1999 DODGE RAM Recalls (13)
- Campaign:
- 99V034000 on 02/24/1999
- Component:
- Fuel system, other:storage:tank assembly
- Manufactured:
- 09/14/1998 - 02/14/1999
- Affected:
- 45
- Defect:
- Vehicle description: vans equipped with compressed natural gas (cng) fuel tanks. incorrect fuel tank straps were installed on the small fuel tank. as a result, the fuel tank may not be securely attached to the vehicle.
- Consequence:
- The fuel tank could move increasing the risk of a fire and/or explosion.
- Correction:
- Dealers will replace the mounting straps for the small fuel tank.
- Notes:
- Owner notification began march 22, 1999. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chrysler at 1-800-992-1997.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 99V044000 on 03/16/1999
- Component:
- Fuel system, other:delivery:hoses, lines/piping, and fittings
- Manufactured:
- 09/14/1998 - 02/14/1999
- Affected:
- 45
- Defect:
- Vehicle description: passenger vans and wagons equipped with compressed natural gas (cng). the fuel hose that connects the left and right fuel rails may shrink and leak fuel if exposed to high engine operating temperatures.
- Consequence:
- Fuel leakage in the presence of an ignition source can result in a fire.
- Correction:
- Dealers will replace the fuel rail assembly.
- Notes:
- Owner notification began march 22, 1999.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chrysler at 1-800-992-1997. also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 99V115000 on 05/11/1999
- Component:
- Power train:clutch assembly
- Manufactured:
- 07/30/1993 - 04/29/1999
- Affected:
- 8,883
- Defect:
- Vehicle description: pickup trucks equipped with manual transmission, v10 engines and four-wheel-drive transfer cases. under sustained maximum rated vehicle load, while driving up a steep grade in four-wheel-drive low range in hot ambient conditions, the local exhaust temperature proximate to the hydraulic clutch line can generate line temperatures that exceed the temperature limit of the clutch line material. if this condition occurs and the clutch is depressed, the line could rupture.
- Consequence:
- The fluid could ignite on the hot exhaust possibly resulting in a vehicle fire.
- Correction:
- Dealers will replace the hydraulic clutch assembly.
- Notes:
- Owner notification began december 27, 1999. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chrysler at 1-800-992-1997. also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 99V190000 on 07/18/1999
- Component:
- Power train:clutch assembly
- Manufactured:
- 02/01/1999 - 06/20/1999
- Affected:
- 8,378
- Defect:
- Vehicle description: pickup trucks equipped with gasoline engines and manual transmissions. the underbody hydraulic clutch line heat shield is too short, allowing the plastic clutch line material to be directly exposed to exhaust temperatures. it is possible to exceed the melting temperature of the clutch line material.
- Consequence:
- If the line melts, hydraulic fluid can leak onto the vehicle exhaust and cause an underbody fire.
- Correction:
- Dealers will install the proper length heat shield.
- Notes:
- Owner notification began august 9, 1999.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chrysler at 1-800-992-1997.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 00V107000 on 04/27/2000
- Component:
- Trailer hitches
- Manufactured:
- 12/31/1997 - 09/29/1999
- Affected:
- 357,000
- Defect:
- Vehicle description: pickup trucks equipped with optional trailer hitch. the trailer hitch side brackets were manufactured using material with insufficient strength.
- Consequence:
- Brackets built without proper material could fatigue and fracture in the area where the trailer hitch mounts to the frame.
- Correction:
- Dealers will inspect the trailer hitches and replace any trailer hitch showing signs of fatigue cracking. if no evidence of cracking exists, the dealer will install two reinforcement brackets.
- Notes:
- Owner notification began april 24, 2000.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1-800-992-1997. also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 01V040000 on 02/12/2001
- Component:
- Latches/locks/linkages:hood:latch
- Manufactured:
- 07/22/1993 - 05/09/1999
- Affected:
- 701,000
- Defect:
- On certain pickup trucks originally sold in or currently registered in the following "salt belt" states: maine, new hampshire, vermont, massachusetts, rhode island, connecticut, new york, new jersey, pennsylvania, delaware, maryland, the district of columbia, west virginia, ohio, indiana, michigan, illinois, wisconsin, minnesota, iowa, and missouri. corrosion of the return spring on the hood secondary latch could cause the mechanism to bind in the "release position."
