1999 DODGE DURANGO Recalls (5)
- Campaign:
- 99V342000 on 12/06/1999
- Component:
- Fuel system, gasoline:storage:tank assembly:mounting
- Manufactured:
- 08/26/1997 - 09/24/1998
- Affected:
- 150,729
- Defect:
- Vehicle description: sport utility vehicles. the fuel tank strap can separate due to fatigue during operation. if this occurs, the tank will be unsupported, increasing the risk of a fuel leak.
- Consequence:
- Fuel leakage, in the presence of an ignition source, could result in a fire.
- Correction:
- Dealers will replace the double toggle lock fuel tank straps with single toggle lock design. note: affected vehicles built through may 21, 1998, also require the rear brake tube inspection/repair. as a result, the fuel tank strap and brake tube repair will be performed on these vheicles in a single service procedure under recall 99v-341/daimlerchrysler #841. affected vehicles built from may 22, 1998 through september 25, 1999, only require the fuel tank strap repair, which will be performed under recall 99v-342/daimlerchrysler #842.
- Notes:
- Owner notification began february 7, 2000. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1-800-992-1997.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 01V119000 on 04/23/2001
- Component:
- Seat belts:front:retractor
- Manufactured:
- 12/05/1998 - 01/14/1999
- Affected:
- 161,682
- Defect:
- Vehicle description: certain van, wagon, pickup trucks, passenger and sport utility vehicles, fail to comply with requirements of fmvss no. 209, "seat belt assemblies." the front seat belt retractor may not comply with the requirements of the standard.
- Consequence:
- If the retractor does not work properly, it will not adequately protect occupants in the event of a crash.
- Correction:
- Dealers will replace the seat belt retractor. owner notification began august 20, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1-800-853-1403.
- Notes:
- Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 01V153000 on 05/17/2001
- Component:
- Air bags
- Manufactured:
- 05/29/2000 - 10/30/2000
- Affected:
- 216,100
- Defect:
- Vehicle description: pickup trucks. sound deadener material inside the steering wheel could become detached from the cover and housing. note: the ram pickup trucks were built at the warren assembly plant ("s" in the 11th vin position) from may 16, 2000 through october 23, 2000; st. louis north assembly plant ("j" in the 11th vin position) from may 19, 2000 through october 23, 2000; lago alberto assembly plant ("m" in the 11th vin position) from may 23, 2000 through october 23, 2000; and saltillo assembly plant ("g" in the 11th vin position) from may 23, 2000 through october 23, 2000. important: vehicles that have already had the proper clockspring installed, according to warranty records, have been excluded from this recall. in addition, 1997-2000 model year vehicles that have had a suspect replacement clockspring installed, according to warranty records, have been added to this recall.
- Consequence:
- When this occurs, the material could interfere with the clockspring ribbon and cause an open circuit. the driver air bag system will become disabled, and the air bag warning lamp will illuminate on the instrument panel.
- Correction:
- Dealers will replace the clockspring assembly. owner notification began june 18, 2001. also some 1997-200 model year vehicles that, according to warranty records, have had a suspect replacement clockspring installed, will also be included in this campaign. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1-800-853-1403.
- Notes:
- Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 06E024000 on 03/16/2006
- Component:
- Engine and engine cooling
- Affected:
- 44,386
- Defect:
- Certain replacement k&n fuel performance kits, p/nos. 57-1509, 57-1511, 57-1511-1, 57-1517, 57-1517-1, 57-1527, and 57-1530. also, a small percentage of these kits were sold under the mopar performance parts brand name (p/nos. p5007069 and p5007070). all kits were manufactured from april 20, 1999, through september 23, 2004. these assemblies were manufactured as replacement equipment for certain dodge pickup trucks and suvs. a small piece of material from the tube wall could be sucked into the engine throttle body, which could cause the throttle to become jammed in the open position.
- Consequence:
- A jammed open throttle could cause unintended acceleration of the vehicle, possibly resulting in a crash or increased stoping distances when braking.
- Correction:
- K&n will provide owners with a free repair kit along with repair instructions. the recall began on april 20, 2006.
