- Some vehicles with 139 inch wheelbase, 4r70w equipped trucks may exhibit a vibration and transmission fluid leak or bushing spin and / or walk-out during sustained high speed operation. *tt
- Bulletin:
- 13010
- Component:
- 103600 power train:automatic transmission:cooling unit and lines
- Summary:
- Some vehicles equipped with the 5.4l engine, 4r100 transmission and an auxiliary transmission oil cooler may exhibit a coastdown moan concern. *tt
- Bulletin:
- 13479
- Component:
- 162300 structure:body:door
- Summary:
- Some vehicles may exhibit cracks in the door sheet metal at the lower rear of the window opening near the belt molding. *tt
- Bulletin:
- 13550
- Component:
- 162000 structure:body
- Summary:
- Some vehicles may exhibit dents on the wheel well sheet metal of the pcik-up box area when used in off-road applications. *tt
- Bulletin:
- 0014
- Component:
- 161000 structure:frame and members
- Summary:
- Vehicles may experience inner fender well- dented or dinged from stones being thrown into wheelwell. *mjs
- Bulletin:
- 0015
- Component:
- 103000 power train:automatic transmission
- Summary:
- Information regarding the new transmission cooler flusher- service tip. *mjs
- Bulletin:
- 7821
- Component:
- 162700 structure:body:trunk lid
- Summary:
- Cracks in the door sheet metal at the lower rear of the window opening near the belt molding.
- Bulletin:
- 7816
- Component:
- 133000 visibility:power window devices and controls
- Summary:
- Some vehicles may exhibit interior lights, power windows and / or inoperative running board lights for a short period of time in the morning. *tt
- Bulletin:
- 8163
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles with 4.6l, or 6.8l engines may exhibit a roller finger follower coming off during engine cranking in cold temperatures below zero degrees f. a one-time noise from the engine may be heard, followed by rough running / misses
- Bulletin:
- 0038
- Component:
- 103600 power train:automatic transmission:cooling unit and lines
- Summary:
- Vehicles may experience solid particle contaminants from prior transmission concerns or excess wear, may be trapped in the transmission fluid cooling system is not properly flushed, fluid in-line filter kit. *mjs
- Bulletin:
- 13838
- Component:
- 131000 visibility:windshield
- Summary:
- Concerns with vehicles exhibiting a windshield creak / squeak. *tt
- Bulletin:
- 8021
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Some vehicles may exhibit a crackling/popping noise from the exhaust, vehicles built between 11/1/97 and 12/8/99. *mjs
- Bulletin:
- 13737
- Component:
- 980000 unknown or other
- Summary:
- All vehicles may exhibit an inoperative or inaccurate speedometer, 4x4 light inoperative and/or dtc p1635 after a pcm has been replaced. *mjs
- Bulletin:
- 13745
- Component:
- 100000 power train
- Summary:
- Some vehicles may experience a condition of no 4 x 4 low range engagement or a stuck in 4 x 4 low range. *mjs
- Bulletin:
- 13806
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Some vehicles built between 11/1/97 and 12/8/99 may exhibit a crackling/popping noise from the exhaust. *mjs
- Bulletin:
- 8455
- Component:
- 021530 suspension:front:control arm:lower arm
- Summary:
- Some vehicles may exhibit a popping noise from the lower control arm. *tt
- Bulletin:
- 00611
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Some bi-fuel vehicles may require powertrain control module (pcm) replacement during service and may not run on cng or lpg., recalibration of the pcm/replacement. *mjs
- Bulletin:
- 14029
- Component:
- 021530 suspension:front:control arm:lower arm
- Summary:
- Some vehicles may exhibit a popping noise from the lowe control arm. *tt
- Bulletin:
- 14031
- Component:
- 980000 unknown or other
- Summary:
- Concerns with erratic remote entry functions. *tt
- Bulletin:
- 985200
- Component:
- 022140 suspension:rear:springs:leaf spring assembly
- Summary:
- Vehicles built with 3-leaf rear springs may exhibit a rear spring rattle *mjs
- Bulletin:
- 9805014
- Component:
- 980000 unknown or other
- Summary:
- Exhibiting a check engine light on and possible diagnostic trouble codes p0715, p0716, p0717, p0718, p1901 (turbine shaft speed - tss codes) or p0720, p0721, p0722, p1900 (output shaft speed - oss codes). *tt
- Bulletin:
- 9805015
- Component:
- 114200 electrical system:wiring:interior/under dash
- Summary:
- Brief information stating that certain vehicles are equipped with a new hybrid electronic instrument cluster (hec). *tt
- Bulletin:
- 12086
- Component:
- 100000 power train
- Summary:
- Some vehicles may exhibit an inoperative speedometer and dtc p1635 after a pcm has been replaced. *mjs
- Bulletin:
- 985028
- Component:
- 110000 electrical system
- Summary:
- Information regarding a new service part released for the license plate light circuit which will reduce the cose of repairs. *tt
- Bulletin:
- 12104
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Some vehicles equipped with 4r100 transmission may exhibit a flashing tcil with diagnostic trouble code dtc 1728 in memory. *mjs
- Bulletin:
- 12112
- Component:
- 104000 power train:transfer case (4-wheel drive)
- Summary:
- Some vehicles with the 5.4 l engine may exhibit difficulty engaging into and out of 4 x 4 low, while cold. *mjs
- Bulletin:
- 12120
- Component:
- 100000 power train
- Summary:
- Some vehicles with 4r70w transmissions built from 4/16/98 through 10/30/98 may exhibit a leak from the vent area of the transmission. *mjs
- Bulletin:
- 12139
