1995 FORD F SERIES (MEDIUM) TSBs (28)
- Bulletin:
- 942320
- Component:
- 061110 engine and engine cooling:engine:gasoline:belts and associated pulleys
- Summary:
- main front end accessory drive belt rolls off. *tw
- Bulletin:
- 942321
- Component:
- 105300 power train:driveline:driveshaft
- Summary:
- multi-piece driveshaft misalignment with center bearing. *tw
- Bulletin:
- 942213
- Component:
- 042200 service brakes, air:supply:governor
- Summary:
- mounting location of the air compressor governor interfering with power steering hose. *tw
- Bulletin:
- 942613
- Component:
- 113000 electrical system:starter assembly
- Summary:
- starter stays engaged after key is released. *tw
- Bulletin:
- BC3461950201
- Component:
- 034000 service brakes, hydraulic:foundation components
- Summary:
- the hydromax brake reservoir mounting bracket may seperate or fluid may slosh from the reservoir. *tw
- Bulletin:
- 95325
- Component:
- 162000 structure:body
- Summary:
- stationary engine cover cracks. *tw
- Bulletin:
- 95327
- Component:
- 013000 steering:gear box (other than rack and pinion)
- Summary:
- steering - revised camber specification. *tw
- Bulletin:
- 942025
- Component:
- 180000 vehicle speed control
- Summary:
- throttle - hand throttle difficult to operate. *tw
- Bulletin:
- 95620
- Component:
- 111000 electrical system:battery
- Summary:
- battery covers for outboard frame-mounted batteries rattle or crack. *tw
- Bulletin:
- 95723
- Component:
- 114100 electrical system:wiring:front underhood
- Summary:
- the engine wiring harness may become pinched between the cab and left hand frame rail. *tw
- Bulletin:
- BC1853950705
- Component:
- 353600 equipment:air conditioner
- Summary:
- a/c compressor may be damaged due to the overall length of the hose between the accumulator and the compressor. the hose may not be adequate to to allow for engine movement. *tw
- Bulletin:
- 951115
- Component:
- 114000 electrical system:wiring
- Summary:
- stall or no start - fuel shutdown solenoid - wiring chafing on fuel injector lines-vehicles built before 10/19/94 with fd1060 engine and bosch p7100 fuel injection pump. *tw
- Bulletin:
- 95620
- Component:
- 015000 steering:hydraulic power assist system
- Summary:
- Unknown
- Bulletin:
- BC1300950906
- Component:
- 042100 service brakes, air:supply:compressor
- Summary:
- improved air compressor support bracket. *tw
- Bulletin:
- 951517
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- leaks - oil - front cover or gear housing vehicles with fd1460 engine. *sd
- Bulletin:
- 951713
- Component:
- 112000 electrical system:alternator/generator/regulator
- Summary:
- generator-motorcraft 95amp-front bearing concern-fd1060/1460 engines- vehicles built before 7/3/95. *sd
- Bulletin:
- 951714
- Component:
- 061100 engine and engine cooling:engine:gasoline
- Summary:
- engine- 'knocking' noise - when operating engine at 200-2300 rpm - fd1460 engine
- Bulletin:
- BC0203960102
- Component:
- 033000 service brakes, hydraulic:power assist
- Summary:
- w/ hydraulic brakes & tilt hood, hydraulic fluid may leak from the brake pump reservoir. tsb 95-10-13 provided a reservoir support bracket to minimize leakage. it was determined that this repair was not entirely effective. engineering is w
- Bulletin:
- BC0187960102
- Component:
- 062100 engine and engine cooling:cooling system:radiator assembly
- Summary:
- on f/b series w/ fd 1060 engine there may be a concern regarding insuffi- cient in-cab heat. to resolve this, the current thermostat can be replaced with a new low leak thermostat. the needed parts are available from cummis engine. refer t
- Bulletin:
- 952010
- Component:
- 072000 fuel system, gasoline:delivery
- Summary:
- hard starting or a no start concern may occur on some vehicles. this may be due to diesel fuel draining out of the fuel injection system back into the fuel tank. this condition causes the injection system to lose its prime which leads to l
- Bulletin:
- 952012
- Component:
- 062100 engine and engine cooling:cooling system:radiator assembly
- Summary:
- the engine coolant temp gauge may read on the cold side of the normal range, or may stay below normal even though the engine is at its proper operating temp on some vehicles. this is caused by the coolant temp sending unit not being positi
- Bulletin:
- 95212
- Component:
- 036000 service brakes, hydraulic:antilock
- Summary:
- the use of petroleum-based grease as a lubricant in servicing disc brakes is no longer acceptable because it may be incompatible with the rubber material used in the disc brake system. if petroleum-based grease is used to lubricate any par
- Bulletin:
- BC0678961025
- Component:
- 102000 power train:manual transmission
- Summary:
- Information on aode/4r7w transmission main control & case replacement. *tt
- Bulletin:
- BC0844961008
- Component:
- 102000 power train:manual transmission
- Summary:
- E4od trans may emit a tick/rattle noise when driving at light loads in 1st gear at 1100 to 1800 rpm rpm. *tt
- Bulletin:
- BC0883961004
- Component:
- 063200 engine and engine cooling:exhaust system:manifold/header/muffler/tail pipe
- Summary:
- Vehicles may exhibit an exhaust leak &/or noise due to warped exhaust manifolds. *tt
- Bulletin:
- 97218
- Component:
- 021210 suspension:front:springs:coil springs
- Summary:
- Suspension - noise from front spring rear hanger - revised rear spring hanger insulator pad - vehicles equipped with 6000, 7000 or 9000 lb axles built through 10/1/97. *tw
- Bulletin:
- BC3236970211
- Component:
- 113000 electrical system:starter assembly
- Summary:
- Fd 1060 engines - new design starter motor to alleviate hard start/no start concerns in cold ambients. *tw
- Bulletin:
- 13736
- Component:
- 102200 power train:manual transmission:floor shift assembly
- Summary:
- Some vehicles may experience oil leaking from the shift lever. *mjs
Home | Privacy