1997 HYUNDAI TIBURON Recalls (4)
- Campaign:
- 97V026000 on 03/02/1997
- Component:
- Visibility:windshield wiper/washer:motor
- Manufactured:
- 12/17/1995 - 10/17/1996
- Affected:
- 74,965
- Defect:
- The windshield wiper motor circuit breaker electrical contacts were contaminated during assembly.
- Consequence:
- This contamination interferes with the electrical circuit continuity and prevents the windshield wiper motor from operating. inoperative windshield wipers can contribute to reduced visibility during inclement weather increasing the risk of a vehicle crash.
- Correction:
- Dealers will remove the contaminants from the windshield wiper motor circuit breaker contacts.
- Notes:
- Owner notification:owner notification is expected to begin march 18, 1997.note:owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact hyundai at 1-800-829-9956.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
- Campaign:
- 00V095001 on 03/28/2000
- Component:
- Fuel system, gasoline:storage:tank assembly
- Manufactured:
- 08/31/1996 - 08/30/1997
- Affected:
- 84,020
- Defect:
- Vehicle description: passenger vehicles. the evaporative emission control systems can apply excessive vacuum to the fuel tanks during the canister purge cycle. if excessive vacuum is applied, minor fuel tank distortion can result. a small crack could develop on the upper fuel tank surface. the "check engine" light would then illuminate and, in some cases, the vehicle driver may notice a gasoline odor.
- Consequence:
- Fuel leakage in the presence of an ignition source could result in a fire.
- Correction:
- Dealers will pressure check the vehicle's fuel tank to determine if it has cracked. if the fuel tank has cracked, it will be replaced.
- Notes:
- Owner notification began april 28, 2000.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact hyundai at 1-800-633-5151.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 00V095002 on 08/23/2000
- Component:
- Fuel system, gasoline:storage:tank assembly
- Affected:
- 7,111
- Defect:
- Vehicle description: passenger vehicles. the evaporative emission control systems can apply excessive vacuum to the fuel tanks during the canister purge cycle. if excessive vacuum is applied, minor fuel tank distortion can result. a small crack could develop on the upper fuel tank surface. the "check engine" light would then illuminate and, in some cases, the vehicle driver may notice a gasoline odor.
- Consequence:
- Fuel leakage in the presence of an ignition source could result in a fire.
- Correction:
- Dealers will pressure check the vehicle's fuel tank to determine if it has cracked. if the fuel tank has cracked, it will be replaced.
- Notes:
- Owner notification began september 18, 2000. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact hyundai at 1-800-981-0452.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 01V345000 on 11/14/2001
- Component:
- Seat belts:front:webbing
- Manufactured:
- 02/29/1996 - 08/27/2000
- Affected:
- 42,782
- Defect:
- Vehicle description: passenger vehicles. the driver and front passenger seat belts may not extend and retract smoothly through the d-ring guides mounted on the body pillars aft of the doors. if the seat belts do not extend and retract smoothly, they may twist in the d-ring guides and make it inconvenient to extend and retract the seat belts.
- Consequence:
- If the seat belts are inconvenient to use, the seat occupant may not be inclined to wear the seat belts properly, increasing the risk of injury in the event of a crash.
- Correction:
- Dealers will install a stopper over each front seat belt d-ring guide to assist the seat belt to smoothly extend and retract. owner notification began december 10, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact hyundai at 1-800-633-5151.