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles equipped with 4.6l or 6.8l engines may exhibit a cold start engine noise until warmed up. *mjs
- Bulletin:
- 12144
- Component:
- 980000 unknown or other
- Summary:
- Information regarding the 1999 scheduled maintenance guide for any light truck, sport utility or van equipped with a 4r100 transmission normal maintenance schedule, is not correct. *mjs
- Bulletin:
- 12154
- Component:
- 116300 electrical system:ignition:anti-theft controller
- Summary:
- Some vehicles equipped with pats (securilock) except certain models now have availability of fleet keys through rotunda. *mjs
- Bulletin:
- 12161
- Component:
- 022140 suspension:rear:springs:leaf spring assembly
- Summary:
- Some vehicles built with 3-leaf rear springs may exhibit a rear spring rattle. *mjs
- Bulletin:
- 985080
- Component:
- 100000 power train
- Summary:
- Certain vehicles may exhibit an inoperative speedometer and diagnostic trouble code p1635 after a pecm has been replaced. *tt
- Bulletin:
- 985141
- Component:
- 103000 power train:automatic transmission
- Summary:
- Some vehicles equipped with 4r100 transmission may exhibit a flashing tcil with diagnostic trouble code 1728 in memory. *tt
- Bulletin:
- 985167
- Component:
- 103000 power train:automatic transmission
- Summary:
- Some vehicles equipped with the 5.4l engine may exhibit difficulty engaging into and out of 4x4 low, while cold. *tt
- Bulletin:
- 0084
- Component:
- 022000 suspension:rear
- Summary:
- Concerns with a chattering noise from the rear axle heard when turning or cornerning. **mr
- Bulletin:
- 0087
- Component:
- 110000 electrical system
- Summary:
- Concerns with courtesy, glove compartment, underhood, running board lamps; power windows; radio; and rear wiper all inoperative in the morning or after vehicle is left unattended for 45 minutes. *mr
- Bulletin:
- 8021
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Exhibiting a crackling / popping noise from the exhaust. **mr
- Bulletin:
- 8464
- Component:
- 980000 unknown or other
- Summary:
- Information regarding erractic remote entry functions-new gem released. **mr
- Bulletin:
- 8582
- Component:
- 114200 electrical system:wiring:interior/under dash
- Summary:
- Some vehicles may exhibit a delayed operation / inoperative instrument cluster with koeo or koer. **mr
- Bulletin:
- 14086
- Component:
- 114200 electrical system:wiring:interior/under dash
- Summary:
- Exhibiting a delayed operation / inoperative instrument cluster with koeo or koer. *tt
- Bulletin:
- 14191
- Component:
- 100000 power train
- Summary:
- Some vehicles equipped with a manual transfer case may exhbit an inoperative speedometer. *tt
- Bulletin:
- 99-6189
- Component:
- 116200 electrical system:ignition:module
- Summary:
- Subject regarding abs electronic module now available for service. *t
- Bulletin:
- 99-6193
- Component:
- 116300 electrical system:ignition:anti-theft controller
- Summary:
- Information on resetting the passive anti-theft system (pats). *tt
- Bulletin:
- 99-6197
- Component:
- 162000 structure:body
- Summary:
- Information to technicians regarding objectionable windnoise identified during pre-delivery. *tt
- Bulletin:
- 6232
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Some vehicles may develop a coolant leak at the worm gear clamp located at the joint between the metal intake coolant tube and the coil resulting in engine misfire with diagnostic trouble code p0304 and / or rough idle. *tt
- Bulletin:
- 6242
- Component:
- 106100 power train:axle assembly:banjo housing
- Summary:
- Experiencing a vibration and / or transmission extension housing bushing damage. *tt
- Bulletin:
- 6287
- Component:
- 185000 vehicle speed control:cruise control
- Summary:
- Some vehicles may experience an idle vibration. *tt
- Bulletin:
- 6293
- Component:
- 160000 structure
- Summary:
- Subject regarding cowl leaf screen change. *tt
- Bulletin:
- 12750
- Component:
- 036400 service brakes, hydraulic:antilock:abs warning light
- Summary:
- Some vhicles may exhibit an anti-lock brake system (abs) indicator lamp with no diagnostic trouble codes (dtc). *tt
- Bulletin:
- 12776
- Component:
- 036000 service brakes, hydraulic:antilock
- Summary:
- Some vehicles may exhibit an anti-lock brake system (abs) indicator lamp on with no diagnostic trouble codes (dtc) detected. *tt
- Bulletin:
- 6702
- Component:
- 103600 power train:automatic transmission:cooling unit and lines
- Summary:
- Vehicles equipped with the 5.4l engine, 4r100 transmission and an auxiliary transmission oil cooler may exhibit a coastdown moan concern. *tt
- Bulletin:
- 12704
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Subject regarding all vehicles requires a parameter reset to be performed on the passive anti-theft system module (pats / vic / hec) when the powertrain control module (pcm) is replaced. *tt
- Bulletin:
- 12708
- Component:
- 160000 structure
- Summary:
- Subject regarding vehicles exhibiting windnoise at pre-delivery. *tt
- Bulletin:
- 12720
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Some vehicles may develop a coolant leak at the worm gear clamp located at the joint between the metal intake coolant tube and the flexible rubber coolant hose. *tt
- Bulletin:
- 12725
- Component:
- 106100 power train:axle assembly:banjo housing
- Summary:
- Some vehicles may exhibit a vibration and / or transmission extension housing bushing damage from sustained high speed operation. *tt
- Bulletin:
- 12738
- Component:
- 161000 structure:frame and members
- Summary:
- Some vehicles may exhibit a idle vibration.
