1998 FORD E-150 Recalls (4)
- Campaign:
- 01V114000 on 04/22/2001
- Component:
- Fuel system, gasoline:storage:tank assembly
- Manufactured:
- 04/08/1996 - 11/13/2000
- Affected:
- 151,000
- Defect:
- Vehicle description: on certain vans with ambulance prep packages or other severe-duty applications involving operation at or near the gross vehicle weight with frequent twisting of the vehicle body, such as off-road, rough road or speed bump events, the 35 gallon mid-ship fuel tank could develop a crack where it contacts the frame cross member. if the fuel tank cracks, fuel leakage could occur.
- Consequence:
- Fuel leakage in the presence of an ignition source could result in a fire.
- Correction:
- Dealers will inspect the fuel tank and, if cracked, will replace the tank. insulator pads will be installed on all vehicles to reduce the stress levels in the fuel tank. owner notification began april 19, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.
- Notes:
- Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 07V336000 on 08/02/2007
- Component:
- Vehicle speed control
- Manufactured:
- 04/08/1996 - 08/01/2002
- Affected:
- 3,600,000
- Defect:
- On certain pickup trucks, passenger vehicles, sport utility vehicles, and motor homes chassis, the speed control deactivation switch may, under certain conditions, leak internally and then overheat, smoke, or burn.
- Consequence:
- This could result in an underhood fire.
- Correction:
- Dealers will install a fused wiring harness. owners of the passenger cars included in this campaign will be instructed to return their vehicles to their dealers to have the speed control deactivation switch disconnected as an interim repair. as soon as repair parts are available (expected october 2007), owners will be instructed to return to the dealers for installation of a fused wiring harness. the recall began on august 13, 2007, and mailing completed by september 19, 2007. owners may contact ford at 1-888-222-2751.
- Notes:
- Ford recall no. 05s28.customers may also contact the national highway traffic safety administration;s vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
- Campaign:
- 08V051000 on 02/03/2008
- Component:
- Vehicle speed control:cruise control
- Manufactured:
- 09/02/1991 - 09/14/2003
- Affected:
- 225,000
- Defect:
- Ford is recalling 225,000 my 1992-2003 econoline, my 1993-1995 taurus sho, my 1992-1998 crown victoria, my 1993 bronco, f-series, my 1995-1997 f-series super duty stripped chassis, my 1992-1998 mercury grand marquis, and my 1992-1995 lincoln town car vehicles. the affected vehicles were previously repaired using a wiring harness that is not compatible with the vehicle circuit polarity.
- Consequence:
- As a result, the fuse is located in the output circuit rather than in the intended input power feed circuit, and may not offer the intended protection in the event of an electrical short to ground.
- Correction:
- Dealers will install a new wiring harness, or replace the mating electrical component. the recall began on february 18, 2008. owners may contact ford at 1-800-392-3673.
- Notes:
- Ford recall no. 08s01.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
- Campaign:
- 09V399000 on 10/12/2009
- Component:
- Vehicle speed control
- Affected:
- 4,500,000
- Defect:
- Ford is recalling model years 1995-2003 windstar, 2000-2003 excursion diesel, 1993-1997 and 1999-2003 f-250 sd through f-550 sd diesel, 1992-2003 e-150 through e-550, 1995-2002 explorer, 1997 and 2002 mercury mountaineer, 1995-1997 and 2001-2003 ranger, and 1994 f53 vehicles equipped with the texas instruments speed control deactivation switch (scds). the scds may leak internally and then overheat, smoke, or burn.
- Consequence:
- A vehicle fire could occur with or without the engine running.
- Correction:
- Ford will notify owners that dealers will install a fused wiring harness in line with the scds. on 1999-2003 windstar vehicles with a leaking scds, dealers will also inspect the abs control module connector and repair as necessary. repairs will be completed free of charge. the safety recall began on october 27, 2009. owners may contact ford at 1-888-222-2751.
- Notes:
- Ford's recall campaign number is 09s09.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .
1998 FORD E-150 TSBs (60)
- Bulletin:
- BC0718961021
- Component:
- 034530 service brakes, hydraulic:foundation components:disc:rotor
- Summary:
- Information on brake rotor turning/replacing. *tt
- Bulletin:
- BC4651961001
- Component:
- 072100 fuel system, gasoline:delivery:fuel pump
- Summary:
- Vehicle may not start after being parked in below freezing temps. may be due to moisture freezing in the fuel pump relay contained within the ccrm (constant control relay module). *tt
- Bulletin:
- BC4854961001
- Component:
- 102000 power train:manual transmission
- Summary:
- Revised eec calibration has been incorporated in pcm calibration for vehicles which display lack of power due to torque converter engagement scheduling, catalytic converter failures, rough idle or hard start on hot restart. *tt
- Bulletin:
- BC5075961001
- Component:
- 162300 structure:body:door
- Summary:
- Information on erratic or self locking door locks. *tt
- Bulletin:
- BC5172961001
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Information for concerns of check engine light 'on' on 4.2l/4.6l/5.4l/6.8l vehicles. *tt
- Bulletin:
- BC5173961001
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- On various 4.0l applications the oil indicator tube (dip stick) is coming into contact w/ the crankshaft. *tt
- Bulletin:
- BC5174961001
- Component:
- 162300 structure:body:door
- Summary:
- Information to diagnose wind noise & water leaks at the lower passenger door area & 3rd door. *tt
- Bulletin:
- BC5175961001
- Component:
- 353600 equipment:air conditioner
- Summary:
- Concerns of a/c going to defrost mode when climbing grades or accelerating are likely caused by vacuum leaks. *tt
- Bulletin:
- BC5176961001
- Component:
- 072100 fuel system, gasoline:delivery:fuel pump
- Summary:
- Connection between the sender (9a299) & the fuel pump (9350) changed from the existing spade terminal to an eyelet terminal which is secured under the top sender mount screw. *tt
- Bulletin:
- BC5181961001
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Engine oil leak at the oil pan, front cover &/or the front & rear crankshaft oil seal. *tt
- Bulletin:
- BC5182961001
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Information on correcting an oil pan gasket leak. *tt
- Bulletin:
- BC5183961001
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- An oil leak in the area of the engine oil filter may be caused by a damaged or mis-installed (i.e. rolled over, pinched, sheared, nicked, etc.) oil pump body seal. *tt
- Bulletin:
- BC5185961001
- Component:
- 103000 power train:automatic transmission
- Summary:
- Vehicles may exhibit a grinding noise while shifting into 4l. *tt
- Bulletin:
- BC5186961001
- Component:
- 185000 vehicle speed control:cruise control
- Summary:
- Vehicles may experience an intermittent high idle after decel to a stop, when clutch pedal is depressed w/ no throttle movement. *tt
- Bulletin:
- BC5190961001
- Component:
- 114200 electrical system:wiring:interior/under dash
- Summary:
- Vehicles experiencing chafing on the 14401 wire harness causing the accessory fuses to become open (primarily the cigar fuse). *tt
- Bulletin:
- BC5198961001
- Component:
- 022400 suspension:rear:shock absorber
- Summary:
- Improved rear shock absorbers for customers who may experience a low tone rattling noise or whoosh sound from the rear of the vehicle while traveling less than 25 mph & going over small to moderate bumps. *tt
- Bulletin:
- BC5204961001
- Component:
- 116000 electrical system:ignition
- Summary:
- Concerns of check engine light (mil) w/codes p0300 thru p0308 & engine runs rough/misses may be due to a spark plug wire boot that is not fully seated on the spark plug. *tt
- Bulletin:
- BC5207961001
- Component:
- 110000 electrical system
- Summary:
- Information for servicing the electronic/hydraulic control unit (ehcu) on 4wabs. *tt
- Bulletin:
- BC5209961001
- Component:
- 034420 service brakes, hydraulic:foundation components:drum:shoes/linings
- Summary:
- Revised rear brake lining for both 9 inch & 10 inch applications for concerns w/ rear brake grab during the first few brake applications when the brakes are cold or in the morning after an overnight rain. *tt
- Bulletin:
- BC5214961001
- Component:
- 162800 structure:body:hood
- Summary:
- Revised hood seal for concerns of a wind whistle at speeds over 35 mph. *tt
- Bulletin:
- BC5217961001
- Component:
- 102000 power train:manual transmission
- Summary:
- Information on replaced/repaired manual transmission under warranty and returned w/ signs of improper/lack of maintenance or misdiagnosis. *tt
- Bulletin:
- BC5218961001
- Component:
- 198000 tires:temporary/emergency spare tire
- Summary:
- Information on stowing the spare tire stowage. *tt
- Bulletin:
- BC5224961001
- Component:
- 036100 service brakes, hydraulic:antilock:control unit/module
- Summary:
- Information on abs sensors returned for analysis are identified as 'no problem found'. *tt
- Bulletin:
- BC5227961001
- Component:
- 140000 air bags
- Summary:
- Information for air bag dtc b1813 observe the air bag lamp flash out code & perform the appropriate pinpoint test for the flash out code. *tt
- Bulletin:
- BC9642961001
- Component:
- 102000 power train:manual transmission
- Summary:
- Procedure for vehicles equipped with an aode or 4r70w transmission has a concern of shudder from the transmission torque converter clutch in 3rd or 4th gear or during 3-4 shift. *tt
- Bulletin:
- BC9668961001
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Concern for vehicles exhibiting lean codes p0171 & p0174 (vacuum leak). *tt
- Bulletin:
- BC9671961001
- Component:
- 063000 engine and engine cooling:exhaust system
- Summary:
- Push connection between the flexible fuel vapor line at the carbon canister & the metal fuel vapor line may not seat fully on the fuel vapor line. *tt
- Bulletin:
- BC9672961001
- Component:
- 051000 parking brake:conventional
- Summary:
- Procedure for brake warning indicator stays on red in cluster. *tt
- Bulletin:
- BC9673961001
- Component:
- 032100 service brakes, hydraulic:switches:brake light
- Summary:
- Procedure for brake exterior lights stay on (tail & high mount stop light). *tt
- Bulletin:
- BC9674961001
- Component:
- 106000 power train:axle assembly
- Summary:
- Light to moderate axle noise (axle whine) at 50 to 65 mph (80 to 105 kph) during accels, decels or cruise may be due to axle noise being transmitted from the axle into the vehicle. *tt
- Bulletin:
- BC9676961001
- Component:
- 075000 fuel system, gasoline:carburetor system
- Summary:
- Improper rtv application at the front/rear lower intake manifold end seals & side gaskets may cause an oil/coolant leak. *tt
- Bulletin:
- BC9680961001
- Component:
- 133000 visibility:power window devices and controls
- Summary:
- Concern where the door glass drops when cycled down on vehicles with the power door option. *tt
- Bulletin:
- BC9682961001
- Component:
- 011000 steering:wheel and handle bar
- Summary:
- Concerns for the labor time standard in tbs 96-19-02 (steering - grunt noise during steering wheel return from full right turn) is incorrect. *tt
- Bulletin:
- BC9694961001
- Component:
- 102000 power train:manual transmission
- Summary:
- Information on vehicles that may exhibit a slight delay in the first drive away after the vehicle has been parked overnight, or for a longer period of time. *tt
- Bulletin:
- BC9695961001
- Component:
- 138000 visibility:defroster/defogger system
- Summary:
- Electronic automatic temperature control (eatc) invalid diagnostic codes u1235 & 155 may be stored if the ignition switch is cycled from 'off' to 'run' extremely slowly. *tt
- Bulletin:
- 97090297183
- Component:
- 103100 power train:automatic transmission:control module (tcm, pcm)
- Summary:
- Experiencing difficulties with the malfunction indicator lamp (mil). *yc
- Bulletin:
- 980317
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Symptoms regarding p0300-p0308 misfire dtcs with 4.6l engines. *yc
- Bulletin:
- 982474
