1996 AMTRAN RE Recalls (6)
- Campaign:
- 97V048000 on 04/03/1997
- Component:
- Steering:hydraulic power assist:hose, piping, and connections
- Manufactured:
- 03/06/1995 - 01/20/1997
- Affected:
- 1,473
- Defect:
- The low pressure power steering return hose can either burst or become disconnected due to increased fluid viscosity in frigid temperatures.
- Consequence:
- If the low pressure return hose bursts or separates, there would be a loss of power assist to the steering and a reduction in power assist to the brakes on vehicles equipped with hydraulic brakes.
- Correction:
- Dealers will replace the return hoses with a hose that can tolerate higher pressures, use improved clamps and a power steering fluid that is less viscous in frigid temperatures.
- Notes:
- Owner notification:owner notification is expected to beginapril 29, 1997. note:owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact amtran at 1-800-843-5615 or navistar at 10800-448-7825.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
- Campaign:
- 98V301000 on 12/01/1998
- Component:
- Structure:body:door:hinge and attachments
- Manufactured:
- 04/30/1995 - 10/17/1996
- Affected:
- 37,656
- Defect:
- Vehicle description: school buses. the emergency door hinges that consist of steel pin fittings and/or lacklubrication can bind from rust and/or corrosion.
- Consequence:
- This could cause difficulty in opening the doors in the event of an emergency.
- Correction:
- Owners will be provided with a repair kit and installation instructions. the owners can contact an amtran dealer for assistance if they so desire.
- Notes:
- Owner notification began january 6, 1999. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact am-tran at 1-800-843-5615.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 99V061000 on 03/24/1999
- Component:
- Seats:front assembly:recliner
- Manufactured:
- 04/30/1995 - 02/25/1999
- Affected:
- 7,738
- Defect:
- Vehicle description: school buses equipped with flip seats at the emergency exits. the seat cushion hinge on the combination flip seat is located in such a manner that it is within easy reach of the passenger sitting in the seat located behind the combo flip seat.
- Consequence:
- The hinges on the combo flip seat can cause a pinching condition, resulting in personal injury.
- Correction:
- Owners will be notified and sent kits to remedy these seats.
- Notes:
- Owner notification began april 1, 1999.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact amtran at 1-800-993-7686.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 01V057000 on 02/27/2001
- Component:
- Equipment:other:labels
- Manufactured:
- 02/14/1994 - 01/11/1999
- Affected:
- 554
- Defect:
- Vehicle description: school and transit buses. some certification labels displayed the incorrect tire pressure for the tire specified to meet the gross axle weight rating for the front and/or rear axles. this does not meet the certain requirements of fmvss no. 120, "tire selection and rims for motor vehicles other than passenger cars," and 49 cfr part 567, "certification."
- Consequence:
- Under or over-inflated tires can cause or contribute to premature tire failure, possibly resulting in a sudden blowout or other failure which could result in a loss of control of the vehicle.
- Correction:
- New certification labels are being provided to owners. owner notification began march 16, 2001. owners who do not receive the free certification label within a reasonable time should contact amtran at 1-800-993-7686.
- Notes:
- Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 01V241000 on 07/30/2001
- Component:
- Visibility:defroster/defogger system:windshield:blower
- Manufactured:
- 12/31/1994 - 05/30/1996
- Affected:
- 11,944
- Defect:
- Vehicle description: certain school and transit buses were built with a poor quality heater/defroster blower switch. in some cases this has caused the melting of the heater harness connector at the switch terminals or the high-speed wire insulation at the connector. also, some of the units had improper circuit protection size installed in the heater defroster circuit.
- Consequence:
- If an operator detects smoke or the smell of melting wire insulation from the blower control panel, the operation of the heater/defroster at high speed should be discontinued until the repair is made.
- Correction:
- Owners will be provided with instructions and parts to replace the switch and switch harness with a new switch, switch harness, relay and relay harness. for the re units built prior to january 1, 1999, the kit will also include a 20-ampere manual circuit breaker. owner notification began december 15, 2001. owners who do not receive the free remedy within a reasonable time should contact amtran at 800-843-5615.
- Notes:
- Also contact the national highway traffic safety administration=s auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 03V354000 on 01/14/2004
- Component:
- Structure:body
- Manufactured:
- 04/10/1995 - 08/21/1995
- Affected:
- 66,749
- Defect:
- Ce model school buses which fail to comply to federal motor vehicle safety standard no. 221, school bus body joint strength. the roof top sheet may be improperly located, reducing the material edge distance at the rivet line.
- Consequence:
- In the event of a vehicle crash, the joint strenght could fail possibily resulting in injuries to the vehicle occupants.
- Correction:
- Ic will notify its customers and will provide inspection and repair instruction. the recall began on january 25, 2005. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ic customer service at (we do not yet have a telephone number for this campaign.)
- Notes:
- Ic recall no. 03305.also, customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
Home | Privacy