- Bulletin:
- 12753
- Component:
- 160000 structure
- Summary:
- Subject regarding cowl leaf screen change. *tt
- Bulletin:
- 12574
- Component:
- 090000 fuel system, other
- Summary:
- Some owners may report slow fuel gauge response time during re-fueling. *tt
- Bulletin:
- 12590
- Component:
- 105500 power train:driveline:differential unit
- Summary:
- Some 4x4 vehicles may exhibit a moan noise from the front differential when the vehicle is operating in 4x2 mode and goes away when operating in 4x4 mode. *tt
- Bulletin:
- 13054
- Component:
- 131000 visibility:windshield
- Summary:
- Experiencing windnoise at the top of the door glass seal / weatherstrip molding area. *tt
- Bulletin:
- 13099
- Component:
- 980000 unknown or other
- Summary:
- Brief information regarding the discontinued tool box. *tt
- Bulletin:
- 13100
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Subject regarding discontinue of the engine compartment beauty shield. *tt
- Bulletin:
- 13106
- Component:
- 162200 structure:body:bumpers
- Summary:
- On some vehicles the front bumpers may exhibit red staining (spots) on the bumer wing ends. *tt
- Bulletin:
- 13146
- Component:
- 116100 electrical system:ignition:switch
- Summary:
- Subject regaring the ignition tamper switch. *tt
- Bulletin:
- 13149
- Component:
- 160000 structure
- Summary:
- Subject regarding a loose / detached gimp moulding at the rear window. *tt
- Bulletin:
- 6489
- Component:
- 022140 suspension:rear:springs:leaf spring assembly
- Summary:
- Some vehicles built with 3-leaf or 4-leaf rear springs may exhibit a rear spring rattle. *tt
- Bulletin:
- 12879
- Component:
- 022140 suspension:rear:springs:leaf spring assembly
- Summary:
- Subject regarding rear spring clip kits for vehicles exhibiting a rear spring rattle. *tt
- Bulletin:
- 12882
- Component:
- 022140 suspension:rear:springs:leaf spring assembly
- Summary:
- Subject regarding the availability of rear spring clip kits for vehicles exhibiting rear spring rattle. *tt
- Bulletin:
- 7292
- Component:
- 980000 unknown or other
- Summary:
- Nners of the edsr-of-the-month quality award announcement for september. *tt
- Bulletin:
- 13505
- Component:
- 103400 power train:automatic transmission:lever and linkage:column shift
- Summary:
- All 4x4 vehicles with electronic shift onthe fly transfer cases will display contact plate pids opposite of the 1999 or earlier workshop manual indicates when using ngs with 15.0 level or later software. *tt
- Bulletin:
- 4660
- Component:
- 111000 electrical system:battery
- Summary:
- Subject regarding the nagative battery terminal cover on some vehicles. *tt
- Bulletin:
- 99-8-15
- Component:
- 162300 structure:body:door
- Summary:
- Subject regarding door trim panel replacement - service tip. *tt
- Bulletin:
- 99111
- Component:
- 980000 unknown or other
- Summary:
- Information designed to aid in the diagnosis, testing and repair of noise, vibration and harshness (nvh) concerns. *tt
- Bulletin:
- 991210
- Component:
- 980000 unknown or other
- Summary:
- Ford motor company has released a private labeled material to be used for iron particle / acid rain service repairs. *tt
- Bulletin:
- 4981
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles equipped with 5.4l engines may exhibit a cold start engine knock concern until warmed up. *tt
- Bulletin:
- 5141
- Component:
- 103000 power train:automatic transmission
- Summary:
- Some vehicles with 4r100 transmission may exhibit a flashing tcil with diagnostic trouble code (dtc) 1728 in memory.dtc 1728 is defined as internal transmission element slippage. this splippage can occur anywhere in the transmission includ
- Bulletin:
- 5233
- Component:
- 133000 visibility:power window devices and controls
- Summary:
- Information on the alive memory (dam) feature during various diagnostic and repair procedures. *tt
- Bulletin:
- 5257
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Information on vehicles exhibiting cold engine knock. *tt
- Bulletin:
- 5262
- Component:
- 136000 visibility:windshield wiper/washer
- Summary:
- Information on diagnosticing erratic windshield wiper operation. *tt
- Bulletin:
- 5267
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Subject regarding misfire codes on all engines. *tt
- Bulletin:
- 5349
- Component:
- 100000 power train
- Summary:
- Subject regarding technical assistance for speedometer accuracy concerns. *tt
- Bulletin:
- 5356
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles built with the 4.2l engine that are operating in mexico may exhibit a backfire concern. *tt
- Bulletin:
- 12253
- Component:
- 350000 equipment
- Summary:
- Effective january 4, 1999 certain vehicles built with throw-in-mats will be built with the deltar clip attachment as a means of attachment to the floor. *tt
- Bulletin:
- 12265
- Component:
- 102000 power train:manual transmission
- Summary:
- Some vehicles equipped with m50d r2 mazda 5 speed manual transmission may exhibit a gear shift rattle condition in third gear. *tt
- Bulletin:
- 12266
- Component:
- 100000 power train
- Summary:
- Some vehicles may require technical assistance for speedometer accuracy concerns. *tt
