1995 THOMAS ER TRANSIT Recalls (3)
- Campaign:
- 00V174000 on 06/29/2000
- Component:
- Exterior lighting:headlights:switch
- Manufactured:
- 11/30/1994 - 07/30/2000
- Affected:
- 803
- Defect:
- Certain school buses with weldon technologies' 5050-1400 surface mount marker lights have an option to replace each of the twelve clearance/marker/identification lights with four-candlepower lights, twice the candlepower normally used. the higher current demand created by these lights can cause excessive heat through the headlight switch connection if a relay is not installed between the combination tail/marker light circuit and the headlight switch.
- Consequence:
- This can result in deformation of the plastic connectors that connect the headlight switch to its wiring harness.
- Correction:
- Dealers will install a relay to reduce the current draw through the headlight switch. owner notification began september 8, 2000. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact thomas built at 1-336-881-7219.
- Notes:
- Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 03V246000 on 07/16/2003
- Component:
- Vehicle speed control
- Affected:
- 62
- Defect:
- On certain trucks and buses equipped with cummins electronic control modules on the c8.3g and l10g engines, the ecm does not have the ability to detect a throttle fail-safe engine shutdown command. this could result in an unanticipated, uncommanded open throttle condition without warning.
- Consequence:
- If this event occurs, the vehicle operator will not have control of the engine speed, possibly resulting in a vehicle crash.
- Correction:
- Cummins will notify the customers and replace the ecm. owners should contact cummins at 1-800-343-7357 or freightliner at 1-503-745-5219.
- Notes:
- Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 08V087000 on 02/26/2008
- Component:
- Structure:body:door:hinge and attachments
- Manufactured:
- 12/31/1993 - 03/09/2008
- Affected:
- 243,435
- Defect:
- Daimler trucks is recalling 243,435 my 1995-2008 thomas built school buses manufactured between january 1994, and march 10, 2008. (additional buses have been added to this recall campaign. please see supplemental report no. 4) the emergency exit door handle begins corroding around the securing roll pin and square drive mechanism causing the protective finish to chip and flake. continued corrosion and pitting weakens the handle. handles weakened by corrosion may break while trying to open the door from the exterior.
- Consequence:
- In the event of an emergency, a person on the outside of the bus may break the door handle trying to open the emergency exit potentially delaying evacuation and increasing the risk of personal injury to the vehicle's occupants.
- Correction:
- Daimler trucks will notify owners and will replace the handles with a more robust handle free of charge. repairs will be performed by thomas built buses dealerships. the recall began on august 18, 2008, and notification for the revised population is expected to begin on or about april 29, 2009. owners may contact thomas built at 336-889-4871.
- Notes:
- Daimler trucks recall no. fl-525.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
Home | Privacy