- Consequence:
- if the primary latch is not engaged, the hood could open unexpectedly.
- Correction:
- Dealers will replace the secondary hood latch. owner notification began september 17, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1-800-853-1403.
- Notes:
- Daimlerchrysler recall no.973.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 01V119000 on 04/23/2001
- Component:
- Seat belts:front:retractor
- Manufactured:
- 12/17/1998 - 01/14/1999
- Affected:
- 161,682
- Defect:
- Vehicle description: certain van, wagon, pickup trucks, passenger and sport utility vehicles, fail to comply with requirements of fmvss no. 209, "seat belt assemblies." the front seat belt retractor may not comply with the requirements of the standard.
- Consequence:
- If the retractor does not work properly, it will not adequately protect occupants in the event of a crash.
- Correction:
- Dealers will replace the seat belt retractor. owner notification began august 20, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1-800-853-1403.
- Notes:
- Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 01V153000 on 05/17/2001
- Component:
- Air bags
- Manufactured:
- 05/29/2000 - 10/30/2000
- Affected:
- 216,100
- Defect:
- Vehicle description: pickup trucks. sound deadener material inside the steering wheel could become detached from the cover and housing. note: the ram pickup trucks were built at the warren assembly plant ("s" in the 11th vin position) from may 16, 2000 through october 23, 2000; st. louis north assembly plant ("j" in the 11th vin position) from may 19, 2000 through october 23, 2000; lago alberto assembly plant ("m" in the 11th vin position) from may 23, 2000 through october 23, 2000; and saltillo assembly plant ("g" in the 11th vin position) from may 23, 2000 through october 23, 2000. important: vehicles that have already had the proper clockspring installed, according to warranty records, have been excluded from this recall. in addition, 1997-2000 model year vehicles that have had a suspect replacement clockspring installed, according to warranty records, have been added to this recall.
- Consequence:
- When this occurs, the material could interfere with the clockspring ribbon and cause an open circuit. the driver air bag system will become disabled, and the air bag warning lamp will illuminate on the instrument panel.
- Correction:
- Dealers will replace the clockspring assembly. owner notification began june 18, 2001. also some 1997-200 model year vehicles that, according to warranty records, have had a suspect replacement clockspring installed, will also be included in this campaign. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1-800-853-1403.
- Notes:
- Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 04V185000 on 04/19/2004
- Component:
- Service brakes, hydraulic:antilock:control unit/module
- Manufactured:
- 06/30/1997 - 06/29/2003
- Affected:
- 44,588
- Defect:
- On certain van and wagon vehicles equipped with 4-wheel antilock brake systems (abs), aftermarket batteries may leak electrolyte onto the abs control module connector, which can compromise sealing integrity of the connector.
- Consequence:
- This may allow development of a short circuit in the connector, which could eventually lead to a fire.
- Correction:
- Dealers will inspect the abs control module connector for electrolyte damage and replace the connector as necessary. the recall will begin on september 27, 2004. owners should contact daimlerchrysler at 1-800-853-1403.
- Notes:
- Daimlerchrysler recall no. d20.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 06E060000 on 06/28/2006
- Component:
- Exterior lighting
- Affected:
- 87,745
- Defect:
- Certain aai motorsports combination lamps sold as replacement lamps for use on the above list passenger vehicles. combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment."
- Consequence:
- Lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash
- Correction:
- Aai motorsports will notify owners and replace the lamps free of charge. the recall began on august 1, 2006. owners may contact aai motorsports at 909-923-9188.
- Notes:
- This recall only pertains to aai motorsports aftermarket lamps and has no relation to any original equipment installed on the listed passenger vehicles.for more information on the lamp model numbers, click on document search and view document titled "lamp model numbers."customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 08E050000 on 08/13/2008
- Component:
- Exterior lighting:headlights
- Affected:
- 1,921
- Defect:
- K2 motor is recalling 1,921 aftermarket headlamps of various models sold for use on the above listed vehicles. these headlamps are missing the amber side reflex reflector which fails to conform with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment."
- Consequence:
- Without the amber side reflex reflectors, the lighting visibility may be affected, possibly resulting in a vehicle crash.