- Bulletin:
- 12266
- Component:
- 100000 power train
- Summary:
- Some vehicles may require technical assistance for speedometer accuracy concerns. *tt
- Bulletin:
- 12272
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles built with the 4.2l engine that are operating in mexico may exhibit a backfire concern. *tt
- Bulletin:
- 985185
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Cold start engine noise
- Bulletin:
- 00232
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles may exhibit an intermittent hesitation or buck while driving in any fuel mode (lpg, cng or gasoline). *tt
- Bulletin:
- 00238
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles may exhibit a no crank / no start condition in temperatures below 12 degrees c (10 degrees f). *tt
- Bulletin:
- 00239
- Component:
- 110000 electrical system
- Summary:
- A condition may exist with possible electronc damage occuring to the compuvalve from voltage spikes between the compuvalve connections when connecting or disconnecting the main compuvalve harness c4025. *tt
- Bulletin:
- 002310
- Component:
- 103600 power train:automatic transmission:cooling unit and lines
- Summary:
- Subject regarding contamination from prior transmission concerns or excess wear may be trapped in the transmission fluid cooling system. *tt
- Bulletin:
- 00258
- Component:
- 020000 suspension
- Summary:
- Some vehicles may exhibit a clunking sound on some svt lightning vehcles during parking maneuvers. *tt
- Bulletin:
- 00261
- Component:
- 185000 vehicle speed control:cruise control
- Summary:
- Some vehicles equipped with a 4.6l, 5.4l, or 6.8l engine may exhibit a rough idle / miss after start-up in cold ambient temperatures. *tt
- Bulletin:
- 14609
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Subject regarding high idle and/or check engine light condition. *jb
- Bulletin:
- 01111
- Component:
- 160000 structure
- Summary:
- Some vehicles may exhibit a water leak around the rear (sliding) window. *tt
- Bulletin:
- 00142
- Component:
- 100000 power train
- Summary:
- Inoperative or inaccurate speedometer, 4x4 lamp illuminated and / or diagnostic trouble codes (dtcs) p1635 or p1639 present after a powertrain control module (pcm) or instrument cluster replacement. *jb
- Bulletin:
- 00L07
- Component:
- 355100 equipment:other:labels
- Summary:
- This bulletin involves fuel door label application / replacement. *jb
- Bulletin:
- 00192
- Component:
- 110000 electrical system
- Summary:
- Some vehicles may exhibit an inoperative courtesy, glove compartment, underhood, running board lamps, power windows, radio and rear wiper in the morning or after vehicle is left unattended for 45 minutes. *jb
- Bulletin:
- 00184
- Component:
- 980000 unknown or other
- Summary:
- Concerns with malfunction indicator lamp (mil) illumination and diagnostic trouble code (dtc) p0171 and / or p0174 stored in memory. *jb
- Bulletin:
- 00189
- Component:
- 135000 visibility:rearview mirrors/devices
- Summary:
- Concerns with the signal mirror reflective surface deteriorating over time, developing dark spots due to chrome plating delamination. *jb
- Bulletin:
- 14365
- Component:
- 061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
- Summary:
- This bulletin addresses concerns a noise at intial engine startup when cold from the accessory drive belt. *jb
- Bulletin:
- 0162
- Component:
- 116300 electrical system:ignition:anti-theft controller
- Summary:
- Vehicles equipped with passive anti-theft system (pats) may not start or crank. *tt
- Bulletin:
- 0182
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some bi-fuel vehicles may exhibit a no start condition. *tt
- Bulletin:
- 0142
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles may exhibit the engine oil sending unit contacting the oil drip shield attached to the front axle. *tt
- Bulletin:
- 0147
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Subject regarding engine oil recommendations for use in 2001 vehicles - sae 5w-20 motor oil. *tt
- Bulletin:
- 0193
- Component:
- 106100 power train:axle assembly:banjo housing
- Summary:
- A condition may exist where a driveline vibration and / or a transmission fluid leak from the extension housing seal area may occur on some vehicles. this may be caused by the extension housing bushing or seal walking / spinning out due t
- Bulletin:
- 14918
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- This bulletin states that on some vehicles (including 2002 blackwood) a battery disconnect or parameter reset is required during powertrain control module (pcm) or instrument cluster (vic / hec / icm) replacement. *tt
- Bulletin:
- 14907
- Component:
- 980000 unknown or other
- Summary:
- Concerns with vehicles exhibiting the oil pressure gauge registering low or no oil pressure usually on initial start-up after several hours of cold soak. *tt
- Bulletin:
- 14942
- Component:
- 980000 unknown or other
- Summary:
- Some vehilces equipped with 4.6l romeo engine and manual transmission only, may exhibit a check engine light on and diagnostic trouble coe p0172 / p0175 stored in memory with possible driveabltility conditions such as hesitation / stumble.