- Notes:
- This recall only pertains to replacement k&n fuel performance kits and has no relation to any original equipment installed on dodge vehicles manufactured by daimlerchrysler.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 08E064000 on 10/19/2008
- Component:
- Suspension:front:hub
- Affected:
- 2,805
- Defect:
- Skf is recalling 2,805 hub units, part no. br930361, sold as a service part for 1997-2004 dodge dakota vehicles and 1999-2003 dodge durango vehicles equipped with 2-wheel drive & rear axle abs. due to a specification error, the rotor pilot for the hub unit may be too long. this results in the wheel to not be seated fully against the hub flange face during mounting.
- Consequence:
- Improper seating of the wheel can result in excessive vibration, brake rotor noise, difficulty removing the wheel after installation and operation of the vehicle, and possibly wheel-end separation during vehicle operation. should wheel-end separation occur, the driver could loose control of the vehicle, possibly resulting in a crash.
- Correction:
- Skf will notify owners and replace the defective hub units free of charge. the recall began on november 5, 2008. owners may contact skf vsm north america customer service at 1-800-644-8999.
- Notes:
- Skf's recall no. skf pro 08-029us/ca.this recall only pertains to aftermarket skf hub units and has no relation to any original equipment installed on dodge dakota or durango vehicles manufactured by chrysler.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
1999 DODGE DURANGO TSBs (88)
- Bulletin:
- 070598
- Component:
- 062200 engine and engine cooling:cooling system:fan
- Summary:
- Experiencing engine cooling fan noises. *yc
- Bulletin:
- 070798
- Component:
- 062000 engine and engine cooling:cooling system
- Summary:
- engine overheating in high ambient temperatures.*ak
- Bulletin:
- 241698
- Component:
- 138000 visibility:defroster/defogger system
- Summary:
- Subject regarding rear overhead air conditioning performance testing. *yc
- Bulletin:
- 235198
- Component:
- 220000 seats
- Summary:
- Concerns about left front leather seat side shield chafing the seat cover. *ak
- Bulletin:
- 250298
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Subject regarding i/m ( inspection maintenance ) testing - obd ii "carb" readiness monitor information. *yc
- Bulletin:
- 234598
- Component:
- 980000 unknown or other
- Summary:
- Approval of using of in- transit protective film. on all vehicles at all assembly plants. *ak
- Bulletin:
- 021198
- Component:
- 020000 suspension
- Summary:
- Information on alignment specifications. *yc
- Bulletin:
- 050598
- Component:
- 034500 service brakes, hydraulic:foundation components:disc
- Summary:
- Brake grind or growl sound coming from the front brakes during low speed braking. *ak
- Bulletin:
- 085298
- Component:
- 120000 exterior lighting
- Summary:
- Information regarding the fog lamp service. *yc
- Bulletin:
- 183598
- Component:
- 116000 electrical system:ignition
- Summary:
- Exhibiting mil illumination with dtc $ 12 (p0443) - evaporative purge solenoid circuit failure, can be caused by electrical noise generated through the ignition switch. *ak
- Bulletin:
- 183698
- Component:
- 180000 vehicle speed control
- Summary:
- Some vehicles may exhibit an idle undershoot or die out during engine starting and may be caused by iac lost steps. *ak
- Bulletin:
- 183798
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- some consumers that inadvertently flood their engines during starting may try to perform a clear flood procedure to help start their vehicles. *ak
- Bulletin:
- 184898
- Component:
- 116000 electrical system:ignition
- Summary:
- Subject regarding ignition system cross fire/ secondary ignition wire induction. *ak
- Bulletin:
- 081798
- Component:
- 145000 air bags:on-off switch assembly
- Summary:
- Subject regarding airbag on - off switches. *yc
- Bulletin:
- 211698
- Component:
- 103000 power train:automatic transmission
- Summary:
- Revised front band adjustment for 42re transmissions. *yc
- Bulletin:
- 240599
- Component:
- 138000 visibility:defroster/defogger system
- Summary:
- Subject regarding rear a/c unit blows warm air when ambient temperatures are high. *tt
- Bulletin:
- 230299
- Component:
- 980000 unknown or other
- Summary:
- Customer may comment that the center armrest lid rattles. *tt
- Bulletin:
- 050399
- Component:
- 034000 service brakes, hydraulic:foundation components
- Summary:
- Information regarding front brake caliper mounting to steering knuckle thread repair. *tt
- Bulletin:
- 9912
- Component:
- 355100 equipment:other:labels
- Summary:
- Subject regarding incorrect axle ratio information on the monroney label. *tt
- Bulletin:
- 180799
- Component:
- 980000 unknown or other
- Summary:
- Exhibiting erroneous malfunction indicator lamp illumination with diagnostic trouble code $a8 (p1763) governor pressure sensor volts too high. *tt
- Bulletin:
- 210899
- Component:
- 103000 power train:automatic transmission
- Summary:
- Vehicles exhibiting buzz, whining, or moaning like noise from cold transmission when reverse gear is selected. *tt
- Bulletin:
- 231299
- Component:
- 162000 structure:body
- Summary:
- Concerns with center console / armrest cover will not latch. *tt
- Bulletin:
- 240499
- Component:
- 353600 equipment:air conditioner
- Summary:
- Information on leak detection dye added to the air conditioning system. *tt
- Bulletin:
- 9923
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Conditions may exist where oil seepage past the engine oil filter adapter plate gasket. *tt
- Bulletin:
- 180999
- Component:
- 110000 electrical system
- Summary:
- Information pertaining to common diagnostic trouble codes caused by an open fuse. *tt
- Bulletin:
- 081699
- Component:
- 980000 unknown or other
- Summary:
- Conditions with inoperative or intermittent remote keyless entry (rke) transmitter. *tt
- Bulletin:
- 030499
- Component:
- 105000 power train:driveline
- Summary:
- Conditions with differential gear lubricant weeping from the front differential vent. *tt
- Bulletin:
- 081699A
- Component:
- 980000 unknown or other
- Summary:
- Conditions with inoperative or intermittent remote keyless entry (rke) transmitter. *tt
- Bulletin:
- 241199
- Component:
- 353600 equipment:air conditioner
- Summary:
- Subject on air conditioner cooling performance deteriorating after a few minutes of operation. *tt
- Bulletin:
- 020599
- Component:
- 020000 suspension
- Summary:
- Experiencing squeaking or creaking from front wheel area at low speeds. *tt
- Bulletin:
- 020699
- Component:
- 021600 suspension:front:wheel bearing
- Summary:
- Subject on the front wheel bearing grease is evident on the bearing seal area. *tt
- Bulletin:
- 181299
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- This bulletin explains the operation and application of the leak detection pump (ldp) monitor test. *tt
- Bulletin:
- 9912A
- Component:
- 106000 power train:axle assembly
- Summary:
- Supplemental information regarding repair procedure change for vehicles with an incorrect axle ratio identified on the monroney label. *tt
- Bulletin:
- 090699
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Subject regarding spark knock and engine oil consumption due to intake manifold pan gasket oil leak. *tt
- Bulletin:
- 241999
- Component:
- 353600 equipment:air conditioner
- Summary:
- Subject regarding air conditioning performance. *tt
- Bulletin:
- 233599
- Component:
- 220000 seats
- Summary:
- Information on child seat tether anchors. *tt
- Bulletin:
- 020699
- Component:
- 021600 suspension:front:wheel bearing
- Summary:
- On some vehicles the front wheel bearings may incorrectly be diagnosed as faulty due to the evidence of wheel bearing grease on the bearing seal areas. *tt
- Bulletin:
- 081698
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Information on installation of radio transmitting equipment. *ak
- Bulletin:
- 183298
- Component:
- 162000 structure:body
- Summary:
- Subject on flash programming failure recovery. *yc
- Bulletin:
- 233299
- Component:
- 162000 structure:body
- Summary:
- Concerns with the center console / armest lid hinge being bent. *tt
- Bulletin:
- 242099A
- Component:
- 138000 visibility:defroster/defogger system
- Summary:
- A condition may occur while in bi-level mode, air flow from panel vents is less than that of the floor vents. *tt
- Bulletin:
- 020699A
- Component:
- 020000 suspension
- Summary:
- This bulletin mentions that the front wheel bearing grease is evident on the bearing seal area. *tt
- Bulletin:
- 235299
- Component:
- 131000 visibility:windshield
- Summary:
- Subject regarding a squeak heard coming from the window area as the window is rolled down. *tt
- Bulletin:
- 182599
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Information on erroneous engine miss while performing diagnostics with the diagnostic scan tool (drb iii). *tt
- Bulletin:
- 083799
- Component:
- 145000 air bags:on-off switch assembly
- Summary:
- Daimlerchrysler corporation is now offerinb airbag on / off switches for selected vehicles. *tt
- Bulletin:
- 070399
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles may experience a high engine temperature condition. *tt
- Bulletin:
- 021599
- Component:
- 020000 suspension
- Summary:
- Experiencing a squeak noise coming from rear leaf spring. *tt
- Bulletin:
- 180100
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Subject regarding misdiagnosed leak detection pump systems with diagnostic trouble codes p1494, p0442 p0455, or p0456. *tt
- Bulletin:
- 080600
- Component:
- 114000 electrical system:wiring
- Summary:
- This bulletin provides a revised wire splice procedure and related parts. *tt
- Bulletin:
- 090500
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Experiencing spark knock and engine oil consumption due to intake manifold pan gasket oil leak. *tt
- Bulletin:
- 081000
- Component:
- 110000 electrical system
- Summary:
- Experiencing a dead battery and / or ignition operated electrical accessories function with the ignition switch off. *tt
- Bulletin:
- 020500
- Component:
- 022140 suspension:rear:springs:leaf spring assembly
- Summary:
- Some customers may comment about a squeaking / clicking noise from rear leaf springs. *tt
- Bulletin:
- 030200
- Component:
- 022000 suspension:rear
- Summary:
- Subject pertains to 9.25 axle gear marking compound causing a milky-life appearance to the axle fluid. *tt
- Bulletin:
- 080700
- Component:
- 110000 electrical system
- Summary:
- Some vehicles may exhibit an erroneous malfunction indicator lamp due to diagnostic trouble code p0443 (purge ckt) and / or a possible key-off battery draw. *tt
- Bulletin:
- 080800
- Component:
- 980000 unknown or other
- Summary:
- Concerns with an inoperative or intermittent remote keyless entry (rke) transmitter. *tt
- Bulletin:
- 230800
- Component:
- 220000 seats
- Summary:
- Subject regarding child seat tether anchors. *tt
- Bulletin:
- 233599REVA
- Component:
- 162000 structure:body
- Summary:
- Subject on the child seat tether anchors. *mjs
- Bulletin:
- 242099
- Component:
- 138000 visibility:defroster/defogger system
- Summary:
- Subject regarding vehicles that experience while in bi-level mode, air flow from panel vents is less that that of the floor vents. *mjs
- Bulletin:
- 030800
- Component:
- 106000 power train:axle assembly
- Summary:
- ;subject regarding rtv use on corporate axle. *tt
- Bulletin:
- 082400
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- On some vehicles the engine cranks but does not start or starts and stalls. *tt
- Bulletin:
- 233400
- Component:
- 132000 visibility:glass, side/rear
- Summary:
- Subject regarding outside mirror glass replacement. *tt
- Bulletin:
- 180600B
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicle engines may exhibit a light-to-moderate spark knock condition during acceleration (under load). *tt
- Bulletin:
- 082700
- Component:
- 140000 air bags
- Summary:
- Subject regarding non-deployed airbag handling procedures. *tt
- Bulletin:
- 2300800B
- Component:
- 220000 seats
- Summary:
- Subject regarding child seat tether anchors. *tt
- Bulletin:
- 180600C
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicle engines may exhibit a light to moderate spark knock condition during acceleration (under load). *tt
