1995 SPARTAN MOUNTAIN MASTER Recalls (4)
- Campaign:
- 95V064000 on 03/30/1995
- Component:
- Electrical system:alternator/generator/regulator
- Manufactured:
- 03/31/1994 - 02/28/1995
- Affected:
- 1,166
- Defect:
- When in operation, the pre-heater requires good engine ground. however, the alternators are not grounded through the case, limiting the ground for engine electrical components. the pre-heater amperage can then ground to the steel braided air compressor hose which is secured in a rubber lined clip. in some circumstances, the clip can contact the frame rail causing an arc.
- Consequence:
- This condition can cause a hole to be burned through the air line, preventing the air compressor from delivering sufficient air pressure to the braking system reducing brake capability and increasing the potential for a vehicle accident.
- Correction:
- Dealers will install a 6 gauge ground cable between the engine and the existing starter ground cable located inside the frame rail.
- Notes:
- System: electrical; alternator; regulator; starter.vehicle description: motorhome chassis equipped with a 1994 or later 300 h.p.c 8.3 cummins engine equipped with pre-heaters and a 160 amp leece neville "powerline" alternator.note: if your vehicle is presented to an authorized dealer on an agreed upon service date and the remedy is not provided free of charge within a reasonable time, please contact spartan at 1-517-543-6400, ext. 370.also contact the national highway traffic safety administration's auto safety hotline at1-800-424-9393.
- Campaign:
- 96V014000 on 01/24/1996
- Component:
- Steering:wheel and handle bar
- Manufactured:
- 12/31/1994 - 09/30/1995
- Affected:
- 358
- Defect:
- Intermittent disruption of the functions controlled by the steering wheel center touch pad can occur caused by electrical shortage inside the steering wheel assembly. this does not conform to the requirements of fmvss no. 104, "windhsield wiping and washing systems;" and no. 108, "lamps, reflective devices and associated equipment."
- Consequence:
- Consequence of non-compliance: this condition can cause improper operation of the functions controlled by the touch pad. the function (1) fails to operate; (2) operates intermittently; or (3) operates unexpectedly, i.e. a function comes on without being switched on. any of these could distract a driver increasing the potential for an accident.
- Correction:
- Dealers will repair the steering wheel center control assemblies to eliminate the electrical shorting.
- Notes:
- System: steering wheel and column; fmvss nos. 104 and 108. vehicle description: class a motor home chassis, gvwr 23,000 to 31,000 pounds, equipped with a "vip" steering wheel with center controls (also called the "smartwheel" or "intelliwheel").note: owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time, should contact spartan at 1-800-722-3025. also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
- Campaign:
- 96V072000 on 05/07/1996
- Component:
- Electrical system:fuses and circuit breakers
- Manufactured:
- 12/31/1994 - 04/30/1995
- Affected:
- 741
- Defect:
- These solenoids can fail to operate or pass current. these solenoids are used to turn the power to the ignition bus bar(s) on the power panel(s) on and off.
- Consequence:
- Failure of a solenoid will cause the set of controlled devices not to function. some of these devices are: cruise control, back-up lamp, anti-lock brake electr0nic control unit power; turn signals; heater/ defroster, and/or windshield wipers.
- Correction:
- Dealers will replace these defective solenoids with an "automotive controls company" solenoid.
- Notes:
- Vehicle description: class a motorhome chassis, transit bus, and speciality vehicle chassis applications equipped with prestolite chassis power panel solenoids. note: owner notification is expected to begin during late may 1996. note: owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time, should contact spartan at 1-800-722-3025. also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
- Campaign:
- 96V201000 on 11/26/1996
- Component:
- Vehicle speed control
- Manufactured:
- 05/31/1993 - 09/26/1996
- Affected:
- 7,633
- Defect:
- The eco-cruise actuator can bind the throttle.
- Consequence:
- If the actuator binds, engine speed may not decrease to the level anticipated by the operator, increasing the risk of a vehicle accident.
- Correction:
- Dealers will remove these actuators until new or remanufactured units can be supplied.
- Notes:
- Owner notification:owner notification began november 25, 1996.note:owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact spartan at 1-800-543-4277.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
Home | Privacy