- Correction:
- K2 motor will notify owners and offer a full refund. the recall began on decemeber 17, 2008. owners may contact k2 motor at 1-909-839-2992.
- Notes:
- This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles manufactured by honda, ford, or chrysler llc. customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 09E012000 on 04/06/2009
- Component:
- Exterior lighting
- Affected:
- 16,270
- Defect:
- Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
- Consequence:
- Decreased lighting visibility may result in a vehicle crash.
- Correction:
- Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on may 11, 2009. owners may contact sabersport at 1-909-598-7589.
- Notes:
- This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by sabersport.the list can be found under "document search" located at the bottom of your screen.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
- Campaign:
- 09E025000 on 05/10/2009
- Component:
- Exterior lighting:headlights
- Affected:
- 42,540
- Defect:
- Dope, inc. is recalling 42,540 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. these headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
- Consequence:
- Decreased lighting visibility may result in a vehicle crash.
- Correction:
- Dope, inc. will notify owners and offer a full refund for the noncompliant combination lamps. the safety recall began on july 28, 2009. owners may contact dope, inc. at 1-626-272-1798.
- Notes:
- This recall only pertains to aftermarket replacement equipment and has no relation to any original equipment installed on vehicles produced by the vehicle manufacturer.in order to determine if your aftermarket lamp assembly is affected by this noncompliance, please review the list of model numbers provided to us by dope, inc.the list can be found under "document search" located at the bottom of your screen. owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
1999 DODGE RAM TSBs (117)
- Bulletin:
- 050498
- Component:
- 034300 service brakes, hydraulic:foundation components:differential proportional valve
- Summary:
- Vehicles listed on this bulletin are eqipped with rear height sensing proportioning valve that adjust brake pressure to the rear brakes based upon distance between frame and rear axle. *ak
- Bulletin:
- 020898
- Component:
- 021000 suspension:front
- Summary:
- A knocking noise may be heard in the front suspension when the steering wheel is rotated to the full left or right steering positions. *yc
- Bulletin:
- 233798
- Component:
- 162000 structure:body
- Summary:
- Subject on cargo net eliminated from production. *yc
- Bulletin:
- 233598
- Component:
- 162300 structure:body:door
- Summary:
- When removing door trim panel from the door, it is extremely important that each individual plastic retainer clip is separated from door by using atrim panel removal too, such as snap on tool a161b/door panels should never be removed by h
- Bulletin:
- 9844
- Component:
- 112000 electrical system:alternator/generator/regulator
- Summary:
- Approximately 3800 1999 dodge truck rams built in mexico may have a generator with a suspect solder connection in the brush holder assembly. if solder connection opens, generator field circuit opens, causing generator to malfunction. *ak
- Bulletin:
- 211098
- Component:
- 103000 power train:automatic transmission
- Summary:
- Conditions with loss of fifth gear. *yc
- Bulletin:
- 090498
- Component:
- 061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
- Summary:
- Some vehicles may exhibit a condition where the accesory drive belt becomes damaged on the inboard edge. *yc
- Bulletin:
- 085198
- Component:
- 110000 electrical system
- Summary:
- Subject pertaining to compass mini trip computer indicates erroneous average miles per gallon, distance to empty, and/ or trip odometer. *yc
- Bulletin:
- 130298
- Component:
- 162000 structure:body
- Summary:
- Information regarding vehicles with adjustable front fascia. *yc
- Bulletin:
- 235898
- Component:
- 162000 structure:body
- Summary:
- Vehicles may exhibit a condition where a windnoise whistle occurs from the front of the vehicle. *yc
- Bulletin:
- #9865
- Component:
- 110000 electrical system
- Summary:
- Subject on compass mini trip computer may display inaccurate distanc to empty readings after the compass mini trip computer is replaced. *yc
- Bulletin:
- 250298
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Subject regarding i/m ( inspection maintenance ) testing - obd ii "carb" readiness monitor information. *yc
- Bulletin:
- 234598
- Component:
- 980000 unknown or other