- Notes:
- Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
1997 HYUNDAI TIBURON TSBs (50)
- Bulletin:
- 9650009
- Component:
- 033200 service brakes, hydraulic:power assist:hydraulic
- Summary:
- Brake booster check valve (shop manual correction). *tw
- Bulletin:
- 9650009
- Component:
- 033100 service brakes, hydraulic:power assist:vacuum
- Summary:
- Brake boooster check valve (shop manual correction). *tw
- Bulletin:
- 9701998
- Component:
- 136200 visibility:windshield wiper/washer:motor
- Summary:
- Recall 97v-026 - the windshield wiper motor thermal switch circuit contact points must be cleaned on certain hyundai vehicles which fall into the following prodution ranges to correct a possible intermittent interruption of wiper operation
- Bulletin:
- 9760001
- Component:
- 134000 visibility:sun roof assembly
- Summary:
- Procedure for sunroof assembly removal and installation. *jd
- Bulletin:
- 9720002
- Component:
- 980000 unknown or other
- Summary:
- The cylinder head torque sequence for in-line 4 cylinder engines noted in the listed shop manuals is incorrect. *jd
- Bulletin:
- 9740013
- Component:
- 105300 power train:driveline:driveshaft
- Summary:
- Modified transaxle control modules. *tw
- Bulletin:
- 97040012
- Component:
- 105300 power train:driveline:driveshaft
- Summary:
- Manual transaxle poppet valve design change. *tw
- Bulletin:
- 9790002
- Component:
- 103000 power train:automatic transmission
- Summary:
- Atm 3rd to 4th gear upshift delay during cruise control operation. *tw
- Bulletin:
- 9760002
- Component:
- 162300 structure:body:door
- Summary:
- Door weatherstrip removal and installation procedure. *tw
- Bulletin:
- 9740002
- Component:
- 105300 power train:driveline:driveshaft
- Summary:
- Shift condition caused by short circuit in inhibitor switch. *tw
- Bulletin:
- 9790006
- Component:
- 136200 visibility:windshield wiper/washer:motor
- Summary:
- The rear wiper motor in the 1997 tiburon may stall in heavy load conditions. *tw
- Bulletin:
- 9797001
- Component:
- 353600 equipment:air conditioner
- Summary:
- Tiburon a/c switch sticking. *tw
- Bulletin:
- 9790005
- Component:
- 353400 equipment:electrical:radio/tape deck/cd etc.
- Summary:
- Audio system connector replacement. *tw
- Bulletin:
- 9760003
- Component:
- 162000 structure:body
- Summary:
- Tiburon/accent rear spoiler center high mounted stop lamp. *tw
- Bulletin:
- 9709001
- Component:
- 114000 electrical system:wiring
- Summary:
- Hds adapter cable hy02 installation procedure. *tw
- Bulletin:
- 97100190014
- Component:
- 133000 visibility:power window devices and controls
- Summary:
- Information on power window lock switch operation. *yc
- Bulletin:
- 97080140026
- Component:
- 102000 power train:manual transmission
- Summary:
- Information on a new double cone synchronizer. *yc
- Bulletin:
- 97080190013
- Component:
- 120000 exterior lighting
- Summary:
- Information and procedures on projector beam headlight adjustment. *yc
- Bulletin:
- 97110160007
- Component:
- 162000 structure:body
- Summary:
- Information on torsion bars, gas struts and chmsl. *yc
- Bulletin:
- 97110199004
- Component:
- 162000 structure:body
- Summary:
- Various information on proper care for vehicle exteriors and corrective steps for environmental damage. *yc
- Bulletin:
- 970901400131
- Component:
- 105100 power train:driveline:universal joint
- Summary:
- Modified transaxle control modules. *yc
- Bulletin:
- 9820001
- Component:
- 061200 engine and engine cooling:engine:diesel
- Summary:
- A procedure for the installation of a block heater. *yc
- Bulletin:
- 9809006
- Component:
- 063100 engine and engine cooling:exhaust system:emission control
- Summary:
- Information on the oxygen sensor offset voltage change. *yc
- Bulletin:
- 9850002
- Component:
- 030000 service brakes, hydraulic
- Summary:
- Specification on rear brake disc minimum thickness. *yc
- Bulletin:
- 9807-9880009
- Component:
- 162000 structure:body
- Summary:
- Corrosion may form around the edge of the sunroof lid panel lip due to inadequate sealing of the weatherstrip against the sunroof lid panel on some vehicles. *yc