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles with the 4.2l engine may exhibit a vibration or boom, off idle between 870-900 rpms. *yc
- Bulletin:
- 976011
- Component:
- 070000 fuel system, gasoline
- Summary:
- Experiencing difficulty diagnosing vehicles with evaporative fuel system diagnostic trouble codes. *tt
- Bulletin:
- 99131
- Component:
- 060000 engine and engine cooling
- Summary:
- Concerns with engine coolant leaking into engine oil on some vehicles. *tt
- Bulletin:
- 99146
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Concerns with the oil dipstick and / or pcv valve dislodging from the engine and / or engine oil leaking from dipstick tube. *tt
- Bulletin:
- 99207
- Component:
- 060000 engine and engine cooling
- Summary:
- Subject on engine coolant leaking into the engine oil on some vehicles. *tt
- Bulletin:
- 99234
- Component:
- 980000 unknown or other
- Summary:
- Information on diagnosing a vehicle with malfunction indicator lamp illuminated and diagnostic trouble codes p0442 and p0455 stored in continuous memory. *tt
- Bulletin:
- 6996
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Information regarding a change in the torque values of the engine front cover water pump bolts. *tt
- Bulletin:
- 13186
- Component:
- 060000 engine and engine cooling
- Summary:
- Information regarding front cover & water pump bolts-torque valve revision/3.8-4.2l. *mjs
- Bulletin:
- 985122
- Component:
- 036000 service brakes, hydraulic:antilock
- Summary:
- Subject regarding the availability of the fqr anti-lock braking system hydraulic control unit (abs-hcu) assemblies. *tt
- Bulletin:
- 11496
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Some vehicles equipped with the 4.2l engine may exhibit a vibration or boom, off idle between 870 - 900 rpms. *tt
- Bulletin:
- 4619
- Component:
- 980000 unknown or other
- Summary:
- Some vehicles may exhibit malfunction indicator light on with evaporative diagnostic trouble codes p0442, p0455 set. *tt
- Bulletin:
- 4628
- Component:
- 106000 power train:axle assembly
- Summary:
- Some vehicles may exhibit rear axle noise. *tt
- Bulletin:
- 4638
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Malfunction indicator lamp on, with p0300 - p0308 misfire diagnostic trouble codes with a 4.6l engine. *tt
- Bulletin:
- 090308
- Component:
- 980000 unknown or other
- Summary:
- Mil light on with evaporative dtc p0442, p0455
- Bulletin:
- 15082
- Component:
- 070000 fuel system, gasoline
- Summary:
- Information used when servicing, or replacing the cng fuel fill valve on all dedicated and bi-fuel cng vehicles. *tt
- Bulletin:
- 15038
- Component:
- 034000 service brakes, hydraulic:foundation components
- Summary:
- Some vehicles may exhibit rapid wear of the front brake pads (under 10,000 miles). *tt
- Bulletin:
- 14992
- Component:
- 105500 power train:driveline:differential unit
- Summary:
- Some vehicles equipped with 4r70w transmission (driveshaft >70 inch) may exhibit a driveline vibration / roughness on acceleration or under load at about 50 - 55 mph. *tt
- Bulletin:
- 15517
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Subject regarding exaggerated engine braking on deceleration. *yd
- Bulletin:
- 15354
- Component:
- 034500 service brakes, hydraulic:foundation components:disc
- Summary:
- Some vehicles may exhibit accelerated front disc brake pad wear under extreme loading conditions. *tt
- Bulletin:
- 15799
- Component:
- 100000 power train
- Summary:
- Some vehicles equipped with 4r70w transmission (driveshaft >70 inch) may exhibit a vibration / roughness on acceleration or under load at about 50-55 mph. *tt
- Bulletin:
- 17381
- Component:
- 034520 service brakes, hydraulic:foundation components:disc:pads
- Summary:
- Front brake pad wear. *tt
- Bulletin:
- 05248
- Component:
- 020000 suspension
- Summary:
- Vibration/harshness above 45 mph (72 km/h) after tire balance. *tt
- Bulletin:
- 071110
- Component:
- 040000 service brakes, air
- Summary:
- Brake booster system may exhibit a brake pedal kickback and/or grabbing condition when applying the brakes. *nj
Home | Privacy