- Summary:
- Approval of using of in- transit protective film. on all vehicles at all assembly plants. *ak
- Bulletin:
- 070898
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Conditions with diesel engine overheating. *yc
- Bulletin:
- 070998
- Component:
- 062200 engine and engine cooling:cooling system:fan
- Summary:
- Subject on viscous fan drive service. *yc
- Bulletin:
- 085498
- Component:
- 110000 electrical system
- Summary:
- Conditions with static in side speakers and / or side speaker cuts on when power outside mirror operates. *yc
- Bulletin:
- 183598
- Component:
- 116000 electrical system:ignition
- Summary:
- Exhibiting mil illumination with dtc $ 12 (p0443) - evaporative purge solenoid circuit failure, can be caused by electrical noise generated through the ignition switch. *ak
- Bulletin:
- 183698
- Component:
- 180000 vehicle speed control
- Summary:
- Some vehicles may exhibit an idle undershoot or die out during engine starting and may be caused by iac lost steps. *ak
- Bulletin:
- 183898
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles may exhibit intermittent poor driveability during steady state highway driving. *yc
- Bulletin:
- 183798
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- some consumers that inadvertently flood their engines during starting may try to perform a clear flood procedure to help start their vehicles. *ak
- Bulletin:
- 184898
- Component:
- 116000 electrical system:ignition
- Summary:
- Subject regarding ignition system cross fire/ secondary ignition wire induction. *ak
- Bulletin:
- 184998
- Component:
- 105000 power train:driveline
- Summary:
- Driveline induced vehicle surge / vibration diagnosis. *ak
- Bulletin:
- 211598
- Component:
- 103000 power train:automatic transmission
- Summary:
- Some vehicles may exhibit what looks to be a transmission front pump seal leak due to wetness around the lower edge of the bell housings. *yc
- Bulletin:
- 211698
- Component:
- 103000 power train:automatic transmission
- Summary:
- Revised front band adjustment for 42re transmissions. *yc
- Bulletin:
- #9844
- Component:
- 112000 electrical system:alternator/generator/regulator
- Summary:
- Concerns about inoperative generators. *yc
- Bulletin:
- 210399
- Component:
- 102000 power train:manual transmission
- Summary:
- A condition may exist where the transmission is difficult / grinds while shifting into first gear and/or pops out of first gear. *tt
- Bulletin:
- 180299
- Component:
- 103700 power train:automatic transmission:torque converter
- Summary:
- Subject regarding erratic torque converter clutch (tcc) operation. *tt
- Bulletin:
- 9906
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- Service action regarding ethylene glycol concentration too low in engine coolant mixture. *tt
- Bulletin:
- 230899
- Component:
- 980000 unknown or other
- Summary:
- Exhibiting creaks or squeaks near the left and / or right side of the instrument panel. *tt
- Bulletin:
- 080699
- Component:
- 110000 electrical system
- Summary:
- Customer may complain of intermittent poor reception on two-way radio. *tt
- Bulletin:
- 180799
- Component:
- 980000 unknown or other
- Summary:
- Exhibiting erroneous malfunction indicator lamp illumination with diagnostic trouble code $a8 (p1763) governor pressure sensor volts too high. *tt
- Bulletin:
- 180899
- Component:
- 180000 vehicle speed control
- Summary:
- Some customers may complain that their vehicle speed cotnrol system may be too busy or drift more than 2 mph below or above the initial vehicle set speed. *tt
- Bulletin:
- 210899
- Component:
- 103000 power train:automatic transmission
- Summary:
- Vehicles exhibiting buzz, whining, or moaning like noise from cold transmission when reverse gear is selected. *tt
- Bulletin:
- 050499
- Component:
- 020000 suspension
- Summary:
- Under certain road conditions, most vehicles will move to the right or left uncontrolled by the driver. *tt
- Bulletin:
- 9923
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Conditions may exist where oil seepage past the engine oil filter adapter plate gasket. *tt
- Bulletin:
- 180999
- Component:
- 110000 electrical system
- Summary:
- Information pertaining to common diagnostic trouble codes caused by an open fuse. *tt
- Bulletin:
- 081799
- Component:
- 353000 equipment:electrical
- Summary:
- Information regarding compass mini-trip computers which no longer need calibration during new vehicle preparation. *tt
- Bulletin:
- 081699
- Component:
- 980000 unknown or other
- Summary:
- Conditions with inoperative or intermittent remote keyless entry (rke) transmitter. *tt
