1998 WESTERN STAR 4900 Recalls (2)
- Campaign:
- 01V387000 on 01/01/2002
- Component:
- Electrical system:battery:cables
- Manufactured:
- 11/30/1998 - 02/09/2000
- Affected:
- 3,500
- Defect:
- On certain trucks equipped with caterpillar 3406e and c-15 engines, interference between the positive battery cable and stud mounting electronic control module (ecm) to the engine exists. chafing can wear through the battery cable insulation to allow contact between the battery cable and the stud.
- Consequence:
- This contact could provide a short circuit, which may cause a fire.
- Correction:
- Dealers will inspect the vehicles and the battery cables will be replaced and/or re-routed as necessary. owner notification began april 18, 2002. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner at 1-800-547-0712.
- Notes:
- Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 03V112000 on 03/25/2003
- Component:
- Suspension:front:hub
- Manufactured:
- 07/31/1998 - 02/27/2001
- Affected:
- 5,716
- Defect:
- On certain trucks equipped with truck hub units manufactured by skf exclusively for use on arvinmeritor's ff98x series non-drive steer axles, the hub unit bearings can wear prematurely.
- Consequence:
- Seizure of the bearings can cause wheel separation or wheel end fire.
- Correction:
- Dealers will replace both front hubs. owner notification is expected to begin on or before september 20, 2003. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner at 1-800-547-0712.
- Notes:
- Freightliner recall no. fl-407.customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
1998 WESTERN STAR 4900 TSBs (3)
- Bulletin:
- SB-49-12
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- Western star: around the diesel exhaust fluid (def) an excessive amount of crystal or powder built up indicates a leak caused by evaporation of def exposed to air and/or dampness. *pe
- Bulletin:
- SBW-4714
- Component:
- 070000 fuel system, gasoline
- Summary:
- Western star: fuel tanks rotating in saddles. anti-slip material may need to be installed, or an additional strip of rubber. *js
- Bulletin:
- 54-39
- Component:
- 110000 electrical system
- Summary:
- Western star: pyrometer thermocouple, ammeter shunt, fuel level, and other sensor inputs may be connected to the rx module. no model years were provided. *js
Home | Privacy