1995 GMC SONOMA Recalls (7)
- Campaign:
- 97V096001 on 08/20/1997
- Component:
- Seat belts
- Manufactured:
- 12/31/1993 - 08/29/1995
- Affected:
- 586,058
- Defect:
- Vehicle description: extended cab pickup trucks equipped with 60/40 front bench seats and extended cab pickup trucks and 2-door utility vehicles equipped with manual locking recliner bucket seats. the outboard safety belt webbing on the driver's and/or passenger's seat can separate during a frontal impact.
- Consequence:
- If a separation occurred and there were secondary crash events or vehicle rollover, there would be no belt restraint of the occupant and increased injuries could occur.
- Correction:
- Dealers will install a protective cover over the recliner mechanism.
- Notes:
- Owner notification:owner notification will begin during september 1997. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
- Campaign:
- 98V150001 on 02/10/1999
- Component:
- Visibility:windshield wiper/washer
- Manufactured:
- 07/31/1994 - 05/30/1996
- Affected:
- 1,557,585
- Defect:
- Vehicle description: light duty pickup trucks and sport utility vehicles, 2 and 4-wheel drive. solder joints near the wiring harness connector can crack causing the windshield wipers to work intermittently.
- Consequence:
- This condition can result in inoperative wipers, reducing a driver's visibility, and increasing the risk of a vehicle crash.
- Correction:
- Dealers will replace the wiper motor circuit board and cover.
- Notes:
- Owner notification began december 15, 1998.owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 99I006000 on 07/20/1999
- Component:
- Service brakes, hydraulic:antilock
- Affected:
- 2,400,000
- Defect:
- This is not a safety recall in accordance with the safety act. however, it is deemed a safety improvement campaign by the agency. vehicle description: certain light duty pickup trucks, sport utility vehicles, or minivans equipped with 3-sensor abs (antilock braking system) ebc4 units.
- Consequence:
- These vehicles can experience extended stopping distances during abs stops on certain multiple surfaces, increasing the risk of a crash.
- Correction:
- Dealers will modify the computer program which operates the abs unit on some vehicles, or replace the computer on others to improve the performance of the abs on these surfaces.
- Notes:
- On vehicles which required the computer program to be modified, owner notification has began.for vehicles which require a new computer module, gm has scheduled owner notificatiion to begin during the last week of may 2000.a phased mailing will be required, with the last mailing scheduled to be completed by december 2000.owners can contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782.
- Campaign:
- 99V193000 on 07/20/1999
- Component:
- Service brakes, hydraulic:antilock
- Affected:
- 1,125,749
- Defect:
- Vehicle description: certain 4-wheel drive pickup trucks and sport utility vehicles equipped with abs (antilock braking system) manufactured from september 1989 through august 1996. under certain driving conditions the switch which signals the abs system whether the vehicle is in 2-wheel or 4-wheel drive can malfunction causing increased stopping distances during abs stops while in the two-wheel drive mode.
- Consequence:
- If this occurred at a time when minimum stopping distance was required, a vehicle crash could occur without prior warning.
- Correction:
- Dealers will replace or repair the 4-wheel/2-wheel drive switch.
- Notes:
- The first phase of owner notification letters began may 31, 2000,with the last mailing completed by october 2000. owners can contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
- Campaign:
- 06E041000 on 05/17/2006
- Component:
- Fuel system, gasoline:delivery:hoses, lines/piping, and fittings
- Affected:
- 7,800
- Defect:
- Certain r&b, inc. central multiport fuel injection (cmfi) fuel return lines, models help 55163, napa balkamp 700-3270, and the connection 2560001, sold for use as replacement equipment for the vehicles listed above. the fuel return line has a mechanical bleed valve which was not installed at the proper torque.
- Consequence:
- A fuel leak can occur at the valve, possibly resulting in a fire.
- Correction:
- R&b, inc. will notify owners and at the customers request, either replace the fuel line or offer a full refund. the recall began on may 4, 2006. owners may contact r&b, inc. at 215-712-5330.
- Notes:
- This recall only pertains to r&b, inc. aftermarket cmfi return fuel lines and has no relation to any original equipment installed on the listed passenger vehicles.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 06E043000 on 05/21/2006
- Component:
- Fuel system, gasoline
- Affected:
- 88,303
- Defect:
- Certain replacement fuel filters, fram brand name p/n g3727, with date codes x52911 through x60801 sequentially or x600141 and a mexico country or origin marking on the fuel filter housing manufactured from october 18, 2005, through march 21, 2006, sold for use on the vehicles listed above and on certain school buses. (to see the school bus engine sizes, click on "document search" and then "bus applications"). the connector on the fuel filter was not manufactured to honeywell's specification. as a result, the o-ring may not seat correctly on the fuel line.
- Consequence:
- This condition may cause an inadequate seal at the connection, potentially leading to a fuel leak. in the presence of an ignition source, a fire could occur.
- Correction:
- Honeywell will notify owners and replace the fuel filters free of charge. the recall began on october 18, 2006. owners may contact fram customer service at 1-800-890-2075 (option 1).