- Bulletin:
- 081699A
- Component:
- 980000 unknown or other
- Summary:
- Conditions with inoperative or intermittent remote keyless entry (rke) transmitter. *tt
- Bulletin:
- 050799
- Component:
- 034000 service brakes, hydraulic:foundation components
- Summary:
- Brief information on the use of asbestos fiber brake linings. *tt
- Bulletin:
- 050699
- Component:
- 034000 service brakes, hydraulic:foundation components
- Summary:
- Information regarding accelerated brake lining wear, front versus rear. *tt
- Bulletin:
- 190399
- Component:
- 010000 steering
- Summary:
- Conditions with steering slow to return to center. *tt
- Bulletin:
- 190499
- Component:
- 010000 steering
- Summary:
- Customers may complain that the steering system feels heavy or the steering wheel is not centered while driving on a straight road. *tt
- Bulletin:
- 020699
- Component:
- 021600 suspension:front:wheel bearing
- Summary:
- Subject on the front wheel bearing grease is evident on the bearing seal area. *tt
- Bulletin:
- 181299
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- This bulletin explains the operation and application of the leak detection pump (ldp) monitor test. *tt
- Bulletin:
- 181199
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Experiencing slow acceleration or lack of power while towing or hauling a heavy load. *tt
- Bulletin:
- 250199
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Experiencing a knocking or tapping like noise from the engine compartment. *tt
- Bulletin:
- 021399
- Component:
- 022140 suspension:rear:springs:leaf spring assembly
- Summary:
- Experiencing squeaking noise from rear leaf springs. *tt
- Bulletin:
- 090699
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Subject regarding spark knock and engine oil consumption due to intake manifold pan gasket oil leak. *tt
- Bulletin:
- 182199
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Subject regarding 5.9l - 24v cummins diesel low power or poor performance diagnostic. *tt
- Bulletin:
- 233599
- Component:
- 220000 seats
- Summary:
- Information on child seat tether anchors. *tt
- Bulletin:
- 020699
- Component:
- 021600 suspension:front:wheel bearing
- Summary:
- On some vehicles the front wheel bearings may incorrectly be diagnosed as faulty due to the evidence of wheel bearing grease on the bearing seal areas. *tt
- Bulletin:
- 081698
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Information on installation of radio transmitting equipment. *ak
- Bulletin:
- 183298
- Component:
- 162000 structure:body
- Summary:
- Subject on flash programming failure recovery. *yc
- Bulletin:
- 080699A
- Component:
- 110000 electrical system
- Summary:
- Customers may complain of radio interference to / from two way radio receivers. *tt
- Bulletin:
- 084299
- Component:
- 090000 fuel system, other
- Summary:
- A condition with the fuel gauge reading full for an excessive period of time. *tt
- Bulletin:
- 020699A
- Component:
- 020000 suspension
- Summary:
- This bulletin mentions that the front wheel bearing grease is evident on the bearing seal area. *tt
- Bulletin:
- 182599
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Information on erroneous engine miss while performing diagnostics with the diagnostic scan tool (drb iii). *tt
- Bulletin:
- 210100
- Component:
- 103000 power train:automatic transmission
- Summary:
- Subject pertains to intermittent harsh engagement into reverse gear on certain re model transmissions. *tt
- Bulletin:
- 180100
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Subject regarding misdiagnosed leak detection pump systems with diagnostic trouble codes p1494, p0442 p0455, or p0456. *tt
- Bulletin:
- 080600
- Component:
- 114000 electrical system:wiring
- Summary:
- This bulletin provides a revised wire splice procedure and related parts. *tt
- Bulletin:
- 084499
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Experiencing intermittent operation / static in any or all speakers. *tt
- Bulletin:
- 090200
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- A customer may complain of a heavy oil or fuel-like odor coming from the engine compartment. *tt
- Bulletin:
- 090500
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Experiencing spark knock and engine oil consumption due to intake manifold pan gasket oil leak. *tt
- Bulletin:
- 084399
- Component:
- 110000 electrical system
- Summary:
- Subject regarding central timer module software update when a wiper module is replaced. *tt
- Bulletin:
- 020400
- Component:
- 022140 suspension:rear:springs:leaf spring assembly
