1994 VOLVO VN TSBs (47)
- Bulletin:
- SB-824-002
- Component:
- 160000 structure
- Summary:
- Volvo truck: to reduce the potential for cab water intrusion, a cab cowl seal has been released by engineering. the seal part number 8083305 is positioned above the top edge of the cowl panel to divert water flow onto the cowl panel rathe
- Bulletin:
- SP-891-004
- Component:
- 162900 structure:body:roof and pillars
- Summary:
- Volvo: trucks built prior to 18/8/2011 were shipped without four (4) spring nuts pre-installed from the factory. *js
- Bulletin:
- FSB-255-023
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Volvo trucks: connector pin, replacement. severe fretting damage of the engine variable geometry turbocharger actuator (engine vgt actuator) harness and turbine shaft speed sensor (tss) connector may cause an unreliable signal to the engin
- Bulletin:
- FSB-212-002
- Component:
- 061000 engine and engine cooling:engine
- Summary:
- Volvo trucks: oil seepage at flywheel housing. this problem has already been solved in production, but the production solution is not compatible with previous generation flywheel housings. *js
- Bulletin:
- FSB-357-002
- Component:
- 330000 interior lighting
- Summary:
- Volvo: light control module (lcm), reprogramming. on some volvo units equipped with clear led clearance lights in the sun visor, the may exhibit an active fault code mid 216 psid 49 fmi 5. this fault indicates a trailer marker open issue wh
- Bulletin:
- SP-514-005
- Component:
- 043000 service brakes, air:slack adjusters
- Summary:
- Volvo trucks: on the steering axle of the volvo trucks, the zerk fitting on the meritor slack adjuster comes into contact with the bolt head of the steering arm causing the fitting to break. *js updated 8/17/12. *pe
- Bulletin:
- FSB-221-011
- Component:
- 060000 engine (pws)
- Summary:
- Volvo: low oil pressure, on certain vehicles, during long hard pull conditions, diagnostic trouble codes (dtcs) pid 100 fm1, spn 100 fmi 1 or p252400, can log on, with or without engine shut down lamp. model vn, vt. no years listed. *pe
- Bulletin:
- FSB-51-001
- Component:
- 045000 service brakes, air:disc
- Summary:
- Volvo: the air disc brake, on some trucks, may experience thermal overload due to an over adjustment of normal pad wear compensation that maintains clearance running between brake pad and rotor. models vah, vhd, vn. no years listed.
- Bulletin:
- FSB-512-002
- Component:
- 045000 service brakes, air:disc
- Summary:
- Volvo: on some trucks, air disc brake may experience a condition of thermal overload. thermal overload reduces running clearance between pad and rotor below desired level which is an over adjustment of normal pad wear compensation. model
- Bulletin:
- FSB 293-016
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- Exhaust gas recirculation (egr) valve oil supply line, updated part
- Bulletin:
- FSB 284-047
- Component:
- 114000 electrical system:wiring
- Summary:
- Oil level sensor harness wire splice
- Bulletin:
- SP 284-049
- Component:
- 118000 electrical system: software
- Summary:
- Engine control module (ecm) software update
- Bulletin:
- FSB 432-014
- Component:
- 103000 power train:automatic transmission
- Summary:
- Transmission ecu compatibility
- Bulletin:
- FSB 371-049
- Component:
- 111100 electrical system:battery:cables
- Summary:
- Battery cable, routing
- Bulletin:
- SP 386-004
- Component:
- 118000 electrical system: software
- Summary:
- Fuel management module, replacement, incorrect calibration
- Bulletin:
- FSB 375-010
- Component:
- 220000 seats
- Summary:
- Seat harness routing (non-swivel) wires pulling away from clipping points
- Bulletin:
- FSB 375-011
- Component:
- 220000 seats
- Summary:
- Seat harness routing (swivel) wires pulling away from clipping points