- Bulletin:
- 2303400A
- Component:
- 135000 visibility:rearview mirrors/devices
- Summary:
- Subject regarding outside mirror glass replacement. *tt
- Bulletin:
- 0800600REV
- Component:
- 110000 electrical system
- Summary:
- Subject regarding wire splice repairs. *sb
- Bulletin:
- 0200600
- Component:
- 021510 suspension:front:control arm:upper arm
- Summary:
- Subject regarding upper control arm bushing service. *tt
- Bulletin:
- 2304000
- Component:
- 162300 structure:body:door
- Summary:
- Some vehicles may exhibit a rear door lock(s) that do not operate properly. *tt
- Bulletin:
- 0801001
- Component:
- 110000 electrical system
- Summary:
- Subject regarding airbag / clock spring service for various models including 2002 model year jeep liberty. *tt
- Bulletin:
- 1801201
- Component:
- 350000 equipment
- Summary:
- Subject regarding generic scan tool (gst), publication no. 81-170-00008 provided with this technical service bulletin to provide reference information when using generic scan tool on obdii vehicles. *tt
- Bulletin:
- 2500401
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Subject regarding additional diagnostic for diagnostic trouble codes caused by an evaporative system leak. *tt
- Bulletin:
- 2100601
- Component:
- 103000 power train:automatic transmission
- Summary:
- Automatic transmission fluid usage atf+4. *tt *mj
- Bulletin:
- 2600501
- Component:
- 980000 unknown or other
- Summary:
- This technical service bulletin contains both updated self-adhesive service and / or diagnostic manual pages and update pages. *tt
- Bulletin:
- 2302701
- Component:
- 135200 visibility:rearview mirrors/devices:exterior
- Summary:
- Subject regarding outside rearview mirror glass replacement. *tt
- Bulletin:
- 2401301
- Component:
- 353600 equipment:air conditioner
- Summary:
- Some vehicles may blow warm air out the instrument panel outlets while the a/c is on at idle. *tt
- Bulletin:
- 1800402
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Subject regarding 1999 my engine spark knock. *tt
- Bulletin:
- 1803001
- Component:
- 100000 power train
- Summary:
- Subject regarding 46re shift quality and durability improvements. *tt
- Bulletin:
- 1801802
- Component:
- 070000 fuel system, gasoline
- Summary:
- Subject regarding flash: nox emission failure when performing an asm type i/m emission test. *slc
- Bulletin:
- 2301502
- Component:
- 135200 visibility:rearview mirrors/devices:exterior
- Summary:
- Subject regarding outside rearview mirror glass replacement. *slc
- Bulletin:
- 0800702
- Component:
- 110000 electrical system
- Summary:
- Subject regarding remote keyless entry programming procedures. *slc
- Bulletin:
- 1801702
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding flash: malfunction indicator lamp illumination for injector circuit fault. *slc
- Bulletin:
- 1802002
- Component:
- 980000 unknown or other
- Summary:
- Flash programming failure recovery. *slc
- Bulletin:
- 2100202
- Component:
- 103000 power train:automatic transmission
- Summary:
- Subject regarding revision in diagnostic procedures and labor operation times for re transmissions. *tt
- Bulletin:
- 03004
- Component:
- 036000 service brakes, hydraulic:antilock
- Summary:
- Inoperative anti-lock brake system (abs) software reprogramming. advance service information #03-004. *tt
- Bulletin:
- 2401305
- Component:
- 353600 equipment:air conditioner
- Summary:
- Air conditioning (a/c) cooling coil odor. *tt
- Bulletin:
- 9002901
- Component:
- 100000 power train
- Summary:
- Part description: seal - shift shaft on rfe transmissions issue description: this seal (04799346) is replaceable with seal kit (68235551aa), which includes a seal and retainer. the seal kit is applicable to all (5)45rfe transmissions.
- Bulletin:
- 9002849
- Component:
- 160000 structure
- Summary:
- Part description: insulator on lever assy manual valve - valve body - rwd transmission issue description: the manual valve insulator, attaching rivet and instruction sheet are now available as a kit. if the insulator requires replacement
Home | Privacy