- Bulletin:
- 13737
- Component:
- 100000 power train
- Summary:
- Inoperative or inaccurate speedometer as well as 4x4 light inoperative and / or diagnostic trouble code p1635 and / or p1639 after a powertrain control module (pcm) has been replaced. *tt
- Bulletin:
- 14160
- Component:
- 980000 unknown or other
- Summary:
- A condition may exist where the malfunction indicator lamp is on with diagnostic trouble code p0340 (camshaft position (cmp) sensor a circuit) stored, accompanied with a driveability concern. *tt
- Bulletin:
- 14417
- Component:
- 010000 steering
- Summary:
- Some lightning models may exhibit a clunking sound from the front end area during parking maneuvers. *tt
- Bulletin:
- 14029
- Component:
- 021530 suspension:front:control arm:lower arm
- Summary:
- Exhibiting a popping noise from the lower control arm. *tt
- Bulletin:
- 01136
- Component:
- 070000 fuel system, gasoline
- Summary:
- Subject regarding overview of bi-fuel cng vehicle parameter identification data (pid), inputs and outputs as a diagnostic aid for bi-fuel vehicles. *tt
- Bulletin:
- 01137
- Component:
- 103000 power train:automatic transmission
- Summary:
- Some vehicles equipped with a 4r70w automatic transmission may exhibit a clunk noise during the 2-1 downshift event. *tt
- Bulletin:
- 01141
- Component:
- 104000 power train:transfer case (4-wheel drive)
- Summary:
- Some vehicles may exhibit inadvertent 4x4 hi or low shift events, 4x4 and / or low range indicator flashing or solid or vehicle stuck in 4l after uncommanded shift. *tt
- Bulletin:
- 15068
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Vehicles equipped with a 4.6l engine and 5 speed manual transmission may exhibit a slight hesitation on light tip-in acceleration and a malfunction indicator lamp on with diagnostic trouble codes p0172 and p0175. *tt
- Bulletin:
- 15101
- Component:
- 100000 power train
- Summary:
- Some vehicles equipped with a 4.6l engine a 5 speed manual transmission may exhibit a slight hesitation on light tip-in acceleration and a malfunction indicator lamp on with diagnostic trouble code p0172 and p0175. *tt
- Bulletin:
- 01122
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- On some vehicles there may be an oil leak from the right hand head gasket at the rear of the block / head joint. *tt
- Bulletin:
- 14990
- Component:
- 162300 structure:body:door
- Summary:
- Concerns that some trucks may exhibit a loose / detached rear window halo trim gimp moulding. *tt
- Bulletin:
- 01155
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Some vehicles, bi fuel, may exhibit a no start condition in both the gasoline mode and the alt fuel mode, vehicles equipped with 5.4l or 6.8l bi fuel engines only. *slc
- Bulletin:
- 01156
- Component:
- 138120 visibility:defroster/defogger system:windshield:heater core
- Summary:
- Some vehicles may exhibit heater core leaks. *slc
- Bulletin:
- 01157
- Component:
- 980000 unknown or other
- Summary:
- Information regarding transmission fluid usage charts. *slc
- Bulletin:
- 01151
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Some vehicles equipped with a 4.6l engine and m5od 5 speed manual transmissions may exhibit hesitation on acceleration and a check engine light illumination with diagnostic trouble codes 90172 and 90175. *slc
- Bulletin:
- 15164
- Component:
- 353600 equipment:air conditioner
- Summary:
- Some vehicles may exhibit a loss of coolant from the charge air cooler reservoir. *yh
- Bulletin:
- 15113
- Component:
- 091100 fuel system, other:storage:tank assembly
- Summary:
- Some vehicles may exhibit a fuel fill valve sealing condition. *yd
- Bulletin:
- 15145
- Component:
- 173100 latches/locks/linkages:tailgate:latch
- Summary:
- Some vehicles equipped with remote locking tailgates may exhibit a tailgate locking itself when the vehicle is being driven over rough roads or is slammed shut. *et
- Bulletin:
- 15187
- Component:
- 160000 structure
- Summary:
- Some vehicles may exhibit a loose/detached rear window halo gimp molding. *et
- Bulletin:
- 01182
- Component:
- 162300 structure:body:door
- Summary:
- Some vehicles may experience a cosmetic crack in the outer door panel at the lower rear corner of window opening.*jb
- Bulletin:
- 010901
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Certain 1999 and 2000 model year f150 lightning vehicles - intercooler replacement. *nlm
- Bulletin:
- 01181
- Component:
- 103800 power train:automatic transmission:park/neutral start switch
- Summary:
- Brake shift interlock.*jb
- Bulletin:
- 15219
- Component:
- 980000 unknown or other
- Summary:
- Some vehicles may exhibit a condition where all the guages inthe instrument cluster will sweep at initial start up. *tt
- Bulletin:
- 15271
- Component:
- 091110 fuel system, other:storage:tank assembly:filling/charging
- Summary:
- Dedicated cng regulator bowl kit available. *jg
- Bulletin:
- 15259
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Concerns with the lower power in high ambient temepratures. *tt
- Bulletin:
- 15260
- Component:
- 113000 electrical system:starter assembly
- Summary:
- Concerns with corroded positive starter cable. *tt
- Bulletin:
- 01192
- Component:
- 034430 service brakes, hydraulic:foundation components:drum:drum
- Summary:
- Some vehicles may exhibit a grabbing condition from the rear drum brakes during the first few brake applications after extended humidity exposure. *tt
- Bulletin:
- 01214
- Component:
- 180000 vehicle speed control
- Summary:
- Information to aid in diagnosis for clarification of lock-off solenoid and solenoid tank valve coil rsistances for bi-fuel vehicles. *tt