- Notes:
- This recall only pertains to aftermarket fram fuel filters and has no relation to any original equipment installed on the vehicles listed.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
- Campaign:
- 07E021000 on 03/11/2007
- Component:
- Fuel system, other:storage:tank assembly:pressure relief devices
- Affected:
- 742
- Defect:
- Certain delphi fuel pressure regulators, p/nos. fp10020-11b1, fp10026-11b1, and fp10027-11b1, sold after january 9, 2007, as aftermarket equipment for various passenger vehicles listed above. the universal pressure regulators (upr) were produced without an o'ring and retainer.
- Consequence:
- Fuel may leak, possibly resulting in a fire.
- Correction:
- Delphi will notify owners and replace the upr free of charge. the recall began on april 23, 2007. owners can contact delphi at 877-411-8770.
- Notes:
- This recall only pertains to aftermarket delphi fuel pressure regulators and has no relation to any original equipment installed by general motors.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
1995 GMC SONOMA TSBs (23)
- Bulletin:
- 567301
- Component:
- 101000 power train:clutch assembly
- Summary:
- clutch pedal squeak noise. *tw
- Bulletin:
- RCL/95C27
- Component:
- 355100 equipment:other:labels
- Summary:
- general motors has determined that certain 1995 s/t gmc trucks equipped with 4.3l engines and manual transmissions may have been built with an incorrect emission engine family description name on the emission label. to correct this condit
- Bulletin:
- CAMP/95C31
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- recall campaign 95-c-31 - general motors has determined that certain 1995 gmc truck 2 wheel and 4 wheel drive sonoma pickup trucks equipped with 4.3l engines (rpo l35 - vin code w) and 1995 gmc truck 4 wheel drive jimmys equipped with 4.3l
- Bulletin:
- GM569002
- Component:
- 180000 vehicle speed control
- Summary:
- stepper motor cruise control will not resume or reset (replace smcc module). *tw
- Bulletin:
- CAMP/95C31
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Unknown
- Bulletin:
- GM91C31
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- Unknown
- Bulletin:
- 576404
- Component:
- 113000 electrical system:starter assembly
- Summary:
- click-no-crank condition (install new starter motor).*sd
- Bulletin:
- 521501
- Component:
- 162810 structure:body:hood:hinge and attachments
- Summary:
- hood hinge rattle (install spring washer).*sd
- Bulletin:
- CAMP95C35A
- Component:
- 091000 fuel system, other:storage
- Summary:
- fuel tank plastic reservoir attachement. *sd
- Bulletin:
- CAMP95C53
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- general motors has decided that certain 1995 s trucks equipped with 2.2l (in2) 4 cylinder engines may have pushrod that may be in hard contact with the anti- rotation bracket securing the roller lifters. if the pushrod is in hard contact,
- Bulletin:
- 776001
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Knock, rattle or tap noise from the engine before the engine has reached operating temperature or under light load conditions at operating temperature knock, rattle or tap noise from the engine before the engine has reached operating
- Bulletin:
- 776001
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Information concerning engine knock/rattle or tap noise before engine has reached operating temperature or under light load conditions at operating temperature (replace piston and/or rod assemblies). ak
- Bulletin:
- 240699
- Component:
- 036000 service brakes, hydraulic:antilock
- Summary:
- Subject regarding abs 3-sensor ebc4 - special policy. *tt
- Bulletin:
- 98043
- Component:
- 136200 visibility:windshield wiper/washer:motor
- Summary:
- Product recall campaign involving windshield wiper motor replacement. *tt
- Bulletin:
- 220801
- Component:
- 220000 seats
- Summary:
- Customers may comment that the seat recliner handle is stripped. *jg
- Bulletin:
- 020730024A
- Component:
- 103400 power train:automatic transmission:lever and linkage:column shift
- Summary:
- Diagnosis of cracked or broken transmission case. *tt 2006 and prior cars and light duty trucks. *tt
- Bulletin:
- 020525006
- Component:
- 036000 service brakes, hydraulic:antilock
- Summary:
- Antilock brake (abs) activation at low speeds. *tt
- Bulletin:
- 020525006A
- Component:
- 046000 service brakes, air:antilock
- Summary:
- Antilock brake (abs) activation at low speeds on various models including the 1995 and 1996 envoy. *tt
- Bulletin:
- 990730016A
- Component:
- 100000 power train
- Summary:
- Diagnostic information for intermittent transmission downshift, slip, busy/cycling tcc or noisy cooling fan. *tt
- Bulletin:
- PIP4723B
- Component:
- 118000 electrical system: software
- Summary:
- This preliminary information communicates to the dealer the process for downloading or updating operating software for the tire pressure monitor, active fuel injector tester, multi media tester, pico scope, gr8 starting/charging tester and
- Bulletin:
- PIC4696A
- Component:
- 353100 equipment:electrical:anti-theft devices
- Summary:
- This preliminary information communication provides information to the technician on how to unlock radios that are delco theftlock. technician will use the radio to get the scrambled code. technician will need to contact the radio unlock ce
- Bulletin:
- PIC4696B
- Component:
- 353100 equipment:electrical:anti-theft devices
- Summary:
- This preliminary information communication provides information to the technician on how to unlock radios that are delco theftlock. technician will use the radio to get the scrambled code. technician will need to contact the radio unlock ce
- Bulletin:
- PIC4696C
- Component:
- 150000 seat belts
- Summary:
- This preliminary information communication provides information to the technician on how to unlock radios that are delco theftlock. technician will use the radio to get the scrambled code. technician will need to contact the radio unlock ce
Home | Privacy