- Summary:
- Some customers may comment on a squeaking / clicking noise from rear leaf springs. *tt
- Bulletin:
- 030200
- Component:
- 022000 suspension:rear
- Summary:
- Subject pertains to 9.25 axle gear marking compound causing a milky-life appearance to the axle fluid. *tt
- Bulletin:
- 080800
- Component:
- 980000 unknown or other
- Summary:
- Concerns with an inoperative or intermittent remote keyless entry (rke) transmitter. *tt
- Bulletin:
- 210200
- Component:
- 103000 power train:automatic transmission
- Summary:
- Some customers may experience a condition where the transmission may seen to have a delayed 3-4 upshift, while moderately accelerating from 30 to 50 mph. *tt
- Bulletin:
- 030699
- Component:
- 106000 power train:axle assembly
- Summary:
- Subject on the vehicle experiencing low speed squeak-like sound coming from the front axle, vehicle's equipped with a 216 fbi (dana m44) front axle and four wheel drive. *mjs
- Bulletin:
- 083299
- Component:
- 110000 electrical system
- Summary:
- Vehicles may experience radio interference to/from two-way radio receivers. *mjs
- Bulletin:
- 233599REVA
- Component:
- 162000 structure:body
- Summary:
- Subject on the child seat tether anchors. *mjs
- Bulletin:
- 081600
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Concerns with a buzz noise coming from the front door speaker(s). *tt
- Bulletin:
- 090700
- Component:
- 075000 fuel system, gasoline:carburetor system
- Summary:
- Subject pertaining to air filter service. *tt
- Bulletin:
- 140300
- Component:
- 070000 fuel system, gasoline
- Summary:
- Subject regarding maintenance to the water-in-fuel sensor probes due to possible fuel contamination. *tt
- Bulletin:
- 082300
- Component:
- 110000 electrical system
- Summary:
- Subject regarding plastic boot to protect the electrical harness b+ end terminal at the generator. *tt
- Bulletin:
- 180600
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Subject regarding 1999 model year engine spark knock. *tt
- Bulletin:
- 030800
- Component:
- 106000 power train:axle assembly
- Summary:
- ;subject regarding rtv use on corporate axle. *tt
- Bulletin:
- 082400
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- On some vehicles the engine cranks but does not start or starts and stalls. *tt
- Bulletin:
- 210800
- Component:
- 103700 power train:automatic transmission:torque converter
- Summary:
- Some customers may experience a delayed torque converter clutch engagement (lock-up). this condition may illuminate the malfunction indicator lamp due to diagnostic trouble code p1740 - tcc or o/d solenoid performance. *tt
- Bulletin:
- 233400
- Component:
- 132000 visibility:glass, side/rear
- Summary:
- Subject regarding outside mirror glass replacement. *tt
- Bulletin:
- 181500
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Customers may complain of poor driveability when winter fuel is used to power the engine and / or a no start hot engine restart condition when using any type of good quality diesel fuel. *tt
- Bulletin:
- 180600B
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicle engines may exhibit a light-to-moderate spark knock condition during acceleration (under load). *tt
- Bulletin:
- 180600A
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicle engines may exhibit a light-to-moderate spark knock condition during acceleration (under load). *tt
- Bulletin:
- 2300800B
- Component:
- 220000 seats
- Summary:
- Subject regarding child seat tether anchors. *tt
- Bulletin:
- 180600C
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicle engines may exhibit a light to moderate spark knock condition during acceleration (under load). *tt
- Bulletin:
- 2303400A
- Component:
- 135000 visibility:rearview mirrors/devices
- Summary:
- Subject regarding outside mirror glass replacement. *tt
- Bulletin:
- 0800600REV
- Component:
- 110000 electrical system
- Summary:
- Subject regarding wire splice repairs. *sb
- Bulletin:
- 0200101
- Component:
- 020000 suspension
- Summary:
- Some customers may experience a situation in which the rear of the vehicle sits too high to attach their fifth wheel or goose neck trailer to the trailer hitch turnable. *jb
- Bulletin:
- 1801500A
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Customer may complain of poor driveability when winter fuel is used to power the engine. or, the customer may complain of a hard or no-start condition, while the engine is at normal operating temperatures, when using any type of good qual
- Bulletin:
- 0900201
