1998 THOMAS ER TRANSIT Recalls (6)
- Campaign:
- 98V229000 on 09/24/1998
- Component:
- Seats
- Manufactured:
- 03/31/1996 - 04/09/1998
- Affected:
- 4,300
- Defect:
- Vehicle description: school and transit buses equipped with national seating series 93b-sb driver seat. a bracket attaching to the height adjusting shock absorber on the driver's seat can deform and break.
- Consequence:
- This condition can result in a sudden drop of the driver's seat, increasing the risk of loss of control of the vehicle and a crash.
- Correction:
- Dealers will add a reinforcement to the bracket, or if the bracket is deformed and/or broken, the entire seat base will be replaced.
- Notes:
- Owner notification began december 7, 1998.owners who take their buses to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact thomas built at 1-336-841-5991.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 00V174000 on 06/29/2000
- Component:
- Exterior lighting:headlights:switch
- Manufactured:
- 11/30/1994 - 07/30/2000
- Affected:
- 803
- Defect:
- Certain school buses with weldon technologies' 5050-1400 surface mount marker lights have an option to replace each of the twelve clearance/marker/identification lights with four-candlepower lights, twice the candlepower normally used. the higher current demand created by these lights can cause excessive heat through the headlight switch connection if a relay is not installed between the combination tail/marker light circuit and the headlight switch.
- Consequence:
- This can result in deformation of the plastic connectors that connect the headlight switch to its wiring harness.
- Correction:
- Dealers will install a relay to reduce the current draw through the headlight switch. owner notification began september 8, 2000. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact thomas built at 1-336-881-7219.
- Notes:
- Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 00V232002 on 08/08/2000
- Component:
- Service brakes, air:antilock
- Manufactured:
- 02/12/1998 - 08/02/2000
- Affected:
- 35,405
- Defect:
- Vehicle description: heavy duty trucks and school bus chassis built with bendix air abs with an ec-17 1030r electronic control unit (ecu), there have been reports of unwanted abs activation at low speeds caused by 1) chafed abs wheel speed sensor wires on rotating parts or 2) a damaged component at the wheel end that generates a certain type of erratic sensor signal.
- Consequence:
- This condition could cause the abs ecu to exhaust the air at the air brake modulators for one or more of the wheels. this could result in extended braking distances and a possible crash.
- Correction:
- Dealers will replace the abs ecu.
- Notes:
- Owner notification began august 29, 2000, to school buses and emergency vehicle customers. owners of the remaining population were sent letters on september 9, 2000. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner at 1-800-547-0712.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 00V362000 on 11/05/2000
- Component:
- Seats
- Manufactured:
- 03/31/1996 - 09/29/2000
- Affected:
- 6,500
- Defect:
- Vehicle description: certain school buses and transit buses equipped with national seating's series 93b-sb driver seat. a bracket attaching the gas spring shock to the height adjuster of the seat can deform and break. this bracket is located at the top of the height adjuster.
- Consequence:
- If the bracket is not replaced after deforming, and is allowed to break, its breaking will result in a sudden drop of the driver's seat, increasing the risk of loss of control of the vehicle and a crash.
- Correction:
- Dealers will replace the seat base and add reinforcement to the seat assembly
- Notes:
- Owner notification began february 9, 2001.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact thomas built atalso contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 00V232011 on 11/28/2000
- Component:
- Service brakes, air:antilock
- Manufactured:
- 02/12/1998 - 08/02/2000
- Affected:
- 4,780
- Defect:
- Vehicle description: school bus chassis and emergency vehicles built with bendix air abs with an ec-17 1030r electronic control unit (ecu), there have been reports of unwanted abs activation at low speeds caused by 1) chafed abs wheel speed sensor wires on rotating parts or 2) a damaged component at the wheel end that generates a certain type of erratic sensor signal.
- Consequence:
- This condition could cause the abs ecu to exhaust the air at the air brake modulators for one or more of the wheels. this could result in extended braking distances and a possible crash.
- Correction:
- Dealers will replace the abs ecu.
- Notes:
- Owner notification began august 29, 2000, to school buses and emergency vehicle customers. owners of the remaining population were sent letters on september 9, 2000. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner at 1-800-547-0712.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 08V087000 on 02/26/2008
- Component:
- Structure:body:door:hinge and attachments
- Manufactured:
- 12/31/1993 - 03/09/2008
- Affected:
- 243,435
- Defect:
- Daimler trucks is recalling 243,435 my 1995-2008 thomas built school buses manufactured between january 1994, and march 10, 2008. (additional buses have been added to this recall campaign. please see supplemental report no. 4) the emergency exit door handle begins corroding around the securing roll pin and square drive mechanism causing the protective finish to chip and flake. continued corrosion and pitting weakens the handle. handles weakened by corrosion may break while trying to open the door from the exterior.
- Consequence:
- In the event of an emergency, a person on the outside of the bus may break the door handle trying to open the emergency exit potentially delaying evacuation and increasing the risk of personal injury to the vehicle's occupants.
- Correction:
- Daimler trucks will notify owners and will replace the handles with a more robust handle free of charge. repairs will be performed by thomas built buses dealerships. the recall began on august 18, 2008, and notification for the revised population is expected to begin on or about april 29, 2009. owners may contact thomas built at 336-889-4871.
- Notes:
- Daimler trucks recall no. fl-525.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Home | Privacy