- Bulletin:
- 01218
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles may exhibit a no crank, no start condition due to corrosion of the starter cable b+ terminal at the starter solenoid. *tt
- Bulletin:
- 012110
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles equipped with the romeo built 4.6l 2v engine may exhibit an engine oil leak or oil weepage from the cylinder head gasket at the right hand rear or the left hand front of the engine. *tt
- Bulletin:
- 012112
- Component:
- 180000 vehicle speed control
- Summary:
- A condition may exist, where throttle sticking may occur on a few vehicles in very cold ambient temperatures afte operating at steady speed or extended idle for a period of time. *tt
- Bulletin:
- 012113
- Component:
- 116100 electrical system:ignition:switch
- Summary:
- Some ignition switch lock cylinder assemblies may exhibit rougness and / or excess effort in turning, key does not fully return from start, a malfunction indicator lamp may illuminate with p0500, p1502 and u1039 stored in powertrian control
- Bulletin:
- 01201
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles may exhibit high idle and/or pcv system icing after steady state driving in extreme cold ambient temperatures on vehicles equipped with 4.2l engine built thorugh 1/24/2000. *tt
- Bulletin:
- 01205
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles may exhibit vacuum or air leaks in the intake manifold and / or engine system causing diagnostic trouble codes p0171 and or p0174. *tt
- Bulletin:
- 0214
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some engine assemblies with aluminum cylinder heads repaired in-vehile have been found to leak coolant and/or oil from the cylinder head gasket area. *tt
- Bulletin:
- 15570
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles may exhibit various driveability conditions including lacks power, hesitates, hard to start, and/or malfunction indicator lamp (mil) illuminated and produce possible diagnostic trouble codes p0103, p0172 and p0175. *tt
- Bulletin:
- 15299
- Component:
- 113000 electrical system:starter assembly
- Summary:
- Some vehicles may exhibit corrosion at the attachment point of the starter cable b+ terminal, at the starter solenoid. *tt
- Bulletin:
- 01221
- Component:
- 070000 fuel system, gasoline
- Summary:
- Some dedicated compressed natural gas (cng) vehicles may exhibit a rough idle, or no start in cold conditions. *tt
- Bulletin:
- 01231
- Component:
- 070000 fuel system, gasoline
- Summary:
- Some compressed natural gas (cng) vehicles may exhibit rough idle or no start when cold. *tt
- Bulletin:
- 15431
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Exhibiting lack of power condition when vehicle is operated in ambient temperatures. *tt
- Bulletin:
- 01246
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Engine oil system priming procedures, service tips for reports of premature engine failure. *tt
- Bulletin:
- 01255
- Component:
- 033000 service brakes, hydraulic:power assist
- Summary:
- Some lightning model vehicles may exhibit a reduced power assist after the first two or three brake applications during operating in freezing ambient temperatures. *tt
- Bulletin:
- 01L07
- Component:
- 355100 equipment:other:labels
- Summary:
- Field service action 01l07 to replace incorrect tire size and pressure information on the tire information label. *tt
- Bulletin:
- 15502
- Component:
- 021000 suspension:front
- Summary:
- Concerns with pop/clunk/click noise from the front suspension when making low-speed turns in forward or reverse gears. *tt
- Bulletin:
- 0253
- Component:
- 091100 fuel system, other:storage:tank assembly
- Summary:
- Subject regarding alternative fuel vehicle compressed natural gas tank inspection. *tt
- Bulletin:
- 0258
- Component:
- 100000 power train
- Summary:
- Inoperative or inacurrate speedometer, 4x4 lamp illuminatd, and / or diagnostic trouble code p1635 or p1639. *tt
- Bulletin:
- 0245
- Component:
- 111000 electrical system:battery
- Summary:
- Information regarding discharged battery charging service tips and guidelines. *tt
- Bulletin:
- 02105
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some bi-fuel cang and lpg vehicles may exhibit a no start condition. *tt
- Bulletin:
- 02106
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some bi-fuel lpg vehicles (with coolant lock off) may exhibit a no start condition. *tt
- Bulletin:
- 02108
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles equipped with the 5.4l 2v engine may exhibit a whistling noise fromthe formed nylon tube inthe idle-air bypass flow circuit. *tt
- Bulletin:
- 16172
- Component:
- 034400 service brakes, hydraulic:foundation components:drum
- Summary:
- Some vehicles with 4-wheel disc brakes may exhibit a moan from the rear brakes on light brake applications. *tt
- Bulletin:
- 16019
- Component:
- 980000 unknown or other
- Summary:
- Some lightning and harley davidson supercrews may exhibit check engine light illumination with diagnostic trouble codes p0171 or p0174. *tt
- Bulletin:
- 16033
- Component:
- 103400 power train:automatic transmission:lever and linkage:column shift
- Summary:
- Some vehicles with electronic shift-on-the fly may exhibit an inadvertent 4x4 low engagement while driving. *tt
- Bulletin:
- 15692
- Component:
- 020000 suspension
- Summary:
- Some vehicles may exhibit a squeak, snap, rattle, or clunk in the front end when turning or going over bumps. *tt
- Bulletin:
- 15707
- Component:
- 075000 fuel system, gasoline:carburetor system
- Summary:
- Information on vehicle exhibiting evidence of oil in the air intake system. *tt
- Bulletin:
- 15711
- Component:
- 102000 power train:manual transmission
- Summary:
- Some vehicles equipped with a 5-speed mazda r2 manual transmission may exhibit a high effort condition when shifting any gear. *tt
- Bulletin:
- 15742
- Component:
- 070000 fuel system, gasoline
- Summary:
- Information on vehicles exhibiting a perceived poor fuel range / economy, and or a faulty fuel gauge. *tt
- Bulletin:
- 15758
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Snow packing of the air filter when driving in severe snow conditions may exhibit loss of power and / or the malfunction indicator lamp illuminating. *tt
- Bulletin:
- 020503
- Component:
- 071100 fuel system, gasoline:storage:tank assembly
- Summary:
- Guidance for cng tank inspection for vehicles produced after december 2, 1996. *tt update. *tt
- Bulletin:
- 15817
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles equipped with bi-fuel (cng/lpg) alternate fuel engines may exhibit hard / no start, runs rough or misses after starting, and or hesitation on acceleration when operated in the bi-fuel mode. *tt
- Bulletin:
- 15913
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles equipped with 5.4l v8 engine may exhibit air induction system conditions as well as engine hesitation / surge and / or a malfunction indicator lamp illuminated. *tt
- Bulletin:
- 870197
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Incorrectly installed gear driven camshaft position (cmp) sensor synchronizer assemblies causing surge, lost of power, malfunction indicator lamp on and diagnostic trouble codes p1336, p1309 and p0340. *tt
- Bulletin:
- 03610
- Component:
- 017500 steering:linkages:tie rod assembly
- Summary:
- Tie rod end inspection procedure. canada vehicles only. *tt *jb
- Bulletin:
- 0342
- Component:
- 090000 fuel system, other
- Summary:
- Possible fuel leak may occur at the fuel fill valve, on some dedicated cng vehicles. *tt *jb
- Bulletin:
- 0324
- Component:
- 133000 visibility:power window devices and controls
- Summary:
- Driver's side door glass that binds when operated. *tt
- Bulletin:
- 16602
- Component:
- 173100 latches/locks/linkages:tailgate:latch
- Summary:
- Locking tailgate locks itself. *tt
- Bulletin:
- 16605
- Component:
- 010000 steering
- Summary:
- Reduced power steering assist and/or power steering leaks when driven in temperatures equal to or less than -25 degrees celcius. *tt
- Bulletin:
- 030402
- Component:
- 090000 fuel system, other
- Summary:
- On some dedicated cng vehicles, a possible fuel leak may occur at the fuel fill valve. revised service parts. *tt
- Bulletin:
- 16928
- Component:
- 110000 electrical system
- Summary:
- Various intermittent electrical concerns including but not limited to some accessories remaining powered up with the key out of the ignition, multiple system warning lights with short to power or low battery voltage diagnostic trouble codes
- Bulletin:
- 16835
- Component:
- 173100 latches/locks/linkages:tailgate:latch
- Summary:
- Tailgate locking by itself when slammed shut or when the vehicle is being driven over rough roads. *tt
- Bulletin:
- 03102
- Component:
- 070000 fuel system, gasoline
- Summary:
- Compressed natural gas (cng). rough idle or no start when cold. vehicles equipped with cng bi-fuel engine only. *tt
- Bulletin:
- 03103
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Vehicles without the coolant lock-off may exhibit a no start condition. *tt
- Bulletin:
- 03104
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Bi-fuel lpg vehicles (with coolant lock off) may exhibit a no start condition. *tt
- Bulletin:
- 0398
- Component:
- 090000 fuel system, other
- Summary:
- Malfunction indicator lamp (mil) illumination with diagnostic trouble codes p0442, p0455, p0456, p0457, p1442 or check fuel cap lamp illuminated with diagnostic trouble code p0457. *tt
- Bulletin:
- 0399
- Component:
- 010000 steering
- Summary:
- Tie rod end inspection procedure. *tt
- Bulletin:
- 17009
- Component:
- 110000 electrical system
- Summary:
- Malfunction indicator lamp (mil) illumination with no hard fault. *tt
- Bulletin:
- 17063
- Component:
- 110000 electrical system
- Summary:
- Malfunction indicator lamp (mil) on with diagnostic trouble codes (dtc) p0171, or p0174. f150 lighting and f150 harley davidson supercrew. *tt
- Bulletin:
- 031513
- Component:
- 017500 steering:linkages:tie rod assembly
- Summary:
- Tie rod end inspection procedure. *tt
- Bulletin:
- 03144
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Engine misfire or rough running condition with coil on plug (cop) ignition systems may be more accurately diagnosed using the optional worldwide diagnostic system (wds) coil on plug (cop) kit. 2003 super duty f series included. *tt
- Bulletin:
- 03148
- Component:
- 103600 power train:automatic transmission:cooling unit and lines
- Summary:
- New transmission cooler flusher - service tips. 2003 escort and super duty f series included. *tt
- Bulletin:
- 16969
- Component:
- 120000 exterior lighting
- Summary:
- Damaged rear license plate lamps due to rocks and/or gravel hitting the lamp assemblies. *tt
- Bulletin:
- 03183
- Component:
- 180000 vehicle speed control
- Summary:
- Dedicated compressed natural gas (cng) rough idle or no start when cold vehicles equipped with dedicated 4.6l or 5.4l cng engine only. *tt
- Bulletin:
- 03206
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Some dedicated cng vehicles may exhibit various driveability conditions due to a loss of injector performance, resulting from fuel quality. loss of power at heavy load, diagnostic trouble codes (dtcs) for lean fuel, rough idle, hard start,