- Bulletin:
- 9840013
- Component:
- 103000 power train:automatic transmission
- Summary:
- Subject pertaining to improved 2-1 downshift at low speeds. *yc
- Bulletin:
- 9840007
- Component:
- 101100 power train:clutch assembly:pedal/linkage
- Summary:
- Technical service bulletin on clutch cover assembly. *yc
- Bulletin:
- 9940002
- Component:
- 106000 power train:axle assembly
- Summary:
- Vehicles may exhibit a slight shift flare during the upshift from 2nd to 3rd gear. *tt
- Bulletin:
- 9940004
- Component:
- 106000 power train:axle assembly
- Summary:
- Subject regarding automatic transaxle diagnostic trouble code p1613/1614. *tt
- Bulletin:
- 9740010
- Component:
- 103000 power train:automatic transmission
- Summary:
- Conditions with a slight shift "flare" during the 2nd to 3rd gear upshift. *tt
- Bulletin:
- 9940008
- Component:
- 103700 power train:automatic transmission:torque converter
- Summary:
- Some vehicles may experience an oil leak behind the torque converter. *tt
- Bulletin:
- 9940005
- Component:
- 102000 power train:manual transmission
- Summary:
- Subject regarding double cone synchronizer. *tt
- Bulletin:
- 9936010
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Subject regarding crankshaft position sensor replacement procedure. *tt
- Bulletin:
- 0040005
- Component:
- 106000 power train:axle assembly
- Summary:
- Some transaxles produced prior to 05/15/99 may experience an oil leak in the bellhousing behind the torque converter. *tt
- Bulletin:
- 010101
- Component:
- 106000 power train:axle assembly
- Summary:
- Information on performing a test drive for transaxle shift quality. *tt
- Bulletin:
- 0001004
- Component:
- 071100 fuel system, gasoline:storage:tank assembly
- Summary:
- Subject regarding fuel tank pressure check campaign 037 for vehicles exhibiting excessive vacuum formation in the fuel tank. *et
- Bulletin:
- 0101006
- Component:
- 151100 seat belts:front:anchorage
- Summary:
- Subject regarding tiburon seat belt d-ring guide stopper. *yd
- Bulletin:
- 0250002
- Component:
- 034510 service brakes, hydraulic:foundation components:disc:caliper
- Summary:
- Subject regarding front brake caliper rattle noise repair kit. *tt
- Bulletin:
- 0240010
- Component:
- 103000 power train:automatic transmission
- Summary:
- Subject on automatic transaxle harsh or delayed park reverse or park drive engagement. *yh
- Bulletin:
- 0240012
- Component:
- 103000 power train:automatic transmission
- Summary:
- Subject regarding automatic transaxle diagnostic trouble codes list. *yh
- Bulletin:
- 0240016
- Component:
- 106000 power train:axle assembly
- Summary:
- Subject regarding automatic transaxle oil leaking from oil pan gasket. *jg
- Bulletin:
- 01400061
- Component:
- 106000 power train:axle assembly
- Summary:
- Automatic transaxle pulse generator diagnostic trouble codes p0717 and p0722 - revised. *jg
- Bulletin:
- 0290009
- Component:
- 980000 unknown or other
- Summary:
- Subject regarding diagnostic guide for clifford and dei security system. *jg
- Bulletin:
- 0236028
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Obd-ii readiness test drive cycle. *tt
- Bulletin:
- 0340007
- Component:
- 106000 power train:axle assembly
- Summary:
- Ata solenoid diagnostic trouble codes p0740, p0741, p0742, p0743, p0745, p0747, p0748, p0750, p0752, p0753, p0755, p0757, p0758, p0760, p0765. *tt *mj
- Bulletin:
- 0340022
- Component:
- 106000 power train:axle assembly
- Summary:
- Automatic transaxle pulse generator diagnostic trouble codes p0717 & p0722. 2004 accent included. *tt
- Bulletin:
- 0804
- Component:
- 110000 electrical system
- Summary:
- Replacement cigarette lighter. *nm
- Bulletin:
- 151
- Component:
- 103000 power train:automatic transmission
- Summary:
- Automatic transaxle diagnostic trouble codes list. *tt
- Bulletin:
- 135
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Oxygen sensors. *sc
- Bulletin:
- 0540018
- Component:
- 106000 power train:axle assembly
- Summary:
- Automatic transaxle diagnostic trouble codes list. *tt
Home | Privacy