- Bulletin:
- FSB 593-012
- Component:
- 113100 electrical system:starter assembly:solenoid
- Summary:
- Hill start assist solenoid, replacement
- Bulletin:
- FSB 216-001
- Component:
- 100000 power train
- Summary:
- Twin mass flywheel conversion, transmission removed
- Bulletin:
- FSB 293-027
- Component:
- 063130 engine and engine cooling:exhaust system:emission control:gas recirculation valve (egr valve)
- Summary:
- Egr mass flow rate low, diagnostic trouble code
- Bulletin:
- FSB 431-010
- Component:
- 350000 equipment
- Summary:
- Range synchronizer, repair
- Bulletin:
- FSB 811-005
- Component:
- 350000 equipment
- Summary:
- Floor cracks repair (front panel)
- Bulletin:
- FSB 811-006
- Component:
- 350000 equipment
- Summary:
- Floor cracks repair (rear panel)
- Bulletin:
- FSB 284-038
- Component:
- 118000 electrical system: software
- Summary:
- Engine coolant thermostat software update
- Bulletin:
- FSB 215-002
- Component:
- 354000 equipment:mechanical
- Summary:
- Timing plate leak repair
- Bulletin:
- FSB 593-012
- Component:
- 113100 electrical system:starter assembly:solenoid
- Summary:
- Hill start assist solenoid, replacement
- Bulletin:
- FSB 215-003
- Component:
- 350000 equipment
- Summary:
- Timing plate flange screw
- Bulletin:
- FSB 284-057
- Component:
- 060000 engine (pws)
- Summary:
- High soot output
- Bulletin:
- FSB 222-004
- Component:
- 060000 engine (pws)
- Summary:
- Oil filter housing
- Bulletin:
- FSB 432-013
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Amt high range cone replacement
- Bulletin:
- FSB 801-003
- Component:
- 162300 structure:body:door
- Summary:
- Service door rust prevention
- Bulletin:
- FSB 593-012
- Component:
- 355200 equipment:other:owners/service/other manual
- Summary:
- Hill start assist solenoid, replacement
- Bulletin:
- FSB 234-018
- Component:
- 070000 fuel system, gasoline
- Summary:
- Single fuel tank ventilation filter kit
- Bulletin:
- FSB 234-019
- Component:
- 070000 fuel system, gasoline
- Summary:
- Dual fuel tanks ventilation filter kit
- Bulletin:
- SP 293-027
- Component:
- 060000 engine and engine cooling
- Summary:
- Coolant hose, egr cooler, replacement
- Bulletin:
- FSB 252-031
- Component:
- 061120 engine and engine cooling:engine:gasoline:turbo-charger
- Summary:
- Turbocharger outlet pipe
- Bulletin:
- FSB 258-035
- Component:
- 070000 fuel system, gasoline
- Summary:
- Aftertreatment def tank vent filter
- Bulletin:
- FSB 258-036
- Component:
- 353000 equipment:electrical
- Summary:
- Def sensor assembly routing
- Bulletin:
- FSB 210-045
- Component:
- 110000 electrical system
- Summary:
- Regeneration in pto mode
- Bulletin:
- FSB 222-004
- Component:
- 060000 engine (pws)
- Summary:
- Oil filter housing
- Bulletin:
- FSB 593-012
- Component:
- 113100 electrical system:starter assembly:solenoid
- Summary:
- Hill start assist solenoid, replacement
- Bulletin:
- FSB 293-022
- Component:
- 060000 engine (pws)
- Summary:
- In the event that an egr temperature sensor replacement is required on a volvo d13h engine, a new routing configuration is required.
- Bulletin:
- SP 398-001
- Component:
- 110000 electrical system
- Summary:
- On some trucks with the telematics gateway (tgw) system, the tgw control unit may not correctly communicate with the vehicle systems after restarting.
- Bulletin:
- SP2 284-036
- Component:
- 118000 electrical system: software
- Summary:
- Software update, revise document
- Bulletin:
- SP 431-021
- Component:
- 118000 electrical system: software
- Summary:
- Transmission ecu programming
- Bulletin:
- FSB 216-001
- Component:
- 350000 equipment
- Summary:
- Twin mass flywheel conversion
- Bulletin:
- FSB216-002
- Component:
- 060000 engine (pws)
- Summary:
- Flywheel resurfacing guidelines, i-shift
Home | Privacy