- Bulletin:
- 0416
- Component:
- 105000 power train:driveline
- Summary:
- Driveline clunking/grunting noise or shudder sensation during light to moderate accelreation and/or braking. *tt
- Bulletin:
- 0422
- Component:
- 162000 structure:body
- Summary:
- Windnoise and/or a water leak from the sliding back glass area. *tt
- Bulletin:
- 17655
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Evidence of oil in the air intake system. *tt
- Bulletin:
- 17320
- Component:
- 063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
- Summary:
- Broken exhaust manifold studs. *tt
- Bulletin:
- 17731
- Component:
- 015000 steering:hydraulic power assist system
- Summary:
- Whine from power steering. *tt
- Bulletin:
- 17448
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Remote oil filter adaptor replacement - new service part. *tt
- Bulletin:
- 02221
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Engine-gear driven synchronizers-incorrect installation-camshaft position synchronizer (cmp) installation tool correct application. *mj
- Bulletin:
- 02227
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Engine-cylinder head deck leak-4.6 and 5.4l engines-new service-only gasket and cylinder head kits availability. *mj
- Bulletin:
- 16416
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- No/hard start in cold ambients / new two-piece block heater cord released. *mj
- Bulletin:
- 0457
- Component:
- 130000 visibility
- Summary:
- Pop/thump noise at end of window movement and/or driver's window bounce back and reverse to mid-position. *tt
- Bulletin:
- 17777
- Component:
- 022140 suspension:rear:springs:leaf spring assembly
- Summary:
- Rear leaf spring noise. *tt
- Bulletin:
- 17823
- Component:
- 015200 steering:hydraulic power assist:hose, piping, and connections
- Summary:
- Power steering leak - service tip. *tt
- Bulletin:
- 02193
- Component:
- 073000 fuel system, gasoline:fuel injection system
- Summary:
- Driveability-idle-high idle speeds-throttle sticks after steady state driving in extreme cold ambient temperatures-vehicles built through 12/31/01 equipped with 4.6l engine. *mj
- Bulletin:
- 04L19
- Component:
- 017500 steering:linkages:tie rod assembly
- Summary:
- Customer maintenance reminder - literature program 04l19 - tie rod inspection procedure. *tt
- Bulletin:
- 031404
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Engine misfire or running - coil on plug (cop) ignition systems - wds cop kit diagnostic tips. to include various 2005 models. * ar this article 04161 supersedes tsb 03-14-04.
- Bulletin:
- 04217
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- General power train control module (pcm) programming procedures. *tt
- Bulletin:
- 042107
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- General (pcm) power train control module programming procedures. *tt
- Bulletin:
- 04266
- Component:
- 105000 power train:driveline
- Summary:
- A driveline clunk or bump when starting from a stop. *tt
- Bulletin:
- 18466
- Component:
- 106000 power train:axle assembly
- Summary:
- Axle whine howl. this includes 1997-05 ford vehicles. *eh
- Bulletin:
- 05417
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- Intermittent rough idle - non-commanded egr (exhaust gas recirculation valve) flow. *tt
- Bulletin:
- 0554
- Component:
- 063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
- Summary:
- Use of stainless steel exhaust studs in service for 5.4l 2v engine. *tt
- Bulletin:
- 050618
- Component:
- 022000 suspension:rear
- Summary:
- Rear axle noise repair. *sc
- Bulletin:
- 05618
- Component:
- 106000 power train:axle assembly
- Summary:
- Rear axle noise repair. *tt
- Bulletin:
- 041601
- Component:
- 060000 engine and engine cooling
- Summary:
- Wds cop kit diagnostic tip - coil on plug (cop) ignition systems - engine misfire or rough running. *tt
- Bulletin:
- 07212
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Some 1997-2008 vehicles equipped with a 4.6l 2v, 5.4l 2v, or 6.8l 2v engine--spark plug thread repair procedure--not covered under new vehicle limited warranty. *nj this includes f-53 motorhome chassis. updated 2/23/10. *pe
- Bulletin:
- 20228
- Component:
- 061320 engine and engine cooling:engine:other fuel types:turbo-charger
- Summary:
- 1999-2008 7.3l/6.0l/6.4l/4.5l diesel f-super duty - clean the charge air cooler (cac) system after certain turbo or engine failures - service tip. *nj
- Bulletin:
- CSP-08B01
- Component:
- 063140 engine and engine cooling:exhaust system:emission control:catalytic convertor
- Summary:
- Ford: certain 1999-2001 model year vehicles up to 6000 lb gvwr registered in new york and certain 2001 vehicles up to 6000 lb gvwr registered in the state of maine, certified for sale in california-federal emission warranty refund. *pe
- Bulletin:
- TSB-14-0147
- Component:
- 071100 fuel system, gasoline:storage:tank assembly
- Summary:
- Ford/lincoln: safety recall issued due to one or both fuel tank straps fracturing due to being in high corrosion areas for an extended period and dislodging fuel tank. model 1997-99 f250, 1997-03 f150, 2004 f150 heritage, 2002-2003 blackw
- Bulletin:
- TSB-14-0164
- Component:
- 071100 fuel system, gasoline:storage:tank assembly
- Summary:
- Ford/lincoln: safety recall regarding high corrosion areas for operating, for an extended time, vehicles where both or one strap of fuel tank can fracture, after contacting ground. model 1997-99 f250 ld, 1997-03 f150, 2004 f150 heritage,
Home | Privacy