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Vehicles that are used for extended heavy trailer hauling purposes may experience a loss of exhaust manifold bolt torque. *tt
- Bulletin:
- 1801201
- Component:
- 350000 equipment
- Summary:
- Subject regarding generic scan tool (gst), publication no. 81-170-00008 provided with this technical service bulletin to provide reference information when using generic scan tool on obdii vehicles. *tt
- Bulletin:
- 2500401
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Subject regarding additional diagnostic for diagnostic trouble codes caused by an evaporative system leak. *tt
- Bulletin:
- 2600401
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding service / diagnostic manual revisions. *tt
- Bulletin:
- 0801301
- Component:
- 110000 electrical system
- Summary:
- Subject regarding radio connector repair kit. *tt
- Bulletin:
- 1801401
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Subject regarding performance enhancements, hard starting and / or idle speed fluctuations for severe cold weather environments. *tt
- Bulletin:
- 2100601
- Component:
- 103000 power train:automatic transmission
- Summary:
- Automatic transmission fluid usage atf+4. *tt *mj
- Bulletin:
- 0900601
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Vehicles may experience oil pan gasket leaks.*slc
- Bulletin:
- 1801901
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles may experience cold idle engine warming *slc
- Bulletin:
- 2302701
- Component:
- 135200 visibility:rearview mirrors/devices:exterior
- Summary:
- Subject regarding outside rearview mirror glass replacement. *tt
- Bulletin:
- 0900401
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Customer may complain of high oil consumption, grey oil smoke coming out of the exhaust or breather tube, or mechanical knocking. *tt
- Bulletin:
- 1800402
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Subject regarding 1999 my engine spark knock. *tt
- Bulletin:
- 1803001
- Component:
- 100000 power train
- Summary:
- Subject regarding 46re shift quality and durability improvements. *tt
- Bulletin:
- 1800602C
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Subject regarding flash: surge (beaming), lack of power in 3rd gear, and no 3/4 upshift after 4/3 downshift. *slc
- Bulletin:
- 0900202
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Subject regarding crankcase breather overflow. *slc
- Bulletin:
- 2301502
- Component:
- 135200 visibility:rearview mirrors/devices:exterior
- Summary:
- Subject regarding outside rearview mirror glass replacement. *slc
- Bulletin:
- 0800702
- Component:
- 110000 electrical system
- Summary:
- Subject regarding remote keyless entry programming procedures. *slc
- Bulletin:
- 1801902A
- Component:
- 980000 unknown or other
- Summary:
- Revision of flash process for new engine control module (ecm) from cummins. *slc this bulletin supersedes bulletin 18-019-02 dated june 17, 2002. *tt
- Bulletin:
- 1802002
- Component:
- 980000 unknown or other
- Summary:
- Flash programming failure recovery. *slc
- Bulletin:
- 2100202
- Component:
- 103000 power train:automatic transmission
- Summary:
- Subject regarding revision in diagnostic procedures and labor operation times for re transmissions. *tt
- Bulletin:
- 1400202A
- Component:
- 070000 fuel system, gasoline
- Summary:
- Information on tampering with vp44 fuel pump on cummins diesel engine. *tt
- Bulletin:
- 1400202
- Component:
- 070000 fuel system, gasoline
- Summary:
- Information on tampering with vp44 fuel pump on cummins diesel engines. *tt
- Bulletin:
- 0900802
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Engine knock or rattle sound when climbing a long grade and towing a heavy trailer. *tt
- Bulletin:
- 1803003
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Generic cummins engine control module (pcm) procedure. *tt
- Bulletin:
- 1803003A
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Generic cummins engine control module (pcm) procedure. *tt this bulletin replaced 18-030-03. *tt this bulletin replaced 18-030-03a dated 10/17/03. to also include 2005 ram truck. *tt
- Bulletin:
- 1100605
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Illuminated mil as the result of a diagnostic trouble code (dtc) p0420 - catalyst efficiency, or may have failed a california smog or state i/m test but without an illuminated mil, or a rattling sound from the underside of the vehicle. cat
- Bulletin:
- 0601
- Component:
- 103700 power train:automatic transmission:torque converter
- Summary:
- Catalytic converter warranty coverage customer reminder letter. *tt
Home | Privacy